Professional Documents
Culture Documents
Show your checks of As> As min, εt, and placement of reinforcing steel.
2. Select b, d, h and the reinforcing steel for a 36 ft. simply supported rectangular
beam, which supports its own dead load plus a uniform live load of 1.8 kips per
foot and an additional uniform dead load of 0.4 kips per foot. . Use f’c = 4000 psi
and fy = 60,000 psi. Check reinforcing steel placement using 1 ½” clear cover and
#3 stirrup.
3. Select b, d, h and the reinforcing steel for a 24-ft-span simply supported
rectangular beam which supports its own dead load plus a superimposed service
dead load of 1.0 kips/ft plus a service live load of which consists of two
concentrated loads of 12 kips each located at the third points of the span. Use f’c=
3000 psi and fy=60,000 psi. Check reinforcing steel placement using 1 ½” clear
cover and #4 stirrup.
Problem 2:
For the following three beams, compute Mn. Use f’c = 5000psi and
fy = 60,000psi. Check εt and determine factor. Based on the results, comment on
whether adding compression steel is an effective way to increase moment capacity
(compare increase in steel to increase in moment capacity).
31"
a) b) c)
24ft-0in
Plan View
12ft-0in 10ft-0in
21in
6 ea #10 bars 6in
12in (typ)
Section
Problem 4:
For the following T-beam, compute Mn. Also check t, determine the factor and check
As > Asmin.
26"
6"
12"
33"
2 1/2"
Problem 5:
For the following non-rectangular beam, compute Mn. Also check t, determine the
factor and check As > Asmin.
8"
6"
16"
32"
2 1/4"