Professional Documents
Culture Documents
The currenza c 2 can Press key ... How often? Effect The currenza c2 comes Press key ... How often? Effect
be configured so that with pre-programmed
each change tube of the 1 1 x You enter the main configuration menu
coin cassette 1 1 x
You enter the main configuration and service
menu
coin cassette accepts 2 1 x You enter the setting menu configurations. The
no more than a specific specific configuration is 2 1 x You enter the setting menu
number of coins. When 3 until Coin settings You select coin settings submenu indicated on a label on
3 until Coin settings You select coin settings submenu
this number is reached, the front of the cassette,
4 1 x You enter the coin settings
all further coins for this i.e.: USD1, USD8, etc. 4 1 x You enter the coin settings
tube are then directed 5 until Filling level limitation You select filling limitation submenu
into the cash-box Please follow the simple 5 until Coin sorting You select coin sorting submenu
temporarily. Only when 6 1 x You enter the submenu
procedure of the right-
You enter the coin sorting submenu. "Select
coins have been paid 7 until required tube For this tube a filling limitation is to be set hand table to change the 6 1 x
coin cassette" is highlighted
/
out of this tube, coins payout configuration.
are again sorted into 8 1 x Now you can set the filling limitation 7 1 x You enter the first tube combination 01
the tube. 9 until required digit You want to set this digit
/ 8 /
until new payout configuration (01–13) You select desired payout configuration
If this function is
not used, the full 10 /
until required value This value is to be set You lock you selection in memory. c2
9 1 x
confirms with info screen "OK"
sensor of the tubes 11 Repeat steps 9 and 10 to set the other two digits of the filling level limitation
determines from
when the coins will be 12 1 x You lock your setting in memory. 10 1 x/2 x You return to main menu/operation mode
sorted into the cash-
box and no longer 13 If necessary, repeat steps 7 to 12 to set filling level limitations of the other tubes
into the tubes. 14 1 x/2 x You return to main menu/operation mode
To clean the coin path, flight deck and sorter cover: problem. 6 1 x/2 x You return to main menu/operation mode
1 Turn power OFF. C
In addition, the
2 Unlatch sorter cover (blue latch on the right of the display) and swing
it open (Fig. 3, A&B). Diagnostics menu
3 Open flight deck at the insert funnel and hold it open (Fig. 3, C). provides specific
4 Remove any debris. Dust off any accumulation with a small brush or details:
compressed air.
5 Clean the complete coin path, front and back, with a slightly wet cloth.
6 Allow to dry.
7 Close flight deck and latch sorter cover.
07/09 Goe/Roe
8 Turn power ON. Fig. 3: Opening coin validator’s sorter cover and flight deck Version 2.0
KA.C2BMQSU
National Rejectors, Inc. GmbH • Zum Fruchthof 6 • D-21614 Buxtehude • Phone: +49 (0) 41 61-729-0 • Fax: +49 (0) 41 61-729-115 • E-mail: info@nri24.com • www.nri24.com