Professional Documents
Culture Documents
List of Accredited Laboratories For Safety Systems Mar 2018 Rev6 TSE PDF
List of Accredited Laboratories For Safety Systems Mar 2018 Rev6 TSE PDF
U.S.A. /
1 UNDERWRITERS LABORATORIES - ( UL ) www.ul.com
Canada
Norway
6 DET NORSKE VERITAS - ( DNV ) www.dnv.com
Italy
8 IMQ S.P.A - ( IMQ ) www.imq.it
Page 1 of 21
Ministry of Interior, Qatar
General Directorate of Civil Defence
FIRE PREVENTION DEPARTMENT
SAFETY SYSTEMS DIVISION
Doha, Qatar
No. THIRD PARTY COUNTRY WEBSITE
www.warringtoncertification.com
CERTIFIRE - WARRINGTON CERTIFICATION
12 U.K.
EXOVA WARRINGTON CERTIFICATION LIMITED www.waringtonfire.net
( EWCL )
http://www.mpa-
17 MPA DRESDEN GMBH Germany dresden.com
ANPI/ANPICERT www.anpi.be
BOSEC www.bosec.be
20 Belgium www.certalarm.com
CERTALARM
ANPI BE www.anpi.eu
Page 2 of 21
Ministry of Interior, Qatar
General Directorate of Civil Defence
FIRE PREVENTION DEPARTMENT
SAFETY SYSTEMS DIVISION
Doha, Qatar
No. THIRD PARTY COUNTRY WEBSITE
www.dekra-
25 DEKRA Neatherlands certification.com/en
Product certificates
https://basvuruportal.tse.org.
tr/Genel/FirmaArama.aspx#o
pen
29 Turkey Test Certificates
Turkish Standards Institution (TSE)
https://basvuruportal.tse.org.
tr/Genel/DeneySertifika.aspx#
open
Page 3 of 21
Ministry of Interior, Qatar
General Directorate of Civil Defence
FIRE PREVENTION DEPARTMENT
SAFETY SYSTEMS DIVISION
Doha, Qatar
PRODUCTS
No. THIRD PARTY CERTIFICATION TESTING
Page 4 of 21
Ministry of Interior, Qatar
General Directorate of Civil Defence
FIRE PREVENTION DEPARTMENT
SAFETY SYSTEMS DIVISION
Doha, Qatar
PRODUCTS
No. THIRD PARTY CERTIFICATION TESTING
Page 5 of 21
Ministry of Interior, Qatar
General Directorate of Civil Defence
FIRE PREVENTION DEPARTMENT
SAFETY SYSTEMS DIVISION
Doha, Qatar
PRODUCTS
No. THIRD PARTY CERTIFICATION TESTING
and delay devices
Commercial detectors (heat detector, linear heat
detector, duct detector, smoke detector, aspirating
smoke detectors-point detectors, optical beam
detector, flame detector, multisensory fire
detector, carbon monoxide detector)
Domestic detectors (domestic smoke detector,
domestic carbon monoxide detectors, heat
detectors, smoke alarm for the deaf and hard of
hearing)
Fire Resistant Cables
Page 6 of 21
Ministry of Interior, Qatar
General Directorate of Civil Defence
FIRE PREVENTION DEPARTMENT
SAFETY SYSTEMS DIVISION
Doha, Qatar
PRODUCTS
No. THIRD PARTY CERTIFICATION TESTING
Listing of fire performance of grease filters used in
commercial kitchen extract systems
Roofing Systems (protection against fire from
outside the building)
Non-load bearing external cladding systems
external cladding systems applied to masonry face
of the building
( continuation… ) Non-load bearing external cladding systems
external cladding systems fixed to and supported by
LOSS PREVENTION structural frames
CERTIFICATION Reaction to Fire (RTF) classification for materials
and products
BOARD - Fire Protection for structural steel – intumescent
( LPCB-BRE ) thin film coating system
Page 7 of 21
Ministry of Interior, Qatar
General Directorate of Civil Defence
FIRE PREVENTION DEPARTMENT
SAFETY SYSTEMS DIVISION
Doha, Qatar
PRODUCTS
No. THIRD PARTY CERTIFICATION TESTING
Fire resisting partitions and internal glazed sceens
Fire resisting ducts systems
Fire resisting duct sections
Fire safe modular buildings
Fire resisting dampers
Smoke control dampers
Rendering (spray) for the protection of structural
Boards for the protection of structural steel
Internal and external wall and ceiling finishes,
internal partition kits
Fire stopping
Fire sealing and fire protective products
Fire retardant products
Page 8 of 21
Ministry of Interior, Qatar
General Directorate of Civil Defence
FIRE PREVENTION DEPARTMENT
SAFETY SYSTEMS DIVISION
Doha, Qatar
PRODUCTS
No. THIRD PARTY CERTIFICATION TESTING
Ventilation Ducts
EXOVA Dampers
Page 9 of 21
Ministry of Interior, Qatar
General Directorate of Civil Defence
FIRE PREVENTION DEPARTMENT
SAFETY SYSTEMS DIVISION
Doha, Qatar
PRODUCTS
No. THIRD PARTY CERTIFICATION TESTING
WARRINGTON Smoke Extraction Ducts
Components for Natural Smoke and Exhaust
CERTIFICATION Ventilators
LIMITED Powered Smoke and Heat Exhaust Ventilators
Smoke Curtains and Components
( EWCL ) Cables
Cables and General Plastic Materials
Ventilation Ducts
Dampers
Smoke Extraction Ducts
Components for Natural Smoke and Exhaust
Ventilators
Powered Smoke and Heat Exhaust Ventilators
Smoke Curtains and Components
Cables
Cables and General Plastic Materials
Page 10 of 21
Ministry of Interior, Qatar
General Directorate of Civil Defence
FIRE PREVENTION DEPARTMENT
SAFETY SYSTEMS DIVISION
Doha, Qatar
PRODUCTS
No. THIRD PARTY CERTIFICATION TESTING
Domestic smoke alarms
Multi sensor smoke/heat
Multi sensor smoke/CO
Carbon Monoxide detectors
Smoke alarm devices
Page 11 of 21
Ministry of Interior, Qatar
General Directorate of Civil Defence
FIRE PREVENTION DEPARTMENT
SAFETY SYSTEMS DIVISION
Doha, Qatar
PRODUCTS
No. THIRD PARTY CERTIFICATION TESTING
Combustible Gas Alarms
Domestic Smoke Alarms
Domestic Heat Alarms
Page 12 of 21
Ministry of Interior, Qatar
General Directorate of Civil Defence
FIRE PREVENTION DEPARTMENT
SAFETY SYSTEMS DIVISION
Doha, Qatar
PRODUCTS
No. THIRD PARTY CERTIFICATION TESTING
Sealants
Intumescent Paints
Spray Coatings
External Cladding Materials
Composite Panels
Page 13 of 21
Ministry of Interior, Qatar
General Directorate of Civil Defence
FIRE PREVENTION DEPARTMENT
SAFETY SYSTEMS DIVISION
Doha, Qatar
PRODUCTS
No. THIRD PARTY CERTIFICATION TESTING
Hose systems with lay-flat hose
Gas Extinguishing System
Page 14 of 21
Ministry of Interior, Qatar
General Directorate of Civil Defence
FIRE PREVENTION DEPARTMENT
SAFETY SYSTEMS DIVISION
Doha, Qatar
PRODUCTS
No. THIRD PARTY CERTIFICATION TESTING
- Requirements and test methods for special fire
detectors
- Requirements and test methods for pressure gauges
and pressure switches
- Requirements and test methods for mechanical
weighing devices
- Requirements and test methods for pneumatic
alarm devices
- Requirements and test methods for check valves
and non-return valves
Page 15 of 21
Ministry of Interior, Qatar
General Directorate of Civil Defence
FIRE PREVENTION DEPARTMENT
SAFETY SYSTEMS DIVISION
Doha, Qatar
PRODUCTS
No. THIRD PARTY CERTIFICATION TESTING
THOMAS BELL- Fire Rated Doors and Hardware BUILDING CONSTRUCTION COMPONENTS AND
Steel Doors MATERIALS
WRIGHT IC Wooden Doors Fire resistance (General Requirements)
Composite Doors Reaction to Fire - surface burning characteristics
Fully Glazed Doors FLOOR COVERINGS
Door Hardware Reaction to fire - critical radiant flux of floor-covering
Fire Rated Separating Constructions systems
Gypsum based wall construction (steel and stud) FLOOR DOORS AND SHUTTERS
Insulated and un-insulated Bock walls as load and Fire Resistance
non-load bearing construction types WALLS AND PARTITIONS –non load bearing
Glazed fixes and opening windows Fire Resistance
Fully glazed partition, facades and skylights CURTAIN WALLING
Suspended Ceiling Fire Resistance
Floors (timber, concrete, steel based and glazed GLAZING
units) Fire Resistance
Permanent and demountable partitions DAMPERS
Fire Resistance
Exterior Wall Assemblies, Claddings, Curtain Walls, PENETRATION SEALS
Building Materials, Products & Assemblies Fire resistance
Exterior Insulation Finish Systems(EIFS) or Synthetic HOSE STREAM APPLICATION
Stucco Integrity of building elements after fire exposure
Metal composite material cladding(MCM) CONSTRUCTION PRODUCTS AND BUILDING
High Pressure Laminates ELEMENTS
Structural Insulation Panel Systems (SIPS) and Fire classification
Insulated Sandwich Panel Systems (with Foam or
Rockwool insulation)
Weather-resistive Barriers
External timber panelling and facades including
laminated timber
Building Materials, Products and Assemblies:
- Pipe & Duct Insulation materials
- Textile, Paper or Polymeric (including vinyl) wall or
ceiling coverings and of facing and wood veneers
intended to be applied on site over a wood substrate
- Caulks & Sealants
- Tapes
- Reflective Insulation, Radiant barrier and Vinyl
stretch ceiling Materials
- Site-Fabricated Stretch Systems
- Wood products
- Adhesives
- Batt or blanket type insulating materials
- Coating Materials
- Cementitious Mixtures
- Sprayed Fibers
- Plastics
- Composite assemblies/panels
- Flooring
Fire Doors
Single system manufacture of fire doors by licensed
fabricators as both basic fire door cores for further
processing and/or semi-finished door leaves and
frames for minor adjustment and decoratively finished
by licensees
Page 16 of 21
Ministry of Interior, Qatar
General Directorate of Civil Defence
FIRE PREVENTION DEPARTMENT
SAFETY SYSTEMS DIVISION
Doha, Qatar
PRODUCTS
No. THIRD PARTY CERTIFICATION TESTING
Method for determination of the fire resistance of
Fire Fighting System : elements (general principles
Components for gas extinguishing systems – high Construction elements – resistance to fire
and low pressure selector valves and their actuators
Components for gas extinguishing systems – Test methods for determining the contribution to
connectors fire resistance of structural members
Components for gas extinguishing systems – Horizontal protective membranes
pressure gauges and pressure switches Vertical protective members
Components for gas extinguishing systems - check Applied protection to concrete members
valves and non-return valves Applied passive protection to steel members
Applied reactive protection to steel members
Passive Fire Protection :
Fire stopping, Fire sealing and fire protective Methods of determination of the fire resistance of
products – General non-load bearing elements of construction
Reactive coating for fire protection of steel Walls
elements Ceilings
Rendering and Rendering Kit intended for fire Curtain walls – full configuration
resisting applications Curtain walls – part configuration
Fire protective board, slab and mat product and kit Doors, shutters and openable windows
Cables for general applications in construction Elements of building hardware
works subject to reaction to fire requirements
Landing door fire resistance test
Pedestrian doorsets, industrial, commercial, garage
doors and openable windows — Product standard, Methods of determination of the fire resistance of
performance characteristics — Fire resisting and/or load bearing elements of construction
smoke control characteristics
Walls
Floors and roofs
Beams
Columns
Page 17 of 21
Ministry of Interior, Qatar
General Directorate of Civil Defence
FIRE PREVENTION DEPARTMENT
SAFETY SYSTEMS DIVISION
Doha, Qatar
PRODUCTS
No. THIRD PARTY CERTIFICATION TESTING
maintain circuit integrity
Resistance to Fire
Storage cabinets for flammable liquids
Light fire storage units
Electric cables
Door Assemblies
Building Construction and material
Reaction to Fire
Ignitability of products subjected to direct
impridgement – single flame source test
Building products excluding floorings exposed to
the thermal attack by a single burning item
Non combustibility test
Determination of gross heat combustion
Classification using data from reaction to fire test
Thermal insulating materials for building
applications – determination of organic content
Page 18 of 21
Ministry of Interior, Qatar
General Directorate of Civil Defence
FIRE PREVENTION DEPARTMENT
SAFETY SYSTEMS DIVISION
Doha, Qatar
PRODUCTS
No. THIRD PARTY CERTIFICATION TESTING
Page 19 of 21
Ministry of Interior, Qatar
General Directorate of Civil Defence
FIRE PREVENTION DEPARTMENT
SAFETY SYSTEMS DIVISION
Doha, Qatar
PRODUCTS
No. THIRD PARTY CERTIFICATION TESTING
data from external fire exposure to roof tests
Fire Classification of Construction Products and
Building Elements
Walls
Ceilings
Curtain Walling – Full Configuration
Curtain Walling – Part Configuration
Floors and Roofs
Beams
Columns
Linear Joint Seals
Horizontal and Protective Membranes
Vertical Protective Membranes
Applied Protecion to Concrete Members
Applied Passive Protection to Steel Members
Fire Resistance Doors and Shutte Assemblies and
Openable Windows
Door, Shutter and Openable Windows Assemblies
and Elements of the Building Hardware
Smoke Control Doors and Shutter Assemblies
Light Fire Storage Units
Landing Doors
Safety Storage Cabinets fo Flammable Liquids
Safety Cabinets for Pressure Gas Cylinder
Smoke Barriers
Non-loading Construction Products
Raised Access Floors and Hallow Floors
Penetration Seals
Applied Reactive Protection to Steel Members
Building Elements
Construction Elements – Resistance to Fire
Loadbearing
Electric Cables – Resistance to Fire
Fire Test of Door Assemblies
Page 20 of 21
Ministry of Interior, Qatar
General Directorate of Civil Defence
FIRE PREVENTION DEPARTMENT
SAFETY SYSTEMS DIVISION
Doha, Qatar
Head, Safety Systems Division
Page 21 of 21