Professional Documents
Culture Documents
1
1
6A
4. ELECS Solve for the ripple factor for 30V, 100uF, 50mA.
4.3%
5. Moving closed loop wire (???)
Current induced
6. What is hall effect chuvaness used/ application
Sensor application
7. Connection of Thermocouple
Results to Thermocouple effect, that is required to be
compensated for.
8. Rtds are typically connected to other resistors in;
bridge type configuration
9. A resistive strain gauge reading
based on the gauge factor and less than an ohm
10. Holding current in scr can be described as A:
Minimum current for conduction
11. The alternator blah blah has a freq of 50 hz find the
required rotation speed
1000
12. Passive attenuator, find gain
0.1
13. (d ko matandaan ung circuit )
Soln: 6.3V+6.3mA(1.54kΩ)
16V
16. Advantage of CMOS.
Low power consumption
18. Op amp usually employs negative feedback to:
Control the gain
20. Advantage of J-K Over R-S Flip flop
More predictable output.
30. It is a bias that has a good stability but uses both positive
and negative supply
Emitter bias
31. Determine the average voltage of ......... if the peak
voltage is 55 V.
34.98
32. 2 inductors connected series, both 100uH, 0.4 inductor
coupling. What is the equivalent inductance?
280uH
33. Apparent power 100W, Reactive Power 40W. What is
the true power?
92W
34. Rating of soldering iron, 600W and 110V, find current
5.455
35. What is the majority carrier of emitter in PNP transistor?
Holes
37. Is caused by switching between devices driving a load,
most often when transistor are matched
Crossover Distortion
38. What is Power?
Rate of energy radiated or dissipated.
39.
0 instantaneous change of rate
40. Flute is different from violin. They play in same pitch but
they are different in:
Waveform