Professional Documents
Culture Documents
PROPERTIES:
For diameters > 100 mm where great demands are made on fatigue strength.
STANDARDS:
General requirements:
When reference to this MAT NO appears on FLS Drawing or FLS Parts List or in FLS Purchace Order the data from the
Primary Standard is used as acceptance criteria.
Specific deviations in requirements made in the FLS Parts List, the FLS Purchace Order or a FLS Instruction always
overrules this data sheet.
Alternatively accepted International Standards listed in this sheet may be used if the suppliers documentation covers at
least the documentation required in the Primary Listed Standard. This means that supplementary tests in some cases
will be necessary.
Primary Standard:
S-EW 550 (1976) , MATERIAL: Ck 35 , MATERIAL No.: 1.1181
Stähle für grössere Schmiedestücke - Gütevorschriften
CHEMICAL COMPOSITION:
Dim, mm % C max % Si max % Mn max or % P max % S max % N max % Al min
or range or range range or range or range or range or range
0.32-0.39 0.4 0.5-0.8 0.035 0.035 - -
Dim, mm % Cr max % Mo max % Ni max % V max % Nb max % Ti max % Cu max % Other max
or range or range or range or range or range or range or range or range
0,4 0,1 0,4 - - - - -
%Cr+%Mo+%Ni < 0,63%
DELIVERY CONDITIONS:
This material shall be delivered quenched and tempered.
The conditions given here are guidelines.
Quenching: 840 - 880 °C - soak in water, oil or synthetic quenchant.
Tempering: 550 - 660 °C
Revisions:
Rev. No Rev. Date Change Responsible
0,7 31-01-2002 Text editions AnJo
Prepared & Approved changed
References to Alternative Standards added to supplier version
Hardness interval can not be used as only acceptance criteria
0,8 15-01-2004 Standards updated AsK