Professional Documents
Culture Documents
Presented by:
BEZALEEL C. GONZALES
JAXL JOHM P. HILARIO
CLOUIE A. MAGNAYE
DANNY N. OXINA
March 2019
i|P ag e
APPROVAL SHEET
This design entitled “Enterprise Passive Optical LAN for Rizal Technological University –
Boni (RTU-BONI)” has been presented by Gonzales, Bezaleel C., Hilario, Jaxl Johm P.,
Magnaye, Clouie A., Oxina, Danny N.
Approved by:
Approved and accepted as Partial Fulfilment of the requirements for the Degree of Bachelor of
Science in Electronics and Communications Engineering by the distinguished members of the
committee of the oral examiners with a grade of ________
ii | P a g e
THE COMPANY
COMPANY PROFILE
MISSION
Lux FiberTech Inc. is committed to provide a good quality of services, reliability and
credibility to its clients. The company always seeks what is new so that the technology itself will
continue to improved and always be updated. The infrastructures, cable lining and all other
engineering parameters is well-designed to ensure that there would be no casualties and to prevent
any possible errors.
VISION
Lux FiberTech Inc. envision is to be the preferred partner when solving complex telecom
network challenges and continue to be a sovereign company serving the desires of telecom network
operators and managements.
iii | P a g e
DEDICATIONS
“Failures are part of life. If you don’t fail, you don’t learn. If you don’t learn, you will never
change.” – Anonymous -
To each one of us whose knowledge, efforts and sacrifices are given in the fullest.
To those people who believe that we can do it and to those who support us when we are feeling
down.
iv | P a g e
ACKNOWLEDGEMENT
This thesis will not be accomplished without the support of others. We would like to express our
sincere gratitude to all of them.
For our instructor, Engr. Julius Mabanglo, who give their full support, guidance and knowledge
of information for the entire thesis period.
For the members of panels who make their presence despite of their schedule and support us by
their comments and evaluations that help us to improve our work.
For our friends and for those people who share their knowledge and experienced about the study.
And also to our Almighty God who gave us the strength, courage and wisdom to comply with the
prescribed requirement of this particular
v|Page
ABSTRACT
In this time of our life, technology development is at its finest. Discovering new things,
innovations through the designs, concepts and ideas are now bloom in our world. In signal
transmission, innovation is already made possible. One of these is the use of Optical Fiber, a high
bandwidth, electromagnetic interference immune, and long-distance transmission medium.
With the use of Optical Fiber in the designs, different development can achieve. It can help
particularly in network designs and also it can provide much faster and more reliable signal
transmission than the others. The proponents designed a Passive Optical LAN technology covering
the Rizal Technological University at Boni, Mandaluyong City. The designers surveyed the area
to discover its sophistication and the need of data signal transfer. To confirm the feasibility of the
design, we had done a series of calculations and deep analysis involving demand forecasting,
transmission loss calculations, the network layout and others. And also, to make this design more
understandable and more accurate, we use the floor plan of the university and also equipment
specifications are included.
This also scopes the design procedures, major considerations, necessary computations and
equipment being used. Data and illustrations are enunciated into chapters for clear visualization
and comprehension of the design.
vi | P a g e
TABLE OF CONTENTS
PAGE
Front Page i
Approval Sheet ii
The Company iii
Dedication iv
Acknowledgement v
Abstract vi
Table of Content vii
CHAPTER
I. OVERVIEW OF THE DESIGN 1
Introduction 1
Objectives 3
Scopes and Delimitations 3
Significance of the Study 4
Definition of Terms 5
vii | P a g e
III. OVERVIEW OF THE SITE 13
Rizal Technological University Boni Campus (RTU-BONI) 13
Site Location 17
Network Architecture (Existing) 19
Network Architecture (Proposed) 20
V. SUMMARY RECOMMENDATION 96
Recommendation 96
Conclusion 99
viii | P a g e
OVERVIEW OF THE DESIGN
INTRODUCTION
Every day the demand for faster and cheaper telecommunications services rises and rises.
Companies around the world are clamoring for a strong internet service to transfer large volumes
of data at the cheapest price available in the market. Passive Optical LAN (POL) is now the latest
way to structure a telecommunications network for companies around the world. It replaces
traditional structured cabling, which consists of numerous levels of switch, router and hubs, which
tends to be problematic. More and more companies are now switching to POL.
POL is a more cost effective and energy efficient alternative. POL uses a different
architecture with single-mode fiber extended closer to the user and electronic devices that flatten
the Local Area Network, eliminating distance constraints and reducing the quantity of cable to the
workstations.
A Passive Optical LAN offers significant capital and operational benefits. Beyond financial
savings, the long-term value proposition is what makes POL so compelling to the hospitality
vertical.
The Optical Line Terminal (OLT) resides in the datacenter or core network. It connects to
the core switch using traditional Ethernet pluggable. The Passive Optical Splitters connect to each
PON port and replicate traffic downstream (to the end user’s ONT) while combining end user
traffic in the upstream direction. The ONT serves as the end user interface to the network.
1|P ag e
Figure 1: Traditional LAN vs Passive Optical LAN
Passive Optical LAN architectures provide tremendous improvements in the design and
deployment of local area networks. Composed almost entirely of single mode fiber optic cable, a
Passive Optical LAN can span for 20 km (12.5 miles) or more depending on the optics and
splitter ratios deployed. While not all networks may need to span such distances, it is particularly
advantageous for multi-story buildings and campus networks where mid-span switching
equipment is eliminated entirely. Even single building networks can take advantage of these
flexible distances by no longer requiring a telecommunications closet or switch every 300 feet as
is the case with legacy network architectures. (Passive Optical LAN Overview & Benefits)
2|P ag e
General Objective:
Specific Objective
standard
Scope
The design aims to apply the theoretical concepts of Standard Structured Cabling.
3|P ag e
The design includes the costing and is stipulated under the Bill of Materials.
Delimitation
The design did not consider the actual setup and configuration of each equipment.
The design did not consider Electrical and power layout system.
To help them understand the concept, theories and anything related to Passive Optical
Network.
The outcome of the study will help the instructors to develop effective strategies and
The research design will set as a future reference that could give them an
For RTU-BONI
4|P ag e
DEFINITION OF TERMS
Access Protocol – the methods of communication used by the equipment located at the ends of
the optical paths to ensure reliable and effective transmission and reception of information over
Bandwidth - is the difference between the highest usable frequency of a device (upper frequency
limit) and the lowest usable frequency of the device (lower frequency limit).
Baseband - is a system whose range of frequencies is measured from close to 0 hertz to a cut-off
frequency; a maximum bandwidth or highest signal frequency. Bit-is the smallest unit of
Communication - is a process whereby information is transferred from one point in space and
time, called the source, to another destination or user. The exchange of thoughts, messages or
Communication System - is the totality of mechanism that provides information link between
5|P ag e
Core - of a conventional optical fiber is a cylinder of glass or plastic that runs along the fiber's
length.
CPE (Customer Premises Equipment) - is any equipment either owned by the customer or the
Demarcation Point- a point established in a building to separate customer equipment from service
provider equipment.
IP Camera - a type of digital video camera that receives control data and sends image data via
the Internet. They are commonly used for surveillance. Unlike analog closed-circuit television
(CCTV) cameras, they require no local recording device, but only a local area network. Most IP
cameras are webcams, but the term IP camera or netcam usually applies only to those used for
6|P ag e
ISP – or an Internet Service Provider is a company that provides customers with Internet access.
Data may be transmitted using several technologies, including dial-up, DSL, cable modem,
Local Area Network- is a computer network that interconnects computers within a limited area
Optical Line Terminal- it is a device used which serve as the service provider of the passive
optical network.
Optical Network Terminal- enables optical to electrical conversion and Ethernet connectivity for
voice, video, data, Wi-Fi and all other digital enterprise services and devices.
NVR Poe Controller- is an electronic device used to control the network video recorder which
provides you with centralized video controls to easily view, manage, and store your surveillance
Private Branch Exchange - is a telephone system within an enterprise that switches calls
between enterprise users on local lines while allowing all users to share a certain number of
Passive Optical LANs- is a fiber-based IT infrastructure that combines the best of standards-
based Gigabit Passive Optical Network (G-PON) and advanced enterprise Ethernet technologies.
7|P ag e
Passive Optical Splitter- provide the point-to-multipoint connectivity between the OLT and the
ONTs.
Public old telephone service- is a retronym for voice-grade telephone service employing analog
signal transmission over copper loops.it was commonly used in home service and has a network
based on PSTN.
Router – is a device that forwards data packet along the network. It connects LAN segments
Single Mode Fiber- is the optical cabling that runs throughout the building’s risers and
pathways. It is the SMF that physically connects the OLT, splitters and ONTs.
Wireless Access Point- is a networking hardware device that allows other Wi-Fi devices to
Wide Area Network – are used to connect remote LANs together that may cover a city or
country. It was owned by a service provider such as PLDT, Globe or any telecommunication
companies.
8|P ag e
DESIGN CONSIDERATIONS
Telecommunication Equipment
Equipment considered being able to integrate the existing POTS Network to VoIP
The location of the ONU is inside the wall mounted enclosure and located near
Equipment Room
Equipment rooms should not be exposed to excessive heat or direct sunlight and
subjected to water infiltration; must not be co-located with any electrical and/or
mechanical rooms; and shall not be located directly adjacent to all the cited
At least one rack free be provided for the new equipment and should be securely
9|P ag e
Horizontal Cabling Distribution
The maximum length allowed for single fiber mode is 3000 meter based on
TIA/EIA 568-C.3
100 ohm UTP (24 or 22 AWG) 800 meters (2625 ft) Voice*
150 ohm STP 90 meters (295 ft) Data*
Multimode 62.5/125 µm optical fiber 2,000 meters (6560 ft)
Single-mode 8.3/125 µm optical fiber 3,000 meters (9840 ft)
Table 1: Maximum allowable distance for cables
topology.
from humidity levels and condensation and are separated from power cables.
10 | P a g e
- For main intra-building backbone distribution, CAT6/CAT5e UTP cables
were used.
Telecommunication Closet
Telecommunication closet is the area within a building that protects the
between the horizontal and backbone cabling system. It was based on EIA/TIA 569 standard.
o Twice the size of a data/telecommunications closet allowing for future double growth
rate.
o There must be different pathways for electrical wiring and structured cabling.
– Adequate cooling.
11 | P a g e
– Natural airflow between hot & cold aisles.
Building Entrance:
The physical requirements for building facilities was based on EIA/TIA 568/569
standard:
o The location is near the vertical backbone and horizontal distribution pathways.
Structured Cabling:
a) Floor-based distance is the reflected distance of the cable when looking at the floor plan.
for the length to be consumed on switch connection, host connection, and LAN outlet
connection.
12 | P a g e
OVERVIEW OF THE SITE
Philippines. It was established on July 11, 1969 as the College of Rizal under the administration
of the University of Rizal System (URS) before it separation from it on 1975. RTU is the first
educational institution in the country to utilize Cooperative Education as a curriculum plan which
is recognized by various industries, businesses and agencies all over the country.
History
The RIZAL TECHNOLOGICAL UNIVERSITY (RTU) was established on July 11, 1969
upon the approval by the Secretary of Education in response to the utmost request of the Provincial
Board of Rizal, headed by the Governor Isidro S. Rodriguez, to put up a higher education
institution in the Province of Rizal. It was first known as the College of Rizal.
13 | P a g e
The promulgation of P.D. No. 751 on July 25, 1975 amended certain provisions of P.D. No. 674
and made the operation and maintenance of the Rizal Technological Colleges a joint project and
undertaking of the Provincial Government of Rizal and the MERALCO Foundation, Incorporated.
The College of Rizal opened its classes on July 14, 1969 with course offerings in business
administration, education and liberal arts. On March 20, 1975, the College of Rizal in Pasig and
Rizal Technical High School in Mandaluyong, both situated in the Province of Rizal, were merged
and converted into the Rizal Technological Colleges by the virtue of Presidential Decree (PD) No.
674 The decree authorized the expansion of curricular programs and promotion of researches in
This Decree broadened the support and strengthened the organization of the College. In
1975, upon the establishment of the Metropolitan Manila Commission, Pasig was transferred to
the territorial jurisdiction of the MMC. The Province of Rizal could not continue supporting
financially the Colleges. Several alternatives were proposed to save the RTC. One was to transfer
the management and administration of the RTC to one of the existing towns in the Province of
Rizal or Metropolitan Manila. The worst possible alternative was to phase out the Colleges. The
leadership, the faculty, and the studentry of the Colleges would not allow this to happen, however,
Through the support of then Metropolitan Manila Governor Madam Imelda Marcos, the
RTC constituency, with the Kabataang Barangay School Chapter of the RTC led by Dr. Jesus
Rodrigo F. Torres, and the Collegiate and High School Faculty Clubs at the forefront of the
14 | P a g e
struggle for survival, President Ferdinand E. Marcos signed into law Presidential Decree 1341-A
on April 1, 1978 converting the Rizal Technological Colleges into a State College.
The decree, however, was received only on October 13, 1978; thus, the RTC has been
celebrating its College Week, and later its University Week on the days centered on October 13.
After 19 years, the College was converted into the Rizal Technological University on October 11,
special instructions in the fields of engineering and technology, education, business and
entrepreneurial technology, and the programs; and promote research, extension and advance
studies in its areas of specialization. Through its Cooperative Education Program, it shall continue
to lead in the provision of work- integrated learning through partnership with industry and
involvement of students in civic activities. Today, RTU has six campuses. The main campus is
Other campuses are situated in Barangay San Miguel, Pasig City; Barangay San Roque,
Antipolo, Rizal; Barangay San Salvador, Baras, Rizal; Kawit, Cavite; and Palauan, Occidental
Mindoro. RTU is the first state university in Mandaluyong City and Pasig City, Metro Manila and
in the provinces of Rizal and Occidental Mindoro. The University has been placed under the
stewardship of six administrators: As College of Rizal – Dr. Jose M. Singson, Executive Dean
(1969); Dr. Marcial Renosa, Acting Executive Dean (1969-1974); and Dr. Lydia M. Profeta,
15 | P a g e
As Rizal Technological Colleges (locally funded) – Dr. Julio Balmes, Officer-in-Charge
(1975-1976) and Dr. Lydia M. Profeta, Executive Dean (1976-1978). As Rizal Technological
Colleges (state college, nationally funded) – Dr. Lydia M. Profeta, Acting President (1979-1986);
Dr. Josefina V. Estolas, Officer- in- Charge (1986-1987) and College President (1987-1993), Dr.
University President (1997 to date), Dr. Jesus Rodrigo F. Torres Second University President.
Today, RTU has the distinction of being the first educational institution in the Philippines to utilize
Aside from being the pioneer of several innovative academic programs in the Philippines,
Control Technology, the University has established itself as National Instrumentation and Control
Center and Welding and Research Training Center. It also has been the pilot school of Technology
Resource Center under the Ministry of Human Settlements and now a member of the school
network implementing the Engineering and Science Education Program (ESEP) of the Philippines.
The functions and services of RTU are not confined to instruction alone as it is has shifted
to full gear towards the enhancement of its research and development programs and continued to
pursue the policy of sharing its expertise and resources with the community through its non-formal
16 | P a g e
At present, RTU rises as a state university that will unceasingly fulfill its mission, vision, goals
https://www.rtu.edu.ph/?page_id=16.
Site Location
Address: 704 Boni Ave Cor Sacrepante, Mandaluyong, 1550 Metro Manila
Polar Coordinates: Latitude 14°34'27.16"N Longitude 121° 2'31.13"E, image captured via Google
Earth (Satellite)
17 | P a g e
Figure 4: RTU-Boni Vicinity Map via Google Maps Image
18 | P a g e
NETWORK ARCHITECTURE (EXISTING)
19 | P a g e
NETWORK ARCHITECTURE (PROPOSED)
20 | P a g e
DESIGN CALCULATIONS
This chapter presents the several computation methods by the proponents for their
telecommunication design for RTU. It is subdivided into five sections, namely the
The data are presented in tabular form and presents relevant details such as existing
equipment facilities, the number of calls held per week, call duration summary and number of
ports used.
The data gathered are used to compute the bandwidth requirements for voice, video, data and
wireless.
1 3 1 11 6 21
2 1 3 11 3 18
MAB 3 4 4
4 5 5
5 1 1 1 5 8
21 | P a g e
1 5 5 67 1 5 83
2 22 7 59 3 4 95
ITB 3 1 2 18 1 22
4 2 1 1 4
5 2 2
1 1 13 13 27
2 4 17 1 4 26
ITC 3 1 10 1 16 28
4 1 10 11
5 0
1 2 2 6 10
2 3 9 5 17
3 6 12 5 23
RND 4 4 21 1 5 31
5 5 5
6 1 32 1 5 39
7 1 1
1 1 1
2 21 21
TED 3 53 53
4 1 1
5 0
22 | P a g e
6 0
7 0
8 2 4 1 7
9 0
10 3 1 4
1 4 1 9 0 7 21
OB 2 3 1 17 6 7 34
3 4 4
The greatest number of equipment used are the personal computer comprising about sixty
five percent of the total equipment. There is currently a total of 626 telecommunications equipment
in RTU.
1 4 11 6 24
MAB
2 4 11 7 25
23 | P a g e
3 3 7 10
4 6 9
5 2 1 6 12
1 10 67 9 89
2 29 59 6 96
ITB 3 3 18 2 7 30
4 2 7 11
5 7 7
1 1 13 13 30
2 4 17 2 12 36
ITC 3 1 10 16 30
4 1 2 18 22
5 6 9
1 2 2 6 12
2 3 9 2 5 19
3 6 12 5 25
RND 4 4 21 5 32
5 2 5 5
6 1 32 5 40
7 5 7
SENAGAH 1 1 6 9
(TED) 2 21 4 27
24 | P a g e
3 53 2 4 59
4 1 4 7
5 4 6
6 2 4 6
7 4 6
8 2 4 4 12
9 2 4 6
10 3 4 9
11 2 5 7
1 4 9 12 34
OB 2 4 17 3 10 39
3 7 15
This is the summary of the proposed equipment for RTU. The biggest difference is the
upgrade of analog phones to VOIP phones. There is also an increase in WAP units and IP cameras
25 | P a g e
CALL SUMMARY
TIME M T W H F S
7:00 AM - 8:00 AM 5 6 5 2 5 0
8:01 AM - 9:00 AM 45 24 25 27 43 0
9:01 AM - 10:00 AM 50 38 32 41 42 3
10:01 AM - 11:00 AM 45 32 34 35 36 4
11:01 AM - 12:00 PM 23 28 25 33 27 1
12:01 PM - 1:00 PM 7 8 12 6 11 0
1:01 PM - 2:00 PM 27 25 19 32 27 1
2:01 PM - 3:00 PM 38 32 37 22 32 2
3:01 PM - 4:00 PM 31 25 30 27 41 1
4:01 PM - 5:00 PM 38 27 19 18 36 0
5:01 PM - 6:00 PM 18 10 10 13 28 0
6:01 PM - 7:00 PM 5 5 9 7 8 0
7:01 PM - 8:00 PM 4 4 3 4 4 0
8:01 PM - 9:00 PM 2 5 4 5 3 0
9:01 PM - 10:00 PM 2 1 2 2 3 0
Table 4.3: Number of Incoming and Outgoing Calls of RTU per week.
The table shows the busy hour call happens on Monday, 9:00-10:00am with 50 calls held.
26 | P a g e
Call Duration Summary (Mins)
TIME M T W H F S
7:00 AM - 8:00 AM 20 22 25 26 2 0
8:01 AM - 9:00 AM 81 36 51 33 52 0
10:01 AM - 11:00 AM 96 71 64 40 61 12
11:01 AM - 12:00 PM 75 77 50 70 59 5
12:01 PM - 1:00 PM 7 8 12 6 11 0
1:01 PM - 2:00 PM 53 55 12 14 75 5
2:01 PM - 3:00 PM 67 69 15 10 96 10
3:01 PM - 4:00 PM 77 11 16 18 65 4
4:01 PM - 5:00 PM 40 27 21 18 74 0
5:01 PM - 6:00 PM 50 10 10 13 28 0
6:01 PM - 7:00 PM 5 5 9 7 8 0
7:01 PM - 8:00 PM 4 4 3 4 4 0
8:01 PM - 9:00 PM 2 5 4 5 3 0
9:01 PM - 10:00 PM 2 1 2 2 3 0
Table 4.4: Duration of Incoming and Outgoing Calls of RTU per week.
The table shows the busy hour call has a duration of 120 minutes which assumes that there are
27 | P a g e
BANDWIDTH CALCULATIONS
This section shows the bandwidth required for voice, video and data services. These were also
computed using online bandwidth calculator such as Erlang.com. The computed bandwidth
determines what subscription will be availed from the ISP provider/s. This section is divided into
Coding
Bandwidth Quality Complexity Delay
Algorithm
5.6kbps
G.723.1 Good Very high 37.5ms
6.4kbps
28 | P a g e
Bandwidth
Service
(Mbps)
Bandwidth per computer = 0.3Mbps (Based on average online applications download speeds like
Total Bandwidth for data = (395) (0.3Mbps) = 118.5 Mbps (For estimation purposes)
Bandwidth
Service
(Mbps)
Data 120
Total Bandwidth for Access Point = (24) (5 Mbps) = Mbps (For estimation purposes)
29 | P a g e
Bandwidth
Service
(Mbps)
Overall Bandwidth = 6.8 Mbps + 120 Mbps + 120 Mbps = 246.8 Mbps (For estimation
purposes)
Voice 6.8
Data 120
Total 246.8
Actual
Bandwidth to be 250
considered
30 | P a g e
IP SUBNETTING
The following were the computations to determine the number of subnet masks to be used in a
private IP address. The various servers are also reflected in the succeeding tables.
The total number of hosts is 2046. The Subnet mask used is also: /21
PC VLAN IP address
The total number of hosts is 395. The Subnet mask used is: /23
The total number of hosts is 245. The Subnet mask used is: /24
31 | P a g e
The total number of hosts is 85. The Subnet mask used is: /25
No. of Host IP
VLAN Name CIDR Subnet Mask address
available
SIP SERVER VLAN 255.255.255.252
DHCP VLAN 255.255.255.252
DNS VLAN 255.255.255.252
FTP VLAN /30 255.255.255.252 2
WEB SERVER VLAN 255.255.255.252
DATA BASE SERVER
255.255.255.252
VLAN
MC SERVER VLAN 255.255.255.252
VOICE VLAN /25 255.255.255.128 126
VIDEO VLAN /24 255.255.255.0 254
PC VLAN /23 255.255.254.0 510
WIRELESS VLAN /21 255.255.248.0 2046
Table 4.10: Subnet Mask Determination
No. of
VLAN
VLAN Name End IP Address/Range Host Adress/es Range
ID
Users
10 SIP SERVER VLAN 192.168.10.0/30 192.168.10.1
11 DHCP VLAN 192.168.11.0/30 192.168.11.1
12 DNS VLAN 192.168.12.0/30 192.168.12.1
13 FTP VLAN 1 192.168.13.0/30 192.168.13.1
14 WEB SERVER VLAN 192.168.14.0/30 192.168.14.1
DATA BASE SERVER
15 192.168.15.0/30 192.168.15.1
VLAN
16 MC SERVER VLAN 192.168.16.0/30 192.168.16.1
192.168.20.1-
20 VOICE_VLAN 85 192.168.20.0/25
192.168.20.126
192.168.30.1-
30 VIDEO_VLAN 245 192.168.30.0/24
192.168.30.254
192.168.40.1-
40 PC_VLAN 395 192.168.40.0/23
192.168.41.254
192.168.54.1-
50 WIRELESS_VLAN 2046 192.168.50.0/21
192.168.61.254
32 | P a g e
LINK POWER BUDGET CALCULATIONS
We proponents employ the Class B+ system budget loss based on the OLT equipment compliance
with ITU-G.984.2 standard. It computes the farthest distance of fiber optic cable deployment from
OLT to the ONU. The attenuation or fiber light loss must be considered to know if the system has
Data Gathered:
o 1310nm:0.34dB/km
o 1490nm:0.21dB/km
o 1550nm:0.20dB/km
33 | P a g e
Calculating the optical power link budget allowance per the standards involves the
following steps:
1. Calculate optical fiber loss at the 1310, 1490 and 1550 nanometer (nm) wavelength.
5. Include the loss of the connector at the end of the channel (and optical fiber patch cords).
ODN Losses = Connector Loss + Splitter Loss + Splice Loss + Cable Attenuation
System Margin = ONT Laser Diode Output – OLT Detector Sensitivity – OLT Received Power
34 | P a g e
Power Link Budget for 1490nm (downstream)
ODN Losses = Connector Loss + Splitter Loss + Splice Loss + Cable Attenuation
System Margin = ONT Laser Diode Output – OLT Detector Sensitivity – OLT Received Power
ODN Losses = Connector Loss + Splitter Loss + Splice Loss + Cable Attenuation
System Margin = ONT Laser Diode Output – OLT Detector Sensitivity – OLT Received Power
35 | P a g e
Tabulated Data for 1310nm
Terminal
Optical Splitter
Splice Fusion
Telecommunication
Patch
Room
Cable/SMF 270km 0.34dB/km 0.0918dB
9/125um
Network SC
Unit
36 | P a g e
Equipment Optical Connector 1
Terminal
Optical Splitter
Splice Fusion
Telecommunication
Patch
Room
Cable/SMF 270km 0.21dB/km 0.0567dB
9/125um
Network SC
Unit
Terminal
37 | P a g e
1:8 10.5 10.5dB
Optical Splitter
Splice Fusion
Telecommunication
Patch
Room
Cable/SMF 270km 0.20dB/km 0.054dB
9/125um
Network SC
Unit
1310nm 18.2082dB
1490nm 18.2433dB
1550nm 18.246dB
38 | P a g e
AUTO CAD DESIGN LAY-OUT
39 | P a g e
ITB 3RD FLOOR
40 | P a g e
ITB 5TH FLOOR
41 | P a g e
ITC 2ND FLOOR
42 | P a g e
ITC 4TH FLOOR
43 | P a g e
MAB 1ST FLOOR
44 | P a g e
MAB 3RD FLOOR
45 | P a g e
MAB 5TH FLOOR
OB 1ST FLOOR
46 | P a g e
OB 2ND FLOOR
OB 3RD FLOOR
47 | P a g e
RND 1ST FLOOR
48 | P a g e
RND 3RD FLOOR
49 | P a g e
RND 5TH FLOOR
50 | P a g e
RND 7TH FLOOR
51 | P a g e
SENAGAH 2ND FLOOR
52 | P a g e
SENAGAH 4TH FLOOR
53 | P a g e
SENAGAH 6TH FLOOR
54 | P a g e
SENAGAH 8TH FLOOR
55 | P a g e
SENAGAH 10TH FLOOR
56 | P a g e
SINGLE LINE DIAGRAM - ITC
57 | P a g e
SINGLE LINE DIAGRAM – OB
58 | P a g e
SINGLE LINE DIAGRAM - RND
59 | P a g e
INTERCONNECTION OF BUILDINGS DIAGRAM
60 | P a g e
Data Center and Equipment Room
Product Description:
The MA5603T functions as an optical line terminal (OLT) in a GPON network to work with the
optical network unit (ONU) and optical network terminal (ONT).
Specification:
61 | P a g e
Extinction Ratio 10dB
Conductor Material BC
62 | P a g e
Waterproof LAN cable Single Jacket or double jacket
Product Details:
100% compatibility with Cisco SFP-GE-T guaranteed
Uses a cost-effective cabling alternative to fiber-optic set ups
SFP modules are backed by a lifetime warranty
Product Specifications:
Maximum Data Transfer Rate: 1.25 Gbps
Type: Copper
Connection Type: RJ45 Connector
Maximum Transfer Distance: 100 m (328 ft)
MTBF: 4,655,371 hours
Power Consumption: Less than 1.3 Watts
Digital Diagnostics Monitoring (DDM): No
63 | P a g e
Hikvision DS-7732NI-14/16P 32 Channel POE NVR
64 | P a g e
Instant playback for assigned channel during multi-channel display
mode
Product Details:
65 | P a g e
RJ45 Plug
Product Details:
RJ45 connectors terminate the ends of 10BT patch cable 50-micron gold-plated contacts
for optimum data transmission. Save money by using these connectors to create your own patch
cables Color clear.
TELECOMMUNICATION OUTLET
Product Details:
- 6176 - dual telephone / dual universal network socket outlets (RJ45/RJ12/RJ11).
66 | P a g e
IBM BLADECENTER HX5 (FILE/DATA SERVER OR SYSTEM SERVER)
Product Details:
Components Specification
I/O expansion slots Single node: One CIOv connector (two ports) and one CFFh
connector (four ports)
Two nodes: Two CIOv connectors (two ports each) and two
CFFh connectors (four ports each)
Single node + MAX5: One CIOv connector and one CFFh
connector (four ports)
Disk bays (total/hot Two non-hot-swap bays per single-wide HX5 - supporting
swap) solidstate drives
67 | P a g e
Maximum Up to 800 GB of solid-state storage per single-wide HX5 (with
internal storage 400 GB SSDs)
Network interface Broadcom 5709S onboard NIC with dual Gigabit Ethernet ports
with TOE
Some models: Emulex Virtual Fabric 10Gb Expansion Card
(CFFh)
RAID support Optional RAID-0, -1, -1E
Systems management Integrated systems management processor
OS support Microsoft Windows, Red Hat Linux, SUSE Linux, VMware
Limited warranty Three-year customer-replaceable unit and onsite limited
warranty
Product Details:
Switching: Non -blocking
Power Voltage: AC 100V ~ 240V AC
Adapter Memory Back-Up Duration: 7 Years
Dialing CO Lines DP :(10pps, 20pps)
DTMF Extension DP :(10pps, 20pps)
DTMF Connectors: CO Line RJ11 (2 wire) x each CO Port Station RJ11 (4 wire) x each
Extension Port Paging Output 1 Jack Ring Frequency 20/25 Hz (Selectable) Central Office
Loop Limit 1600 ohms max.
Operating Environment Temperature: 0˚ - 40˚C, 32˚ - 104˚F
Humidity: 10% - 90%
Conference Call Trunk: 3-Party x 10
Conference Calls: 8-Party x 4
68 | P a g e
Conference Calls Music On Hold (MOH): 1 Port
Selectable Tone/External Music Source (Level control: -6dB ~ + 6dB per 3dB)
External MOH (Music On Hold) 1 Port (Level control: -6dB ~ + 6dB per 3dB)
Internal Paging Level control: -6dB ~ + 3dB per 3dB
External Paging 1 Port (Level control: -15dB ~ + 6dB per 3dB)
Interface Ports USB: 1 Port RS232C: 1 Port
Dimensions :(H x W x D) 14.8" x 10.8" x 4.6" (275 x 376 x 117 mm)
Weight: (when fully configured) 7.7 Lbs. (3.5 kg)
Maximum Capacity
Trunk Ports: 8
Extension Ports :24
Single Line Telephones :24
Analog Proprietary Telephones and DSS Console KX-T7700, 7300 and 7000 Series: 24
Cell Station: (KX-T0141) 4
Voice Processing System: 4 Ports (1 system)
Wireless Telephones (KX-TD7680 and KX-TD7690): 28
Door-phones: 4
Product Description:
ETP4830-A1 can convert 220 V input to stabilized to 48 V DC output. It can also be
configured with 48 V/15 A rectifiers and provide 30 A output. All the function units have
standard sized design with 1U.
ETP4830-A1 can be embedded in 19 inch rack or cabinet or other scenarios. The system
can provide excellent performance such as intelligent battery management, remote
monitoring, etc.
69 | P a g e
Features:
Product Details:
Hardware:
WAN Speed : 400Mbps
Firewall Performance: 1.9Gbps
Device Switching Capacity: 32Gbps
Slot Switching Bandwidth: SIC slots (slot 1,3) 2 G bps SIC slots (slot 2,4) 5Gbps WSIC slots
5Gbps XSIC & EXSIC s lots 20Gbps
Fixed WAN Port: 3xGE (1xcombo port)
SIC Slots:4
WSIC Slots: 2 to 4
DSP Slot:1
Serial auxiliary/ console port: 1
Memory: 2Gbps/4Gpbs
Maximum Power: 60 watts
AC power: 100-240VAC
Frequency:50/60Hz
70 | P a g e
DC Power: -48-60VDC
Software:
Basic Features: DHCP server/client, PPPoE server/client, PPPoA client, PPPoEoA client,
NAT, Subi nterface management
Voice: RTP, SIP, SIP AG, IP PBX/TDM PBX, FXO/FXS, VoIP/conference call, BEST, DISA,
SBC, H.323 gatekeeper
3G : CDMA 2000EV-DO Rev A, WCDMA, individual 3G uplink/backup link
LTE: FDD LTE: Uplink: 50Mbps Downlink: 100Mbps
LAN: IEEE 802.1P, IEEE 802.1Q, IEEE 802.3, VLAN and MAC address management, MSTP
Security: ACL, firewall, 802.1x authentication, MAC address authentication, Web
Authenticatio n, AAA authentication, RADIUS authentication, HWTACACS
authentication, broadca st storm suppression, ARP security, ICMP attack defense, URPF,
IP Source Guard, DHCP snooping, CPCAR, blacklist, IP source tracing
71 | P a g e
Wireless Controller
Product Details:
Hardware Specifications:
72 | P a g e
Software Specification:
73 | P a g e
Product Details of Cisco ASA 5550 Firewall
74 | P a g e
HUAWEI e-Space U1960 used in PSTN and SIP trunks
Product Details:
Item Specification:
75 | P a g e
Backbone Connection
Product Description:
The Smart-AX MA5603T Multi-service Access Module is a GPON a medium-capacity access
product launched by Huawei Technologies Co., Ltd. The MA5603T provides the data, voice, and
video services that feature large capacity, high rate and high bandwidth. To be specific,
The MA5603T functions as an optical line terminal (OLT) in a GPON network to work with the
optical network unit (ONU) and optical network terminal (ONT).
76 | P a g e
Specification:
77 | P a g e
CONDUIT
78 | P a g e
Key Features
Low insertion loss
Corrosion resistant body
Precision mechanical dimension
Meets Telecordia-GR-326-CORE specifications
Ultra low back reflection
One Piece with pre-domed ceramic ferrule is designed for easy assembly
Fixed key and activity key can be selected
For 3.0mm, 2.0mm jacket or 900um buffer
ROHS compliant
Applications
Telecommunication
LAN & WAN
Broadband CATV
Network
FTTX.
Specifications
79 | P a g e
Product Description:
The SmartAX MA5620 are industry-leading remote multi dwelling units (MDUs) launched
by Huawei, which provide broadband services and IP voice services on the Fiber to the Building
(FTTB) network for family users and small to medium enterprises. The MA5620 are box-type
devices. It provides two GPON or GE uplink ports and supports 8-channel, 16-channel, or 24-
channel LAN access (LAN: POTS = 1:1). They feature broad temperature range, low power
consumption, mute design, high stability, environment-friendly and energy conservation, and
can be used on work benches and installed in corridors and cabinets, facilitating installation and
maintenance.
Product Details:
80 | P a g e
1:8 Optical Splitter
Product Details:
81 | P a g e
Telecommunication Room
Product Description:
The SmartAX MA5620 are industry-leading remote multi dwelling units (MDUs) launched
by Huawei, which provide broadband services and IP voice services on the Fiber to the Building
(FTTB) network for family users and small to medium enterprises. The MA5620 are box-type
devices. It provides two GPON or GE uplink ports and supports 8-channel, 16-channel, or 24-
channel LAN access (LAN: POTS = 1:1). They feature broad temperature range, low power
consumption, mute design, high stability, environment-friendly and energy conservation, and
can be used on work benches and installed in corridors and cabinets, facilitating installation and
maintenance.
Product Details:
82 | P a g e
Heat Dissipation No fans; Passive Cooling
Power Supply 220 VAC /110VAC
Lightning Protection Capability LAN: 6kv/ POTS: 4kv
Weight 24 ports:2.3kg
16 ports:2.29kg
8 ports: 2.28kg
Launch power/Receiver Sensitivity 5dBm / -28dBm
Networking Configurations FTTBC+HGW (GPON Networking, ONU
Providing the VoIP Service)
83 | P a g e
Ripcord Optional
Jacket Material PVC/PE/LSZH
Certification CE/ISO/ROHS/TCL/UL
Packing Cartoon Box or Wooden Drum
RJ45 Plug
Product Details:
RJ45 connectors terminate the ends of 10BT patch cable 50-micron gold-plated contacts
for optimum data transmission. Save money by using these connectors to create your own patch
cables Color clear.
TELECOMMUNICATION OUTLET
84 | P a g e
Product Details:
- 6176 - dual telephone / dual universal network socket outlets (RJ45/RJ12/RJ11).
Geo Vision GV-EVD2100 2MP 3-9mm H.264 Super Low Lux WDR IR IP Dome Camera
Product Details:
1/2.8\" progressive scan super low lux CMOS Dual streams from H.264 and
MJPEG Up to 30 fps at 1920 x 1080 Intelligent IR
Day and Night function (with removable IR-cut filter) Megapixel lens P-Iris lens
for auto Iris control IR distance up to 50 m (164 ft.)
3-axis mechanism (pan / tilt / rotate) DC 12V / PoE (IEEE 802.3af) Two-way
audio Wide Dynamic Range (WDR) ONVIF (Profile S) conformant
Defog Motion detection Tampering alarm Text overlay 31 languages on Web
interface
Privacy mask IP address filtering NAS Recording assigned by GV-Edge
Recording Manager (Windows and Mac) Supports iPhone, iPad, Android and
3GPP
85 | P a g e
Product Details:
100% compatibility with Cisco SFP-GE-T guaranteed
Uses a cost-effective cabling alternative to fiber-optic set ups
SFP modules are backed by a lifetime warranty
Product Specifications:
86 | P a g e
Unified IP VOIP phone 7942G
Description:
Weight:
Phone-Casing Composition
Acrylonitrile butadiene styrene (ABS) plastic in textured dark gray color with silver bezel
Power:
Model Number:
Codec Algorithm:
Quality of service:
87 | P a g e
HP E-MSM466 Dual Radio 802.11n AP (WW)
88 | P a g e
89 | P a g e
AIRCONDITIONING SYSTEM
Samsung 2.5HP Split Type Aircon Inverter AR24MVFHHWKNTC
Noise Level (Indoor, High/Low, dBA) Net Dimension (Indoor, WxHxD, mm)
44/30 dBA 1065*298*243 mm
Noise Level (Outdoor, High/Low, dBA) Net Dimension (Outdoor, WxHxD, mm)
53 dBA 880*648*310 mm
90 | P a g e
Technical Information Anti-Bacteria
Yes
Piping Length (Max, m)
Auto Clean (Self Cleaning)
20 m
Yes
Piping Height (Max, m)
12 m Convenience
Quiet
Allergy Care
Yes
91 | P a g e
INTERNET SERVICE PROVIDER
92 | P a g e
93 | P a g e
Bill of Materials
DATA ROOM
APC Power-Saving Back UPS Pro 900, 230V PHP 158,000.00 pc 2 PHP 316,000.00
94 | P a g e
BACKBONE
95 | P a g e
SUMMARY OF RECOMMENDATION
This section consists of two sections, the a) recommendations regarding wide area network
(WAN) and b) recommendations from the Panel.
96 | P a g e
97 | P a g e
2nd Revision List – March 30, 2019
98 | P a g e
APPENDIX A
DOCUMENTATION
99 | P a g e
APPENDIX A
100 | P a g e
APPENDIX B
PROPONENTS PROFILE
101 | P a g e
BEZALEEL GONZALES, ECT
Address:719, Lunas St., Brgy. Malamig, Mandaluyong City
Email Address: bezaleelgonzales @gmail.com
License Number: 0015769
Cellphone Number: +63 926 244 4084
Telephone Number: 02 952 2535
OBJECTIVES
To be able to contribute my knowledge and skills to the field I have chosen,
Communications Engineering, in order to do my part in helping my future company achieve its
goals, surpass their expectations of me and to help upgrade the living of each Filipino and to
answer the needs on communications systems with the advent of the latest technology
QUALIFICATIONS
Licensed Electronics Technician (October 2017)
Licensed Class C Amateur Radio Operator
Computer Systems Servicing NCII, Electronic Products Assembly and Servicing NCII
Student Leader- Vice President (External Affairs), RTU- Electronics and
Communications Engineering and Technology Student Society
Three-time Dean’s Lister
Diploma Holder- Electronics and Communications Engineering Technology
(Ladderized)
EDUCATION
2000-2006 Elementary Amazing Grace School
2006-2010 Secondary San Geronimo Emiliani School
2014-Present Bachelor’s Degree Rizal Technological University (Electronics Engineering)
EXPERIENCE
2013 Production Trainee Icoast Manufacturing Co.
2017 OJT PLDT Inc. (Mandaluyong)
TRAINING/SEMINAR
2011 Creative Writing Filipinas Heritage Library
2011 Travel Writing Filipinas Heritage Library
2013 Automotive Servicing San Pedro Technological Institute
2014 Speech Workshop Tehillah Worship Institute
2016 Industrial Electronics MFI Foundation, Inc.
EXTRA-CURICULLAR
2009-2010 Feature Editor The Dove (High School Publication)
2010-Present Choir Member Praise Minstrels Choir
2014-2017 Member RTU- Electronics and Communications Engineering
2017-Present Vice President and Technology Student Society
102 | P a g e
SKILLS
Technical Skills (Electronics Technician)
English Communication (Writing and Speaking Fluent, winner of various speech
contests both in high school, college and inter-college)
Computer Literate (Microsoft applications, programming, and photo editing)
People-oriented Skills (Able to work in groups and friendly)
Driving (with non-professional license)
FOREIGN TRAVELS
Brunei Darussalam, Malaysia and Shanghai and Hongkong, China
LOCAL TRAVELS
Cebu, Aklan (Boracay), Baguio, Ifugao (Banaue Rice Terraces), and Batangas (Taal
Volcano)
I hereby affirm that all above information are true and correct to the best of my knowledge and
ability.
103 | P a g e
JAXL JOHM 541 Concha St., Brgy. 62- Zone 6,
Tondo, Manila
0977 750 3406
HILARIO Jaxl.johm.hilario@gmail.com
OBJECTIVE
My goal is to become associated with a company where I can utilize my skills and
gain further experience while enhancing the company’s productivity and reputation.
EDUCATION
BS Electronics and Communications Engineering| Universidad de Manila
SY 2012 – 2014
BS Electronics and Communications Technology | Rizal Technological University
SY 2014 – 2017
BS Electronics and Communications Engineering | Rizal Technological University
SY 2017 – PRESENT
EXPERIENCE
Intern | PLDT Inc.
JUNE 2016 – OCTBER 2016
Used to be as an intern for Engineering and Technology Department
Intern | Sky Cable
NOVEMBER 2016 – APRIL 2017
Used to be as an intern for Information and Technology Department
SKILLS
Basic knowledge on Electronics and its Applications; proper handling of
VOM and Oscilloscope.
Basic knowledge and skill on Telephony
Proficient in Microsoft Windows environment especially Word, Excel and
PowerPoint.
Strong Interpersonal and Communication Skills
Intermediate knowledge in AutoCAD, Arduino, Adobe Photoshop and PLC.
104 | P a g e
ACTIVITIES
Licensed Class C Amateur Radio Operator
October 2016 to June 2020
CHARACTER REFERENCE:
Prof. Ian Louie Vargas
ECE Department, Rizal Technological University
0917 934 0005
Prof. Jayros Amar
ECE Department, Rizal Technological University
0905 289 8508
105 | P a g e
YN CLOUIE A. MAGNAYE
#149 BATO-BATO ST. BRGY. COMMONWEALTH QUEZON CITY
106 | P a g e
YN DANNY N. OXINA
2-C SANTOLAN RD., BGY. VALENCIA, QUEZON CITY
SKILLS EDUCATION
REFERENCE DIEBOLD-NIXDORF
TRAINEE•
107 | P a g e
APPENDIX C
SURVEY FORMS
108 | P a g e
APPENDIX C
APPENDIX C
109 | P a g e
110 | P a g e
111 | P a g e
112 | P a g e
APPENDIX D
REFERENCES
113 | P a g e
APPENDIX D
References:
Google Maps
http://apolanglobal.org/passive-optical-lan-overview-benefits/
https://www.entranceuniversity.com/city/rizal-technological-university/
https://www.rtu.edu.ph/?page_id=16.
https://www.cisco.com/c/en/us/products/collateral/collaboration-endpoints/unified-ip-phone-
7942g/product_data_sheet0900aecd8069bb68.html
https://www.cisco.com/c/en/us/products/security/asa-5500-series-next-generation-
firewalls/data_sheet_c78-345385.pdf
https://www.cisco.com/c/en/us/products/security/asa-5500-series-next-generation-
firewalls/data_sheet_c78-345385.pdf
114 | P a g e