z=Total speed steps(speeds) on spindle Certain progressions GP gives optimum distribution of Variation in diameters incase of GP is Gear speeds compared to AP not as wide as AP q=similar speed steps P1=P2 i.e two speed steps are similar q=2 12 N12=445=nmax 14.2 Ø must be constant It is Possible in GP only Loss in Economical cutting speed is constant in GP R: In honour the Engineer Charles Renard Gearing Diagram Gear Box Layout Minimum difference between teeth of Adjacent Gears must be 4 4 ≤ [Z2 ̶ Z1 ] OR 4 ≤ [ Z2 ̶Z3] Number of teeth for Z=6 No change in gear ratio Change in gear Ratio Gc=0.634 Ge=1.59 Problem 02 Z=9