Professional Documents
Culture Documents
MODEL EXAM
SEM: III Network Theory
18 ohm 2 ohm
2 ohm
50v 8 ohm
5 ohms 10 ohms
20V 3 ohms
5A
or
14. For the circuit shown in the fig below, find I3 and verify reciprocity theorem.
2 ohm 2 ohm
1.375 ohm
10 ohm
1 ohm
3 ohm
10 v
www.ktustudents.in
15. A parallel RLC circuit with R=10, L =10 mH & C=1Mf has an applied voltage of 200
V at resonant frequency. Calculate the resonant frequency, the current in the circuit and
the voltages across the elements at resonance. Find also the quality factor and bandwidth.
or
16. Write a short note on analysis of single and double tuned coupled circuits.
17. A series RL circuit with R=100 & L=20H has a dc voltage of 200V applied through a
switch at t=0 find a) the equation for the current and t=0 find a) the equation for the
current and voltages across the different elements, b) the current at t=0.5 seconds, c) the
current at 1 sec.
Or
18. For the circuit shown in figure. Determine the current when the switch is closed at t=0.
Assume zero charge on the capacitor initially.
10 ohms
10 sin 50t
5F
or
19. (i) Derive the expression for balanced star connected load and draw the phasor diagram.
(ii) Give the short notes on symmetrical component and un-symmetrical component.
or
20. The power flowing into a balanced three phase inductive load measured by the 2
wattmeter method are 200 W and 1000 W. the line voltage are 400V, 50 Hz. Determine
the total power, KVA and the power factor of the load.
www.ktustudents.in