Professional Documents
Culture Documents
SECTION-A
There are FOUR questions in this section. Answer any THREE.
I. (a) Discuss different ship design stages with design spiral. (20)
(b) Discuss ship contract in details. (15)
3. (a) Discuss the ABS or any other international CS rule for centre girder design. (10)
(b) Show with figure how to maintain continuity of the longitudinal stiffeners through the
4. (a) An unequal angle bracket is welded to a column by 10mm fillet welds as shown in
figure for Q. No. 4(a). Determine the maximum eccentricity, at which a load of 120 kN
can be placed on the bracket, if the stress in the weld is limited to 80 MPa. (20)
(b) A hollow circular steel column with its ends fixed in position has unsupported span of
2m, an outside diameter of 100 mm and an inside diameter of 80 mm. Determine the
permissible load according to the ABS or any other international CS rule. (15)
SECTION-A
There are FOUR questions in this section. Answer any THREE.
5. (a) With neat sketches, describe different types of rudders. How can you construct a
rudder? (15) .
(b) Discuss different type of stem construction. (10)
(c) What can you say about marine propeller from the construction/assembly point of
view. (10)
Contd P/2
=2=
NAME 355
6. (a) With neat sketches, explain elaborately plimsoll marks used in ships. (12)
(b) How would you describe Admiralty pattern, stockless, Admiralty cast, CQR and
Danforth anchors? (13)
(c) How could you discuss manhole cover details? (10)
8. (a) Can you make a distinction between thermal insulation and accounting insulation? (10)
(b) How would you explain the principle of operation of a sounding pipe? (10)
(c) Write short notes on: (15)
(i) Bilge system
(ii) Anti-fouling paint
(iii) Scuppers
(iv) Sampson posts
(v) Bulwark
T
200
[J
-,,
---x