Professional Documents
Culture Documents
NOTE: Bolting long enough to reach only through the compressor foot and a deck plate or
flange of an I-beam can loosen if not provided with engineered devices to maintain bolt pre-
load.
a. For JGT compressors with ET crosshead guides, use 7/8”–9 TPI size in TABLE 1
as the minimum torque.
Imperial Size
Metric Size (Class 8.8) c
Foot Hold- Hole (basis 100,000 psi)
Compressor
down Bolt Diameter Recom. Min. Nut Recom. Min. Nut
Model
Application b inch (mm) Stud Size Torque e Stud Size d Torqued
inch--TPI lb-ft (N•m) mm x pitch lb-ft (N•m)
M20x2.5 250 (340)
M36x4 1500 (2030)
The contents of this document are proprietary and confidential. They are the property of Ariel Corporation and may
not be disclosed, reproduced, or used for manufacture in part or in whole without written permission from Ariel
Corporation.