You are on page 1of 21

EXAMINATION AVIATION LEGISTION.

Name : …………………………………..
Student No. : …………………………………..
Class : …………………………………..
Date : …………………………………..

A. Multiple Choice :

1. Definitions of aviation, refer to CASR Part 1 Amdt.1, means:

a. Anything relating to the use of airspace, aircraft, airports,


concerning air transport, aviation security and safety and
supporting facilities,
b. Any activity using an aircraft for carrying passengers, cargo
and/or post in trips from one airport to another.
c. Activities of aircraft for the use of interstate, overseas, or
foreign air commerce.
d. An aircraft operation in which an aircraft is used for
specialized service.

2. Definitions of aircraft, refer to CASR Part 1 Amdt.1, means:


a. A power-driven heavier-than-air aircraft, deriving its lift in
flight chiefly from aerodynamic reactions on surfaces which
remain fixed under given conditions of flight.
b. Any machine that can derive support in the atmosphere from
the reactions of the air other than the reactions of the air
against the earth’s surface.
c. A machine registered in Indonesia and has an identity of the
nation of Indonesia and used for commercial and non-
commercial purposes.
d. None of answer above are correct.
3. Definitions of airport, refer to CASR Part 1 Amdt.1, means:
a. A defined area, to accommodate aircraft for purposes of
loading or unloading passengers, mail or cargo, fuelling,
parking or maintenance.
b. A defined area on land or water (including any buildings,
installations and equipment) intended to be used for the
arrival, departure.
c. An area of land and/or water within the territory of the
Republic of Indonesia which is used for the aviation
activities of the Armed force.
d. An area to which an aircraft may proceed when it becomes
either impossible or inadvisable to proceed to or to land at
the area of intended landing.

4. Definitions of accident, refer to CASR Part 1 Amdt.1, means:

a. A person is fatally or seriously injured as a result of being in


the aircraft for intension to flight,
b. The aircraft sustains damage or structural failure which
adversely affects the structural strength,
c. The aircraft is missing or is completely inaccessible.
d. All answer above are correct.

5. Refer to CASR Part 65.33 the basic certificate for the airframe
and powerplant categories consist of :

a. A1; A2; A3 and A4.


b. C1; C2; C3 and C4.
c. B1; B2; B3 and B4.
d. There are no categories.

6. Refer to CASR 65.33 the basic certificate for the Electrical /


Avionic catagories consist of :

a. C1;C2;C3 and C4.


b. C1;C2 and C4.
c. B1;B2;B3;B4.
d. A1;A2;A3;A4.
7. The validity of the basic certificate according to CASR 65 is valid
until :

a. Two years from the date of issued.


b. As mention on the certificate.
c. No validity for the basic certificate.
d. Six month from the date of issued.
8. The validity of the Aircraft Maintenance Engineer License
according to CASR 65 :

a. Should be three years from the date of issued


b. Shall not exceed three years from the date of issued.
c. Not mention on the license.
d. There is no validity of AMEL.

9. One of the condition to renewal the aircrfat maintenance


engineer license are :

a. Having the experience at least in 24 months.


b. Shall exercise their privileges at least 6 months within 24
months.
c. Submit the their basic cerificate.
d. Attend type training.

10. Refer to the CASR 65.11 the time for the re-examanation after
fail from the basic certificate examanation are :

a. 30 days
b. Less than 30 days from the date after applicant is failed
c. Not less than 30 days after the date the applicant failed
d. 60 days from the date of examination failed.

11. According to CASR part 65.17 change address must be reported


to the DGCA within :

a. 20 days after address changes


b. 30 days after any change to a permanent address
c. 5 bussiness days
d. 60 days after address changes.

12. How many years old that a basic certificate will issue by the
DGCA :

a. 21 years of age
b. 19 years of age
c. Not less than 19 years of age
d. More than 19 years of age

13. According to CASR part 65.41 how many years old that a license
will issue :
a. 21 years old
b. Not less than 21 years of age
c. 19 years old
d. Less than 21 years of age

14. According to the CASR part 1 what does it mean by an


accident :

a. A person is fatally or seriously injured


b. A damage on aircraft during maintenance
c. A missing part of the aircraft
d. Loss of engine cowl or parts of thrust reverser.

15. A person who authorized to perform maintenance refer to CASR


part 43 are :
a. A holder of a basic certificate
b. A holder of aircraft maintenance engineer license
c. A senior technician
d. Maintenance manager.

16. According to the CASR 43.7 who authorized to aproved


aircraft;engine and propeller after maintenance :

a. A holder of AMO certificate


b. A holder of basic license
c. A non rated engineer.
d. Maintenance manager

17. According to the CASR 43 a person may authorized to perform


maintenance and preventive maintenance except :

a. A holder AMO certificate


b. A holder of AOC
c. A holder of Basic Certificate
d. A DGCA Inspector.
18. After performing a major repair and major alteration an AMO
shall execute a DGCA form, what number of form :

a. Form 43 – 337.
b. Form 43-373.
c. Form 43 – 37.
d. Form 43-377.

19. According to the CASR part 45.11 aircrfat identification plate


must be secured in location :
a. Near an entrance door
b. Apu section
c. Nose area of the fuselage
d. Tail section area

20. According to the CASR part 45.11 aircrfat engine identification


plate must be secured in location :

a. At accessible location on the engine


b. Nose of the engine area
c. At casing of the engine
d. Inside engine cowling

21. According to the CASR 45.13 the identification plate shall


include the following information :

a. Model; serial number; type cert.number,builder


b. Name; model; serial number and part number
c. Name; Model; serial number; engine performance
d. Model; serial number; Ownership; engine type.

22. According to the CASR part 45.20 the color of the Nationality
and Registration marks must :
a. Black color on the white background
b. Yellow color on the black background
c. Contrast in color with the background
d. Have ornamentation with yellow in color.

23. The aircrfat registration letter may install on the aircraft except :

a. PK - TTT
b. PK – GVW
c. PK – FQU
d. PK - CKA
24. How height the registration of small aircraft mark install on the
wing :

a. At least 15 centimeters
b. At least 6 inches
c. At least 25 centimeters
d. At least 5 inches

25. How height the registration of the small aircraft install on the
fuselage :
a. At least 15 centimeters
b. At least 5 inches
c. At least 25 centimeters
d. At least 5 inches

26. The height of the identification marks on the wing of the big
aircraft are :

a. At least 50 centimeters
b. At least 25 centimeters
c. At least 15 inches
d. At least 15 centimeters

27. The height of the identificationmarks on the fuselage or vertical


tail surface of a big aircraft shall :

a. At least 30 centimeters
b. At least 25 inches
c. At least 15 centimeters
d. At least 25 centimeters

28. The widht of each character for the aircraft registration shall :
a. Two – thirds of the height of a character
b. One – sixth of the height of a characer
c. One – quarter of the height
d. One – thirds of the height of a character

29. According to the CASR part 65.47 the privileges of an aircraft


maintenance engineer license are :

a. Perform maintenance of an aircraft or component


b. Release an aircraft or component to service after
maintenance
c. Answer a and b are correct
d. Only for aircraft maintenance.
30. According to CASR 65 the group of airframe rating consist of :

a. Three groups and three sub-groups.


b. Three groups and no sub groups
c. Three groups and four sub-groups,
d. Two groups and four sub-groups.

31. Refer to CASR 65 the group of radio rating consist of :

a. Two groups.
b. Three groups.
c. Six groups.
d. Four groups.

32. The Airplane catagories according to CASR part 23 consist of :

a. Five categories.
b. Four categories.
c. Three categories.
d. Two categories.

33. According to CASR part 23 every product must comply with


standard airworthiness, so what does it mean by airworthy :

a. The article ready for flight.


b. Conform to type design and safe for flight.
c. The article ready for return to service.
d. Have been performed a schedule maintenance .

34. The certificate of airworthiness are issued by :

a. National Aviation Authority.


b. The aviation company.
c. The Airline company.
d. The aircraft manufacture.

35. According to the CASR Part 45.29 the thickness of characters


lines shall be :

a. One-quarter of the height of a character


b. One-quater of the height of a hyphen
c. One-fourth of the height of a hyphen.
d. One-sixth of the height of a character
36. According to the CASR Part 65 a license category C has :

a. Three categories,
b. Two categories,
c. Four categories,
d. One category

37. According to the CASR 45 the Aircrfat registration may install


on aircraft are :

a. PK – SOS
b. PK - PAN
c. PK – GQA
d. PK – QBA

38. According to CASR 65 the categories of Basic Certificate are :

a. Five categories.
b. Six categories.
c. Seven categories,
d. Eight categories.

39. The different betwen Type Certificate and Supplemental Type


Certificate are :

a. TC issued by Authority and STC issued by Manufacture.


b. TC for new product and STC for any change of the product.
c. Answer a and b are correct.
d. Supplement Type Certificate.

40. According to CASR 43.11 the maintenance record shall contain


as follow :

a. Type of inspection; date of inspection and signature.


b. Date of A/C hangar in and date of inspection finish.
c. Type of inspection and date of A/C hangar in.
d. Name of the organization performed inspection.

41. According to CASR 45 the identification marks of an A/C


registered consist of:

a. Nationality and Registration mark


b. Nationality and three letters
c. Nationality only
d. Type of aircraft and company name.

42. When an aircraft is registered in Indonesia is sold the aircraft


registration shall remove unless :

a. The purchaser from Indonesia.


b. The registration should be removed.
c. The purchaser from outside Indonesia.
d. The purchaser A citizen of Indonesia.

43. The different between Certificate of Maintenance Approval and


AMEL are :
a. Validity of a license
b. Experience
c. Type rating certificate
d. Skill and knowledge

44. According to the CASR 65 definition of a basic certificate are :

a. A license issued by Authority


b. A Certificate issued by Aircraft Maintenance Training
Organization (AMTO).
c. As answer a but without rating
d. As answer a but with rating

45. Actions required by Airworthiness Directives shall:


a. Specify inspections to be carried out,
b. Specify conditions and limitations must comply
c. Resolve an unsafe condition.
d. All above answer are correct.

46. According to the CASR Part 39 which number for the emergency
AD :

a. AD 2006 – 05 – 49
b. AD 2002 – 10 – 52
c. AD 2004 – 08 – 09
d. None of above answer are correct
47. Refer to the AD number 2006 – 10 – 06 what does it mean by
number 10 :

a. Bi weekly 10
b. Number of AD issued
c. AD Revision number.
d. Sequense number of AD issued

48. Alternate Methode of Compliance ( AMOC ) is issued by :


a. Manufacture
b. Aircraft Maintenance Organization.
c. Manufacture Authority
d. National Aviation Authority

49. According to the CASR 121 an air carrier whose authorized


operation outside of Indonesia having approval as :

a. A Domestic Air Carrier


b. A Charter Air carrier.
c. A Flag Air Carrier
d. Supplemental Air Carrier

50. DGCA airworthiness directives are legally enforceable rules


that apply to the following products:

a. aircraft,
b. aircraft engines,
c. propellers and appliances.
d. All of above are correct.

51. According to the CASR 21 Technical Standard Order (referred


to in this subpart as "TSO")is issued by:
a. Aircraft Maintenance Organization for temporary repair.
b. DGCA and is a minimum performance standard for
specified articles
c. Aircraft Manufacture for product improvement.
d. Aircraft Manufacture by issuing Service Bulletin.

52. Refer to the CASR 121.29 the validity of Air Operator Certificate
are :

a. 24 months
b. Three years
c. Two years
d. One year

53. According to the CASR Part 21 the aviation product are devided
into :

a. Two classes.
b. There are no classes.
c. Three classes.
d. Class I ; Class II and Class III products.

54. Refer to the CASR Part 21 the class I product consist of :

a. A complete Aircrfat ; Engine and Propeller.


b. Aircraft; Engine and Propeller.
c. Wing; Engine and Aircraft.
d. Engine and fuselage.

55. Refer to the CASR Part 39 issues an airworthiness directive


addressing:

a. In a product when an unsafe condition exists or develop in


other of the same type.
b. In a product for improvement or development of the same
type.
c. In a Wing; Engine and Aircraft only.
d. In a product as Engine and fuselage.

56. According to the CASR 21.197 a special permits issued by


Authority for the purpose of :

a. Flight testing new product.


b. There’s no special permit issued.
c. Normal flight.
d. Experimental Flight.

57. What is the purpose of Weight and Ballance on the aircrfat :

a. To know the take of weight.


b. To determine the central of gravity .
c. To know landing weight.
d. For certification purposes only.

58. Refer to the CASR Part 21 the aviation product class II consist
of :

a. Wing; Fuselage; Landing gear and control surface.


b. Aircraft; Fuselage; and Landing gear.
c. Landing Gear; wing and Engine.
d. Fuselage, aircraft and engine.

59. A Technical Standard Order (referred to in this subpart 21 as


"TSO") is issued by:

a. AMO and is a minimum performance standard.


b. DGCA and is for aircraft, engine and propeller.
c. DGCA and is a minimum performance standard.
d. Aircraft manufacture and is a minimum performance
standard.
60. Refer to the CASR Part 21 Standard airworthiness certificates
and special airworthiness certificates issued for primary,
restricted or limited category aircraft are effective for:

a. One year after the date of issuance or renewal.


b. Two year after the date of issuance or renewal.
c. Three year after the date of issuance.
d. Four year after the date of issuance or renewal.

61. Refer to CASR 21.181, duration of special flight permit is


effective for :

a. The period of time as one year.


b. The period of time as two years.
c. The period of time specified in the permit.
d. The period of time as six month.

62. Refer to CASR 39.5, Airworthiness directives issued by foreign


airworthiness authorities:

a. Will be re-adjusted with Indonesian CASR.


b. Will be ignored and not valid.
c. Will be adopted without further technical investigation.
d. Will be adopted with further technical investigation and
may not adding anything.

63. CASR 45.29 stated that height size of rotorcraft registration


mark should be:

a. Bottom surface should not less than 50 cm.


b. Bottom surface should not less than 20 cm.
c. Bottom surface should not less than 15 cm.
d. Bottom surface should not less than 6 inches.

64. CASR 45.29 stated that height size of rotorcraft registration


mark should be:

a. Side surface should not less than 50 cm.


b. Side surface should not less than 20 cm.
c. Side surface should not less than 15 cm.
d. Side surface should not less than 6 inches.

65. Refer to Appendix A CASR 43, which one is categories as


major repair:

a. Removal, installation, and repair of landing gear tires.


b. Replacing elastic shock absorber cords on landing gear.
c. Servicing landing gear shock struts by adding oil, air, or
both.
d. Repair main seat support brace and brackets.

66. Refer to Appendix A CASR 43, which one is not categories as


preventive maintenance:

a. Repair main seat support brace and brackets.


b. Removal, installation, and repair of landing gear tires.
c. Replacing elastic shock absorber cords on landing gear.
d. Servicing landing gear shock struts by adding oil, air, or
both.
67. Refer to 91.7, on a civil aircraft who is responsible for
determining whether the aircraft is in condition for safe flight:

a. Pilot in command,
b. Flight Operation Officer,
c. Aircraft Maintenance Organization.
d. Engineer in the hangar.

68. Refer to CASR 91.21, any portable electronic device not allowed
to be operated on:

a. Indonesian registered aircraft operated by AOC holder.


b. Indonesian register aircraft operated under IFR.
c. Passengers cabin only.
d. a and b answer are correct.

69. Rules stated in CASR 91.107 regarding seat belt as:

a. Each person on board aircraft is briefed on how to fasten


and unfasten that person's safety belt.
b. Ensures that each person on board aircraft has been
notified to fasten his or her safety belt.
c. Seat belt properly secured about him or her during
movement on the surface, for takeoff, and landing.
d. All above answer are correct.

70. Refer to CASR 91.146 refuelling with passengers onboard are:


a. Refuelling is prohibited,
b. Only during passengers disembarking.
c. Only during passengers embarking.
d. Allowed with certain requirement.

71. For VFR flight during the day according to CASR 91.205, the
following instruments are not required:

a. Altimeter,
b. Weather Radar,
c. Magnetic Direction Indicator,
d. Airspeed Indicator.
72. Emergency Locator Transmitter refer to CASR 91.207, must be
installed:

a. At least one automatic ELT unit,


b. At least two automatic ELT unit,
c. At least three automatic ELT unit,
d. At least four automatic ELT unit,

73. Emergency Locator Transmitter refer to CASR 91.207,for 19


passengers after 1 July 2008 must be installed:

a. At least one automatic ELT unit,


b. At least two automatic ELT unit,
c. At least three automatic ELT unit,
d. At least four automatic ELT unit,

74. Emergency Locator Transmitter refer to CASR 91.207,must be


performed inspection for every:

a. Within six months calendar time,


b. Within twelve months calendar time,
c. Within eighteen months calendar time,
d. Within twenty-four months calendar time,

75. According to CASR 121.367,Maintenance program for the


operator should containing the following :

a. Maintenance tasks and the intervals to be performed,


b. A continuing structural integrity program;
c. Maintenance task as required inspection items.
d. All above answer are correct.

76. CASR 121.373 regarding continuing and analysis maintenance


program shall include:

a. A function to monitor maintenance program


performance.
b. A function to monitor maintenance program effectiveness
c. Procedure for recording of maintenance carried out
and retention of maintenance record;
d. Both answer a and b are correct.

77. Which one of the containing of Company Maintenance Manual


refer to CASR 121.369 was not:

a. Procedure for the administrative arrangements between the


certificate holder and the approved maintenance
organization;
b. Maintenance procedures and the procedures for
completing and signing a maintenance release;
c. A function to monitor maintenance program effectiveness;
d. Procedure for recording of maintenance carried out
and retention of maintenance record;

78. Refer to CASR 121, Procedures to control, and all amendments


promptly to all organizations or persons to whom the manual
has been issued was:

a. Aircraft Maintenance Manual,


b. Minimum Equipment List,
c. Continuing and Surveillance Analysis
d. Company Maintenance Manual.

79. CASR 121.377:each person who ’s working on PK registered


airplanes performing maintenance or preventive
maintenance functions shall be relieve from duty for a
period of:

a. At least 12 hours during seven days,


b. At least 24 hours during seven days,
c. At least 36 hours during seven days,
d. At least 48 hours during seven days,
80. Refer to CASR 121.3, this part applicable for operator utilizing:

a. Airplanes having a passenger seating configuration of less


than 30 seats.
b. Airplanes having a passenger seating configuration of more
than 30 seats.
c. Airplanes having payload capacity of more than 7,500
kilograms.
d. Airplanes having payload capacity of less than 3,409
kilograms.

81. According to CASR 121.380 the last airframe, engine, propeller


overhaul record shall be retained for:

a. One year after the work performed,


b. Two years after the work performed,
c. Three years after the work performed,
d. Four years after the work performed,

82. Refer to CASR 135.3, this part applicable for operator utilizing:

a. Aeroplanes having a passenger seating configuration of less


than 30 seats.
b. Aeroplanes having a passenger seating configuration of
more than 30 seats.
c. Aeroplanes having payload capacity of more than 7,500
kilograms.
d. Aeroplanes having payload capacity of less than 3,409
kilograms.

83. Refer to CASR 91.411, Altimeter System and Altitude system


must be tested and inspected:

a. Within the preceding 12 calendar months,


b. Within the preceding 18 calendar months,
c. Within the preceding 24 calendar months,
d. Within the preceding 32 calendar months,

84. Aerial work operations stated in CASR 135.3 as:

a. Flight inspection or calibration,


b. Helicopters carrying external loads,
c. Towing of objects,
d. All of above answer are correct
85. According to Aviation Law No.1 Yr 2009, airworthiness mean as:

a. Compliance to requirements on design of aircraft type and in


a safe condition for operation.
b. No defect and safe for operation.
c. A commercial air transportation activity serving air
transportation.
d. An activity using an aircraft for transporting passengers.
86. Refer to CASR 145.55, certificate or rating for AMO located in
the Republic of Indonesia shall remain in force for period:

a. Determined by the DGCA shall not exceed 1 years.


b. Determined by the DGCA shall not exceed 2 years.
c. Determined by the DGCA shall not exceed 3 years.
d. Determined by the DGCA shall not exceed 4 years.

87. Refer to CASR 145.55,for AMO certificate or rating located


outside of the Republic of Indonesia shall remain in force for
period:

a. Determined by the DGCA shall not exceed 4 years.


b. Determined by the DGCA shall not exceed 3 years.
c. Determined by the DGCA shall not exceed 2 years.
d. Determined by the DGCA shall not exceed 1 years.

88. The DGCA may need to issue temporary extension validity of


AMO certificate or rating due to unusual circumstances up to:

a. 30 days extension after the expiration date,


b. 60 days extension after the expiration date,
c. 90 days extension after the expiration date,
d. 120 days extension after the expiration date,

89. Refer to CASR 145.157, certified personnel to approve article


for return to service under AMO certified located in Indonesia,
should be:
a. Understand, reads, and writes English.
b. Trained in safety management system and human factor.
c. Proficient in the use of the various inspection methods,
techniques, practices,
d. All a, b, c are correct.
90. Refer to CASR 145.157, certified personnel to approve article
for return to service under AMO certified located outside
Indonesia, should be:
a. Understand, reads, and writes English.
b. Trained in safety management system and human factor.
c. Proficient in the use of the various inspection methods,
techniques, practices,
d. Licensed and meet the requirement ICAO Annex 1.

91. Refer to CASR 145.55, DGCA issued certificate or rating classes


for AMO located in the Republic of Indonesia as follows:
a. Instrument has 3 classes, propeller has 2 classes.
b. Airframe has 4 classes, power-plant has 3 classes.
c. Radio has 4 classes, propeller has 2 classes.
d. Airframe has 3 classes, accessories has 2 classes.

92. Refer to CASR 145.55, DGCA issued AMO certificate or rating


classes for airframe as follows:
a. Class 1: Combination construction of small aircraft.
b. Class 2: Composite construction of large aircraft.
c. Class 3: Non Metal construction of small aircraft.
d. Class 4: Combination construction of large aircraft.

93. Refer to CASR 145.219, Certificated AMO must have record


keeping specified as:
a. Must retain the records required by this section for at least 1
year from the date the article was approved for return to
service.
b. Must retain the records required by this section for at least 2
years from the date the article was approved for return to
service.
c. Must retain the records required by this section for at least
18 months from the date the article was approved for
return to service.
d. Must retain the records required by this section for at least
36 months from the date the article was approved for
return to service.

94. Refer to CASR 145.55, AMO certificate or rating classes for


instrument as follows:
a. Class 1: Mechanical, a diaphragm, bourdon tube,
aneroid, optical, or mechanically driven.
b. Class 2: A mechanical accessory that depends on friction,
hydraulics, mechanical linkage.
c. Class 3: An electrical accessory that depends on electrical
energy for its operation, and a generator.
d. Class 4: An electronic accessory that depends on the use
of an electron tube transistor.
95. Refer to CASR 145.55, AMO Safety Management Systems
framework for implementation comprises as:

a. Four components and eleven elements as the minimum


requirements.
b. Four components and twelve elements as the minimum
requirements.
c. Five components and twelve elements as the minimum
requirements.
d. Four components and nine elements as the minimum
requirements.

96. Refer to CASR 19.1: Definition, which one of the statement here
under are correct:

a. Mitigation means the assessment, expressed in terms of


predicted probability and severity.
b. Mitigation means the likelihood that an unsafe event
or condition might occur.
c. Mitigation means the possible consequences of an unsafe
event or condition, taking as reference the worst
foreseeable situation.
d. Mitigation means measures to address the potential hazard or
to reduce the risk probability or severity.
b. Mitigation means an integrated set of regulations and
activities aimed at improving safety.

97. Which one of hereunder are NOT including in hazard


identification process steps:

a. Reporting of hazards, events or safety concerns;


b. Collection and storing the safety data;
c. Analysis of the safety data; and
d. Predictive, proactive and reactive.

98. Refer to CASR 145.55 Appendix B, component of Safety


Management Systems framework for implementation as:
a. Safety risk assessment and mitigation.
b. Safety policy and objectives.
c. Safety performance monitoring and measurement.
d. Training and education.
99. According to CASR 19.1: Definition, which one of the statement
here under are correct:

a. Predictive means the adoption of an approach where


safety measurement is as a responds to the events
that already happened, such as incidents and accidents.
b. Predictive means a method that captures system
performance as it happens in real-time normal operations.
c. Predictive means the adoption of an approach which
emphasizes prevention through the identifi cation of
hazards and the introduction of risk mitigation measures
before the risk-bearing event occurs and adversely affects
safety performance.
d. Predictive means that safety management activities will
be conducted in accordance with a pre-determined
plan, and applied in a consistent manner throughout the
organization.

100. According to CASR 19.1: Definition, which one of the statement


here under are correct:
a. Management System (SMS) means the state in which the
risk of harm to persons or property damage is reduced to,
and maintained at or below, an acceptable level
through a continuing process of hazard identification
and risk management.
c. Safety Management System (SMS) means a systematic
approach to managing safety, including the necessary
organizational structures, accountabilities, policies and
procedures.
d. Management System (SMS) means organized set of
processes and procedures.
c. Management System (SMS) means what the service
providers do with regard to safety performance monitoring
and measurement.
d. Management System (SMS) means a systematic analysis of
a proposed change to equipment or procedures to identify
and mitigate weaknesses before change is implemented.
101. Safety performance monitoring and measurement means
shall include the following:

a. Safety reporting; Sa fe ty a udits ;


b. Sa fe ty s urve y s ; Sa fe ty re vie ws ;
c. Safety studies; internal safety investigations.
d. All a, b and c answer are correct.

You might also like