Professional Documents
Culture Documents
Description
Features
Bi-directional
• 1500W peak pulse power • Fast response time:
capability at 10/1000μs typically less than 1.0ps
waveform, repetition rate from 0V to BV min
(duty cycles):0.01% • Glass passivated chip
• Excellent clamping junction
capability • High temperature to reflow
Agency Approvals • Low incremental surge soldering guaranteed:
resistance 260°C/40sec
Agency Agency File Number • Typical IR less than 1μA • VBR @ TJ= VBR@25°C
E230531 when VBR min>12V x (1+αT x (TJ - 25))
• For surface mounted (αT:Temperature
applications to optimize Coefficient, typical value is
board space 0.1%)
Maximum Ratings and Thermal Characteristics
(TA=25OC unless otherwise noted) • Low profile package • Plastic package is
• Built-in strain relief flammability rated V-0 per
Parameter Symbol Value Unit Underwriters Laboratories
• Typical failure mode is
Peak Pulse Power Dissipation at TA=25ºC by short from over-specified • Meet MSL level1, per
10/1000µs Waveform (Fig.2)(Note 1), (Note 2), PPPM 1500 W
voltage or current J-STD-020, LF maximun
(Note 5) peak of 260°C
Power Dissipation on Infinite Heat Sink at TL=50OC PD 6.5 W • Whisker test is conducted
based on JEDEC • Matte tin lead–free plated
Peak Forward Surge Current, 8.3ms Single Half • Halogen free and RoHS
Sine Wave (Note 3)
IFSM 200 A JESD201A per its table 4a
Maximum Instantaneous Forward Voltage at 100A
and 4c compliant
VF 3.5/5.0 V
for Unidirectional Only (Note 4) • IEC 61000-4-2 ESD • Pb-free E3 means 2nd
Operating Temperature Range TJ -65 to 150 °C
30kV(Air), 30kV (Contact) level interconnect is Pb-
• ESD protection of data free and the terminal finish
Storage Temperature Range TSTG -65 to 175 °C lines in accordance with material is tin(Sn) (IPC/
Typical Thermal Resistance Junction to Lead RθJL 15 °C/W IEC 61000-4-2 JEDEC J-STD-609A.01)
Typical Thermal Resistance Junction to Ambient RθJA 75 °C/W • EFT protection of data
Notes: lines in accordance with
1. Non-repetitive current pulse , per Fig. 4 and derated above TJ (initial) =25OC per Fig. 3. IEC 61000-4-4
2. Mounted on copper pad area of 0.31x0.31” (8.0 x 8.0mm) to each terminal.
3. Measured on 8.3ms single half sine wave or equivalent square wave for unidirectional device only, duty
cycle=4 per minute maximum.
4. VF < 3.5V for single die parts and VF< 5.0V for stacked-die parts. Applications
5. The PPPM of stacked-die parts is 2000W and please contact littelfuse for the detail stacked-die parts.
TVS devices are ideal for the protection of I/O Interfaces,
VCC bus and other vulnerable circuits used in Telecom,
Computer, Industrial and Consumer electronic applications.
Bi-directional
Datasheet Resources Samples
Cathode Anode
Uni-directional
Uni-directional
Bi-directional
Ipp
Vc VBR VR IT
V Vc VBR VR IR
IR VF V
IT IR VR VBR Vc
IT
Ipp Ipp
Figure 1 - TVS Transients Clamping Waveform Figure 2 - Peak Pulse Power Rating
TJ initial = Tamb
stacked-die, 2kW
Voltage Across TVS 10 at 10x1000µs, 25°C
Voltage or Current
0.1
0.001 0.01 0.1 1 10
150
100%
tr=10µsec TJ=25°C
60%
Half Value
40%
IPPM IPPM ( )2
50 10/1000µsec. Waveform
20% as defined by R.E.A
0%
0 25 50 75 100 125 150 175 td
0
TJ Initial Junction Temperature(˚C) 0 1.0 2.0 3.0 4.0
t-Time (ms)
100
100000
Transient Thermal Impedance (°C/W)
Uni-directional V=0V
10000 10
Bi-directional V=0V
Cj(pF)
1000
Uni-directional V=VR
1
100
0.1
Bi-directional V=VR
10
0.01
1
1 10 100 1000 0.001 0.01 0.1 1 10 100 1000
VBR - Reverse Breakdown Voltage(V) TP - Pulse Duration (s)
Figure 7 - Maximum Non-Repetitive Peak Forward Figure 8 - Peak Forward Voltage Drop vs Peak Forward
Surge Current Uni-Directional Only Current (Typical Values)
200 100.0
IFSM - Peak Forward Surge Current (A)
160
Stacked-die
140
10.0
120
100
80
60 1.0
40
20
0
0.1
1 10 100 0.0 1.0 2.0 3.0 4.0 5.0 6.0 7.0 8.0 9.0
Number of Cycles at 60 Hz VF-Peak Forward Voltage(V)
Soldering Parameters
Temperature (T)
Ts(max)
TS(max) to TA - Ramp-up Rate 3°C/second max
Ramp-down
- Temperature (TA) (Liquidus) 217°C Ts(min)
Reflow ts
- Time (min to max) (ts) 60 – 150 seconds Preheat
Dimensions
DO-214AB (SMC J-Bend) Inches Millimeters
Cathode Band
Dimensions
(for uni-directional products only)
Min Max Min Max
A 0.114 0.126 2.900 3.200
B 0.260 0.280 6.600 7.110
C 0.220 0.245 5.590 6.220
A C
D 0.079 0.103 2.060 2.620
E 0.030 0.060 0.760 1.520
F - 0.008 - 0.203
B G 0.305 0.320 7.750 8.130
H 0.006 0.012 0.152 0.305
H I 0.129 - 3.300 -
J 0.094 - 2.400 -
D
K - 0.165 - 4.200
J K L L 0.094 - 2.400 -
F
E G I
SMCJ XXX C A
Cathode Band
(for uni-directional products only)
F
Littelfuse Logo
Bi-Directional XXX
YMXXX
Marking Code
VR Voltage Trace Code Marking
Y:Year Code
Series M: Month Code
XXX: Lot Code
Packaging
SMCJxxxXX DO-214AB 3000 Tape & Reel - 16mm tape/13” reel EIA STD RS-481
0.157
(4.0)
0.63
(16.0)
13.0 (330)
Dimensions are in inches
0.80 (20.2) (and millimeters).
Cathode
Arbor Hole Dia.
Direction of Feed
0.65
(16.4)
Disclaimer Notice - Information furnished is believed to be accurate and reliable. However, users should independently evaluate the suitability of and test each product selected for their own applications. Littelfuse products are
not designed for, and may not be used in, all applications. Read complete Disclaimer Notice at www.littelfuse.com/disclaimer-electronics.
© 2020 Littelfuse, Inc.
Specifications are subject to change without notice.
Revised: BA.08/31/20
Mouser Electronics
Authorized Distributor
Littelfuse:
SMCJ7.5C SMCJ100C SMCJ51 SMCJ6.0C SMCJ6.5CA SMCJ150A SMCJ16CA SMCJ17A SMCJ24
SMCJ40CA SMCJ90 SMCJ13 SMCJ350C SMCJ6.0 SMCJ60 SMCJ15CA SMCJ33C SMCJ130C SMCJ200
SMCJ51CA SMCJ85CA SMCJ110 SMCJ11C SMCJ350 SMCJ54A SMCJ60A SMCJ120 SMCJ170CA SMCJ7.0C
SMCJ180 SMCJ51A SMCJ60C SMCJ11 SMCJ22 SMCJ220 SMCJ36A SMCJ6.0A SMCJ75A SMCJ15C
SMCJ26 SMCJ36 SMCJ90A SMCJ160A SMCJ440C SMCJ75 SMCJ75C SMCJ8.5CA SMCJ36C SMCJ8.0C
SMCJ14CA SMCJ20C SMCJ33 SMCJ20 SMCJ6.5C SMCJ78CA SMCJ24C SMCJ300 SMCJ58C SMCJ70C
SMCJ85C SMCJ18A SMCJ400 SMCJ26C SMCJ28A SMCJ30A SMCJ6.5A SMCJ7.5A SMCJ10C SMCJ110A
SMCJ13CA SMCJ40C SMCJ200A SMCJ20A SMCJ22A SMCJ400CA SMCJ85 SMCJ100 SMCJ120CA
SMCJ130 SMCJ45CA SMCJ54C SMCJ14A SMCJ17C SMCJ22CA SMCJ160C SMCJ300C SMCJ33A
SMCJ160CA SMCJ16A SMCJ250 SMCJ7.5 SMCJ14 SMCJ8.0 SMCJ10CA SMCJ120C SMCJ350A SMCJ440CA
SMCJ64A SMCJ75CA SMCJ22C