You are on page 1of 1

Spinning Reel

Maintenance Tips

DO NOT
• Rinse your reel when drag
knob is loose
• Remove handle when
washing
• Using high pressure water
to wash down your reel
Tighten drag knob and rinse Rotate spool and rinse for 15-20
1. under low pressure tap water in 2. seconds • Wash your reel in an upside
upright position down position
• Soak reel in a bucket of
fresh water
• Place your reel under
direct sunlight after
washing

RECOMMENDATIONS
Use a toothbrush to brush Spin reel in fast rotation to
3. handle area, line roller area 4. channel excess water out • Remove line after deep sea
and drag knob fishing to wash down spool or
if intending to keep for long
time storage
• Avoid placing your reel on
boat side rod holders when
boat is travelling to prevent
splashes of sea water
• Put 1-2 drops of oil on main
shaft / line roller / handle
knob bearings / drive gear
bearings and screws after
2-3 times usage
Use a dry cloth to wipe down Use an air duster to spray difficult
5. reel exterior 6. access area/joints to clear off
• Send for servicing every 6
excess water months if the reel is being
used frequently

Remove drag knob and wipe off Screw back drag knob and
7. excessive water on spool and 8. leave it in a dry and cool
rotor area place

You might also like