Professional Documents
Culture Documents
- +
the first option is displayed. Press the "+" or "-" key to select the options Over
0-3600s
that need to be modified, press the "PROG" key to enter the modified P11 current Current over-load alarm delay. COM NC NO TXD GND RXD
state; press the "+" or "-" key to change the parameter value, press the (30s)
faults delay
"+" or "-" key to remain unchanged, can continuously increase or reduce ALARM OUTPUT
Page- Interval time for water temperature DC 8-36V MAX 3A
the parameter value; after adjustment, press the "PROG" key to return to 1-120s
P12 change and fuel temperature, the max time
the upper parameter browsing interface. After setting the parameters, (120s)
delay is manually change.
press the "PROG" button for 3 seconds, then save and exit the setting Warning: Please don’t move battery during running status or
mode. When the frequency is over than
Freq. it may cause the meter broken.
When setting parameters, if more than 30S is pressed without any 10.0-70.0Hz the pre-set value once on power,
P13 for start
key, the setting interface will automatically exit and the modified (20.0Hz) then it is regarded that engine Notes
success
parameters will be saved. The parameters will take effect immediately crank successfully. 1. If the system checked the frequency is over " Freq. for start
after they are saved and modified. This delay only responds to success "(P13),the meter is connected with main power, then it will
Range Safety
NO. Parameter Notes P14 3-300s(10s) overfrequency and overvoltage regard the genset as cranked successfully. which means the alarm
(defaults) delay
alarms. will occur after the safety delay when the fault is checked.
All the alarm indications and Alarm Alarm relay output setting. 0:alarm 2. When alarm protection occurs, the display page of the alarm
Alarm 0:Disabled 0-120s
P00 outputs are forbidden if it is set as P15 output output disabled, 120:alarm output parameter is automatically displayed. The alarm parameter value is
function 1:Available (120s)
0. delay all the time. locked and flickers. Pressing the "RESET" key can clear the alarm.
Used for setting genset CT primary User 0000-9999 Password to enter parameter 3. All rights reserved. No part of this duplication may be reproduced
5-6000A/5A P16
P01 CT rate current, secondary rated current password (0000) setting interface in any material form(including photocopying or storing in any medium
(500A/5A)
5A. Options Parameters by electronic means or others) without the written permission of the
When the Freq is higher than the Operation Voltage:DC8~36V Continuous copyright holder.
Over freq 20.0-75.0Hz value and comes into over freq Power Consumption:MAX1.5W 4. MEBAY Technology reserves the rights to change the contents of
P02
alarm (57.0Hz) delay but still higher (emergency AC Voltage Input:3 phase 4 wire 30-276VAC(ph-N),10-75Hz this document without prior notice.
faults delay), then over frequency AC Current Input:Secondary input of current transformer MAX 5A