Professional Documents
Culture Documents
Actual
Sl. No. Description Specification Remarks
1 2
3 3° 21' 3° 20'
10 Standout dimension
12 Gauge status
If Over pin variation 0.06 mm on DIAMETER means 1 mm Linear difference will come
Run out more than 0.05 mm means standout will vary accordingly: because; In 4 position ( i.e. based on blocked Spline )
Gauge position will change where the ovality matching in that position gauge show drop arm is over size; where the not matching
In that position gauge show drop arm under size ( this variation due to drifting tool which is supplied by us and it will
Reflect on component drop arm also )
For Dicor and TATA Ace Drop arm Signed sample available with Supplier