Professional Documents
Culture Documents
b. A rotor of mass 4Kg is mounted on lcm diameter shaft at a point l0 cm from one end. The
25cm long shaft is supported by bearings. Calculate the critical speed. If the centre of
gavity of the disc is 0.03mm away from the geometric cente of rotor, find the deflection of B.Tech. DEGREE EXAMINATION, JIJNE 2016
the shaft when the speed of rotation is 5000 rpm. Assume E = 1.96 x l0rr N/m2. Find the
Fifth Semester
critical speed when the rotor is mounted midway on the shaft.
MEIO19 _ FUNDAMENTALS OF VIBRATION AND NOISE
29. a. Find the natural frequencies the system: m1 : 2Kg, m2: 0.5Kg, K: 90N/m, I = 0.25m (For the candidates admitted during the academic year 2013 2014)
-
Note:
(i) Part - A should be answered in OMR sheet within first 45 minutes and OMR sheet should be handed
over to hall invigilator at the end of 45h minute.
(ii) Part - B and Part - C should be answered in answer booklet.
PART-A(20x1=20Marks)
Answer ALL Questions
l. An overdamped system is distributed from equilibrium position with some initial velocity the
- system will
(oR) (A) Not cross the Equilibrium Position @) Vibrate about Equilibrium Position
b. A torsional system has an inertia of 1.5Kg m2 and torsional stiffiress of 4.36 x 103 Nm/rad. It (C) Immediately retum to the (D) WillNotVibrate
is acted upon by a torsional excitation of 54 radls. Deterrrine the parameter of the absorber Equilibrium Position
to be fxed to the main system if it is desired to keep the material frequency atleast 20yo 2. Kinetic Energy of a Rotational system is
away from the impressed frequency. (A) !r0z @) !162
30. a. Use Holzer's method to find the natural frequencies of the systems 11 : 12 = I.r : I and 2 7
Kt1 :61r: 1. (c) ! x. e, (D) ! y.6z
2' 2',
3. Natural Frequency of a Compound Pendulum is
(A) I wh'
t-
(B)
\ltr+mtf Ir+mhz
b. Find the lowest natural frequency of hansverse vibration for a 42cm length simply supported
(c)
\
r;F w,h
(D)
F;;"s
\l-ffi-
beam loaded by 40Kg from l6cm of left 9nd and 20Kg from 18 crn of right end by
Rayleigh's method. Take E :1.96 x l0rr N/mz I:
10{ ma 4. Maximum Magrrification condition is orlorn
(A) (e)
31. a. Explain
i. Single plane balancing
,[26, -1
(c) (D)
ii. Two plane balancing -2€'
(oR) 5. In a Semi Definite system one of the Natural Frequency is
b. Explain with neat sketch (A) Unity (B) Infinite
i. Seismometer and (C) Zerc @) Two
ii.Accelerometer
5. Dynamic Vibration Absorbance is suitable for
32. a. Explain measurement and analysis of noise (A)
Varying Speed Machine (B) Constant Speed Machine
(oR)
(C) Dual Speed Machine (D) Critical Speed Machine
b. Explain various noise control methods in detail. 7. For A machine withN Rotor, Nodes will be
(A) NNodes @) (N+l)Nodes
* * *:t:f (c) (N+2) Nodes @) (N-l)Nodes
Page 4 of 4 07JT'5M810r9 Page I of4 07JF5ME1019
19. Fine detail in the spectnrm is obtained by
8. The number of natural frequencies in a two Rotor system is (A) One Octave Filters @) One Third Octave Filters
(A) Infinite @) Zero (C) Narrow Band Filters (D) One Fourttr Octave Filter
(C) Two @) Four
20. Range of Frequencies in which the Highest frequency within the Range is twice the lower
9. Holzer Method needs how many trial frequencies? frequency within range is
(A) fwo @) Three (A) Narrow Band @) Octave Band
(C) One (D) Four (C) One ThirdBand @) Two ThirdBand
(c)
,ri (D)
LM, y,'
2I . Derive the goveming equation of motion for the figure shown
_ZM, t,2 ZM, y,2
t'zM,h ,
x^z 'yt+
x
11. Eigen Values are
(A) Acceleration @) Frequency
(C) Discplacement @) Time
12. Shape function is suitably taken in
(A) HolzerMethod @) RayleighRitzMethod
(C) Matrix Method @) Influence coefficient Method