Professional Documents
Culture Documents
cardiagn.com
Fig. 383: Prying Off Left Cover From Instrument Panel Using A Screwdriver
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
Fig. 384: Identifying Light Switch, Spreader Pin, And Instrument Cluster
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Installing
{ Press the switch into the switch housing until lock mechanism engages.
cardiagn.com
Fig. 385: Hook 3438
Courtesy of VOLKSWAGEN UNITED STATES, INC.
z Hook 3438
Fig. 386: Pressing Cover Strip At Button Unit For Instrument Cluster
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
{ Press cover strip - 1 - at button unit for instrument cluster in - direction of arrow -.
{ Take cover strip and pull off switch.
cardiagn.com
Fig. 387: Removing Buttons From Instrument Cluster Lining Using Hook 3438
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Installing
Glove Compartment Button E316 and Display Button E506 , removing and installing
z Hook 3438
cardiagn.com
Fig. 389: Pressing Cover Strip At Button For Glove Compartment Release
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
{ Press cover strip - 1 - at button unit for Glove Compartment Button E316 and Display Button E506 in -
direction of arrow -.
{ Take cover strip and pull off switch.
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
cardiagn.com
Fig. 390: Removing Buttons From Instrument Cluster Lining Using Hook 3438
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Installing
cardiagn.com
z Hook 3438 (2x)
Fig. 393: Releasing Spring Pins Of Decorative Panel From Instrument Panel Using Trim Removal Wedge
3409
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
{ Adjust steering wheel downward and to rear as far as possible, use entire adjustment range of steering
column adjustment for this.
CAUTION:
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
{ Carefully release spring pins - 2 - of decorative panel from instrument panel using trim removal wedge
3409.
NOTE: z The instrument panel vent provides a hole on both sides to engage the
hook 3438.
z Carefully remove the instrument panel at both sides from installation
opening using the hook 3438.
If the instrument panel vent cannot be pulled out that way, proceed as follows:
cardiagn.com
{ Release all clips - arrow - by inserting clockmaker screwdrivers - 1 - and - 3 -.
{ Remove instrument panel vent on both sides out of installation opening using hook 3438 , the clockmaker
screwdrivers must remain inserted when doing so.
{ If installed, disconnect electrical harness connector at instrument panel vent.
Fig. 394: Identifying Clips, Trim Panel, And Headlamp Adjuster E102
Courtesy of VOLKSWAGEN UNITED STATES, INC.
{ Release clips - arrows 1 - and remove trim panel toward front - arrow 2 -.
{ Release clips and press Headlamp Adjuster E102 out - arrow 3 -.
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
Installing
cardiagn.com
Fig. 395: Identifying Trim Removal Wedge 3409
Courtesy of VOLKSWAGEN UNITED STATES, INC.
cardiagn.com
Fig. 397: Releasing Spring Pins Of Decorative Panel From Instrument Panel Using Trim Removal Wedge
3409
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
{ Adjust steering wheel downward and to rear as far as possible, use entire adjustment range of steering
column adjustment for this.
{ Carefully release spring pins - 1 - of decorative panel from instrument panel using trim removal wedge
3409.
NOTE: z The instrument panel vent provides a hole on both sides to engage the
hook 3438.
z Carefully remove the instrument panel at both sides from installation
opening using the hook 3438.
If the instrument panel vent cannot be pulled out that way, proceed as follows:
Fig. 398: Pressing Emergency Flasher Switch E3 Out Of Decorative Panel With Air Vent
Courtesy of VOLKSWAGEN UNITED STATES, INC.
cardiagn.com
{ Press Emergency Flasher Switch E3 - 1 - out of decorative panel with air vent - arrow -.
Installing
{ Press the switch into the switch housing until lock mechanism engages.
cardiagn.com
Fig. 401: Releasing Spring Pins Of Decorative Panel From Instrument Panel Using Trim Removal Wedge
3409
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
{ Adjust steering wheel downward and to rear as far as possible, use entire adjustment range of steering
column adjustment for this.
{ Carefully release spring pins - 1 - of decorative panel from instrument panel using trim removal wedge
3409.
NOTE: z The instrument panel vent provides a hole on both sides to engage the
hook 3438.
z Carefully remove the instrument panel at both sides from installation
opening using the hook 3438.
If the instrument panel vent cannot be pulled out that way, proceed as follows:
cardiagn.com
{ Disconnect electrical harness connectors.
Fig. 402: Pushing Buttons Out Of Decorative Panel With Air Vent
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Installing
{ Press the switch into the switch housing until lock mechanism engages.
z T8 screwdriver T40056 A
cardiagn.com
Fig. 404: Identifying Bolts, Handle, Torx Bolts, Upper Trim, And Lower Trim
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
{ Remove lower instrument panel cover on drivers side --> 68 - INTERIOR EQUIPMENT .
{ Adjust steering wheel downward and to rear as far as possible, use entire adjustment range of steering
column adjustment for this.
{ Remove bolts - 3 - and - 4 - using T8 screwdriver T40056 A.
NOTE: z Disregard - 5 -.
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
cardiagn.com
Fig. 405: Removing Bolts And Steering Column Adjustment Switch E167 Upward From Bottom Trim
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Installing
{ Insert top trim piece for steering column switch into catches of bottom trim piece, press together and bolt.
{ Install lower instrument panel cover on drivers side --> 68 - INTERIOR EQUIPMENT .
Tightening torques
Component Nm
Steering Column Adjustment Switch E167 to bottom trim 2.5
Trim for steering column switch 0.6
Bottom trim to steering column 3.5
cardiagn.com
Removing
Fig. 407: Pulling Climatronic Control Module J255 (Control Head) Out Of Mounting Frame
Courtesy of VOLKSWAGEN UNITED STATES, INC.
{ Reach from bottom into recesses into recesses at Climatronic Control Module J255 (control head).
{ Pull Climatronic Control Module J255 (control head) out of mounting frame - arrows -.
{ Put Climatronic Control Module J255 (control head) down on center console on rag to prevent surfaces
from damage.
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
cardiagn.com
{ Disconnect electrical harness connector - E -.
cardiagn.com
Fig. 410: Removing Bolts And Releasing Ashtray Using Screwdriver In Opening
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Fig. 411: Unclipping Boot For Gearshift Lever Or Selector Lever On Both Sides And Pull Off Upward
Courtesy of VOLKSWAGEN UNITED STATES, INC.
{ Unclip boot - 1 - for gearshift lever or selector lever on both sides and pull off upward - arrows -.
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
Fig. 412: Releasing Retaining Spring And Removing Selector Lever Transmission Range (TR) Position
Display Y26 Upward
Courtesy of VOLKSWAGEN UNITED STATES, INC.
cardiagn.com
{ Release retaining spring - 2 - and remove Selector Lever Transmission Range (TR) Position Display Y26
- 1 - upward.
{ Disconnect electrical harness connector.
Fig. 413: Lifting Front Center Console At Rear And Pulling Off Of Instrument Panel Toward Rear
Courtesy of VOLKSWAGEN UNITED STATES, INC.
All:
cardiagn.com
Fig. 415: Identifying Retaining Clips, Decorative Frame, And Multimedia Control Head E380
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Fig. 416: Removing Bolts And Parking Brake Contact Switch F321 At Button Trim
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Installing
Tightening torques
Component Nm
Parking Brake Contact Switch F321 to button trim 0.8
cardiagn.com
Multimedia Control Head E380 to front center console 3
Front center console to center console frame 3
Ashtray housing to front center console frame 3
Fig. 417: Pulling Climatronic Control Module J255 (Control Head) Out Of Mounting Frame
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
{ Reach from bottom into recesses into recesses at Climatronic Control Module J255 (control head).
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
{ Pull Climatronic Control Module J255 (control head) out of mounting frame - arrows -.
cardiagn.com
Fig. 418: Removing Gap Cover Above Ashtray
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Fig. 419: Removing Bolts And Releasing Ashtray Using Screwdriver In Opening
Courtesy of VOLKSWAGEN UNITED STATES, INC.
cardiagn.com
Fig. 420: Pressing Out Access/Start Authorization Button E408
Courtesy of VOLKSWAGEN UNITED STATES, INC.
{ Reach through opening of ashtray and press out Access/Start Authorization Button E408 - 1 - - arrow -.
{ Disconnect electrical harness connector.
Installing
Tightening torque
Component Nm
Ashtray housing to front center console frame 3
Selector Lever Transmission Range (TR) Position Display Y26 , removing and installing
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
cardiagn.com
Fig. 421: Unclipping Mounting Frame For Selector Lever Boot From Center Console
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
{ Unclip mounting frame for selector lever boot - 1 - from center console and lift it upward - arrows -.
{ Fold selector lever boot upward.
Fig. 422: Releasing Retaining Spring And Removing Selector Lever Transmission Range (TR) Position
Display Y26 Upward
Courtesy of VOLKSWAGEN UNITED STATES, INC.
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
{ Release retaining spring - 2 - and remove Selector Lever Transmission Range (TR) Position Display Y26
- 1 - - arrow -.
{ Disconnect electrical harness connector.
Installing
Front seat heater switches are integrated in Climatronic Control Module J255 (also called "control head" ). They
cannot be replaced separately.
cardiagn.com
Special tools, testers and auxiliary items required
z Hook 3438
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
Fig. 424: Pulling Rear Center Console Vent Out Of Rear Center Console Using Hook 3438
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
cardiagn.com
CAUTION: z Switch off all electrical components.
z Switch ignition off and remove ignition key.
NOTE: z Rear center console vent has openings for engaging hook 3438.
z Pull rear center console vent out of rear center console in - direction of
arrow - using hook 3438.
z If installed, disconnect electrical harness connector at rear center console
vent.
Fig. 425: Identifying Left Rear Heated Seat Regulating Switch E128 And Right Rear Heated Seat
Regulating Switch E129
Courtesy of VOLKSWAGEN UNITED STATES, INC.
{ Remove Left Rear Heated Seat Regulating Switch E128 - 2 - and Right Rear Heated Seat Regulating
Switch E129 - 1 - out of mount.
Installing
cardiagn.com
Fig. 426: Identifying Left Rear Heated Seat Regulating Switch E128 And Right Rear Heated Seat
Regulating Switch E129
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
Fig. 427: Removing Bolts And Trim With Lighter From Rear Center Console
Courtesy of VOLKSWAGEN UNITED STATES, INC.
cardiagn.com
{ Remove trim - 1 - with lighter from rear center console.
Installing
Tightening torque
Component Nm
Trim with lighter to rear center console 2
Removing
{ If Rain/Light Recognition Sensor G397 is replaced, select respective control module in "Guided
Functions".
{ Pry off cover - 1 - at upper mirror base - arrows -.
cardiagn.com
Fig. 429: Disconnecting Electrical Harness Connector And Rotating Interior Mirror At Mirror Base
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Fig. 430: Identifying Retaining Clips, Rain/Light Recognition Sensor G397 And Electrical Harness
Connector
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Installing
cardiagn.com
Glove Compartment Lamp Switch E26 , removing and installing
Removing
Installing
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
cardiagn.com
Fig. 432: Identifying Retaining Spring, Electrical Harness Connector, Bracket, And Bolts
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
{ Remove armrest and disconnect electrical harness connector - 5 - for window regulator switch.
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
Fig. 433: Removing Bolts And Switch Mount Cover From Armrest
Courtesy of VOLKSWAGEN UNITED STATES, INC.
cardiagn.com
Fig. 434: Identifying Electrical Harness Connector, Mirror Adjustment Switch, And Catches
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Installing
NOTE: z When installing, make sure that symbol panel is inserted in front of mirror
adjustment switch.
z Press switch into switch mount until catches engage.
z Install front door trim --> 70 - INTERIOR TRIM
Tightening torques
Component Nm
Cover vor mirror adjustment switch to armrest 2.5
Armrest to door trim 2.5
Power Window Control Head (in drivers door) E512 , removing and installing
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
Fig. 435: Identifying Retaining Spring, Electrical Harness Connector, Bracket, And Bolts
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
cardiagn.com
CAUTION: z Switch off all electrical components.
z Switch ignition off and remove ignition key.
{ Remove armrest and disconnect electrical harness connector - 5 - for window regulator switch.
Fig. 436: Identifying Catches, Retaining Element, And Power Window Control Head E512
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Installing
{ Press Power Window Control Head (in drivers door) E512 into switch mount until catches engage.
{ Install front door trim --> 70 - INTERIOR TRIM
Tightening torque
Component Nm
Armrest to door trim 2.5
Rear Lid Remote Control Lock Switch E233 and Fuel Tank Lid Unlock Button E319 , removing and installing
cardiagn.com
Fig. 437: Identifying Catches, Electrical Harness Connector, Rear Lid Remote Control Lock Switch E233
And Fuel Tank Lid Unlock Button E319
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
Installing
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
cardiagn.com
Fig. 438: Identifying Catches, Window Regulator Switch E107, And Electrical Harness Connector
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
Installing
{ Press Window Regulator Switch (in RF door) E107 into switch mount until catches engage.
{ Install front door trim --> 70 - INTERIOR TRIM
Left Rear Window Switch E52 / Right Rear Window Switch E54 , removing and installing
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
Fig. 439: Disconnecting Electrical Harness Connector For Window Regulator Switch And For Ashtray
Illumination
Courtesy of VOLKSWAGEN UNITED STATES, INC.
cardiagn.com
Removing
Installing
Tightening torque
Component Nm
Armrest to door trim 2.5
Front Seat Memory Program Control E97 / E277 , removing and installing
cardiagn.com
Fig. 441: Removing Decorative Panel From Door Trim
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
Fig. 442: Removing Bolts And Front Seat Memory Program Control From Door Trim
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
Installing
Tightening torque
Component Nm
Front seat memory program control to door trim 1.5
cardiagn.com
Door contact switches, removing and installing
The door contact switch is located in the door lock and cannot be replaced individually when faulty.
{ Replace front door lock --> 57 - FRONT DOORS, WINDOW REGULATORS, CENTRAL
LOCKING SYSTEM .
{ Replace rear door lock --> 58 - REAR DOORS, WINDOW REGULATORS .
Drivers Interior Locking Switch E150 / Front Passengers Interior Locking Switch E198 (central locking switch),
removing and installing
Removing
Installing
{ Press interior locking switch into switch mount until retaining springs engage.
{ Install front door trim --> 70 - INTERIOR TRIM
Passenger Compartment Monitoring Switch E183 and Alarm System -Off- Switch E217 , removing and installing
cardiagn.com
Fig. 444: Prying Panel Out Of Door Trim Using A Small Screwdriver
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
{ Carefully pry panel - 1 - out of door trim - arrow - using a small screwdriver.
{ Disconnect electrical harness connector.
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
Fig. 445: Identifying Catches, Passenger Compartment Monitoring Switch E183 And Alarm System -Off-
Switch E217
Courtesy of VOLKSWAGEN UNITED STATES, INC.
cardiagn.com
{ Carefully release catches - arrows - using a small screwdriver.
{ Remove Passenger Compartment Monitoring Switch E183 and Alarm System -Off- Switch E217 - 1 -
toward rear out of panel - 2 -.
Installing
Left Rear Interior Lock Switch E273 / Right Rear Interior Lock Switch E274 (central locking switch), removing and
installing
Removing
{ Release retaining clips - arrows - and press rear interior locking switch from door trim toward vehicle
interior.
Installing
{ Press rear interior locking switch into switch mount until retaining springs engage.
{ Install rear door trim --> 70 - INTERIOR TRIM .
cardiagn.com
Fig. 447: Identifying Electrical Harness Connector, Bolts, And Sunroof Regulator E139
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
{ Remove front interior/reading light --> Front interior light module, removing and installing.
{ Disconnect electrical harness connector - 1 -.
{ Remove bolts - arrows -.
{ Remove Sunroof Regulator E139 - 2 - from interior/reading light.
Installing
Component Nm
Sunroof regulator to interior/reading light 1.5
Removing
cardiagn.com
CAUTION: z Switch off all electrical components.
z Switch ignition off and remove ignition key.
Fig. 449: Releasing Retaining Springs Using A Small Screwdriver And Pivoting Garage Door Opener
Control Head E284 Out Of Interior/Reading Light
Courtesy of VOLKSWAGEN UNITED STATES, INC.
{ Release retaining springs - arrows - using a small screwdriver and pivot Garage Door Opener Control
Head E284 out of interior/reading light.
{ Disconnect electrical harness connector.
Installing
Rear Lid Lock Button (in luggage compartment) E406 , removing and installing
Fig. 450: Releasing Retaining Springs At Rear Lid Lock Button (In Luggage Compartment) E406
Courtesy of VOLKSWAGEN UNITED STATES, INC.
cardiagn.com
Removing
{ Release retaining springs - arrows - at Rear Lid Lock Button (in luggage compartment) E406.
{ Carefully guide Rear Lid Lock Button (in luggage compartment) E406 out of rear lid trim.
{ Disconnect electrical harness connector.
Installing
Fig. 451: Identifying Rear Lid Contact And Rear Lid Lock
Courtesy of VOLKSWAGEN UNITED STATES, INC.
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
Trunk Lock/Alarm/Central Locking Switch F124 is located in rear lid lock - arrow - and cannot be replaced
separately if malfunctioning.
cardiagn.com
Fig. 452: Identifying Nut And Electrical Harness Connector
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
Installing
ANTI-THEFT IMMOBILIZER
Anti-theft Immobilizer
Immobilizer control is integrated in Access/Start Control Module J518. Component location: Integrated in
steering column, removing and installing --> 48 - STEERING .
If control module is replaced, select "Guided Functions" of respective control module in.
cardiagn.com
Fig. 453: Access/Start Authorization System - Component Overview
Courtesy of VOLKSWAGEN UNITED STATES, INC.
installing
cardiagn.com
z Removing and installing --> 48 - STEERING
cardiagn.com
Fig. 454: Keyless Access Authorization System - Component Overview
Courtesy of VOLKSWAGEN UNITED STATES, INC.
z Component overview --> Outside door handle for keyless access authorization system - component
overview
z Component overview --> Outside door handle for keyless access authorization system - component
overview
cardiagn.com
z Component location: At right luggage compartment rear cross panel
z Removing and installing --> Luggage Compartment Access/Start Authorization Antenna R137 ,
removing and installing
z Component overview --> Outside door handle for keyless access authorization system - component
overview
z Component overview --> Outside door handle for keyless access authorization system - component
overview
Outside door handle for keyless access authorization system - component overview
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
cardiagn.com
Fig. 455: Outside Door Handle For Keyless Access Authorization System - Component Overview
Courtesy of VOLKSWAGEN UNITED STATES, INC.
1 - Cover
z Drivers Outside Door Handle Touch Sensor G415 , Front Passengers Outside Door Handle Touch Sensor
G416
z cannot be replaced separately
z Replacing outside door handle --> 57 - FRONT DOORS, WINDOW REGULATORS, CENTRAL
LOCKING SYSTEM
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
z Right Rear Outside Door handle Touch Sensor G418 , Left Rear Outside Door Handle Touch Sensor
G417
3 - Mounting bracket
4 - Bolt (2 Nm)
z Drivers Outside Door Handle Central Locking Button E369 , Front Passengers Outside Door Handle
Central Locking Button E370
z Removing and installing --> Drivers/Passengers Outside Door Handle Central Locking Button E369 /
cardiagn.com
E370 , removing and installing
z Left Rear Outside Door Handle Central Locking Button E371 , Right Rear Outside Door Handle Central
Locking Button E372
z Removing and installing --> Left/Right Rear Outside Door Handle Central Locking Button E371 /
E372 , removing and installing
6 - Lock cylinder
z Drivers Door Handle Switch F272 , Passengers' Door Handle Switch F273
z Removing and installing --> Drivers/Passengers' Door Handle Switch F272 / F273 , removing and
installing
z Left Rear Door Handle Switch F274 , Right Rear Door Handle Switch F275
z Removing and installing --> Left/Right Rear Door Handle Switch F274 / F275 , removing and
installing
Fig. 456: Identifying Release Clips, Door Handle, And Mounting Bracket
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
cardiagn.com
{ Remove outside door handle --> 57 - FRONT DOORS, WINDOW REGULATORS, CENTRAL
LOCKING SYSTEM .
{ Remove mounting bracket --> 57 - FRONT DOORS, WINDOW REGULATORS, CENTRAL
LOCKING SYSTEM .
{ Carefully release clips - 2 - and - 3 - and pivot front outside door handle - 1 - in - direction of arrow A -
out of clips.
{ Slide front door handle switch off of mounting bracket - 4 - - arrow B -.
Installing
Left/Right Rear Door Handle Switch F274 / F275 , removing and installing
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
Fig. 457: Identifying Release Clips, Door Handle, And Mounting Bracket
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
cardiagn.com
{ Remove outside door handle --> 58 - REAR DOORS, WINDOW REGULATORS .
{ Remove mounting bracket --> 58 - REAR DOORS, WINDOW REGULATORS .
{ Carefully release clips - 2 - and - 3 - and pivot rear outside door handle - 1 - in - direction of arrow A -
out of clips.
{ Slide rear door handle switch off of mounting bracket - 4 - - arrow B -.
Installing
Drivers/Passengers Outside Door Handle Central Locking Button E369 / E370 , removing and installing
Fig. 458: Removing Bolt And Outside Door Handle Central Locking Button From Mounting Bracket
Courtesy of VOLKSWAGEN UNITED STATES, INC.
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
Removing
{ Remove outside door handle --> 57 - FRONT DOORS, WINDOW REGULATORS, CENTRAL
LOCKING SYSTEM .
{ Remove mounting bracket --> 57 - FRONT DOORS, WINDOW REGULATORS, CENTRAL
LOCKING SYSTEM .
{ Remove bolt - 1 -.
{ Remove outside door handle central locking button - 2 - from mounting bracket - 3 -.
Installing
cardiagn.com
{ Install outside door handle --> 57 - FRONT DOORS, WINDOW REGULATORS, CENTRAL
LOCKING SYSTEM .
Tightening torque
Component Nm
Front outside door handle central locking button to mounting bracket 2
Left/Right Rear Outside Door Handle Central Locking Button E371 / E372 , removing and installing
Fig. 459: Removing Bolt And Outside Door Handle Central Locking Button From Mounting Bracket
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
{ Remove rear outside door handle central locking button - 2 - from mounting bracket - 3 -.
Installing
Tightening torque
Component Nm
Rear outside door handle central locking button to mounting bracket 2
cardiagn.com
Fig. 460: Identifying Insulation, Bolts, Electrical Harness Connector, And Interior Access/Start
Authorization Antenna 1 R138
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
Installing
Tightening torque
Component Nm
Interior Access/Start Authorization Antenna 1 R138 to center console 3.5
cardiagn.com
Front Passengers Access/Start Authorization Antenna R135 , removing and installing
Fig. 461: Identifying Bolts, Front Passengers Access/Start Authorization Antenna R135, And Electrical
Harness Connector
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
Installing
Tightening torque
Component Nm
Front Passengers Access/Start Authorization Antenna R135 to door trim 2
cardiagn.com
Fig. 462: Identifying Bolts, Drivers Access/Start Authorization Antenna R134, And Electrical Harness
Connector
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
Installing
Tightening torque
Component Nm
Drivers Access/Start Authorization Antenna R134 to door trim 2
Fig. 463: Identifying Luggage Compartment Cargo Floor And Spare Wheel Cover
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
cardiagn.com
{ Remove luggage compartment storage area floor - 1 - and cover for spare wheel - 2 -.
Fig. 464: Identifying Bolts, Luggage Compartment Access/Start Authorization Antenna R137, And
Electrical Harness Connector
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Installing
Tightening torque
Component Nm
Luggage Compartment Access/Start Authorization Antenna R137 to body 2
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
Fig. 465: Identifying Bolts, Electrical Harness Connector, And Keyless Access Authorization Reader J723
Courtesy of VOLKSWAGEN UNITED STATES, INC.
cardiagn.com
Removing
Installing
Tightening torque
Component Nm
Keyless Access Authorization Antenna Reader J723 to central tube 3
cardiagn.com
Fig. 466: Identifying Electrical Harness Connector, Clips, Interior Monitoring Sensor G273, And
Interior/Reading Light
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
{ Remove front interior/reading light --> Front interior light module, removing and installing.
{ Disconnect electrical harness connector - 1 - at Interior Monitoring Sensor G273.
{ Release clips - arrows - and remove Interior Monitoring Sensor G273 - 2 - and - 3 - from interior/reading
light.
Installing
{ Install front interior/reading light --> Front interior light module, removing and installing.
Component location: In plenum chamber at front between E-box, right, and blower box.
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
cardiagn.com
Fig. 467: Removing Rubber Seal For Plenum Chamber Cover & Plenum Chamber Cover
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
{ Disconnect electrical harness connector and remove Alarm Horn H12 from plenum chamber.
Installing
Tightening torques
Component Nm
Alarm Horn H12 to bracket 5
Bracket to chassis 7
cardiagn.com
Vehicle Inclination Sensor G384 is integrated in Vehicle Electrical System Control Module 2 J520 and cannot
be replaced separately in case of malfunction.
{ Replace Vehicle Electrical System Control Module 2 J520 --> Vehicle Electrical System Control
Module 2 J520 , removing and installing.
Fig. 469: Prying Out Make-Up Mirror Light Using A Flat Screwdriver At Recess
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
{ Carefully pry out make-up mirror light using a flat screwdriver at recess - arrow -.
{ Disconnect electrical harness connector.
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
cardiagn.com
{
Installing
Removing
{ Open eyeglass compartment - 1 - and release center covers - 2 - and - 3 - of interior/reading light - arrow
-.
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
cardiagn.com
Fig. 473: Identifying Bolts
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Installing
Component Nm
Interior light to roof trim 2
cardiagn.com
Fig. 474: Identifying Electrical Harness Connectors, Clips, LED, And Interior/Reading Light
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
{ Remove front interior/reading light --> Front interior light module, removing and installing.
{ Disconnect electrical harness connectors - 1 - and - 2 -.
{ Release clips - arrows - and remove LED for ambient lighting - 3 - and - 4 - from interior/reading light.
Installing
Removing
cardiagn.com
CAUTION: z Switch off all electrical components.
z Switch ignition off and remove ignition key.
{ Open eyeglass compartment - 1 - and release center covers - 2 - and - 3 - of interior/reading light - arrow
-.
cardiagn.com
NOTE: z Disregard - 1 - and - 2 -.
Installing
Removing
{ Open eyeglass compartment - 1 - and release center covers - 2 - and - 3 - of interior/reading light - arrow
-.
cardiagn.com
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Installing
cardiagn.com
z Trim removal wedge 3409
Fig. 482: Prying Off Interior/Reading Light Out Of Headliner Opening Using Trim Removal Wedge 3409
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
{ Carefully pry off interior/reading light - 1 - out of headliner opening - arrow - using trim removal wedge
3409.
{ Disconnect electrical harness connector.
Installing
Light bulb for rear interior/reading light with angular diffusion lens, replacing
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
Fig. 483: Pulling Diffusion Lens For Interior Light Out Of Socket
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
cardiagn.com
{ Remove rear interior/reading light --> Rear interior light/reading lights, removing and installing.
{ Carefully pull diffusion lens - 1 - for interior light out of socket - 2 - - arrows -.
Installing
Rear interior/reading light with round diffusion lens, removing and installing
cardiagn.com
Fig. 486: Prying Off Interior/Reading Light Out Of Roof Cutout Using Trim Removal Wedge 3409
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
{ Carefully pry off interior/reading light - 1 - out of roof cutout - arrow - using trim removal wedge 3409.
{ Disconnect electrical harness connector.
Installing
Light bulb for rear interior/reading light with round diffusion lens, replacing
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
Removing
cardiagn.com
{ Remove rear interior/reading light --> Rear interior/reading light with round diffusion lens, removing
and installing.
{ Remove bulb - 1 - or - 2 - (12 V, 5 W) from socket.
Installing
Front Passengers Airbag Disabled Indicator Lamp K145 , removing and installing
cardiagn.com
Fig. 490: Releasing Spring Pins Of Decorative Panel From Instrument Panel Using Trim Removal Wedge
3409
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
{ Adjust steering wheel downward and to rear as far as possible, use entire adjustment range of steering
column adjustment for this.
{ Carefully release spring pins - 1 - of decorative panel from instrument panel using trim removal wedge
3409.
NOTE: z The instrument panel vent provides a hole on both sides to engage the
hook 3438.
z Carefully remove the instrument panel at both sides from installation
opening using the hook 3438.
If the instrument panel vent cannot be pulled out that way, proceed as follows:
cardiagn.com
{ Disconnect electrical harness connectors.
Fig. 491: Releasing Clips And Removing Front Passengers Airbag Disabled Indicator Lamp K145 From
Decorative Panel With Air Vent
Courtesy of VOLKSWAGEN UNITED STATES, INC.
{ Release clips - arrows - on left and right and remove Front Passengers Airbag Disabled Indicator Lamp
K145 - 1 - from decorative panel with air vent.
Installing
{ Press switch into decorative panel with air vent until it engages.
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
cardiagn.com
Fig. 492: Identifying Catch, Glove Compartment Lamp, And Electrical Harness Connector
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
Installing
{ Insert glove compartment lamp into opening and engage on opposite side.
Fig. 493: Pulling Climatronic Control Module J255 (Control Head) Out Of Mounting Frame
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
cardiagn.com
{ On vehicles with automatic transmission, place selector lever in position "S".
{ Reach from bottom into recesses into recesses at Climatronic Control Module J255 (control head).
{ Pull Climatronic Control Module J255 (control head) out of mounting frame - arrows -.
{ Put Climatronic Control Module J255 (control head) down on center console on rag to prevent surfaces
from damage.
cardiagn.com
Fig. 496: Removing Bolts And Releasing Ashtray Using Screwdriver In Opening
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Fig. 497: Releasing Retaining Wedge And Removing Ashtray Illumination Toward Rear
Courtesy of VOLKSWAGEN UNITED STATES, INC.
{ Release retaining wedge - 2 - in - direction of arrow - and remove ashtray illumination - 1 - toward rear.
cardiagn.com
Installing
Tightening torque
Component Nm
Ashtray housing to front center console frame 3
Fig. 498: Identifying Electrical Harness Connector, Bulb Socket, And Door Opener
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
Installing
{ Insert light bulb for door opener light into opening and engage.
{ Install respective door trim --> 70 - INTERIOR TRIM .
cardiagn.com
Fig. 499: Identifying Electrical Harness Connector And Door Trim
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
Fig. 500: Pulling Light Strip For Door Illumination Off Of Door Trim
Courtesy of VOLKSWAGEN UNITED STATES, INC.
{ Carefully pull light strip for door illumination - 1 - off of door trim - arrows -.
{ Guide electrical wire out of door trim.
Installing
{ Insert light strip for door illumination into door trim and engage.
{ Install respective door trim --> 70 - INTERIOR TRIM .
cardiagn.com
Fig. 501: Identifying Catch, Door Entry Lamp And Electrical Harness Connector
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
{ Press in catch - 1 - using a flat screwdriver and pry out door safety lamp or door entry lamp - 2 -.
{ Disconnect electrical harness connector - 3 -.
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
Fig. 502: Releasing Clips And Pulling Cover Off Above Light Bulb
Courtesy of VOLKSWAGEN UNITED STATES, INC.
{ If present, release clips - arrows - and pull cover - 1 - off above light bulb.
cardiagn.com
Fig. 503: Removing Light Bulb (12 V, 5 W) From Socket On Back Side Of Luggage Compartment Lamp
Courtesy of VOLKSWAGEN UNITED STATES, INC.
{ Remove light bulb - 1 - (12 V, 3 W) from socket - 2 - on reverse side of door safety lamp and door entry
lamp.
Installing
Fig. 504: Disconnecting Electrical Harness Connector For Window Regulator Switch And For Ashtray
Illumination
Courtesy of VOLKSWAGEN UNITED STATES, INC.
cardiagn.com
Removing
Fig. 505: Releasing Clips And Removing Ashtray Illumination Toward Rear
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Installing
Tightening torque
Component Nm
Armrest to door trim 2.5
cardiagn.com
z On vehicles with LED footwell light, entire footwell light must be replaced
if LED is faulty.
Removing
Fig. 506: Identifying Catch, Footwell Lamp, And Electrical Harness Connector
Courtesy of VOLKSWAGEN UNITED STATES, INC.
{ Press in catch - 1 - using a flat screwdriver and pry out footwell lamp - 2 -.
{ Disconnect electrical harness connector - 3 -.
{ Remove bulb (12 V, 5 W) from socket on back side of footwell lamp.
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
Installing
Removing
cardiagn.com
Fig. 507: Pressing In Catch Using A Flat Screwdriver And Pry Out Footwell Lamp
Courtesy of VOLKSWAGEN UNITED STATES, INC.
{ Press in catch - 2 - using a flat screwdriver and pry out footwell lamp - 1 -.
{ Disconnect electrical harness connector.
{ Remove bulb (12 V, 5 W) from socket on back side of footwell lamp.
Installing
cardiagn.com
Fig. 508: Pressing In Catch Using A Flat Screwdriver And Prying Out Luggage Compartment Lamp
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
{ Press in catch - 1 - using a flat screwdriver and pry out luggage compartment lamp - 2 -.
{ Disconnect electrical harness connector - 3 -.
Fig. 509: Releasing Clips And Pulling Cover Off Above Light Bulb
Courtesy of VOLKSWAGEN UNITED STATES, INC.
{ Release clips - arrows - and pull cover - 1 - off above light bulb.
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
Fig. 510: Removing Light Bulb (12 V, 5 W) From Socket On Back Side Of Luggage Compartment Lamp
Courtesy of VOLKSWAGEN UNITED STATES, INC.
{ Remove light bulb - 1 - (12 V, 5 W) from socket - 2 - on back side of luggage compartment lamp.
cardiagn.com
Installing
{ Insert luggage compartment lamp into opening and engage on opposite side.
Fig. 512: Prying Luggage Compartment Lamp Out Of Headliner Opening Using Trim Removal Wedge
3409
Courtesy of VOLKSWAGEN UNITED STATES, INC.
cardiagn.com
Removing
{ Carefully pry out luggage compartment lamp - 1 - out of headliner opening - arrow - using trim removal
wedge 3409.
{ Disconnect electrical harness connector.
Installing
Light bulb for luggage compartment lamp, removing and installing (Avant)
Fig. 514: Prying Luggage Compartment Lamp Out Of Headliner Opening Using Trim Removal Wedge
3409
cardiagn.com
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
{ Carefully pry out luggage compartment lamp - 1 - out of headliner opening - arrow - using trim removal
wedge 3409.
{ Disconnect electrical harness connector.
Fig. 515: Pulling Diffusion Lens For Interior Light Out Of Socket
Courtesy of VOLKSWAGEN UNITED STATES, INC.
{ Carefully pull diffusion lens - 1 - for interior light out of socket - 2 - - arrows -.
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
cardiagn.com
Installing
Fig. 517: Identifying Catch, Rear Lid Courtesy Lamp, And Electrical Harness Connector
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
{ Press in catch - 1 - using a flat screwdriver and pry out rear lid courtesy lamp - 3 -.
{ Disconnect electrical harness connector - 2 -.
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
Fig. 518: Releasing Clips And Pulling Cover Off Above Light Bulb
Courtesy of VOLKSWAGEN UNITED STATES, INC.
{ Release clips - arrows - and pull cover - 1 - off above light bulb.
cardiagn.com
Fig. 519: Removing Light Bulb (12 V, 5 W) From Socket On Back Side Of Luggage Compartment Lamp
Courtesy of VOLKSWAGEN UNITED STATES, INC.
{ Remove light bulb - 1 - (12 V, 5 W) from socket - 2 - on back side of rear lid courtesy lamp.
Installing
{ Insert rear lid courtesy lamp into opening and engage on opposite side.
HORNS
cardiagn.com
Removing
Fig. 521: Disconnecting Electrical Harness Connectors And Prying Out Wire Clip
Courtesy of VOLKSWAGEN UNITED STATES, INC.
cardiagn.com
{ Remove Signal Horn/Dual Tone Horn H1 from bracket.
Installing
Tightening torques
Component Nm
Signal Horn/Dual Tone Horn H1 to bracket 11
Bracket for Signal Horn/Dual Tone Horn H1 to lock carrier 8
Fig. 523: Identifying Bolt, Harness Connector, And Garage Door Opener Control Module
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Removing
cardiagn.com
{ Remove front bumper cover --> 63 - BUMPERS .
{ Remove bolt - 3 - on battery retaining strap - 4 -.
{ Remove Garage Door Opener Control Module - 2 - from lock carrier.
{ Disconnect electrical connection - 1 -.
Installing
Tightening torque
Component Nm
Garage Door Opener Control Module J530 to bumper cover 2.5
Removing
{ Remove font interior light module --> Front interior light module, removing and installing.
2006 Audi A6 Quattro
ELECTRICAL Electrical Equipment
cardiagn.com
Fig. 524: Identifying Electrical Harness Connector, Clips, Interior Monitoring Sensor G273, And
Interior/Reading Light
Courtesy of VOLKSWAGEN UNITED STATES, INC.
{ Where installed, release clips - arrows - and remove interior monitoring sensor/receiver module - 2 -
from front interior light module.
Fig. 525: Identifying Electrical Connection, Retaining Clips, And Front Interior Light Module
Courtesy of VOLKSWAGEN UNITED STATES, INC.
Installing
Component Nm
Sunroof switch to front interior light module 1.5
cardiagn.com