Professional Documents
Culture Documents
Cleaver
Instruction Manual
CI-03AT CI-03BT, CS-03AT, CS-01BT,CF-03AT
Wrench Damper
Rack Gear
Pusher Pin Cover
Body
Holder
Blade
Blade Gear
Chip Collector
Ass’y
Wave Washer Slider
▲ Front
<BI-07>
WWW. ILSINTECH.COM
Open the body cover, and Close body Cover and clamp Cleave fiber with pushing the Take cleaved fiber from the
place the stripped fiber on aligned fiber impregnably cleaving button. holder carefully .
the cleaver holder. At this time push cover well in Fiber end-face must be careful
Adjust fiber length with order to rotating blade from dust and debris and the
length marking through gear Pusher cleaved fiber is collected by
automatic chip box
A. Blade Replacement
Rear Pusher
Pusher Pin
In order to replace blade, disassemble Remove blade pin completely using (-) Remove old blade with blade gear from
chip collector assembly and rear pusher. driver. body and replace new blade with blade
Open the cover as shown picture and Turn clockwise blade pin left side bolt gear. In here reassembling should be
press the pusher pin to move slider to done in a reverse order of disassembling.
forward At this time, especially be careful not to
damage the blade.
Check the blade operating condition with
B. Blade Mode (Rotating/locking) change cleaver cover.
A/S Center
This user manual could be edited without notice. For more information, please visit our website and contact AS center 080-671-5600