Professional Documents
Culture Documents
EKT Previous Year Question Papers PDF
EKT Previous Year Question Papers PDF
SSBCrack.com
&
SSCrackExams.com
THE FOLLOWING QUESTIONS ARE A MIX OF
DISCLAIMER:
The answers may not be correct try to search on the Internet to get more accurate answers. Also few
questions are unsolved; if you know the answers share it with others.
All the questions are memory based and may differ from actual questions but if you prepare them you
will clear your EKT for sure as mentioned by the followers. All the best
=====================================================================================
=========================
SECTION-1
<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<EKT-ELECTRONICS AND
COMMUNICATION>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>
=====================================================================================
=========================
16. They give modulation index, carrier power ask us to find total power---------------------------------------
Pt=Pc(1+(m*m/2))
18. They give some freq and ask us to find Image Freq…?------------------------------------------------------
Fi=F(given)+2(I.F=455kHz)
24. They give Vmax and Vmin and ask us to find modulation index?--------------------------------------------m=
((Vmax-Vmin}/ (Vmax+Vmin)
25. A voltage source of 5v with internal resistance 2 ohm can transfer max power to load when the value
of load resistance is-----2 ohm
26. In a communication system, noise is most likely to get into the system
27. When modulation frequency is doubled, the modulation index is halved, and the modulating voltage
remains constant, the modulation system
(A) Amplitude modulation
30. Which one of the following terms does not apply to the Yagi-uda array?
(B) To allow one antenna to be used for reception or transmission without mutual
interference========answer
(C) To prevent interference between two antennae when they are connected to receiver
34. A typical signal strength received from a geosynchronous communication satellite is of the order of
(D) In erlangs===================answer
(B) Logic 0 and 1 are represented by negative and positive voltages respectively
38. Which of the following devices has its characteristics very close to that of an ideal current source?
(D) MOSFET
41. If the peak transmitted power in a radar system is increased by a factor of 16, the maximum range
will be increased by a factor of
52.transmission of light through optical fiber works on principle of ---(total internal reflection,total
internal refraction,etc)-------reflection
53.SHF can be used for ---(radio,satellite,surface wave)-----------------------------------------------------------------
satellite
62.if freq deviation is 15KHZ,modulation signal 75 Khz,then theoretical BW i upto 8th component---
(150,240,480,etc)--150
63.Balanced modulator is used for removal of---(carrier,USB,LSB,etc)------------------------------------------------
-----carrier
=====================================================================================
=========================
<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<END OF SECTION
1>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>
=====================================================================================
=========================
=====================================================================================
=========================
SECTION-2
<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<EKT-
GENERAL>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>
=====================================================================================
=========================
14.aluminum alloy is used in piston:it is light,it is strongest,it is shock less,less wear off------------------------
------------light
15.when a light is passed through a higher refractive index what will happen-------------------------------------
-----------velocity decrease
* Low ionization
energies
* Low
electronegativities
* Highly reactive
26. If u wants to connect two systems through telephone line which of the following u will use..?----------
modem
33. If the gain of the open loop sys’m is doubled then gain margin will become-------------------------
doubled
35. If the speed flow in pipe of diameter 6 mm is 5m/s.If this pipe is connected to another of diameter 3
mm, then speed will be---10m/s
36. They give change in force and change in diameter of a square plate. Ask us to find change in
pressure---(change in area/change in area)
37. They give three sets of measurements .Which are sets forms triangle------------------the one where
a+b>c where a,b,c are sides taken in any order
38. First aid of electrical shock victim----------------plug-off power-------move victim by a wooden stick or
dry clothes sideways
41. what does the symbol "j" represents in vector----------------------------90 degree anticlockwise
movement (imaginary-axis)
46. above curie temperature, magnetic material will become-------------------non magnetic or magnetic
insulator
56.unit of inductance-------------------------------------------------------------henry
62.name of electric motor-both rotor and stator rotating at equal speed------synchronous motor
=====================================================================================
======
Heat transfer from the working fluid to the low-temperature reservoir (Condenser).
Heat transfer from the high-temperature reservoir to the working fluid (Boiler).
An important conclusion from Carnot cycle analysis is that the maximum theoretical efficiency of heat
engines is directly related to:
efficiency = D(T2-T1)/T2
where:
For a heat engine operating between 300oC and 100oC, with a DT of 200 degrees, this maximum
efficiency would be:
75.advantage of sampling
a) simple ckt
a) Watth
==============================================================================answer
b)Watt
c)ampere
d) amp/hr
a)copper
b)nichrome===========================================================================
=answer
c) platinum
d) tungstun
a) top-bottom
b) system
c)two stage
d) 2 state
a) itd length
b) its
radius============================================================================answ
er
a) dc switch
b) ac
switch============================================================================ans
wer
c)both a& b
=====================================================================================
=========================
85.a particle whose motion is described by x=asinwt, y=asinwt z=ut moves along
the answer can be arrived by finding d/dx,d/dy,d/dz which are Vx,Vy,Vz then finding resultant using
sqrt(Vx^2+Vy^2+Vz^2)
similairly again by differentiating we obtain Ax,Ay,Az components of Acc'n...then find their resultant
..similiarly
=====================================================================================
=========================
a) program
b)instruction
c)data================================================================================
= answer
94.Black Body--------------------------------------------------------------------------------------------------------------
ABSORBS/transmits all radns.
97.if on insertion of dielectric,energy stored becomes one fifth..then dielectric strength is---
(5,1/5,25,1/25)--------5
98.A material having resistivity=2 times copper covers a copper metal sheet of same thickness of
resistance 2 ohm ,then resistance of composite sheet is---(6,2/3,4/3,3/4)------------------------------------------
--------------------------------------------------------------3/4
101.if multiplication of n numbers is 1,then their sum ---(n(n+1)/4,divisible by n,1,always less than n)-----
-------------always less than n
102.the material used in solar cells is---(germanium,silicon,etc)-------------------------------------------------------
-----si
105.Two taps A(requires 15 mins to fill a tank) and B(12 mins), time required to fill d tank if both taps
used ?--------(20/3) mins
cobalt----[Ar]
4s2 3d7
148.what is motor called when its stator rotates at same speed as its actuator-----------------------------------
---------syncronized motor
1B 2A 3B 4A 5A 6B 7A 8B 9C 10B
11B 12A 13A 14B 15C 16D 17A 18D 19A 20C
21A 22B 23D 24B 25C 26C 27B 28D 29D 30A
=====================================================================================
=========================
<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<END OF SECTION
2>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>
=====================================================================================
=========================
=====================================================================================
=========================
SECTION-3
<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<EKT-COMPUTERS and
IT>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>
=====================================================================================
=========================
16)Permanent Memory-RAM,Dram,Rom,other-----------------------------------------------------------------------------
-Rom (it is actually EEPROM)
magnetic tape
magnetic drive
all of the
above===========================================================================answe
r
all of the
above===========================================================================???
set of instructions--------------------------------------------------------------------------------------------------------------
program
binary
decimal===============================================================================
==answer
Ascii
recursion is used
in========================================================================???
stack
queue
link list
which is offline
device======================================================================???
connected to cpu
direct storage
ans 3,carry
n-1
n-2
n/2
32
64===================================================================================
==answer
256
240
BCD is:
encoder==============================================================================
====answer
decoder
multiplexer
demultiplexer
encoder
decoder
multiplexer
demultiplexer==========================================================================
===answer
A+0=A
A+A=A
A+1=1
X=+1=================================================================================
===answer
CMOS================================================================================
====answer
TTL
MOSFET
ECL
valves================================================================================
===answer
Transistor
ICs
SSI
Integrator=============================================================================
===answer
differentiator
Comparator
microprocessor and microcomputer providing access to many use---------------------------------------------------
-------- multi-user system
class
a===================================================================================a
nswer
class b
class c
class d
dynamic
ram===============================================================================ans
wer
static ram
prom
rom
cpu consists of
flip flop
one question was like some thing to transfer through bus then which will be used:
DMA=================================================================================
====answer
Interrupt vector
differentiator----------------------------------------------------------------------------------------------------------------------
high pass filter
Integrator-------------------------------------------------------------------------------------------------------------------------
low pass filter
Some option--------------------------------------------------------------------------------------------------------------(dis
option HAS to be the answer)
Swapping=============================================================================
=====answer
Spooling
Exchange
Some option
CCDs=================================================================================
====answer
Disk
Tape
1C 2C 3D 4C 5B 6A 7B 8A 9D 10C
=====================================================================================
=========================
<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<END OF SECTION
3>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>
=====================================================================================
=========================
=====================================================================================
=========================
SECTION-4
<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<EKT-
MECHANICAL,AERONAUTICAL>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>
=====================================================================================
=========================
1) zeroth law of thermodynamics-----------------------------------------------------------------------------------------------
-thermal equilibrium of bodies
14) 2 parallel shafts to be connected in perpendicular by: bevel, spiral , helical or worm gears---------------
------------helical gear
15)Steffan-Boltzman law----------------------------------------------------------------------------------------------------ABS
TEMP RAISE 2 FOUR.
24)Not renewable-NUCLEAR,solar,biomass,wind.--------------------------------------------------------------------------
nuclear
8.self ignition diesel engine as compared to petrol has?----(lower ignition temp,higher ignition temp,etc)-
-----------lower
12.(not so sure) the velocity ratio of 8 teeth wheel and 100 teeth wheel in third gear wheel
is(1:12.5,1:800,etc)-----1:12.5
=====================================================================================
=========================
<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<END OF SECTION
4>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>
=====================================================================================
=========================
=====================================================================================
=========================
SECTION-5
<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<EKT-
ELECTRICAL,ELECTRONICS,INSTRUMENTATION>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>
=====================================================================================
=========================
4)the flow and timing of data to and from the micro processor is done by------------------------------------------
---------control pin
18)capacitor is-----------------------------------------------------------------------------------------------------------------
conductor filled with dielectric
1C 2A 3A 4B 5D 6 7 8B 9 10D
11B 12C 13C 14D 15B 16C 17C 18D 19D 20A
=====================================================================================
=========================
<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<END OF SECTION
5>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>
=====================================================================================
=========================
=====================================================================================
=========================
SECTION-6
=====================================================================================
=========================
(slow down the reaction rate, change in product part, inc the rate of reation…………)
( plank, bohr………………)
4.something related to prism ref index were given one angle is given and other angle has to find-----------
-----------n=sin[(A+D)/2]/sin(A/2)
n=refractive
index
A=refracting
angle
D=Deviation
angle
( uncontrolled nuclear fission, controlled nuclear fission uncontrolled nuclesr fussion, uncontrolled
nuclesr fussion…….)
lambda=decay
constant
8.property of radioactivity---------------------------------------------------------------------------------------------------
gamma rays
10.isotopes r------------------------------------------------------------------------------------------------------------------same
atomic no
( hav same atomic no. ,diff nuclei, diff no of protons……………………)
( 8cm,11cm………)
12. 2882 arrangenet of electrons in an atom hav not true from options---------------------------------------------
------belongs to group 2
13. in potassium-------------------------------------------------------------------------------------------------------------4s>3d
( 4s>3p,4s>3d,4s<3p………….)
( 76,60,90,70…………)
( 8km/s,8km/hr………)
18. plane in air when turned in left wats happens to the nose and tail-----------------------------------------------
-----(actually tail of the airplane move
toward the left, causing the nose
turn to the right. ...)
(nose raise and tail dowm, nose down tail raise, both remain in same position……….)
( ferro mag. ,ferri mag., para mag., dia mag., anti mag…………..)
21. probability of occurance of A and B is ½ probability of not occurance of A and B is 1/ 6 wat is the
probability of A--P(A)P(B)+P(A)P(B')
(1/4…………………)
24. a transmitting signal havinf freq range 10.0mhz-10.1mhz hav sampling freq----------------------------------
-----200KHz
( VHF,VLF,LF,SHF………..)
( telegraphy,telephony,radiotransmission……….)
(1000000,10000,100,……………)
circuit operation
more stable
( circle with radius 4,triangle with sides 3,4,4 , triangle with sides 3,4,5)
( laser…………..)
41. when power of transmitting signal is increased wat happens to its range?-------------------------------------
---increases (RADAR range equation)
PCB technology
(mm,cm,angstrom……….)
45.in a molecule when oen atom is surrounded by four atom at corners the structure is-----------------------
-----tetravalent
(PLL,VCO……………..)
( p^2+q^2+2pqcos@..................)
(clampper,rectifier,demodulator,chopper…..)
51.something like in in length in solenoid something dec wat happens to 3rd value?----------------------------
---???
52. A tap fills bucket in 15min B tap in 13 mins if both tap are open for 1 min starting with b tap in hoe
much time the bucket fills
55. P no of persons promise to give Q$ but R persons did not give the S$ each in charity wat is the eq for
charity given
1)circle 2)ellipse
2) If the area is increased by 69% then how much the side of the square will increase--------------------------
--30 % (new area=1.69*side^2
=(1.3*side)*(1.3*side)=i.e. 30%
increase in length of side)
1)tetrahedral 2)linear
7) Isotopes means-----------------------------------------------------------------------------------------------------same at
no,different at wt
11) In Geometric Progression all are +ve nos, first consecutive two nos are same then common ratio will
be----1
line
voltage=1.732*phase voltage
21) If the frequency is beyond resonant frequency then the impedance is------------------------------------------
purely inductance
26) Water is flowing in a pipe of dia given and spped also given when it is attached with another pipe of
diameter given then what is the speed of the water in second pipe
--------------------------------------------------------------------------------------------------------------------------
A1*V1=A2*V2
A=cross-section
area of respective pipe
V=water speed at
respective pipe
27) Cal of linear strain if weight is given and length it elongates also given-----------------------------------------
Y=stress/strain=(Wt/A)/(l/L)
32) In which compound will the sulphur will have more than one oxidation state--------------------------------
---H2S2O7
33) Alkali metals are characterzed by--------------------------------------------------------------------------------
ionization
1)Solvency 2)Ionization
1)Tetravalency 2)Isomerism
non-zero--not a
factor
36) Probablity of occurence of A is given neither A nor B also given and stated A and B are independent
events.
1)1/4 2)35482
38) logxto the base 8 +logxto the base 4+logxto the base 4=11 then value of x-----------------------------------
64
1)8 2)64
39) In H2O2 oxygen is lost by oxidation or reduction then which bond of oxygen with hydrogen is lost-----
------covalent
=====================================================================================
=========================
43) In trajectile related question Range is given 100 m Initial velocity is 800 m/sec. find height of the
object
-----R=u(squared)*sin2@/g --------------------->find the value of @ i.e angle of elevation and then use it in
the following formulae
H=u(squared)*sin@(squared)/2g
the values in the question are improper..however the concept of solution is as discussed above
=====================================================================================
=========================
44) Ball drops from height of 200 metres bounds back of 2/3 of its height
(actually dia-
magnetic)
46) Same input given to NAND gate then the operation is said to be-------------------------------------------------
--------NOT
1)NAND 2)NOT
1)Wb-Am 2)WbAm-2
1)dielectric 2)conductor
53) Two sine wave modulated by carrier wave of index 0.3 and 0.7 the combined index would be----------
---------------0.76 to be precise
=====================================================================================
=========================
<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<<END OF SECTION
6>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>>