The document discusses key concepts related to vapor cycles. It notes that an ideal working medium for a vapor cycle should be noncorrosive and nontoxic. It also describes that a vapor cycle involves changes in state from gas to liquid via a condenser and uses a working fluid to absorb and release heat energy. Additionally, the document explains that a closed rankine vapor cycle involves a prime mover that obtains energy from the working fluid's expansion.
The document discusses key concepts related to vapor cycles. It notes that an ideal working medium for a vapor cycle should be noncorrosive and nontoxic. It also describes that a vapor cycle involves changes in state from gas to liquid via a condenser and uses a working fluid to absorb and release heat energy. Additionally, the document explains that a closed rankine vapor cycle involves a prime mover that obtains energy from the working fluid's expansion.
The document discusses key concepts related to vapor cycles. It notes that an ideal working medium for a vapor cycle should be noncorrosive and nontoxic. It also describes that a vapor cycle involves changes in state from gas to liquid via a condenser and uses a working fluid to absorb and release heat energy. Additionally, the document explains that a closed rankine vapor cycle involves a prime mover that obtains energy from the working fluid's expansion.
An ideal medium shall be Noncorrosive and Nontoxic
A Heat Stream is often the best way to present a heat balance Low Efficiency is common to all heat power cycles A closed cycle plant contains Auxiliary Equipment added for economic reasons A Binary Vapor Cycle is two power cycles working together An Engine Cycle considers only the changes occurring within the engine A Condenser turns a fluid from its gaseous state to a liquid state Working Medium is a fluid substance capable of absorbing and discharging heat energy. Friction destroys perfect reversibility In a closed rankine vapor cycle, the prime mover obtains the working expansion A no-load input is required to satisfy friction and radiation losses A regenerative heater resembles a small surface condenser Deaerators dissolve oxygen gas in water to prevent corrosion in boiler Engine cycle considers only the changes occurring within the engine High density is a desirable property in securing separation of vapor form liquid in the boiler Heaters are located near the turbine to have little pressure drop to the heater The prime mover of the regenerative cycle plant is a Steam Turbine Surge Tank absorbs the irregularities of cycle flow Regenerative Heater resembles a small surface condenser Pressure Loss is due to pipe friction and throttling at the extraction nozzle Distilled Water is used for feed water make-up Mercury as a vapor cycle has low specific enthalpy Evaporators use extracted steam for vaporizing raw water A closed cycle plant ordinarily contains auxiliary equipment added for economic reasons A balanced heat and power supply are generally economical In a turbine, moisture in expanding steam is undesirable It is assumed that reheating begins at the saturation line. Live steam reheater was once used in earlier reheat cycles Mercury as a vapor cycle has moderate vapor pressure at higher temperature Modernizing existing equipment increases capacity of an existing plant Mercury can seep through joints or cracks that would be impervious to water of steam In a closed rankine vapor cycle, the condenser reduce the exhaust steam to liquid Enthalpy is the sum of internal energy and flow work Economizer is using the extracted steam to preheat the feed water Feed Water Heater designed to preheat boiler feed water of condensing steam extracted from steam turbine Isobaric Process is a process in which the pressure stays constant VAPOR CYCLE
Entropy is a measure of molecular disorder or molecular randomness