Professional Documents
Culture Documents
This month I was assigned by Manager to make some question for RF Team related Job position upgrade from RF to Optimiza
Engineer. Here I would like to share some question test that I made for RF Team just for your reference to expand your Optimi
knowledge.
2G DT Analysis Part:
1. When you perform drive test in the field then you found dropped Call suddenly. What are the root cause possibility of droppe
how to solve it?
Good Answer
1. Hardware Faulty
2. Frequency Interference(Co-channel or Adjacent)
3. Neighbor relation problem(missing Neighbor)
4. Low Signal Strength
5. Failed during HO process
1. Hardware Troubleshooting
2. Clearing Frequency Interference
3. Fix Missing Neighbor
4. Antenna Tuning(Physical Optimization)
5. Change Parameter(HO Parameter, RLT,Timer,etc)
2. When you analyze log file you found too many handover failure. What is the root cause of handover failure and what is your
solve handover failure?
Good Answer
Root Cause and solution to solve handover failure:
3. When perform Monthly drive test you found too much bad quality(RxQual>>5). What is the root cause and solution to imp
Good Answer
4. When you are positioned as Optimization Engineer, there are complain about Can't make a call. What is the root cause of Ca
outgoing call and what is the solution?
Good Answer
1. LAC CI didn't yet registered on Core side----->Check and register LAC CI on Core.
2. SDCCH Blocking on the cell-------->Add SD channel
3. Hardware problem(ex: TRX Module faulty or Combiner problem)------> Fix hardware problem
4. Low Coverage--------> Change Antenna tilt or propose new site to improve coverage.
Good Answer
RXLevel: Receive signal level by MS in dBm, where athe lowest value mean the lowest Level, the greatest value means the gre
RXQual: Receive quality of signal by MS from the BTS which have rage from 0-7. The lowest value mean the best quality, the h
value mean the lowest Quality.
SQI: Speech Quality index, Quality of Speech during dedicated call which range from -20 to 30. The highest value mean the be
of speech, The lowest value mean the bad one
6. During perform drive test you found low throughput. What is root cause of low throughput?
Good Answer
The root cause of low throughput:
7. What is mean and root cause of Low signal strength? give some solution
Good Answer
Low signal strength mean low of the received signal level by MS
Root cause and Solution: