Professional Documents
Culture Documents
Refresher
22 - Basic Principle
Definitions / Plumbing Terms
Reference:
Revised National Plumbing Code of the Philippines
a. sufficient / approved
b. efficient / economical
c. minimum / maximum
d. daring / exotic
Prepared by Marky Robrickz
2. All premises intended for human habitation,
occupancy or use shall be provided with a
supplyof pure and wholesome water, neither
connected with unsafe water supplies nor
subject to hazards of backflow or back-
siphonage.
a. Principle no.1
b. Principle no.2
c. Principle no.3
d. Principle no.4
Prepared by Marky Robrickz
3. Plumbing fixtures, devices and appurtenances
shall be supplied with water in _______ volume
and a pressure ______ to enable them to
function satisfactorily and without undue noise
under all normal conditions of use.
a. exact/exact
b. efficient/equipped
c. sufficient/adequate
d. half/full
Prepared by Marky Robrickz
4. Plumbing shall be designed and adjusted to
use the minimum quantity of water consistent
with proper performance and cleaning.
a. Principle no.1
b. Principle no.2
c. Principle no.3
d. Principle no.4
a.sensorized / equipped
b.designed / installed
c.rough-in / sensorized
d.think / formulate
a. Principle no.5
b. Principle no.6
c. Principle no.7
d. Principle no.8
Prepared by Marky Robrickz
7. Plumbing fixtures shall be made of________
material, free from concealed fouling surfaces
and shall be located in ventilated enclosures.
a. smooth non-irritated
b. smooth non-absorbent
c. watertight
d. glossy non-absorbent
a. Principle no.9
b. Principle no.10
c. Principle no.11
d. Principle no.12
Prepared by Marky Robrickz
10. Each fixture directly connected to the
drainage system shall be equipped with
a______.
a. equipped
b. adequate
c. effectively
d. efficiently
a. Vent terminals
b. Stack
c. SVTR
d. VSTR
a. Principle no.13
b. Principle no.14
c. Principle no.15
d. Principle no.16
a. kitchen hood
b. water closet
c. rest room
d. range hood
a. secure
b. prevent
c. protect
d. effectively
Prepared by Marky Robrickz
18. All plumbing fixtures shall be
installed________ to be accessible for their
intended use.
a. properly ventilated
b. properly spaced
c. properly cleaned
d. All of the above
a. Principle no.22
b. Principle no.21
c. Principle no.20
d. Principle no.19
Prepared by Marky Robrickz
23. Sewage or other waste from a plumbing
system which may be deleterious to surface or
sub-surface waters shall not be discharge into
the ground or into any water way, unless first
rendered innocuous through subjection to some
acceptable form of treatment.
a. Principle no.22
b. Principle no.21
c. Principle no.20
d. Principle no.19
Prepared by Marky Robrickz
1. b. efficient / economical
2. a. Principle no.1
3. c. sufficient/adequate
4. c. Principle no.3
5. b.designed / installed
6. a. Principle no.5
7. b. smooth non-absorbent
8. b. safeguard
9. a. Principle no.9
10. b. water-sealed trap
Prepared by Marky Robrickz
11. b. Drainage piping system
12. c. effectively
13. a. Vent terminals
14. a. Principle no.13
15. c. No substance
16. b. water closet
17. b. prevent
18. b. properly spaced
19. b. Principle no.21
20. a. Principle no.22
Prepared by Marky Robrickz
THE END
thank you!...
Prepared by Marky Robrickz