Professional Documents
Culture Documents
XXXCPTDIIPNFDPNXFMDPNF
%JTIXBTIFS SM…
SB…
BVT *OTUSVDUJPONBOVBM
5HVHWVHF
K
K
K
6WDUW
K
K
K
aus
Table of contents
3
aus Intended use
( Safety instructions
ytefS
a onsitucrtnsi
4
Safety instructions aus
5
aus Safety instructions
6
Safety instructions aus
m Warning m Warning
Risk of injury! Risk of scalding!
To prevent injuries, e.g. Open the door carefully when
caused by stumbling, open the programme is still running.
the dishwasher only briefly There is a risk of hot water
in order to load and unload spraying out of the appliance.
the dishwasher.
Knives and other utensils m Warning
with sharp points must be Risks to children!
placed in the cutlery basket
with the points If fitted, use the childproof
downwards or horizontally on lock. An exact description
the knife shelf*. can be
found in the back of the enve
Do not lean or sit lope.
on the open door. Do not allow children to play
In the case of free-standing with or operate
appliances, ensure that the the appliance.
baskets are not overloaded.
Keep children away from
If the appliance detergents and rinse aid.
is not in a cavity and a side These may cause chemical
panel is accessible, the door burns in the mouth, throat
hinge area must be covered and eyes or asphyxiation.
at the side Keep children away from
for reasons of safety open dishwasher.
(risk of injury). The covers The water in the rinsing
are available as optional compartment is not drinking
accessories from customer water and could contain
service or specialist outlets. detergent residue.
* depending on model Ensure that children do not
place fingers in the tablet
m Warning collecting tray 12. Small
Risk of explosion! fingers could become
Do not add any solvents caught in the slots.
to the washing chamber.
Danger of explosion!
7
aus Protection of the environment
Old appliances
Please follow the safety instructions
under “Disposal of your appliance”.
This appliance is labelled in
accordance with European
Directive 2012/19/EU
concerning used electrical and
electronic appliances (waste
electrical and electronic
equipment - WEEE). The
guideline determines the
framework for the return and
recycling of used appliances as
applicable throughout the EU
8
Getting to know your appliance aus
ngitG
te knowot oury encaipla
As soon as the rinse-aid refill
indicator X is lit on the fascia, there
Diagrams of the control panel
is still a rinse-aid reserve of 1-2 rinsing
and the interior of the appliance can be
processes. Refill with rinse aid.
found in the envelope at the front.
The rinse aid is required for stain-free
Individual positions are referred
utensils and clear glasses. Use only
to in the text.
rinse aid for domestic dishwashers.
Combined detergents with rinse-aid
Control panel component may be used up to a water
hardness of 21° dH (37° fH,
26° Clarke, 3.7 mmol/l) only. If
( ON/OFF switch
the water hardness is over 21° dH,
0 Door opener rinse aid must be used.
8 Programme selector 1. Open the dispenser 1b by pressing
@ START button and lifting the plate on the cover.
H Timer programming *
P Additional options **
X Rinse aid refill indicator
` Display “Check water supply”
h Dry display
)" Cleaning display
* depending on model
** Number depending on model
Appliance interior
2. Carefully pour rinse aid up
to the max. mark in the filler opening.
1" Top basket
1* Knife shelf *
12 Tablet collecting tray
1: Top spray arm
1B Bottom spray arm
1J Filters
1R Cutlery basket
1Z Bottom basket PD[
1b Dispenser for rinse aid
1j Detergent dispenser
9" Lock for detergent dispenser
9* Rating plate
* depending on model
9
aus Utensils
10
Utensils aus
11
aus Utensils
Tip EtagerEtagere *
Other examples, such as the best way
of loading your dishwasher, can The etagere and the space underneath
be found on our homepage as a free can be used for small cups and glasses
download. The corresponding Internet or for larger items of cutlery, such as
address can be found on the back page wooden spoons or serving cutlery. The
of these instructions for use. etagere can be folded up if not required.
Folding spikes *
Foldingspikes
* depending on model
The spikes can be folded down to
improve arrangement of pans, bowls
and glasses.
12
Utensils aus
basket *
* depending on model
Light-weight plastic accessories, e.g. * depending on model
cups, lids, etc. can be held securely in If required, the height of the upper
the small accessories holder. utensils basket 1" can be adjusted to
provide more space for tall utensils
either in the upper or lower basket.
Appliance height 81.5 cm
Top basket Bottom
basket
Setting 1 max. ø 22 cm 30 cm
Setting 2 max. ø 24.5 cm 27.5 cm
Setting 3 max. ø 27 cm 25 cm
Appliance height 86.5 cm
Top basket Bottom
Knife shelf * Knifeshelf
basket
Setting 1 max. ø 24 cm 33 cm
* depending on model
Long knives and other utensils can be Setting 2 max. ø 26.5 cm 30.5 cm
arranged horizontally. Setting 3 max. ø 29 cm 28 cm
Select one of the two following
procedures according to the design of
the top basket for your appliance model:
13
aus Utensils
14
Detergent aus
Adding detergent
. Detergent
1. If the detergent dispenser 1j is still
ntgereD
te
You can use tablets as well as powder closed, press the lock 9" to open
or liquid detergents for dishwashers, but the detergent dispenser.
never use washing up liquid. Pour detergent into the dry detergent
The dosage can be individually adjusted dispenser 1j only (insert tablet flat,
with powder or a liquid detergent not on its edge).
according to the degree of soiling. Dosage: see manufacturer’s
Tablets contain an adequately large instructions on the packaging.
amount of active ingredients The graduated detergent
for all cleaning tasks. Modern, powerful dispenser 1j helps you add the
detergents predominantly use a low- correct amount of powder or liquid
alkaline formulation with phosphate detergent.
and enzymes. Phosphates bond Usually 20 ml–25 ml are adequate
the lime in the water. Enzymes break for normal soiling. If using tablets,
down starch and remove protein. one tablet is adequate.
Phosphate-free detergents are less
frequent. These have a slightly weaker PO
lime bonding capacity and require PO
a higher dosage. To remove coloured PO
stains (e.g. tea, tomato sauce), oxygen-
based bleaching agents are usually
used.
Note
To ensure a good washing result, 2. Close the cover on the detergent
always follow the instructions dispenser by sliding it up until the
on the detergent packaging! lock engages without difficulty.
If you have further questions,
we recommend that you contact
the detergent manufacturers’ helpline.
15
aus Detergent
Tip Notes
If the utensils are only lightly soiled, If programmes are short, tablets
slightly less than the indicated amount may not have full cleaning effect
of detergent is usually adequate. due to different dissolving properties
Suitable detergents and care products and there may even be undissolved
can be purchased online detergent residue. It is
via our website or via customer service recommended to use washing
(see back page). powder for these programmes.
The Intensive programme (on some
m Warning – Do not place small parts models) requires one tab only. When
using washing powder, you can
for washing in the tablet collecting tray
12; this prevents the tablet from apply some of this cleaning agent
dissolving evenly. to the inside of the appliance’s door.
If using detergents in a water-soluble
m Warning – If you want to add more protective cover: Take hold of the
cover with dry hands only and put
utensils after the programme
has started, do not use the tablet the detergent into an absolutely
collecting tray 12 as a handle dry detergent dispenser only,
for the upper basket. The tablet could otherwise the detergent may stick.
already be there and you will touch If you switch from combined
the partially dissolved tablet. detergents to solo detergents,
ensure that the water softening
system and amount of rinse aid have
been set to the correct value.
16
Overview of programmes aus
m
aogrm
/ Overview of programmes
prseofw
eviO
rve
17
aus Overview of programmes
1.) 0:29
Utensils and
cutlery ñ/ð 2.) 0,80
Extra drying
Clean 45°
Intermediate rinse
Quick 45° 3.) 10
Lightly soiled Final rinse 55°
4.) -
1.) 0:15
all types
of utensils ù/ø 2.) 0,05
none Prerinse
Lightly soiled Prerinse 3.) 4
4.) -
Programme selection
You can select a suitable programme
according to the type of utensils and
degree of soiling.
18
Additional options aus
lonaitAdi onsiopt
· Hygiene * Hygien
19
aus Operating the appliance
Timer programming *
1 Operating Timerprogram ing
programme by 3, 6 or 9 hours.
Aqua sensor *
Aquasensor
1. Switch on ON/OFF switch (.
2. Keep pressing the Preselected
* depending on model
starting time button H until the
The Aqua sensor is an optical appropriate display 3h, 6h or 9h is lit.
measuring device (light barrier) which 3. Press START button @, timer
measures the turbidity of the rinsing programming is activated.
water.
4. To delete the preselected starting
The Aqua sensor is used according to time, keep pressing the Preselected
the programme. If the Aqua sensor is starting time button H until none of
active, “clean” rinsing water can be the displays 3h, 6h or 9h is lit.
transferred to the next rinse bath and
You can change your programme
water consumption can be reduced by
selection at any time until the
3–6 litres. If the turbidity is greater, the
programme starts.
water is drained and is replaced with
fresh water. In the automatic
programmes the temperature and End of programme
running time can also be adjusted to the
degree of soiling. The programme has ended when
neither of the two displays h or )" is
Switching on the appliance lit.
Note
1. Turn on the tap fully.
To save energy, the dishwasher
2. Close the door. automatically switches off after the end
3. Switch on ON/OFF switch (. of the programme.
The Cleaning display )" flashes.
4. Rotate programme selector 8
to the required programme. Interrupting the programme
5. Press START button @. 1. Switch off ON/OFF switch (.
The Cleaning display )" is lit. The The LEDs go out. The programme is
programme starts running. saved.
If the door was opened on an
appliance which has a warm water
connection or is heated, first leave
the door ajar for several minutes and
then close. Otherwise, expansion
(pressure) may cause the appliance
door to spring open or water to run
out of the appliance.
2. To continue the programme, switch
on the ON/OFF switch ( again.
20
Cleaning and maintenance aus
(Reset)
2 Cleaning and
maintenance
1. Press START button @ for
ngniaeCl nda encaentm
ia
21
aus Cleaning and maintenance
22
Fault, what to do? aus
In this case:
3 Fault, what to do?
,tF
ula w
tha ot do?
1. First always disconnect
the appliance from the power supply.
Experience has shown that you can 2. Take out top basket 1" and bottom
rectify most faults which occur in daily basket 1Z.
operation yourself. This ensures that 3. Remove the filters 1J.
the machine is quickly available to you
again. In the following overview you can 4. Scoop out water, use a sponge if
find possible causes of malfunctions required.
and helpful information for rectifying 5. Prise out the white pump cover
them. (as illustrated) using a spoon. Grip
the cover on the crosspiece and lift
Note diagonally inwards. Remove cover
If the appliance stops during completely.
dishwashing or does not start for no
obvious reason, first run the Abort
programme function (Reset).
(See chapter entitled “Operating
the appliance”)
m Warning – Don’t forget: Repairs may
be carried out by technicians only. If a
component has to be replaced, ensure
that only original spare parts are used.
Improper repairs or use of non-original
spare parts may cause considerable
damage and put the user at 6. Check impeller wheel and remove
considerable risk. any foreign objects.
7. Place cover in the original position
Waste water pump and press down until it engages
(click).
Large food remnants or foreign objects
which were not captured by the filters
may block the waste water pump. The
rinsing water will then be above
the filter.
23
aus Fault, what to do?
Fault table
24
Fault, what to do? aus
25
aus Fault, what to do?
26
Fault, what to do? aus
27
aus Fault, what to do?
28
Fault, what to do? aus
29
aus Fault, what to do?
30
Customer service aus
Safety instructions
Please follow the safety instructions
under “Installation”.
31
aus Installation and connection
Delivery Installation
Your dishwasher has been checked The required installation dimensions can
thoroughly in the factory to ensure that it be found in the installation instructions.
is in working order. This may cause Level the appliance with the aid of the
small water stains. These will disappear height-adjustable feet. Ensure that the
after the first wash cycle. appliance is situated securely on the
floor.
Technical specifications A built-under or integrated appliance
which is installed subsequently as a
free-standing appliance must be
Weight: secured to prevent it from
max. 60 kg overturning, e.g. by screwing it to the
Voltage: wall or by installing it under
a continuous worktop which is
220–240 V, 50 Hz or 60 Hz
screwed to adjacent cupboards.
Connected load: The appliance can easily be
2.0–2.4 kW installed in a fitted kitchen between
Fuse: wooden and plastic walls.
10/16 A (UK 13A)
Power input: Waste-water connection
switched off 0.1 W
1. The required work sequence can be
not switched off 0.1 W
found in the installation instructions.
Water pressure: If required, fit a siphon with an
at least 0.05 MPa (0.5 bar), maximum drainage connection.
1 MPa (10 bar). At a higher water 2. Connect the waste-water hose to the
pressure: connect pressure-reducing drainage connection of the siphon
valve ahead. with the enclosed parts.
Inlet rate: Ensure that the drainage hose is not
minimum 10 litres/minute kinked, crushed or twisted and that
there is no cover plate in the
Water temperature: drainage to prevent the waste water
for cold water connection only. from flowing out!
Capacity:
12–15 place settings (depending
on model).
32
Installation and connection aus
33
aus Installation and connection
Transportation
Empty the dishwasher and secure loose
parts.
Drain the appliance according
to the following steps:
1. Turn on the tap.
2. Close the door.
3. Switch on ON/OFF switch (.
4. Select programme with the highest
temperature.
5. Press START button @.
Programme sequence starts.
6. After approx. 4 minutes press
the START button @ until all
displays go out.
After approx. 1 min. the appliance is
completely drained.
7. Switch off ON/OFF switch (.
8. Turn off the tap, disconnect supply
hose and drain water.
Transport appliance upright only.
(This prevents residual water from
running into the machine control
and damaging the programme
sequence.)
6XEMHFWWRFKDQJHV
34
&KLOGSURRIORFNGRRUORFN
:DUQLQJ
$FWLYDWHWKHFKLOGSURRIORFN $OZD\VFORVHWKHDSSOLDQFHGRRUFRPSOHWHO\
2SHQWKHGRRUZLWKDFWLYDWHG ZKHQ\RXOHDYHWKHDSSOLDQFH
FKLOGSURRIORFN 7KLVLVWKHRQO\ZD\\RXFDQSURWHFW\RXU
'HDFWLYDWHFKLOGSURRIORFN FKLOGUHQIURPSRWHQWLDOGDQJHUV
%DNLQJVKHHWVSUD\KHDG
/DUJHVKHHWVRUJULOOHVDQGSODWHVZKLFKKDYHDGLDPHWHUJUHDWHUWKDQFPJRXUPHW
SODWHVSDVWDSODWHVGLQQHUSODWHVFDQEHFOHDQHGZLWKWKHDLGRIWKHVSUD\KHDG
7RGRWKLVUHPRYHWKHWRSEDVNHWDQGLQVHUWWKHVSUD\KHDGDVLOOXVWUDWHGLQWKHGLDJUDP
7RHQVXUHWKDWWKHVSUD\MHWFDQUHDFKDOOSDUWVDUUDQJHWKHEDNLQJVKHHWVDVLOOXVWUDWHG
PD[âEDNLQJVKHHWVDQGâJULOOHV
1HYHURSHUDWHWKHGLVKZDVKHUZLWKRXWWKHWRSEDVNHWRUEDNLQJVKHHWVSUD\KHDG
VRPHPRGHOV
$TXD6WRSJXDUDQWHH EPFTOPUBQQMZUPBQQMJBODFTXJUIPVU"RVB4UPQ
*OBEEJUJPOUPXBSSBOUZDMBJNTBHBJOTUUIFTFMMFSCBTFEPOUIFQVSDIBTFDPOUSBDU
BOEJOBEEJUJPOUPPVSBQQMJBODFXBSSBOUZXFXJMMQBZEBNBHFTVOEFS
UIFGPMMPXJOHDPOEJUJPOT
*GPVS"RVB4UPQTZTUFNJTEFGFDUJWFBOEDBVTFTXBUFSEBNBHF
XFXJMMNBLFHPPEUIFEBNBHFGPSQSJWBUFVTFST
5PFOTVSFXBUFSEBNBHFQSPUFDUJPO
UIFBQQMJBODFNVTUCFDPOOFDUFE
UPUIFQPXFSTVQQMZ
5IJTMJBCJMJUZHVBSBOUFFJTWBMJEGPSUIFTFSWJDFMJGFPGUIFBQQMJBODF
"QSFSFRVJTJUFGPSUIFXBSSBOUZDMBJNJTUIBUUIFBQQMJBODFIBTCFFODPSSFDUMZ
JOTUBMMFEBOEDPOOFDUFEXJUI"RVB4UPQBDDPSEJOHUPPVSJOTUSVDUJPOT
5IJTBMTPJODMVEFTUIFDPSSFDUJOTUBMMBUJPOPGUIF"RVB4UPQFYUFOTJPO
PSJHJOBMBDDFTTPSZ
0VSXBSSBOUZEPFTOPUFYUFOEUPEFGFDUJWF
GFFEMJOFTPSGJUUJOHTVQUPUIF"RVB4UPQDPOOFDUJPOPOUIFUBQ
*GZPVSBQQMJBODFJTGJUUFEXJUI"RVB4UPQ
ZPVDBOMFBWFZPVSBQQMJBODF
VOBUUFOEFEEVSJOHPQFSBUJPOBOEMFBWFUIFUBQUVSOFEPOBGUFSXBSET
5IFUBQTIPVMEPOMZCFUVSOFEPGGJGZPVBSFBCTFOUGSPNIPNFGPS
BQSPMPOHFEQFSJPE
FHTFWFSBMXFFLTIPMJEBZ
5HSDLURUGHUDQGDGYLFHRQIDXOWV
(# $BMMTGSPNB#5MBOEMJOFXJMMCFDIBSHFEBUVQUPQFODFQFSNJOVUF
"DBMMTFUVQGFFPGVQUPQFODFNBZBQQMZ
*& ƉQFSNJOVUFBUQFBL0GGQFBLƉQFSNJOVUF
64 UPMMGSFF
$POUBDUJOGPSNBUJPOGPSBMMDPVOUSJFTDBOCFGPVOEPOUIFFODMPTFEDVTUPNFSTFSWJDFMJTU
5REHUW%RVFK+DXVJHUlWH*PE+
$BSM8FSZ4USBF
.ßODIFO
(FSNBOZ
ZZZERVFKKRPHFRP
*9000969717*
9000969717 aus (9402) 640EA