Professional Documents
Culture Documents
DIRECTIONS: Locate where the following information can be found in the Handbook and give
the answer if required.
5. What type of pump is commonly used for a capacity of 200 gal/min and a head of 10 ft of
water?
ANS: Centrifugal pump…………… … Fig. 10-26 pp. 10-24
7. Estimate the terminal settling velocity (ft/s) in water at 70oF of a particle with a sp. gr. of 2.0
and diameter of 100 microns.
ANS: 1.8 x 10-2 ft/s Fig. 6-61 pp. 6-55
10. Determine the enthalpy of steam in kJ/mole at 500K and 5 MPa. Is the steam saturated?
ANS: H = 17.582 kJ/mole, supersaturated Table 2-305 pp. 2-414
13. What is the typical over-all HTC in a tubular HE where kerosene flows in the shell side and
water in the tube side?
ANS: U = 30 to 65 Btu/hr-ft2-oF Table 11-3 pp. 11-25
14. The inside diameter of a 1-1/2 in. O.D. 16 BWG pipe is _____ inches.
ANS: Di = 1.37 inches Table 11-12 pp.11-42
Dr. S. Olano, Jr. Manila Review Institute, Inc. ChE Review for Nov. 2013 Exam
15. What is the viscosity of water in cP at 70oC?
ANS: 0.42 cP Fig. 2-122 p. 2-449
16. Determine the inside diameter and thickness of a 2-in. Sch 80 steel pipe.
ANS: Di = 1.939 in. x = 0.218 in. Table 10-22 pp. 10-78
17. Compare the direct and indirect method of determining the reaction rate constants.
ANS: See Table 7-13 pp. 7-36
19. A thermometer at 0oC is immersed in boiling water. What will be the time constant of the
system if the temperature reading becomes 86oC after 2 secs.
ANS: 2.33 min Fig. 8-9 pp. 8-10
20. What is the Fanning friction factor for a 20 mm ID galvanized iron pipe if the NRe of ethanol
flowing is 3.0 x 104?
ANS: f = 0.0093 Fig. 6-9 pp. 6-10
Dr. S. Olano, Jr. Manila Review Institute, Inc. ChE Review for Nov. 2013 Exam