[A Unit of Vivekananda Vidyavardhaka Sangha, Puttur ®] ECE
Affiliated to Visvesvaraya Technological University AC Approved by AICTE New Delhi & Govt of Karnataka 08/04/2020 Recommended Questions from Module-5 1. Explain the weighted resistor DAC with a neat sketch. 2. With a neat diagram explain R-2R DAC. 3. Explain the operation of successive approximation ADC with the help of neat diagram. 4. What is the difference between normal rectifier and precision rectifier? Explain the working of full wave precision rectifier with the help of neat diagrams. 5. What are the advantages of active filter over passive filter? 6. Define the following a) Pass band b) Stop band c) Attenuation d) Cut off frequency e) Frequency response 7. Draw the circuit of second order low pass filter, explain its operation and draw the expression for the cut off frequency. 8. Design an op-amp based second order active low pass filter with cut off frequency 2KHz. 9. Draw the circuit of second order high pass filter and explain its operation. 10. Explain the operation of wide band and narrow band pass filter. 11. What is band elimination filter, explain and draw the frequency response. 12. Explain the functional block diagram of IC 555. 13. Explain the operation of oneshot Multivibrator using IC 555 14. Explain the operation of free running Multivibrator using IC 555 15. Design a second order active high pass filter using 741 op-amp with cutoff frequency of 12kHz. 16. With necessary circuit diagram and equations, explain R-2R DAC. What output voltage would be produced by a,DAC whose output range is 0 to l0 V and whose input binary number is, (i)1010 (for 4 bit DAC) (ii) 10111100 (for an 8 bit DAC) 17. Design a astable using 555 with an output frequency of 1KHz and 70% duty cycle. 18. Design a one shot multivibrator using 555 for pulse width of 5usec. What must be the voltage applied at the control pin to stretch the pulse width from 5usec to 10usec.
Nehru Nagar, Puttur - 574 203, DK, Karnataka State – INDIA.