You are on page 1of 1

Good afternoon Mr. Efry and friends all.

I will here convey how to change oil properly.

So, the steps that must be done are:

1. Rest the motorcycle on the side standard so that it can come out until it runs out.

2. Open the oil dump screw located at the bottom of the engine while removing the oil filter.

3. Empty the oil that comes out with a container.

4. Open the measuring bolt from the filling hole.

5. Step on the kick starter repeatedly and exhale using the compressor in the filling hole so that

the remaining oil can be wasted.

6. Clean the oil filter.

7. Clean the oil filter rotor before filling the engine with oil regularly.

8. Replace the oil filter and oil cap cover bolt.

9. Fill the crankcase with recommended oil and match the type of motor.

10. Install the measuring bolt.

11. Stationary turn on the engine and leave it for several minutes.

12. Turn off the engine and lean the motorcycle in an upright position.

13. Check and make sure the oil level is at the upper limit

So what i said, i think it's enough. Finished and thank you.

You might also like