You are on page 1of 3

1) About CAR 145.

2) When do you issue CRS

Certifate ished in repect of a/c sysstem aircraft component , equpment certifying that the same has
been maitaned checked tested s per maitenance data and its airworthy to fly

3) If there is a PDR about Capt. Tray Table and you replaced the table, is CRS

Yes we have to ishe crs bcx we have done a maitenace of an aircraft equpment after pdr

4) Explain what is FADEC


Fadec is full authority digital engine control which includes eec its components like acc
actatot vsv actuator etc sensors and all its peripherals and electrical harness

5) The ways to switch ON fadec

By setting the mode selector to ign/start

5 min after power up

5 min after engine sgutdown

Lgciu cbs

Eiu cbs

Push botton for fadec

6) Location of the flight control computers

Exept sec3 all flight control computer is in 80vu

7) Why sec-3 is in 90 vu
8) What is elevator priority logic

E2,e1,s2,s1

9) What will happen if there is water content in the fuel


Water will form in to ice particle it may effect to the fuel system component and it may
block the fuel filter fuel pump
And micro biological groth in the fuel tank

10) How do we check microbiological growth in the fuel

For checking the micro bioligical groth every 6 mnth we r sending sample tro the lab
11) When we do the fuelling, the fuel goes from the hose to the a/c, then from where does the
fuel fumes come from?

NACA intake

12) How torque wrenches are classified

Torque wrench classified as type of torque wrench ,range of torque wrench, drive size

13) What will you check before issuing the torque wrench from the stores

Calibration due date , error

14) Number of fan blades in engine


22 fan blade taitanum havinf a quality of high strength to weight ratio

15) What is material of fan blades and why


16) Are they hollow or solid

They r hollow

17) Advantages and disadvantages of hollow blades

If its hollow then we can reduse the the weight and thus we can increase the fuel effitency

If they r solid thn impact resistance is high

18) If there is a bird ingestion in engine, what all actions you will take

19) What is area ‘A’ and area ‘B’ in fan blade and its dimensions

8inch from tip to root is B


After 8 inch from tip to full area is A
20) If there is bird hit on area ‘A’ of the fan blade and you don’t have borescope facility, can you
release the a/c

Yes we can release the flight to 10fh/2fc

21) In starter, how much oil should be there when you drain

236.6

22) If it is less than 236.6 ml then what is the action

We have to change the starter or else we can contact with mcc to defferd to 50 cycle

23) When installing a O-ring what things you will check and what precautions you will take
O rimg shud be cleen
The o ring slot shud b free from dest
We shud aplly a layer of oil above the oring
O ring shud little bit protrude
24) When an a/c arrives, there is a big nail in the tyre what action you will take
25) Can you release the a/c with the big nail if there is no leak

26) What is the procedure to charge brake accumulator and precautions

We shud put sleeves on landing gr door

After releasing the prs. Dnt enrgise the system

27) Where will you get the pre-charge indication

Thats thr neer to the weel well

28) Which type of charging valve is used in the accumulator

Shredded valve

29) How it is different from other valves

You might also like