Professional Documents
Culture Documents
Insert dimensions for the required product shape in orange Carbon &
boxes, then read off the weight in the red boxes at right. ferritic Austenitic
Material:
Note - Densities shown in green boxes are typical. Add specific stainless stainless
density under "others" for different materials. steels steels
density: 7800 7900
Sheet / plate Thickness (mm)
Width (mm) Length (m)
flat bar 1 kg:
Thickness (mm)
Width (mm)
Coil kg/m:
Round Diameter (mm) Length (m)
bar / wire 1 kg:
A/F (mm) Length (m)
Square bar 1 kg:
A/F (mm) Length (m)
Hex bar 1 kg:
A/F (mm) Length (m)
Oct bar 1 kg:
Thickness (mm)Leg 1 (mm) Leg 2 (mm) Length (m)
Angle bar 1 kg:
OD (mm) ID (mm) Length (m)
Hollow bar 1 kg:
Round OD (mm) WT (mm) Length (m)
tube / pipe 1 kg:
Square / rect Side 1 (mm) Side 2 (mm) WT (mm) Length (m)
tube / pipe 50 50 5 6 kg: 42.12 42.66
Note: All results are approximate. Refer to second sheet for calculation fomulas.
www.rdsteelgroup.com/
SERVICES DEPT.
Copper Aluminium
alloys alloys Others
(Note) (Note) (Note)
8470 2700 5000
Notes
1. These are approximate and actual weights may vary due to specific grade and dimension tolerances.
2. Austenitic stainless steels have slightly higher densities than carbon steels. Consult tables for exact calculations.
3. Dimensional tolerances are particularly wide for hot rolled products, such as plate, pipe.and black bar.
4. Theoretical densities are used for all calculations, and the result is a theoretical mass. This takes no account
of dimensional tolerances.
5. "Billing weights" are often used in commercial quotations - such as 8177 for austenitic stainless steel.
This value accounts for a predominantly + tolerance for plate. It's justification for other products is less obvious.
6. Hollow round includes pipe and tube (specified by OD and WT).
7. Flat product includes plate, sheet, strip, coil and flat bar
Densities
Carbon steel 7800
Stainless steel (austenitic) 7900
Aluminium alloys 2700
Copper (alloy 385) 8470
Formulas for Mass Calculation
Mass (kg/m)
= 0.00000079 x dens x D²
= 0.000000866 x dens x F²
= 0.0000008284 x dens x F²
= 0.00000314 x dens x (D - t) x t
= 0.000001 x dens x 2 x (S1 + S2 - 2 x t) x t
= 0.0000007854 x dens x (D² - d²)
= 0.000001 x dens x T x W
= 0.000001 x dens x (L1 + L2 - t) x t)
d - Inside Diameter (mm)
ctangular hollows (mm)