Professional Documents
Culture Documents
Determination of Applied Loads and Bearing Analysis: Engineering
Determination of Applied Loads and Bearing Analysis: Engineering
A21
•
c
Clo
FsP pinion
apex
ise
ckw
clo
Co nter
Fig. A-1 FtG u
Spur gearing.
Fig. A-3
Straight bevel and zerol gears
– thrust and separating forces
are always in same direction
regardless of direction of
Single helical gearing (Fig. A-2) rotation.
Tangential force Pinion
Tangential force
FtG = (1.91 x 107) H (newtons)
DpGnG FtP = (1.91 x 107) H (newtons)
DmP nP
= (1.26 x 105) H (lbf-in.)
DpGnG = (1.26 x 105) H (lbf-in.)
DmP nP
Separating force
Thrust force
FtG tanΦG FΦP = FtP tan ΦP sin γP
FsG =
cos ΨG FtP
Separating force
Thrust force FaG FsP = FtP tan ΦP cos γP
FsG
FaG = FtG tan ΨG
FsP
A22
•
Thrust force
FtG
FaG = FtG tan ΦG sin γG
Separating force
FsG = FtG tan ΦG cos γG
+
tooth curvature on the near face of the gear (Fig. A-5) inclines to the y from
Cloc
kwise
pinio
left or right from the shaft axis. Direction of rotation is determined n ape
x
by viewing toward the gear or pinion apex.
loc
Ne
_ Thrus gative
rc
Counte t tow
In spiral bevel gearing pinio ard
n ap
ex
FtP = FtG
Fig. A-5
In hypoid gearing Spiral bevel and hypoid gears – the direction
FtG cos ΨP of thrust and separating forces depends
FtP = upon spiral angle, hand of spiral, direction
cos ΨG of rotation, and whether the gear is driving
or driven.
Hypoid pinion effective working diameter
DmP = DmG
( )(
Np
NG
cos ΨG
cos ΨP ) FtP
A23
•
FaW = FtW η
tan λ
Separating force
A24
•