You are on page 1of 16

GROUP 2 ELECTRICAL SYSTEM

1. WHEN STARTING SWITCH IS TURNED ON, MONITOR PANEL DISPLAY DOES NOT APPEAR
ňBefore disconnecting the connector, always turn the starting switch OFF.
ňBefore carrying out below procedure, check all the related connectors are properly inserted and the
fuse No.1 is not blown out.
ňAfter checking, connect the disconnected connectors again immediately unless otherwise specified.

Cause Remedy
YES
Defective cluster Replace
Check voltage
YES
between CN-57
(5) and chassis
Disconnection in Repair or replace
NO
Check voltage wiring harness or poor (after clean)
YES
between CN-8(5) contact between CN-
and chassis
57(5)-CN8(5)

Disconnection in Repair or replace


Check voltage NO
between CN-50 wiring harness or poor (after clean)
(9) and chassis contact between CN-
8(5)-CN50(9)
Voltage : 20~30V
Starting switch : ON
YES
Check voltage Defective controller Replace
between CN-50
NO (8) and chassis
Disconnection in Repair or replace
NO
wiring harness or poor (after clean)
contact between CN-
36(2)-CN50(8)

FUSE
2
No.1
NO.1
CN-36

CLUSTER
8
5 5 9
11 11 3
12 12 CN-50

CN-57 CN-8

Check voltage

YES 20 ~ 30V
NO 0V

6 - 21
2. BATTERY CHARGING LAMP LIGHTS UP(Starting switch : ON)

ňBefore disconnecting the connector, always turn the starting switch OFF.
ňBefore carrying out below procedure, check all the related connectors are properly inserted.
ňAfter checking, connect the disconnected connectors again immediately unless otherwise specified.

Cause Remedy
YES
‫ڞ‬
Check voltage
YES
between CN-51
(3) and chassis
Check voltage Defective controller Replace
YES NO
between CN-50
(2) and chassis
Disconnection in Repair or replace
YES Check voltage NO
between CN-1 (2) wiring harness or poor (after clean)
and chassis contact between
CN-50(2)-CN1(2)
Check voltage Disconnection in Repair or replace
between alternator NO
wiring harness or poor (after clean)
terminal "I" and
chassis contact between
Voltage : 20~30V CN-1(2)-alternator
Engine : running terminal "I"
Defective alternator Replace
NO
YES
Defective cluster Replace
Check voltage
‫ڞ‬ between CN-
7(7) and chassis
Disconnection in Repair or replace
NO
wiring harness or poor (after clean)
contact between
CN-51(3)-CN7(7)

CLUSTER CPU CONTROLLER


*5V
7 7 3
0
CN-56 CN-7 CN-51

CN-50

Check voltage ALTERNATOR


2
YES 20 ~ 30V *5V "I" TERMINAL
NO 0V 0V CN-1

6 - 22
3. WHEN COOLANT OVERHEAT LAMP LIGHTS UP(Engine is started)

ňBefore disconnecting the connector, always turn the starting switch OFF.
ňBefore carrying out below procedure, check all the related connectors are properly inserted.
ňAfter checking, connect the disconnected connectors again immediately unless otherwise specified.

Cause Remedy
YES
Coolant overheat Check engine
(110Ɓ
C) system

YES
Check resistance ‫ڞ‬
YES between CN-1(6) -
Does display go chassis and CN-
off when 51 (6) -chassis Disconnection in wiring Repair or replace
disconnect CD-9 NO
Starting switch : OFF harness or poor contact (after clean)
and connector? Check resistance
YES between
Starting switch : ON between CN-9(3)
Engine : start and chassis CN-9(3)-CN51(6) and
CN-9(3)-CN1(6)
Starting switch : OFF
Check resistance Disconnection in wiring Repair or replace
NO
between CN-56 harness or poor contact (after clean)
NO
(15) and chassis between
Starting switch : OFF CN-56(15)-CN-9(3)
Before checking,
disconnect CN-9 Defective cluster Replace
NO

YES
Defective sensor Replace
Check resistance
between CD-9 -
‫ڞ‬ chassis and
sensor-chassis
Disconnection in wiring Repair or replace
Starting switch : OFF NO
harness or poor contact (after clean)
between
CN-1(6)-CD-9

CLUSTER CPU CONTROLLER

15 3 6

CN-56 CN-9 CN-51 OVERHEAT SWITCH

Check resistance CN-1 CD-9


YES MAX 1‫װ‬
NO MIN 1M‫װ‬

6 - 23
4. WHEN AIR CLEANER LAMP LIGHTS UP(Engine is started)

ňBefore disconnecting the connector, always turn the starting switch OFF.
ňBefore carrying out below procedure, check all the related connectors are properly inserted.
ňAfter checking, connect the disconnected connectors again immediately unless otherwise specified.

Cause Remedy
YES
Check air filter Repair or replace
(after clean)

YES
Disconnection in Repair or replace
wiring harness or poor (after clean)
Does display go off Check resistance contact between
YES between CN-1(7)
when disconnect
CD-10 and and chassis CN-1(7)-CD-10
connector?
Starting switch : OFF
Starting switch : ON
Check resistance NO
Disconnection in Repair or replace
Engine : start YES
between CN-9(2) wiring harness or poor (after clean)
and chassis contact between
Starting switch : OFF CN-9(2)-CN-1(7)

Check resistance
Disconnection in Repair or replace
between CN-56 NO
NO wiring harness or poor (after clean)
(14) and chassis
contact between
Starting switch : OFF
Before checking,
CN-56(14)-CN-9(2)
disconnect CD-10

NO
Defective cluster Replace

CLUSTER AIR CLEANER SWITCH

14 2 7

CN-56 CN-9 CN-1 CD-10

Check resistance

YES MAX 1‫װ‬


NO MIN 1M‫װ‬

6 - 24
5. WHEN ENGINE OIL PRESSURE LAMP LIGHTS UP(Engine is started)

ňBefore disconnecting the connector, always turn the starting switch OFF.
ňBefore carrying out below procedure, check all the related connectors are properly inserted.
ňAfter checking, connect the disconnected connectors again immediately unless otherwise specified.

Cause Remedy
YES
Engine oil leakage, Check engine oil
or defective switch level or replace
switch

YES Disconnection in wiring


Repair or replace
harness or poor (after clean)
Does display go off Check resistance
YES contact between
when disconnect between CN-1 (3)
CD-18 and and chassis CN-1(3)-CD-18
connector?
Starting switch : ON Check resistance Disconnection in wiring Repair or replace
Engine : start YES NO
between CN-9 (1) harness or poor (after clean)
and chassis contact between
Starting switch : OFF CN-9(1)-CN-1(3)

Check resistance
between CN-56 NO Disconnection in wiring Repair or replace
NO
(13) and chassis harness or poor (after clean)
contact between
Starting switch : OFF
Before checking, CN-56(13)-CN-9(1)
disconnect CD-18

NO Defective cluster Replace

ENGINE OIL PRESSURE SWITCH


CLUSTER

13 1 3

CN-56 CN-9 CN-1 CD-18

Check resistance
YES MAX 1‫װ‬
NO MIN 1M‫װ‬

6 - 25
6. WHEN HYDRAULIC OIL TEMPERATURE LAMP LIGHTS UP(Engine is started)

ňBefore disconnecting the connector, always turn the starting switch OFF.
ňBefore carrying out below procedure, check all the related connectors are properly inserted.
ňAfter checking, connect the disconnected connectors again immediately unless otherwise specified.

Cause Remedy
YES
Defective switch Check hydraulic
oil temperature
(105Ɓ
C) ,
YES Disconnection in wiring
Replace
harness or poor contact
Check resistance
Does display go YES between
between CN-3 (12)
off when CN-3(12)-CD-1
and chassis
disconnect CD-1
and connector? Starting switch : OFF
Starting switch : ON Check resistance NO
Disconnection in wiring Repair or replace
YES between CN-7 (12)
Engine : start harness or poor contact (after clean)
and chassis between
Starting switch : OFF CN-7(12)-CN-3(12)
Check resistance
between CN-56 NO
Disconnection in wiring Repair or replace
NO
(12) and chassis harness or poor contact (after clean)
Starting switch : OFF
between
Before checking, CN-56(12)-CN-7(12)
disconnect CD-1

NO
Defective cluster Replace

HYDRAULIC OIL
Check resistance TEMPERATURE SENDER

YES MAX 1‫װ‬


NO MIN 1M‫װ‬
CD-1

12

CN-3

CLUSTER

12 12

CN-56 CN-7

6 - 26
7. WHEN COOLANT LEVEL LAMP LIGHTS UP(Engine is started)

ňBefore disconnecting the connector, always turn the starting switch OFF.
ňBefore carrying out below procedure, check all the related connectors are properly inserted.
ňAfter checking, connect the disconnected connectors again immediately unless otherwise specified.

Cause Remedy
YES
Insufficient Refill coolant
coolant or
Defective switch Replace

YES
Disconnection in Repair or replace
wiring harness or poor (after clean)
Does display go Check resistance contact between
off when YES
between CN-4 (2)
disconnect CD-16 CN-4(2)-CD-16(2)
and chassis
and connector?
Starting switch : ON Starting switch : OFF Disconnection in
Check resistance NO Repair or replace
Engine : start YES
between CN-7 (6) wiring harness or poor (after clean)
and chassis contact between
Starting switch : OFF CN-7(6)-CN-4(2)
Check resistance
between CN-56 NO Disconnection in Repair or replace
NO
(6) and chassis wiring harness or poor (after clean)
Starting switch : OFF
contact between
Before checking, CN-56(6)-CN-7(6)
disconnect CD-16

Defective cluster Replace


NO

CLUSTER WATER LEVEL SENDER

6 6 2 2
1
CN-56 CN-7 CN-5
CD-16

Check resistance

YES MAX 1‫װ‬


NO MIN 1M‫װ‬

6 - 27
8. WHEN COOLANT TEMPERATURE GAUGE DOES NOT OPERATE
(Check coolant temperature lamp ON/OFF)
ňBefore disconnecting the connector, always turn the starting switch OFF.
ňBefore carrying out below procedure, check all the related connectors are properly inserted and the
fuse No.1 is not blown out.
ňAfter checking, connect the disconnected connectors again immediately unless otherwise specified.

Cause Remedy
YES
Coolant overheat Check coolant
or Defective sender temperature or
replace

YES Disconnection in wiring


Repair or replace
harness or poor (after clean)
Does display go off Check resistance contact between
when disconnect YES between CN-1(5)
CD-8 and CN-1(5)-CD-8
and chassis
connector?
Starting switch : ON Starting switch : OFF Disconnection in wiring Repair or replace
Check resistance NO
Engine : start NO
between CN-8(3) harness or poor (after clean)
and chassis contact between
Starting switch : OFF CN-8(3)-CN-1(5)

Check resistance
Disconnection in wiring Repair or replace
between CN-57 NO
NO harness or poor (after clean)
(3) and chassis
contact between
Starting switch : OFF
Before checking, CN-57(3)-CN-8(3)
disconnect CD-8

YES Defective cluster Replace

Check Table
Temperature
(50Ɓ
C) 80Ɓ
C 100Ɓ
C (120Ɓ
C)
Item
C H Unit Resistance(‫)װ‬ (153.9) 51.9 27.4 (16.1)
Tolerance +25, -20 +4.9, -1.2 +1.9, -1.2 Ź1.2

CLUSTER WATER TEMPERATURE SENDER

3 3 5

CN-57 CN-8 CN-1 CD-8

6 - 28
9. WHEN FUEL GAUGE DOES NOT OPERATE(Check warning lamp ON/OFF)

ňBefore disconnecting the connector, always turn the starting switch OFF.
ňBefore carrying out below procedure, check all the related connectors are properly inserted.
ňAfter checking, connect the disconnected connectors again immediately unless otherwise specified.

Cause Remedy
YES
Defective cluster Replace

Check resistance
value between NO
Disconnection in wiring Repair or replace
CN-57(4) and
chassis harness or poor (after clean)
Starting switch : OFF Check resistance contact between
See : TABLE value between CN-57(4)-CN-8(4)
NO CN-8(4) and NO
Disconnection in wiring Repair or replace
chassis
harness or poor (after clean)
See : TABLE Check resistance contact between
value between
YES CN-4(3) and CN-8(4)-CN-4(3)
NO
chassis Disconnection in wiring Repair or replace
See : TABLE Check resistance harness or poor (after clean)
value between contact between
YES CD-2(2) and
chassis CN-4(3)-CD-2(2)
See : TABLE YES
‫ڞ‬

NO
Check circuit Repair or replace
Check resistance between CD-2(1) (after clean)
value between
‫ڞ‬ and chassis
CD-2(2) and
CD-2(1) Defective sender Replace
See : TABLE YES

Check Table
F
Level
Item Empty (1/2) Full

Unit Resistance(‫)װ‬ 110 (32.5) 3


E Tolerance Ź3 Ź2

CLUSTER FUEL SENDER

4 4 3 2
1
CN-57 CN-8 CN-4
CD-2

6 - 29
10. WHEN SAFETY SOLENOID DOES NOT OPERATE

ňBefore disconnecting the connector, always turn the starting switch OFF.
ňBefore carrying out below procedure, check all the related connectors are properly inserted and the
fuse No.8 is not blown out.
ňAfter checking, connect the disconnected connectors again immediately unless otherwise specified.

Cause Remedy
YES Check hydraulic
system
YES Check operation
of solenoid
Defective solenoid Replace
Safety lever : ON-OFF NO
YES
Check voltage Check chassis Replace
between CN-68(1) contact

Starting switch : ON
Voltage : 20~30V
Safety state
Check voltage NO
NO between CN-68(2) Disconnection in Repair or
with chassis wiring harness or poor replace
Safety lever : ON contact between
Voltage : 20~30V
CS-4(3)-CN-68(2)
YES
Disconnection in Repair or
wiring harness or poor replace
Check operation
NO of safety switch contact between
CS-4(1)-Fuse No.8
Voltage : 20~30V
NO
Defective switch Replace
Connector(male)

SAFETY SWITCH
FUSE 3 2
9 1
No.8
NO.8 2
CN-36 3
1
CS-4

SAFETY SOLENOID

2
1

CN-68

6 - 30
11. WHEN TRAVEL SPEED 1, 2 DOES NOT OPERATE

ňBefore disconnecting the connector, always turn the starting switch OFF.
ňBefore carrying out below procedure, check all the related connectors are properly inserted and the
fuse No.6 is not blown out.
ňAfter checking, connect the disconnected connectors again immediately unless otherwise specified.

Cause Remedy
NO
Check voltage Recheck fuse Replace
NO
between CN-36(7)
and chassis Disconnection in wiring Repair or replace
YES
Check voltage harness or poor contact
NO
between CN-3(1) between
and chassis CN-36(7)-CN-3(1)

YES Disconnection in wiring Repair or replace


harness or poor contact
between
CN-70(2)-CN-3(1)

YES
Defective hydraulic Check hydraulic
Check voltage
system system
between CN-70(2) YES Check operation
and chassis of solenoid
Defective solenoid Replace
Starting switch : ON NO
Voltage : 20~30V
YES
Disconnection in wiring Repair or replace
harness or poor contact
Check voltage between
YES
between CN-57 CN-51(14)-CN-57(7)
(7) and chassis
Check voltage
between CN-51 1 speed : 5V
YES 2 speed : 0V Defective cluster Repair or replace
(14) and chassis NO

1 speed : 5V
2 speed : 0V
Defective controller Replace
NO

FUSE
7
NO.6
No.6
CN-36

CONTROLLER TRAVEL SOLENOID

5 6 1
1 2
CN-52
CN-3 CN-70
14

CN-51 CLUSTER

7 7

CN-8 CN-57

6 - 31
12. WHEN ENGINE DOES NOT START

ňCheck supply of the power at engine stop solenoid while starting switch is ON.
ňBefore disconnecting the connector, always turn the starting switch OFF.
ňBefore carrying out below procedure, check all the related connectors are properly inserted and the
fuse No.3 and No.16 are not blown out.
ňAfter checking, connect the disconnected connectors again immediately unless otherwise specified.

Cause Remedy
YES
Defective batteryCheck engine STARTING SW
system 1 B+
Charge(after 3 IG
checking specific 5 START
gravity of battery)
or replace CS-2
Check Check voltage YES
Defective magnet Replace FUSE
operation of
YES between starter of start motor 3
start motor magnet coil
No.3
1
Starting switch : start and chassis Defective start Replace
NO CN-36
Starting switch : start relay
FUSE 24V
NO 1
Check operation Disconnection in wiring Repair or replace No.16
of start relay harness or poor contact
NO CN-38
between
Starting switch : start CN-38(1)-CS-2(1)
FUEL CUT-OFF
YES 9
Check voltage Defective start Repair or replace
between Check voltage 1
switch
NO CS-2(1) and between CS-2
(5) and chassis CN-1
chassis ‫ڞ‬
NO CN-79
Starting switch : start Starting switch : OFF
NO STARTER
Disconnection in wiring Repair or replace
START RELAY
harness or poor contact
Check voltage 1
between
between CN-79
YES CN-36(3)-CN79 2
and chassis
CR-23
Defective fuel cut- Repair or replace M
off solenoid

NO
Disconnection in wiring Replace
harness or poor contact
Check voltage
between CN-1(1)
‫ڞ‬ between CN-1
and CS-2(5)
(1) and chassis
Starting switch : start
Voltage :20~30V
Disconnection in wiring Repair or replace
YES
harness or poor contact
between
CN-1(1)-CR23(1)

6 - 32
13. WHEN STARTING SWITCH "ON" DOES NOT OPERATE

ňBefore disconnecting the connector, always turn the starting switch OFF.
ňBefore carrying out below procedure, check all the related connectors are properly inserted.
ňAfter checking, connect the disconnected connectors again immediately unless otherwise specified. STARTING SWITCH
1 B+
2 BR
Cause Remedy
3 IG
YES
Disconnection in wiring Repair or replace 5 START
harness or poor (after clean)
Check voltage contact between CS-2
YES between CN-4(5)-CR-1 or
CN-4(5) and
chassis defective battery relay
Voltage : 20~30V IG POWER
1
Check voltage Disconnection in wiring Replace
YES between NO
harness or poor CN-36
CS-2(2) and
chassis contact between FUSE
Check voltage Voltage : 20~30V
CS-2(2)-CN-4(5) 1
No.16
NO.16
YES between
CS-2(1) and CN-38
Defective start Replace
NO
switch BATTERY POWER
Voltage : 20~30V 2
CONTINUOUS POWER
1 24V
Check voltage NO
Disconnection in wiring Replace
and specific harness or poor CN-40
gravity of battery contact between BATTERY(12V x 2)

Specific gravity : MIN 1.28 CS-2(1)-CN-38(1)-


Voltage : MIN 24V CN60(1)-CR-1-Battery

Battery capacity Charge or replace


NO
too low (after clean)

FUSIBLE LINK
1 1
2 2

CN-5 CN-60

BATTERY RELAY

CN-4
CR-1

TO STARTER

6 - 33
14. WHEN STARTING SWITCH IS TURNED ON, WIPER MOTOR DOES NOT OPERATE

şBefore disconnecting the connector, always turn the starting switch OFF.
şBefore carrying out below procedure, check all the related connectors are properly inserted and the
fuse No.5 is not blown out.
şAfter checking, connect the disconnected connectors again immediately unless otherwise specified.

Cause Remedy WIPER MOTOR


YES S1 3 B
‫ڞ‬ 3 4 4
Check voltage B 4
YES 2 3 3 S1
between CN-13 E
(3) and chassis 7 2 2
Disconnection in wiring Repair or replace S2 E
NO 1 1 1 1 2
Voltage : 20~30V harness or poor (after clean) S2
Check voltage
YES Starting switch : ON
between CN-6(2) Wiper switch : ON contact between CN-6 CN-13 CN-21
and chassis CN-13(3)-CN-6(2)
Voltage : 20~30V
Starting switch : ON Disconnection in wiring Repair or replace
Wiper switch : ON NO
Check voltage harness or poor (after clean)
YES contact between
between CS-3(1)
and chassis CN-6(2)-CS-3(1)
Voltage : 20~30V
YES
Starting switch : ON Defective wiper motor Replace
Wiper switch : ON
Check voltage YES
Disconnection in wiring Repair or replace
NO between CS-3(6) harness or poor (after clean) WASHER SWITCH
and chassis Check voltage
contact between 10 9 10
Voltage : 20~30V between CN-36(6)
Check operation Starting switch : ON NO and chassis CS-3(1)-CN-36(6) 9 3
of wiper switch Wiper switch : OFF
8
8 6
Voltage : 20~30V Recheck fuse Replace 1
Starting switch : ON Starting switch : ON NO 6
Washer switch : ON-OFF 3
YES
Defective wiper motor Replace 1
YES Check voltage
between CN-21(1) CS-3
and chassis
Disconnection in wiring Repair or replace
NO
Check voltage Wiper switch : OFF harness or poor (after clean)
between CS-3(6) contact between
NO
and chassis WASHER TANK
CN-21(1)-CS-3(6)
Voltage : 20~30V 1
Starting switch : ON
Recheck fuse Replace 2
NO
YES CN-22
Defective wiper Replace
Check voltage motor FUSE
‫ڞ‬ between CN-21(3)
6
and chassis No.5
Disconnection in wiring Repair or replace
NO CN-36
Starting switch : ON harness or poor (after clean)
Wiper switch : ON-OFF
contact between
CN-21(3)-CN-13(3)

6 - 34
15. WHEN STARTING SWITCH IS TURNED ON, HEAD LAMP DOES NOT LIGHT UP

ňBefore disconnecting the connector, always turn the starting switch OFF.
ňBefore carrying out below procedure, check all the related connectors are properly inserted and the
fuse No.12 is not blown out.
ňAfter checking, connect the disconnected connectors again immediately unless otherwise specified.

HEAD LAMP
Cause Remedy
YES 1
Defective bulb Replace
Check voltage 1 2
YES
between CL-4(2)-
chassis CN-4 CL-4
Disconnection in wiring Repair or replace
NO
Voltage : 20~30V harness or poor (after clean) 1
Check voltage
YES Starting switch : ON contact between 2
between CN-4(1) Light switch : ON at 1st
and chassis step CN-4(1)-CL-4(2)
CL-3
Voltage : 20~30V
Starting switch : ON
Light switch : ON at 1st Disconnection in wiring Repair or replace
step NO
Check voltage harness or poor (after clean)
YES
between CS-39 contact between
(5) and chassis CS-39(5)-CN-4(1)
Light switch : ON at 1st
step CLUSTER
YES
Defective bulb Replace
Check voltage 9 9
between CL-3(2)
YES CN-7 CN-56
and chassis
NO Disconnection in wiring Repair or replace
Voltage : 20~30V
Starting switch : ON harness or poor (after clean)
Check operation Light switch : ON at contact between HEAD LAMP SWITCH
1st step
of head lamp CS-39(5)-CL-3(2) 9 10
switch 4
10 2
Starting switch : ON 9 7
Recheck light Replace 1
Light switch: ON-OFF NO 5
5
switch
1

II I 0
YES
Defective light Replace switch
switch CS-39

Check voltage
between CS-39(1)
NO FUSE
and chassis YES
Disconnection in wiring Repair or replace 1
Voltage : 20~30V harness or poor (after clean) No.12
NO.12
Starting switch : ON Check voltage CN-37
contact between
between CN-37
NO CN-37(1)-CS-39(1)
(1) and chassis

NO Recheck fuse Replace

6 - 35
16. WHEN STARTING SWITCH IS TURNED ON, WORK LAMP DOES NOT LIGHTS UP

ňBefore disconnecting the connector, always turn the starting switch OFF.
ňBefore carrying out below procedure, check all the related connectors are properly inserted and the
fuse No.13 is not blown out.
ňAfter checking, connect the disconnected connectors again immediately unless otherwise specified.

Cause Remedy
WORK LAMP
YES
Disconnection in wiring Repair or replace
1 1
harness or poor (after clean)
2 2
Check voltage contact between
YES
between CN-10 CN-10(2)-CL-6(2) and CN-10 CL-5
(2) and chassis CN-10(2)-CL-5(2)
Voltage : 20~30V 1
Starting switch : ON Disconnection in wiring Repair or replace 2
Check voltage Light switch : ON at NO
YES
between CN-4(6) 2nd step harness or poor (after clean)
and chassis CL-6

CN-4
contact between

6
Voltage : 20~30V CN-10(2)-CN-4(6)
Starting switch : ON
Light switch : ON at
2nd step Disconnection in wiring Repair or replace
NO
Check voltage harness or poor (after clean)
YES
between CR-3(4) contact between
and chassis CN-4(6)-CR-3(4)
CLUSTER
Voltage : 20~30V
Starting switch : ON YES
Defective relay Replace 10 10
Light switch : ON at 2nd
step
Check voltage CN-7 CN-56
YES
NO between CR-3(2) Disconnection in wiring Repair or replace
TO HEAD LAMP
and chassis harness or poor (after clean)
WORK LAMP RELAY (Refer to page 6-35)
Voltage : 20~30V Check voltage contact between WORK LAMP SWITCH
Starting switch : ON 3 4
Check operation NO between CN-37 CN-37(2)-CR-3(2) 4 9 10
(2) and chassis 3 10
of work lamp relay 4
Voltage : 20~30V 2
Recheck fuse Replace 2 9
Starting switch : ON NO 7 1
Starting switch : ON 1 5 5
Light switch : ON-OFF YES 1 2
Disconnection in wiring Repair or replace 4
CR-3

II I 0
harness or poor (after clean) 2
Check voltage contact between
YES
between CS-39 CS-39
CS-39(2)-CR-3(3)
(2) and chassis
Light switch : ON-OFF
Defective lamp Replace switch
Check voltage NO
switch
between CS-39 FUSE
NO 2
(4) and chassis YES No.13
Disconnection in wiring Repair or replace NO.13
Voltage : 20~30V CN-37
Starting switch : ON
harness or poor (after clean)
Check voltage contact between
between CN-37
NO CS-39(4)-CN-37(2)
(2) and chassis

Recheck fuse Replace


NO

6 - 36

You might also like