Professional Documents
Culture Documents
ASSIGNMENT II
DESIGN & CONSTRUCTION
SOLVE THE FOLLOWING PROBLEMS: (Show complete solution)
1. A water tank 3m in diameter and 6m high is made from a steel having a thickness of 12mm. When the tank is
filled with water, determine the circumferential stress.
a. 3.76 MPa c. 7.36 MPa
b. 5.76MPa d. 6.37 MPa
2. A cantilever hollow circular bar 5mm thick with outside diameter of 75mm is subjected to a torque of 3 kN-m at
its free end. Find the maximum shear stress in the bar.
a. 81.1 MPa c. 83.1 MPa
b. 82.1 Mpa d. 84.1 MPa
3. A single bolt is used to lap joint two steel bars together. Tensile force on the bar is 20 kN. Determine the
diameter of the bolt required if the allowable shearing stress on it is 70 MPa.
a. 25mm c. 19mm
b. 15mm d. 12mm
Situation 2. Determine the maximum values of the following functions due to a live load consisting of a
concentrated load of 10KN and a uniform load of 2KN/m.
14. Which of the following gives the reaction at the rigid support in N-m?
a. 800 b. 200 c. 1200 d. 1000
14. Which of the following gives the maximum shearing stress in the shaft in MPa?
a. 28.29 b. 25.43 c. 20.36 d. 23.58
16. Which of the following gives the total angle of twist at the free end in degrees?
a. 2.22° b. 1.79° c. 2.76° d. 1.43°
Situation 3
1200 N-m m ,m
1000 N-m m ,m 800 N-m m ,m
2 m ,m 1.5 m ,m 3 m ,m
Pin 30 N
4m 6m 5m