You are on page 1of 4

TITLE

(Must be brief, informative and indicates the main point(s) of the paper
between 10-15words)

Full Name1, Full Name2*, Full Name3


1.
Department of (Author ABSTRACT
Affiliation) with complete An abstract (200 - 300 words) embodying the main
address and Pos Code conclusion and giving the essential information and accompanied
2.
Department of (Author with 3 -5 key words
Affiliation) with complete
address and Pos Code Key words: Key words 1, Key words 2 Key words 3 Key words 4

Submitted: 14-01-2017
Revised: 20-03-2011
Accepted: 11-04-2017

*Corresponding author
Author Correspondent

Email:
Email Correspondent

INTRODUCTION Four individually labeled


should give the research objective and a brief
statement of previous relevant work with references
spectrophotometer tubes were
prepared using different amounts
MATERIAL AND METHODS (as represented in Table 1) of the
This section of the report gives following reagents: a buffer of pH 7,
a detailed account of the procedure a 0.1% catechol substrate, and
that was followed in completing the distilled water. The wavelength of
experiment(s) discussed in the the Spectronic 20
report. Such an account is very spectrophotometer was set at 540
important, not only so that the nm. To calibrate the
reader has a clear understanding of specrophotometer at zero
the experiment, but a well written absorbance, a blank control tube
Materials and Methods section also prepared with no catechol substrate
serves as a set of instructions for and labeled "tube 1" was inverted
anyone desiring to replicate the and inserted into the
study in the future. spectrophotometer.
It is important to note that the
Sample 1 extract to be tested was added to
In preparing the catecholase each tube immediately before
extract, a potato was skinned, placing the tube into the
washed, and diced. 30.0 g of the spectrophotometer. 1.0 ml of
diced potato and 150 ml of distilled catecholase extract was pipetted
water were added to a kitchen into tube 2. Tube 2 was immediately
blender and blended for inverted and placed in the
approximately two minutes. The spectrophotometer. The absorbance
resulting solution was filtered was read and recorded for time zero
through four layers of cheese cloth. (t0), the ten minute mark (t10), and
The extract was stored in a clean, each minute in between. Tube 2
capped container. was removed from the
spectrophotometer and the same
Running title

measurements were taken for tube commenting on the results


3 and tube 4 using the same obtained, interpreting what the
protocol. results mean and, explaining any
results which are unexpected.
Sample 2 You present the
A potato and a knife were measurements made in the
obtained for this experiment. experiment and you
Also, distilled water, a blender, then compare your measurements
cheese cloth, a clean container with to the calculations you made in your
a cover, and eight preliminary work or the published
spectrophotometer tubes were theoretical values.
used. A Spectronic 20
spectrophotometer was used for
CONCLUSION
this experiment, as were buffers of
Conclusion is a brief summary
pHs 4, 6, 7, and 8. Catechol
substrate, Parafilm coverings, of findings and discussion. It is
KimWipes, a black pen, and pipettes strongly recommended to avoid
were also obtained for this mere repetitive statements from the
experiment. Finally, a pencil and previous sections.
pad were obtained for recording
results. ACKNOWLEDGEMENT
If necessary put your
Sample 3 acknowledgements here. In this
In preparing the catecholase section you should give credit to
extract, a potato was skinned, people who have helped you with
washed, and diced. A balance was the research or with writing the
used to obtain 30.0 g of the diced paper. If your work has been
potato. 150 ml of distilled water supported by a grant, you would
was poured into a beaker. The also give credit for that in this
water was added to the diced section.
potato. The cover of a kitchen
blender was removed. The potato REFERENCES
and water were added to the Reference list format is based
blender. The solution smelled like on APA (American Psychological
potato. The cover was placed on the Association) style. Reference list
blender and the power button was should appear at the end of the
depressed. The clock was observed article and includes only literatures
until the second hand circled actually cited in the manuscripts.
twice. The power button was Author should use reference
pushed again to stop the blender. management tool such as
The resulting solution was filtered Mendeley, End Note and
through four layers of cheese cloth. Grammarly. References are
The extract was stored in a clean, ordered alphabetically and
capped container. chronologically. When writing a
reference list, please use the
RESULT AND DISCUSSION following conventions
In the Results and
Discussion section, you present Sample :
your results and discuss them by: Allen LV Jr. Remington. 2012. The
Science and Practice of
Pharmacy: from the past into spectrofluorimetric
the future. Int J Pharm Compd. determination of two
16 (5): 358-62. pharmaceutical
Bankars.K, Chaudhari A.V, Mahale antihypertensive mixtures
N.B and Chaudhari S.R. 2014. containing amlodipine besylate
A Review On Orodispersible together with either
Tabletsprepared Using Spray candesartan cilexetil or
Dried Sustained Release telmisartan. Luminescence.
Microparticles. Journal of 29(7): 893-900. doi:
Advanced Drug Delivery. 1(2): 10.1002/bio.2638
82-95.
Belal TS, Mahrous MS, Abdel-
Khalek MM, Daabees HG,
Khamis MM. 2014. Validated
Running title

TABLE AND FIGURE


All illustrations including figures, charts and graphs, must be labeled (in the bottom),
numbered (1, 2, 3 etc) and supplied on separate pages from the text. The desired placement of
illustrations in the text should be clearly indicated. These illustrations should be referred to and
numbered serial, as figures.

Example :

Table 1. The Title of table


No Variable x Variable y

Figure 1. The title of Figure

You might also like