Professional Documents
Culture Documents
T3 Input Configuration- Consists of two external clock inputs (T3-1 and T3-2).
T3-1 input:
None: to remove/inhibit any signal on the T3-1 port
2 MHz
2 Mbps
2 Mbps-F (Framed)
T3-2 input:
None: to remove/inhibit any signal on the T3-2 port
2 MHz
2 Mbps
2 Mbps-F (Framed)
Go to Timing Configuration.
Select the Quality of timing source for T3 & it should be as per received clock quality.
XDM is providing external clock.
Source for timing signal passed to two T4 output ports on NE. Any NE has ability to provide
clock signal to external equipment (T4 signal) through relevant NE ports.
T4-1
Signal on T4-1. Options:
OFF: to inhibit any signal on T4-1 port
2 MHz
2 Mbps
2 Mbps-F (Framed)
Signal on T4-2. Options:
OFF: to inhibit any signal on T4-2 port
2 MHz
2 Mbps
2 Mbps-F (Framed)
Go to Timing Configuration.
Go to Edit Mode & Select the T4-1 Clock.
Disable the Squelch will cause that the device that use this T4 clock to use this clock
even if the quality was changed.
Disabled the Squelch if external equipment having single clock source form T4 .
Enabled the Squelch will cause to the device that use this T4 clock to use other clock
if exist and if not exist it will use holdover clock
Enabled the Squelch if external equipment having more than once clock source, one
from T4 output & another from other source. Configure threshold as PRC.
XDM is configure with line clock.
Go to Timing Configuration.
Similarly configure the I/O Line-2, I/O Line-3 & I/O Line-4 details as per requirement.
Assign the Priority to I/O Lines as shown below.
T3_1/T4_1 and T3_2/T4_2 Connectors