Professional Documents
Culture Documents
OK
Go To Next Step
OK
Go To Next Step
Check the programmable parameters and the
STEP 3 selected features with an electronic service tool.
Programmable parameters or selected features ............. Set the parameters and features again, if
are not correct necessary. Refer to Procedure 019-078 in Section
19.
OK
Go To Next Step
Allow the engine to warm to operating
STEP 4 temperature. If the engine will not reach operating
............. temperature, refer to the Coolant Temperature
Engine is cold
Below Normal troubleshooting symptom tree in
Section TS.
OK
Go To Next Step
STEP 5 Adjust the engine brakes. Refer to Procedure
.............
Engine brake adjustment is not correct 020-004 in Section 20.
OK
Go To Next Step
STEP 6 Check the engine brake on/off switch and circuit.
Engine brake on/off switch or circuit is ............. Refer to Procedure 019-034 and Procedure
malfunctioning 019-035 in Section 19.
OK
Go To Next Step
OK
Go To Next Step
Engine Brake - Low Retarding Power or Slow to Activate
This is symptom tree t037
Cause Correction
Check for poor battery and chassis grounds.
Check ground wires or cables for loose
connections. Check the following grounds, make
STEP 8 sure they are secure, clean, and on a non-painted
.............
Engine electrical ground is malfunctioning surface; engine block ground, chassis (or frame
rail) grounds, ECM grounds, alternator and starter
negative posts. Disconnect and clean the battery
cable connections.
OK
Go To Next Step
STEP 9 Check the engine brake harness connectors.
Engine brake harness connectors are loose or ............. Check the engine brake harness for continuity.
broken Procedure 019-063 in Section 19
OK
Go To Next Step
STEP 10 Check the oil level. If the level is high, check for a
............. cracked oil suction tube. Refer to Procedure
Air in the lubricating oil system
007-035 Section 7.
OK
Go To Next Step
OK
Go To Next Step
STEP 12
............. Refer to Procedure 020-012 in Section 20.
Engine brake solenoid(s) is malfunctioning
OK
Go To Next Step
OK
Go To Next Step
STEP 14 Check the engine brake assembly for restriction.
.............
Engine brake lubricating oil passage is restricted Refer to Procedure 020-004 in Section 20.
OK
Go To Next Step
Perform diagnostics to determine if the
STEP 15 turbocharger is malfunctioning. Replace the
.............
Turbocharger is malfunctioning turbocharger as necessary. Refer to the Engine
Performance troubleshooting tree in Section TT.