Professional Documents
Culture Documents
NAME:KASHINA K. SAMUEL(JR)
SCHOOL:KAOMA SECONDARY
CATEGORY:INNOVATION
REGION:KAOMA,WESTERN, ZAMBIA
GRADE:11(ELEVEN)
GENDER:MALE
AGE:16
Email: samuelkashina02@gmail.com
ABSTRACT
More than 90% of the world’s power is being generated
using electromagnets based on the faraday’s law of electro-
magnetic induction.Many new technologies were discovered
with time which led to a drastic change in the perception of
electric energy.But at the same time there is a misconception of
FREE ENERGY.Energy becomes free at a point after which we
don’t have to pay for power generation after commissioning the
unit.By using the magnetic force of magnets continuuously,
motion(energy) is generated.
Ferrite magnets are placed near the disc wheel which
consists of nails glued around the top of it in a circular pattern
or arrangement, ring shaped magnets are placed in such a way
that all the north poles or south poles are facing one
direction.These magnets also produce a magnet field which
results in a force of attraction between the Iron nails and the
magnet which makes it rotate with a constant perpetual
motion.The rotation motion of the wheel Is transfered to the DC
motor then transmitted to the bulbs through connecting wires
arranged in a linear pattern.The power extracted is used to light
bulbs in the villages and rural educational institutions such as
schools.
Few positive results are motivating me to create a better model
to stole the energy and use for different necessary applications
by using this free energy.In this research paper, the usage of free
energy was noticed by using a magnet and a few satisfactory
results are motivating me to review few research grounds of
magnets to create a perfect strong prototype for applications.
Email: samuelkashina02@gmail.com
TABLE OF CONTENTS
INTRODUCTION...............................................4
AIMS AND OBJECTIVES....................................5
PROBLEM STATEMENT......................................6
HYPOTHESIS....................................................7
METHODOLOGY................................................8
RESULTS...........................................................9
DISCUSSION..................................................10
ADVANTAGES.................................................11
CONCLUSION..................................................12
ACKNOWLEDGEMENT.....................................13
REFERENCES..................................................14
Email: samuelkashina02@gmail.com
INTRODUCTION
For many years simple magnets have been used for their magnetic
field to produce electric power.They are placed in the inside of motors
and generators.The basic principle of power generation lies under the
principle of magnet effect.It states that “When a conductor is rotated in
a magnetic field,a voltage is induced in the conductor.” So here we will
be dealing with such conductors.
Magnet motor free energy generator is an easy device to generate
electrical energy.It works with on the principle of ferrite magnets.In a
simple motor , magnetic field Is created by the electric coils generally
copper and aluminium (Cu and Al) coils.Those motors continuously
need electrical supply to produce magnetic field.There is a huge amount
of energy lossses but the magnetic motor consists of no such
coils.Hence, there will be minimal losses.It uses permanent magnetic
field of the magnets to generate the required force to move the
motor.The main advantage is that is does not require continuous
electric supply.
Email: samuelkashina02@gmail.com
AIMS AND OBJECTIVES
Email: samuelkashina02@gmail.com
6PROBLEM STATEMENT
It is a well known fact that in previous days till now people living in rural
areas are experiencing challenges with the access to free and cheaper energy for
lighting in schools and homes which could assist those pupils to study even more
effectively and sufficiently not only during the daytime studies but also at
night.For this reason,pupils in rural schools do not actually perform well due to
the lack of electric power for lighting to enable them do their school assignments
and studies.
Additionally, rural heath facilities are at times unable to operate well since solar
energy is not reliable enegy , it cannot always provide free energy, at times
especially during rainy seasons a solar panel may not get enough energy for use
and also hydro-electricity power may be gone at the time of giving treatment and
doing surgical operations and due to this problem, patients may end up dying
even when they could survive.
Email: samuelkashina02@gmail.com
HYPOTHESIS
This project is very helpful more especially to the people living in rural
areas as it will assist them with the energy for lighting.
Email: samuelkashina02@gmail.com
METHODOLOGY
MATERIALS
1.Dc Motor(12 watts)
2.4 small caton boxes
3. 10 L.E.D bulbs
4.Wood glue
5.4 Super glue
6.Model display board(60*60cm)
7.Connecting wires
8.2 Disc(DVD/CD)
9.1 Ferrite Magnet
10.Switch
11.2 Bottle lids
12.Voltmeter
13.30 Nails (1.5 inch)
14.Hammer
EXPERIMENTAL PROCEDURE
Step1.Firstly get a disc and glue some nails around the disc in a circular arrangement
leaving only short gaps between the nails.
Step 2.Glue a bottle lid on the opening at the middle of a disc and make a hole at the middle
of the lid which has been attached to the disc.
Step 3.Fit the DC Motor’s rotor in the the opening to make a disc-wheel and cut a small
circle around another bottle lid and then glue the DC Motor’s rotor in it.
Step 4.Get a wooden board of 60cm length and 60cm width and glue a the DC Motor which
has been just attached to the disc wheel to the board to make it still.
Step 5.Place a magnet on the board making either its north or south poles face In the
direction of the wheel to make an attraction of the magnet to the nails around the wheel.
Step 6.Connect the wires to the DC Motor while carefully matching their respective charges
by following the colour of the cables.Red cables connects the positive charge whereas a
black cable to negative charge.
Step 7.Hit the the nails with a hammer along a linear pattern beginning from where the disc
motor is towards the hats.
Step 8.Pass the cables above the nails and connect the wires to the builbs which are Inside
the hats according to charges.
Step 9.Move the magnet in Its place and the disc wheel will rotate.This produces ekectrical
energy which lights the low wattage L.E.D bulbs.
Email: samuelkashina02@gmail.com
RESULTS
The free energy magnet motor generator produces about 7 volts and
these results according to the conducted experiment indicates that a
totally free source of energy has been newly discovered and this brings
hope that the people in rural areas since they will now have access to a
permanent and free energy source which will stand for generations to
come.
Email: samuelkashina02@gmail.com
DISCUSSION
This free energy will be even advanced further by applying it to reality
through the construction of these machines which will then be made
available to the world on markets.This technology will improve the
efficiency of power energy and provide an alternative source for
lighting energy especially in rural facilities such as clinics and schools
which will now have a better way to do their day to day activitties
without any power problems.
10
Email: samuelkashina02@gmail.com
ADVANTAGES
1.It is renewable.
2.It can work at anytime and anywhere.
3.It can stored in batteries for later use.
4.It is non pollutant to the environment.
5.It is easy to use.
6.It is a cheap source of energy.
7.It is a clean source of energy.
8.It is easy to generate.
11
Email: samuelkashina02@gmail.com
CONCLUSION
12
Email: samuelkashina02@gmail.com
ACKNOWLEDGEMENT
13
Email: samuelkashina02@gmail.com
REFERENCES
14
Email: samuelkashina02@gmail.com
RESEARCH
15
Email: samuelkashina02@gmail.com
These are; the noth and south poles.The magnetic field is the area
around a magnet in which there is magnetic force . Moving electric
charges can make magnetic fields.When two magnets are brought near
each other, they exert a force on each other.This phenomenon is known
as the’Law of Magnets’ and it was discovered by Willian Gilbert.
On the other hand, electricity is the flow of charge through a
conductor in a circuit.An electrical circuit is an enclosed path of charge
in an electric current.Electric current is the rate of the flow of
charge.The consumed energy across the component is called potential
difference (p.d).This is the energy converted per unit charge passing
through a component.The unit of p.d is volt(v).
An instrument called as a voltmeter is used to measure the voltage.
16
Email: samuelkashina02@gmail.com
An electric motor is an electrical machine that converts electrical
energy into mechanical energy and vise versa .
17
Email: samuelkashina02@gmail.com
In an electric motor, the moving part is the rotor, which turns the shaft
to deliver the mechanical power. The rotor usually has conductors lid
into it that carry currents, which interact with the magnetic field of the
stator to generate the forces that turn the shaft. Alternatively, some
rotors carry permanent magnets, and the stator holds the conductors.
18
Email: samuelkashina02@gmail.com
19
Email: samuelkashina02@gmail.com