Professional Documents
Culture Documents
Page No.
6.0 REFERENCES 11
7.0 ATTACHMENTS 12
-i-
1.0 INTRODUCTION AND DISCUSSION
On behalf of Mr. Cort Kwiecinski, NTH Consultants, Ltd. (NTH) has prepared this Baseline
Environmental Assessment (BEA) for the 6556 East McNichols Property in Detroit, Wayne
County, Michigan.
The property is approximately 0.76 acres in size and contains one vacant industrial building.
The Phase I ESA revealed the following recognized environmental conditions (RECs) at the
property:
Past use of the property for industrial purposes with evidence of former subgrade machine
pits, and oil stained floors and walls in the southern portion of the building. No
information is readily available regarding the past occupants’ hazardous material
management and waste disposal practices.
-1-
Three 1,000-gallon underground storage tanks (USTs) reported to contain cutting oil,
lubrication oil and waste oil are present under the canopy area near the southwest corner
of the building.
The east and south adjoining sites are used for automotive salvage operations. No
information is readily available regarding the occupants’ hazardous material management
and waste disposal practices.
The geoprobe drilling technique involves mechanically driving or pushing a two-inch outside
diameter stainless steel sampling tool, with a disposable clear acetate liner, to a desired
sampling depth. This technique does not generate soil cuttings because the geoprobe rods
push soils away from the rods as the tool string advances through the hole. The HAB was
manually advanced by FES personnel using an approximately 2-inch diameter bucket-type
-2-
auger. The geoprobe and hand auger equipment/tools were steam-cleaned prior to use and
between each successive boring location to minimize the possibility of cross-contamination.
Upon completion of drilling activities and after collecting samples, the boreholes were
backfilled with excavated soil and hydrated bentonite chips.
Soil samples retrieved from the borings were screened in the field with RAE Systems
MiniRae™ PID. The PID is capable of detecting total volatile organic compounds (VOCs),
which include many petroleum-related substances, to a detection level of one part per million
(ppm). The field PID measurements on the soil samples are shown on the Log of Geoprobe
Borings in Attachment II. As indicated, the PID readings ranged from less than the detection
limit of the instrument to 96 ppm. Petroleum-type odors were noted in samples retrieved from
boring GP-3 and GP-5.
Observations of subsurface conditions are presented on the boring logs in Attachment II. The
stratification shown on the boring logs represents the approximate boundary between soil
types; the actual transition may be more gradual. In addition, the soil layers are described
based on field classification of observed soil samples. As such, the soil layer descriptions
should be considered generalized.
The subsurface conditions at the boring locations comprise of up to 7 feet of sandy and clayey
fill with pieces of brick, charred wood, and concrete rubble. The fill soil is underlain by native
sands, which in turn are underlain by native clayey soils to the explored depths. Groundwater
was encountered in GP-1, GP-2, GP-3 and GP-5 at depths of about 7 to 8 feet.
Soil samples for analysis were selected based on the results of the field screening including
visual and olfactory observations, and PID measurements. Due to insufficient amounts of
water for sampling, groundwater samples could not be collected from GP-1, GP-2 and GP-3.
-3-
Groundwater samples were collected from GP-5 directly from the borehole by installing a
temporary well. Due to the high turbidity and suspended solids content, a portion of the water
sample for metal analyses was filtered in the field using disposable 0.45-micron filter prior to
sample preservation.
The soil and groundwater samples were placed in laboratory-supplied containers and stored in
coolers packed with ice. The samples were released to FES’ laboratory in accordance with
NTH’s chain-of-custody procedures. The samples were analyzed for VOCs, either
polynuclear aromatics (PNAs) or Semi-VOCs (SVOCs), and the Michigan 10 metals (arsenic,
barium, cadmium, chromium, copper, lead, mercury, selenium, silver and zinc) or cadmium,
chromium and lead. The soil samples for VOC testing were prepared in the field using
Michigan-modified methanol preservation (EPA Method 5035). Additionally, two soil
samples (S-1 of GP-3 and S-1 of GP-5) with the evidence of petroleum odors were also
analyzed for polychlorinated biphenyls (PCBs). Laboratory data for the analyzed samples are
included in Attachment II.
The soil and water analytical data were compared to the MDEQ-established generic residential
cleanup criteria (GRCC) dated December 30, 2013, pursuant to 1994 P.A. 451, Part 201, as
amended.
The results of the soil analysis were compared to the Part 201 generic residential direct contact
(DC) criteria, drinking water protection (DWP) criteria, groundwater/surface water interface
protection (GSIP) criteria, soil volatilization to indoor air criteria (SVIIC), infinite source soil
volatilization to ambient air criteria (VSIC), particulate soil inhalation criteria (PSIC) and soil
saturation concentration screening levels (SSCSL). The results of the metals analyses were
also compared to the statewide default background (SWDB) concentrations, as established by
MDEQ. The results of water analysis were compared to the Part 201 generic residential
drinking water (DW) criteria, groundwater/surface water interface (GSI) criteria, groundwater
-4-
contact criteria (GCC), and groundwater volatilization to indoor air (GVIIC) criteria. The
analytical data is summarized in the tables included in Attachment II.
A Sample Exceedance Plan showing the locations of the samples exceeding Part 201 GRCC is
included in Attachment III.
The soil and groundwater analytical data was also compared with MDEQ’s August 2017
Media-Specific Volatilization to Indoor Air Interim Action Screening Levels (nonresidential).
This comparison indicated that mercury and certain VOCs in soil and certain VOCs in
groundwater samples exceeded these screening levels.
-5-
1.8 BASIS FOR FACILITY DETERMINATION
Based on the hazardous substances identified in Section 1.7, the property is a “facility.”
According to Section 20101(1)(s) of Part 201 of NREPA (1994 P.A. 451, as amended),
“facility” means any area, place, or property where a hazardous substance in excess of the
concentrations that satisfy the cleanup criteria for unrestricted residential use has been
released, deposited, disposed of, or otherwise comes to be located.
-6-
2.0 PROPERTY INFORMATION
-7-
3.0 FACILITY STATUS
-8-
4.0 IDENTIFICATION OF THE AUTHOR
-9-
5.0 ALL APPROPRIATE INQUIRY REPORT
NTH conducted a Phase I ESA at the property in accordance with the scope and limitations of
American Society for Testing and Materials (ASTM) Practice E1527-13, entitled: “Standard
Practice for Environmental Site Assessments: Phase I Environmental Site Assessment
Process”, which is consistent with EPA’s AAI Rule 40 CFR Part 312.
- 10 -
6.0 REFERENCES
MDEQ’s - Revised Part 201 Generic Cleanup Criteria and Screening Levels – Table 1;
Groundwater: Residential and Nonresidential and Table 2; Soil: Residential, published on
December 30, 2013.
- 11 -
7.0 ATTACHMENTS
- 12 -
ATTACHMENT
Phase I ESA Report
I
REPORT
Page No.
2.0 INTRODUCTION 2
2.1 Purpose 2
2.2 Detailed Scope of Services 2
2.3 Significant Assumptions 3
2.4 Limitations and Exceptions 3
2.5 Special Terms and Conditions 4
2.6 User Reliance 4
-i-
TABLE OF CONTENTS (cont.)
Page No.
7.0 EVALUATIONS 21
9.0 REFERENCES 23
-ii-
TABLE OF CONTENTS (cont.)
APPENDICES
-iii-
1.0 EXECUTIVE SUMMARY
This report presents the results of a Phase I Environmental Site Assessment (ESA) for the
6556 E. McNichols Property in Detroit, Wayne County, Michigan. The property is
approximately 0.76 acres in size and contains one vacant industrial building.
The Phase I ESA was performed in accordance with the scope and limitations of American
Society for Testing and Materials (ASTM) Practice E1527-13. This study has revealed the
following evidence of recognized environmental conditions at the property:
Past use of the property for industrial purposes with evidence of former subgrade
machine pits, and oil stained floors and walls in the southern portion of the building. No
information is readily available regarding the past occupants’ hazardous material
management and waste disposal practices.
Three 1,000-gallon underground storage tanks (USTs) reported to contain cutting oil,
lubrication oil and waste oil are present under the canopy area near the southwest corner
of the building.
The east and south adjoining sites are used for automotive salvage operations. No
information is readily available regarding the occupants’ hazardous material management
and waste disposal practices.
This executive summary should not be reviewed separately from the remainder of the report,
and is not a substitute for a thorough review of the entire report.
-1-
2.0 INTRODUCTION
NTH Consultants, Ltd. (NTH) was retained by Cort Kwiecinski to perform a Phase I
Environmental Site Assessment (ESA) for 6556 E. McNichols Road Property in Detroit,
Michigan. A map depicting the location of the property is included as Figure 1 in Appendix
A. The property is approximately 0.76 acres in size and contains a 23,260 square foot vacant
industrial building.
NTH conducted this Phase I ESA in accordance with the scope and limitations of ASTM
Practice E1527-13 entitled: “Standard Practice for Environmental Site Assessments: Phase I
Environmental Site Assessment Process,” which is consistent with USEPA’s AAI Final Rule
(40 CFR Part 312).
2.1 Purpose
Mr. Kwiecinski purchased the property on November 28, 2017. Thus, the objective of this
Phase I ESA was to provide a professional opinion regarding recognized environmental
conditions (RECs), if any, associated with the property. According to ASTM Practice E1527-
13, the term recognized environmental conditions means the presence or likely presence of any
hazardous substances or petroleum products in, on, or at a property: (1) due to any release to the
environment; (2) under conditions indicative of a release to the environment; or (3) under
conditions that pose a material threat of a future release to the environment.
A visual survey of the property and building was conducted to identify RECs. Color
photographs were taken to document prominent surface features. These photographs are
presented in Appendix B and are referenced in the text of the report.
-2-
The neighboring properties were observed to assess whether surface features or activities
on these properties may have a negative environmental impact on the property. The
previous uses of the adjacent properties were determined through review of information
compiled during the Phase I ESA.
Past use history of the property was developed from reasonably ascertainable information.
A regulatory agency file search was performed to identify sites of environmental concerns
located within the ASTM-specified minimum search distances from the property.
The information developed during this study was evaluated and this report was prepared.
-3-
The evaluations and opinions presented in this report are based on the scope of services
defined herein, and should not be misconstrued as those pertaining to a formal environmental
compliance audit. The results of this investigation cannot be construed as a certification of
the absence of any contaminants on the property, but rather a diligent and prudent review of
available data within an established work scope, and time and budgetary constraints.
Limiting conditions encountered during the performance of the Phase I ESA are described in
appropriate sections of this report.
The results of this study may not be relied upon by parties other than those identified above
without the prior knowledge and written consent of NTH. For the avoidance of doubt, the
parties’ respective assigns is intended to include any lending institutions or lenders in
connection with a secured financing of the subject property, and their respective successors
and assigns.
Any authorized third party agrees by accepting this report that any use or reliance on this
report shall be limited by the exceptions and limitations in this report, and with the
acknowledgment that actual site conditions may change with time, and that hidden conditions
-4-
may exist at the property that were not discovered within the authorized scope of the
assessment.
Any use by or distribution of this report to any unauthorized third parties, without the express
written consent of NTH is at the sole risk and expense of such third party. In the absence of a
written agreement with NTH granting such rights, no third parties shall have rights of
recourse or recovery whatsoever under any course of action against NTH or its officers,
employees, vendors, affiliates successors or assigns. Any such unauthorized user shall be
responsible to protect, indemnify and hold NTH and its respective officers, employees,
vendors, affiliates, successors and assigns harmless from any and all claims, damages, losses,
liabilities, expenses including attorneys’ fees and costs attributable to such use. Unauthorized
use of this report shall constitute acceptance of and commitment to these responsibilities,
which shall be irrevocable and shall apply regardless of the cause of action or legal theory
pled or asserted.
NTH’s Phase I ESA User Questionnaire was completed by Mr. Kwiecinski, the property
owner. A copy of this questionnaire is included in Appendix C.
3.1 Title Records, Environmental Liens and Activity and Use Limitations
Title records for the property were not provided to NTH during the current study.
Information obtained from Michigan Department of Environmental Quality (MDEQ) –
Remediation Division website indicated that no environmental liens are recorded against the
property. Additionally, a regulatory agency database search conducted by EDR, Inc. (a
private information agency) did not identify any Activity and Use Limitations (AULs) against
the property.
-5-
Actual Knowledge of the User
Mr. Kwiecinski is not aware of any environmental liens or AULs associated with the
property.
NTH reviewed readily available records to determine: 1) the local geology and hydrogeology
of the area; 2) the potential risk to the property from offsite sources of environmental concern;
3) historical uses of the property; and 4) historical uses of adjacent properties. These records
were reviewed to help identify RECs, if any, associated with the property. Environmental
Data Resources, Inc. (EDR), a private environmental information agency, was retained to
provide physical setting information, regulatory agency database search, Sanborn maps, aerial
photographs, topographic maps, and city directories.
-6-
4.1 Physical Setting Sources
NTH assessed the property’s physical settings based on a review of EDR-provided
information, readily available published information and observations made during the visual
survey. As described in the following subsections, the physical setting includes topography,
soil general geology, hydrology, hydrogeology, and related attributes.
4.1.1 Topography
Information on the topography of the property was obtained from the USGS “Detroit,
Michigan” topographic map. The subject property is generally level at a USGS elevation of
approximately 625 feet above mean sea level.
4.1.2 Geology
According to the USDA Soil Survey of Wayne County Area, the property is in an urban area
where soils have been affected by development. Near-surface soils in the area are expected to
consist of thick sequences of clay. According to other readily available published sources, the
geology of the area is characterized by about 50 to 100 feet of non-homogeneous glacial
lacustrine clay deposits. Underlying these glacial deposits is the Dundee bedrock formation,
which is composed of limestone.
4.1.3 Hydrology
No surface water bodies were observed at or in the immediate vicinity of the property.
4.1.4 Hydrogeology
Groundwater in the area is generally present in both the glacial deposits and in the underlying
bedrock; however, shallow groundwater in the area of the property is expected to be erratic
and almost negligible due to the high clay content of the glacial soils. Intermittent
accumulations of perched water may be encountered where granular soils overlie unsaturated
cohesive soil deposits.
-7-
4.1.5 Oil and Gas Wells
According to information provided in the EDR report (Appendix D), no oil or gas wells are
located at or in the immediate vicinity of the property.
The following tables list the ASTM-recommended databases researched by EDR along with
their respective search distances:
SEARCH
FEDERAL DATABASES RADIUS
(in miles)
National Priorities List (NPL) - Identifies the nation's hazardous sites that warrant further
investigation. Sites are first identified as SEMS and the degree of contamination determines whether 1.0
the site will be included on the NPL.
Delisted NPL - Sites deleted from the NPL where no further response is required. 0.5
Superfund Enterprise Management System (SEMS) - formerly known as Comprehensive
Environmental Response Compensation Liability Index System (CERCLIS) –a comprehensive
tracking and reporting tool provides updated data on the inventory of active and archived
0.5
hazardous waste sites evaluated by the Superfund program. It contains sites that are either
proposed to be or are on the National Priorities List (NPL) as well as sites that are in the
screening and assessment phase for possible inclusion on the NPL.
SEMS - No Further Remedial Action Planned (SEMS-NFRAP) - SEMS sites where no further
0.5
remedial action is planned.
Corrective Action Report (CORRACTs) - Includes hazardous waste handlers with RCRA
1.0
corrective action activities.
Resource Conservation Recovery Act (RCRA) Treatment Storage and/or Disposal (TSD)
Facilities - RCRA provides for the management of hazardous wastes by regulating the 0.5
operations of those who operate treatment, storage or disposal facilities.
RCRA Large Quantity Generator (LQG) - RCRA provides for the management of properties that Property and
generate more than 1,000 kilograms of hazardous waste or over 1 kilogram of acutely hazardous adjoining
waste per month. sites
RCRA Small Quantity Generator (SQG) - RCRA provides for the management of properties that Property and
generate more than 100 kilograms and less than 1,000 kilograms of hazardous waste. adjoining
sites
-8-
FEDERAL DATABASES SEARCH
RADIUS
(in miles)
RCRA Conditionally Exempt Small Quantity Generator (CESQG) - RCRA provides for the Property and
management of properties that generate less than 100 kilograms of hazardous waste or less than 1 adjoining
kilogram of acutely hazardous waste per month. sites
RCRA Non-Generators (NonGen) - Non-generators do not presently generate hazardous waste, Property and
but may have in the past. adjoining
sites
Institutional Controls (US INST CONTROL) -A listing of sites with institutional controls in
place. Institutional controls include administrative measures, such as groundwater use
restrictions, construction restrictions, property use restrictions, and post remediation care Property
requirements intended to prevent exposure to contaminants remaining on site. Deed restrictions
are generally required as part of the institutional controls.
Engineering Controls (US ENG CONTROLS) - A listing of sites with engineering controls in
place. Engineering controls include various forms of caps, building foundations, liners, and
Property
treatment methods to create pathway elimination for regulated substances to enter environmental
media or effect human health.
Emergency Response Notification Sites (ERNS) - Records information about reported releases of
hazardous substances and/or petroleum products. These sites are maintained by the EPA and the Property
MDEQ.
SEARCH
STATE & TRIBAL DATABASES RADIUS
(in miles)
State Hazardous Waste Sites (SHWS) - Known as Part 201 Sites in Michigan, SHWS are
Michigan's equivalent to SEMS. The sites are reported to the State through municipalities, private
companies/citizens. The State has developed a numerical ranking model for determining the present 1.0
and potential hazard that each site poses to public health, safety, welfare and/or the environment.
Each site is scored using this model once identified and annually thereafter.
State Landfill and/or Solid Waste Disposal Site (SWF/LF) - Part 115 of Act 451, as amended,
0.5
regulates and maintains an inventory of solid waste disposal facilities or landfills.
Leaking Underground Storage Tank (LUST) - Part 213 of Act 451, as amended, regulates and
details the corrective action required due to releases from leaking USTs. Part 213 also prescribes the 0.5
powers and duties of certain State agencies and officials, and provides penalties and remedies.
Underground Storage Tank (UST) - Part 211 of Act 451, as amended, regulates certain UST Property and
systems, requires the registration of certain UST systems, prescribes the duties of certain state and adjoining
local agencies and officials, imposes fees, and prescribes penalties and remedies. sites
Above Ground Storage Tank (AST) - Listing of registered ASTs Property and
adjoining
sites
Activity and Use Limitations (AUL) - Sites with institutional controls and/or engineering controls. Property
Brownfields - BEA or leaking UST sites which have been redeveloped by private entities using the
0.5
BEA process.
U.S. Brownfields - List of brownfields properties addressed by Cooperative Agreement Recipients
0.5
and/or Targeted Brownfields Assessments.
Baseline Environmental Assessment (BEA) - Sites of environmental contamination with soil
and/or groundwater contamination levels above MDEQ Part 201 residential cleanup criteria and
have been identified as a “facility” and have submitted a BEA to MDEQ. BEAs provides new 0.5
owners/operators of sites of known contamination exemption from liability for existing
contamination at a site at the time of purchase/occupancy.
-9-
The EDR report identified 89 sites, of which 88 sites were plotted on a street map and one site
was listed as an “orphan site.” The orphan site could not be plotted by EDR on a map due to
lack of proper address or other pertinent information required for precise computer plotting,
and as such could only be located within the city, county or zip code area of the property.
Following review of the EDR report, a drive-through reconnaissance of the area was
conducted to confirm the locations of the plotted sites and to locate the orphan site. Based on
NTH’s experience conducting numerous Phase I and Phase II ESAs in the City of Detroit and
knowledge of local subsurface conditions (i.e., composed of predominantly clayey soils and
lack of a shallow aquifer), only the EDR-identified sites located within 100 foot radius of the
property were further evaluated to determine if any of these sites would be considered off-site
sources of potential environmental concern or RECs. In NTH’s opinion, the sites located
more than 100 feet away are unlikely to have a negative environmental impact on the
property.
The following EDR-identified sites are located within 100 feet of the property and were
further evaluated to determine if these sites would be considered as off-site sources of
potential environmental concern:
Wolverine Nut Corporation (6556 East McNichols Road): This is the subject
property and is listed in the UST, RCRA Non-Generator, WDS, FINDS and ECHO
databases. According to the EDR report, the property historically generated hazardous
waste but no RCRA compliance violations were issued against the property. The WDS,
FINDS, and ECHO listings are associated with RCRA generator status. Review of UST
Facility File obtained from Michigan Department of Licensing and Regulatory Affairs
(LARA), indicates that the three 1,000-gallon USTs were installed on property in 1957.
-10-
The tanks were reported to contain cutting oil, lubrication oil and waste oil and were in
use until the early 1990s. No details on the current environmental status of these tanks
are readily available, which represents an REC.
McNichols Scrap Iron (6550 East McNichols Road): This is the west adjoining site
across Girardin Street and is listed in the SWRCY (or recycling center) and WDS
database. According to the EDR report, the site is identified as a collection and
processing site for scrap metals. No environmental incidents or concern were identified
to be associated with this site. As such, this site is not considered to be an off-site
source of potential environmental concern.
Repair Industries of Michigan (6501 East McNichols Road): This address refers to a
parcel approximately 300 feet northwest of the property, but the listed business also
occupies the north adjoining property at 6535 East McNichols Road. Repair Industries
of Michigan (RIM) is listed in the LUST, UST, AST, RCRA-CESQG databases.
According to the EDR report, no RCRA compliance violations have been issued against
the property. Based the layout of the site, observations from aerial photographs and site
reconnaissance, and the distance across McNichols Road, it is unlikely that the USTs,
AST or other significant areas of chemical use/storage are located within 100 feet of the
subject property. Thus, this site is not considered to be an off-site source of potential
environmental concern.
-11-
4.3.1 Local Governmental Agency Records
A visit was made to the City of Detroit offices to review readily available records for the
property.
Assessing Department
City of Detroit Assessor’s Office identifies the property as Parcel 15003333-4. The property
is recorded as 0.76 acres in size, and contains a single-story, 23,260 square foot industrial
building.
Building Department
City of Detroit Buildings, Safety Engineering & Environmental Department – Mechanical
and Heating Division records did not contain any information for the property.
Fire Department
NTH submitted a request to review Detroit Fire Department (DFD) records. As of the date of
this report, no response has been received from DFD.
Maps covering the property, dated 1933, 1940, 1949, 1951, 1957, 1961, 1977, 1984, 1987,
1990, 1993, 1998, and 2002, were provided by EDR. A review of these maps is summarized
below and its copies are included in Appendix E.
-12-
Year Prominent Features
1933 Vacant land.
1940 Similar features as depicted on the previous Sanborn map.
1949 The northern portion of the property is occupied by a single-story steel warehouse, identified as
6560 East McNichols Road. The southern portion of the property is occupied by a single-story
machine shop, identified as 6556 East McNichols Road.
1951 Similar features as depicted on the previous Sanborn map.
1957 The two existing buildings have been connected by an addition, and an addition has been
constructed on the west side of the machine shop building.
1961 The property is identified as a nut and bolt factory. An addition has been constructed on the
south side of the building. The addition consists of an extension to the machine shop and a
canopy-covered area.
1977 Similar features as depicted on the previous Sanborn map.
1984 Similar features as depicted on the previous Sanborn map.
1987 Similar features as depicted on the previous Sanborn map.
1990 Similar features as depicted on the previous Sanborn map.
1993 Similar features as depicted on the previous Sanborn map.
1998 Similar features as depicted on the previous Sanborn map.
2002 Similar features as depicted on the previous Sanborn map.
-13-
Additional aerial photographs dated 1999, 2002, 2005, 2006, 2007, 2009, 2010, 2011, 2012,
2015, 2016, and 2017 were reviewed on the Google webpage. These aerial photographs were
reviewed to determine past uses and changes in surface features that might indicate possible
environmental concerns.
The scales on the aerial photographs range from 1″ = 100′ to 1″ = 500′. Thus, certain
photographs, particularly those with larger scales, did not clearly identify all the surface
features at the property.
-14-
4.3.5 USGS Topographic Maps
Historical USGS “Detroit, Michigan” topographic maps dated 1905, 1918, 1924, 1934, 1940,
1952, 1968, 1973, 1983, and 2014 were provided by EDR and reviewed to determine past
uses of or changes in the surface features at the property.
Prior to 1968, the property was vacant land with no surface features depicted. The 1968,
1973, and 1983 topographic maps depict the current industrial building. The 2014 map
depicts the property in the general urban setting of the City of Detroit and does not depict any
specific features such as buildings or other improvements.
-15-
East and South
By 1937, the east and south adjoining sites were developed with an industrial building and a
large storage yard. The 1949 Sanborn map identified the building as the N. Silverstine
Company Industrial Supply Warehouse, which sold military surplus goods and remained in
operation until at least 1987. The building was demolished in the 1990s, and the site has been
used as an automotive salvage yard since at least 2005.
A site reconnaissance of the property was conducted to observe for surface features indicative
of RECs.
-16-
5.3 Current Uses of the Property
The property is currently vacant.
During the survey, the property was observed for evidence of RECs such as stressed
vegetation, stained surface soil, and improper waste disposal practices. The visual survey was
conducted by walking the interior of the building, the perimeter of the property, and randomly
traversing the property, where accessible.
The following limiting conditions were encountered which obscured observations of surface
features during the visual survey:
-17-
Electricity to the building was disconnected, so the interior survey was conducted using a
flashlight.
The above limiting conditions impeded visual observations, but are not expected to affect
NTH’s ability to render an opinion regarding the property and are also not expected to change
the conclusion of this report.
A fenced area beneath a canopy is present at the southwest corner of the building, open to
Girardin Street (Photograph 5). Three UST fill ports were observed on the south side of the
enclosure, and staining was noted on a nearby exterior wall (Photograph 6). The building
extends to the lot line on the east and south sides (Photograph 7).
-18-
The following RECs were noted on the exterior of the property during the site reconnaissance:
The northern portion of the building was slab-on-grade construction and consisted of former
offices (Photograph 10) and a high-bay shop (Photograph 11). The concrete floor was in
good condition with no significant staining. A large bay door on the northwest corner of the
shop was bricked up from the outside (Photograph 12). Two former subgrade pits filled in
with concrete were observed on the south side of the shop; based on their unique shape, they
appear to be associated with former scales (Photographs 13 and 14).
The southern portion of the building is also slab-on-grade construction with former offices
and a former machine shop (Photograph 15). A scale was present in the shop south of the
offices (Photograph 16), and a tarp was hung from the ceiling on the south end of the building
(Photograph 17). Areas of patched concrete with embedded metal, indicative of former
machine foundations and/or pits, were observed in the central portion of the building
(Photograph 18). Concrete floors were in poor condition with cracks, pits, and extensive
staining. In addition, the lower five feet of the east wall on the north side of the shop and the
west wall on the south side of the shop were significantly stained, apparently from machining
operations (Photograph 19). Metal piping, cut off at a height of approximately two feet, was
observed in the southwest corner of the building (Photograph 20). The piping was likely
associated with the nearby USTs outside. The wall and floor in this area was also
significantly stained.
-19-
The following RECs were noted on the interior of the building during the site reconnaissance:
Presence of former machine pits, and oil stained floors and walls.
Two pole-mounted electrical transformers were observed at the approximate location depicted
on the Site Plan. No labeling was observed to indicate the PCB content or ownership of the
unit; however, the transformers appear to be in good condition with no visual evidence of
leakage.
-20-
6.0 OWNER PROVIDED INFORMATION
NTH’s Phase I ESA Owner Questionnaire was completed by Mr. Kwiecinski. A copy of this
questionnaire is included in Appendix F. Mr. Kwiecinski indicated that he had purchased the
property in late November 2017. Mr. Kwiecinski is unaware of the past uses of the property
and any environmental concerns associated with the property.
7.0 EVALUATIONS
Three 1,000-gallon USTs reportedly containing cutting oil, lubrication oil, and waste oil are
present under the exterior canopy at southwest corner of the building. Associated piping and
oily staining were observed along the adjacent wall inside the building. The USTs were
reportedly installed in 1957 and remained in active use until the early 1990s. Each of the
USTs contain approximately two feet of an oily substance. No details on the current
environmental status of these tanks are readily available, which represents an REC.
-21-
Based on reviewed historical information the east and south adjoining sites have been used
for automotive salvage operations since at least 2005. No information is readily available
regarding the occupants’ hazardous material handling/storage and waste disposal practices.
Thus, these sites are considered as offsite sources of potential environmental concerns and
RECs for the property.
No controlled or historical RECs, or significant data gaps resulting in RECS were identified at
the property during the current study.
Based on the results of the Phase I ESA, NTH conducted a Phase II ESA at the property on
January 4, 2018 to evaluate the above RECs. The results of the Phase II ESA are presented in
a separate report.
7.2 Conclusions
We have performed a Phase I Environmental Site Assessment in conformance with the scope
and limitations of ASTM Practice E1527 for 6556 E. McNichols property in Detroit, Wayne
County, Michigan. Any exceptions to, or deletions from, this practice are described in this
report. This assessment has revealed no evidence of recognized environmental conditions in
connection with the property, except for the following:
Past use of the property for industrial purposes with evidence of former subgrade
machine pits, and oil stained floors and walls in the southern portion of the building. No
information is readily available regarding the past occupants’ hazardous material
management and waste disposal practices.
Three 1,000-gallon underground storage tanks (USTs) reported to contain cutting oil,
lubrication oil and waste oil are present under the canopy area near the southwest corner
of the building.
-22-
The east and south adjoining sites are used for automotive salvage operations. No
information is readily available regarding the occupants’ hazardous material management
and waste disposal practices.
No non-ASTM scope items were requested by the client during the current study.
9.0 REFERENCES
1) American Society for Testing and Materials (ASTM) E1527-13 - Standard Practice for
Environmental Site Assessments: Phase I Environmental Site Assessment Process.
2) Environmental Data Resources, Inc. (EDR) – Radius Map with GeoCheck; Topographic
Maps; Sanborn Maps; Aerial Photographs; and City Directories.
3) United State Department of Agricultural (USDA) Soil Survey of Wayne County Area;
Western Michigan University - Hydrogeologic Atlas of Michigan.
4) City of Detroit municipal offices (Assessor’s Office; Buildings, Safety Engineering &
Environmental Department’ and Fire Department).
-23-
APPENDIX
Site Location Map, Figure 1;
A
Site Plan, Figure 2;
GIRARDIN STREET
LEGEND
2
DESIGNED BY: PLOT DATE:
NTH Consultants, Ltd.
DRAWN BY: DRAWING SCALE: Infrastructure Engineering
and Environmental Services 6556 E. McNICHOLS ROAD
CHECKED BY: INCEPTION DATE:
DETROIT, MICHIGAN
Parcel Number: 15003333-4 Jurisdiction: CITY OF DETROIT County: WAYNE Printed on 12/18/2017
Grantor Grantee Sale Sale Inst. Terms of Sale Liber Verified Prcnt.
Price Date Type & Page By Trans.
50,000 07/01/1996 PTA NO CONSIDERATION 99984:00060 PTA 0.0
Property Address Class: 301-INDUSTRIAL Zoning: M4 Building Permit(s) Date Number Status
6556 E MCNICHOLS School: DETROIT PUBLIC SCHOOLS
P.R.E. 0%
Owner's Name/Address WARD#: 15
CITY OF DETROIT 2018 Est TCV 0 TCV/TFA: 0.00
65 CADILLAC SQUARE STE 1100
DETROIT MI 48226 X Improved Vacant Land Value Estimates for Land Table INDG.INDG-INDUSTRIAL GENERAL GROUP
Public * Factors *
Improvements Description Frontage Depth Front Depth Rate %Adj. Reason Value
Dirt Road SQ FT RATE BY SIZE 33,279.840 Sq Ft 1.00 100 33,280
Tax Description 0.76 Total Acres Total Est. Land Value = 33,280
Gravel Road
S E MC NICHOLS RD W 90 FT E 300 FT OF N Paved Road
370 FT LYG S & ADJ MC NICHOLS RD W OF Storm Sewer
CAVELLS SUB OF N E 1/4 OF N E 1/4 OF N W Sidewalk
1/4 OF SEC 16 T 1 S R 12 E 15/218 33 300 Water
SQ FT Sewer
Comments/Influences Electric
Gas
Curb
Street Lights
Standard Utilities
Underground Utils.
Topography of
Site
Level
Rolling
Low
High
Landscaped
Swamp
Wooded
Pond
Waterfront
Ravine
Wetland
Flood Plain Year Land Building Assessed Board of Tribunal/ Taxable
Value Value Value Review Other Value
Who When What 2018 EXEMPT EXEMPT EXEMPT EXEMPT
2017 EXEMPT EXEMPT EXEMPT EXEMPT
The Equalizer. Copyright (c) 1999 - 2009.
2016 0 0 0 0
Licensed To: City of Detroit, County of
Wayne, Michigan 2015 0 0 0 0
Photograph 1: Northwest corner of the property, viewed from McNichols Road
Photograph 2: West wall of the northern portion of the subject building, looking northeast
PROPERTY PHOTOGRAPHS
NTH PROJECT NO. 62‐170450‐00
6556 E. McNichols Property, Detroit, Michigan
Photograph 3: Truck well, roll‐off refuse container, and burn pit in the central portion of the site
Photograph 4: Truck well on the northwest corner of the southern portion of the building
PROPERTY PHOTOGRAPHS
NTH PROJECT NO. 62‐170450‐00
6556 E. McNichols Property, Detroit, Michigan
Photograph 5: Fenced enclosure beneath the canopy at the southwest corner of the building
Photograph 6: Three UST fill ports in the enclosure at the southwest corner of the building
PROPERTY PHOTOGRAPHS
NTH PROJECT NO. 62‐170450‐00
6556 E. McNichols Property, Detroit, Michigan
Photograph 7: Obstructed view of the south wall of the building, looking northeast
Photograph 8: Miscellaneous storage in the central and northern portions of the building
PROPERTY PHOTOGRAPHS
NTH PROJECT NO. 62‐170450‐00
6556 E. McNichols Property, Detroit, Michigan
Photograph 9: Containers of plant food in the offices in the southern portion of the building
Photograph 10: Offices in the northern portion of the building
PROPERTY PHOTOGRAPHS
NTH PROJECT NO. 62‐170450‐00
6556 E. McNichols Property, Detroit, Michigan
Photograph 11: High‐bay shop in the northern portion of the building, looking north
Photograph 12: Blocked bay door at the northwest corner of the north portion of the building
PROPERTY PHOTOGRAPHS
NTH PROJECT NO. 62‐170450‐00
6556 E. McNichols Property, Detroit, Michigan
Photograph 13: Location of filled‐in pits on the south side of the northern portion of the building
Photograph 14: Close‐up of filled‐in pits (likely former scales)
PROPERTY PHOTOGRAPHS
NTH PROJECT NO. 62‐170450‐00
6556 E. McNichols Property, Detroit, Michigan
Photograph 15: Looking south into the southern portion of the building (former machine shop)
Photograph 16: Scale in the northwest part of the southern portion of the building
PROPERTY PHOTOGRAPHS
NTH PROJECT NO. 62‐170450‐00
6556 E. McNichols Property, Detroit, Michigan
Photograph 17: Tarp at the south end of the southern portion of the building
Photograph 18: Typical staining and machine pits/foundations in the former machine shop
PROPERTY PHOTOGRAPHS
NTH PROJECT NO. 62‐170450‐00
6556 E. McNichols Property, Detroit, Michigan
Photograph 19: Typical wall staining in the former machine shop
Photograph 20: Piping and wall staining at the southwest corner of the building
APPENDIX
User Questionnaire
C
APPENDIX
EDR Radius Map Report
D
6556 E. Mcnichols Property
6556 E. Mcnichols Road
Hamtramck, MI 48212
FORM-LBC-JUS
TABLE OF CONTENTS
SECTION PAGE
GEOCHECK ADDENDUM
TC5128345.2s
EXECUTIVE SUMMARY
A search of available environmental records was conducted by Environmental Data Resources, Inc (EDR).
The report was designed to assist parties seeking to meet the search requirements of EPA’s Standards
and Practices for All Appropriate Inquiries (40 CFR Part 312), the ASTM Standard Practice for
Environmental Site Assessments (E 1527-13) or custom requirements developed for the evaluation of
environmental risk associated with a parcel of real estate.
ADDRESS
COORDINATES
5128345.2s Page 2
MAPPED SITES SUMMARY
5128345.2s Page 3
MAPPED SITES SUMMARY
5128345.2s Page 4
EXECUTIVE SUMMARY
ECHO
Elevations have been determined from the USGS Digital Elevation Model and should be evaluated on
a relative (not an absolute) basis. Relative elevation information between sites of close proximity
should be field verified. Sites with an elevation equal to or higher than the target property have been
differentiated below from sites with an elevation lower than the target property.
Page numbers and map identification numbers refer to the EDR Radius Map report where detailed
data on individual sites can be reviewed.
A review of the SEMS list, as provided by EDR, and dated 07/11/2017 has revealed that there are 4
Equal/Higher Elevation
____________________ Address
________ Direction / Distance
___________________ Map
_____ID Page
_____
GENERAL DIE CASTING 13700 MOUNT ELLIOTT WSW 1/8 - 1/4 (0.173 mi.) H24 39
CHEMICAL TECHNOLOGY 13271 MT. ELLIOTT SW 1/4 - 1/2 (0.306 mi.) 68 130
AABCO WASTE OIL INC 17400 SAINT LOUIS ST NW 1/4 - 1/2 (0.321 mi.) Q72 133
Lower Elevation
____________________ Address
________ Direction / Distance
___________________ Map ID
_____ Page
_____
DETROIT LEAD 13535 HELEN AVE. SE 1/8 - 1/4 (0.204 mi.) J30 62
A review of the SEMS-ARCHIVE list, as provided by EDR, and dated 07/11/2017 has revealed that there
are 3 SEMS-ARCHIVE sites within approximately 0.5 miles of the target property.
Equal/Higher Elevation
____________________ Address
________ Direction / Distance
___________________ Map
_____ID Page
_____
CADILLAC OIL COMPANY 13650 HELEN ESE 1/4 - 1/2 (0.253 mi.) M58 113
PLATING EQUIPMENT US 17210 GABLE WNW 1/4 - 1/2 (0.383 mi.) 75 150
PELOQUIN ENTERPRISES 5944 DAVISON WNW 1/4 - 1/2 (0.478 mi.) 84 161
A review of the RCRA-CESQG list, as provided by EDR, and dated 09/13/2017 has revealed that there are
6 RCRA-CESQG sites within approximately 0.25 miles of the target property.
Equal/Higher Elevation
____________________ Address
________ Direction / Distance
___________________ Map
_____ID Page
_____
TWH METALS CORPORATI 6450 E MCNICHOLS RD WNW 0 - 1/8 (0.080 mi.) C8 13
REPAIR INDUSTRIES OF 6501 E MCNICHOLS RD NNW 1/8 - 1/4 (0.126 mi.) F17 21
CADILLAC ENAMELING T 17425 SHERWOOD N 1/8 - 1/4 (0.232 mi.) 49 81
KNIGHT ENTERPRISES I 6236 E 6 MILE RD W 1/8 - 1/4 (0.237 mi.) L52 106
Lower Elevation
____________________ Address
________ Direction / Distance
___________________ Map ID
_____ Page
_____
FAIRMONT SIGN CO 6771 E MCNICHOLS RD ENE 0 - 1/8 (0.102 mi.) E15 19
Lower Elevation
____________________ Address
________ Direction / Distance
___________________ Map ID
_____ Page
_____
METAL AND WELDING IN 13595 HELEN ST SE 1/8 - 1/4 (0.186 mi.) G27 50
State and tribal landfill and/or solid waste disposal site lists
SWF/LF: The Solid Waste Facilities/Landfill Sites records typically contain an inventory of solid
waste disposal facilities or landfills in a particular state. The data come from the Department of
Environmental Quality’s Michigan Solid Waste Facilities.
A review of the SWF/LF list, as provided by EDR, and dated 06/28/2017 has revealed that there is 1
SWF/LF site within approximately 0.5 miles of the target property.
Equal/Higher Elevation
____________________ Address
________ Direction / Distance
___________________ Map
_____ID Page
_____
J FONS CO 6451 E MCNICHOLS RD WNW 0 - 1/8 (0.092 mi.) C10 15
Facility Id: 437185
A review of the LUST list, as provided by EDR, and dated 06/30/2017 has revealed that there are 22
LUST sites within approximately 0.5 miles of the target property.
Equal/Higher Elevation
____________________ Address
________ Direction / Distance
___________________ Map
_____ID Page
_____
WAREHOUSE BUILDING 13691 GIRARDIN SSW 0 - 1/8 (0.093 mi.) D13 17
Release Status: Open
Substance Release: Gasoline
Facility Id: 00041776
REPAIR IND 6501 E MCNICHOLS RD NNW 1/8 - 1/4 (0.126 mi.) F18 32
Release Status: Closed
Substance Release: Gasoline
Facility Id: 00035702
FEDERAL PIPE & SUPPL 6464 E MCNICHOLS RD W 1/8 - 1/4 (0.127 mi.) 19 34
Release Status: Closed
Substance Release: Gasoline
Facility Id: 00007392
EAGLE FLY PETRO 6236 E MCNICHOLS RD W 1/8 - 1/4 (0.214 mi.) L43 73
Release Status: Closed
Substance Release: Gasoline,Gasoline,Gasoline,Diesel,Gasoline,Diesel,Kerosene
Substance Release: Gasoline,Unknown
Substance Release: Diesel
Facility Id: 00018527
ABDO M ALI 7100 E MCNICHOLS E 1/8 - 1/4 (0.216 mi.) I44 77
Release Status: Open
Substance Release: Gasoline
Lower Elevation
____________________ Address
________ Direction / Distance
___________________ Map ID
_____ Page
_____
BAAYOUN SERVICE INC 6851 E MCNICHOLS ENE 1/8 - 1/4 (0.181 mi.) I25 46
A review of the UST list, as provided by EDR, has revealed that there are 10 UST sites within
approximately 0.25 miles of the target property.
Equal/Higher Elevation
____________________ Address
________ Direction / Distance
___________________ Map
_____ID Page
_____
J. FONS CO 6451 E MCNICHOLS RD WNW 0 - 1/8 (0.092 mi.) C9 15
Database: UST, Date of Government Version: 10/21/2016
Tank Status: Removed from Ground
Facility Type: CLOSED
Facility Id: 00003138
WAREHOUSE BUILDING 13691 GIRARDIN STREE SSW 0 - 1/8 (0.093 mi.) D14 18
Database: UST 2, Date of Government Version: 10/18/2016
Facility ID: 00041776
REPAIR IND 6501 E MCNICHOLS RD NNW 1/8 - 1/4 (0.126 mi.) F18 32
Database: UST, Date of Government Version: 10/21/2016
Tank Status: Removed from Ground
Facility Type: CLOSED
Facility Id: 00035702
FEDERAL PIPE & SUPPL 6464 E MCNICHOLS RD W 1/8 - 1/4 (0.127 mi.) 19 34
Database: UST, Date of Government Version: 10/21/2016
Tank Status: Removed from Ground
Facility Type: CLOSED
Facility Id: 00007392
CENTRAL STEEL & WIRE 13400 MT ELLIOTT AVE SW 1/8 - 1/4 (0.212 mi.) K41 72
Database: UST, Date of Government Version: 10/21/2016
Lower Elevation
____________________ Address
________ Direction / Distance
___________________ Map ID
_____ Page
_____
BAAYOUN SERVICE INC 6851 E MCNICHOLS ENE 1/8 - 1/4 (0.181 mi.) I25 46
Database: UST, Date of Government Version: 10/21/2016
Tank Status: Removed from Ground
Facility Type: CLOSED
Facility Id: 00006204
ARROW UNIFORM RENTAL 13550 HELEN ST SE 1/8 - 1/4 (0.205 mi.) J33 68
Database: UST 2, Date of Government Version: 10/18/2016
Facility ID: 00017104
AST: The Aboveground Storage Tank database contains registered ASTs. The data come from the
Department of Natural Resources’ Michigan AST database.
A review of the AST list, as provided by EDR, and dated 08/14/2017 has revealed that there is 1 AST
site within approximately 0.25 miles of the target property.
Equal/Higher Elevation
____________________ Address
________ Direction / Distance
___________________ Map
_____ID Page
_____
REPAIR INDUSTRIES OF 6501 E MCNICHOLS RD NNW 1/8 - 1/4 (0.126 mi.) F17 21
Facility Id: 92082564
Tank Status: Currently In Use
A review of the AUL list, as provided by EDR, and dated 08/25/2017 has revealed that there is 1 AUL
site within approximately 0.5 miles of the target property.
Lower Elevation
____________________ Address
________ Direction / Distance
___________________ Map
_____ID Page
_____
BAAYOUN SERVICE 6851 EAST MCNICHOLS ENE 1/8 - 1/4 (0.181 mi.) I26 49
A review of the BROWNFIELDS list, as provided by EDR, has revealed that there are 3 BROWNFIELDS sites
within approximately 0.5 miles of the target property.
Equal/Higher Elevation
____________________ Address
________ Direction / Distance
___________________ Map
_____ID Page
_____
ERINE GULF 6717 E DAVISON ST N 1/4 - 1/2 (0.309 mi.) 69 130
Database: BROWNFIELDS, Date of Government Version: 01/15/2016
Facility Id: 00038115
Ernie Id Number: 82001950
MI DEPT/NATURAL RESO 7440 EDGETON NE 1/4 - 1/2 (0.431 mi.) 81 159
Database: BROWNFIELDS, Date of Government Version: 01/15/2016
Ernie Id Number: 82001630
Lower Elevation
____________________ Address
________ Direction / Distance
___________________ Map ID
_____ Page
_____
MI DEPT/NATURAL RESO 13535 HELEN AVE SE 1/8 - 1/4 (0.204 mi.) J31 65
Database: BROWNFIELDS 2, Date of Government Version: 04/09/2007
Database: BROWNFIELDS, Date of Government Version: 01/15/2016
Ernie Id Number: 82001541
Site Id Number: 1000090
A review of the US BROWNFIELDS list, as provided by EDR, and dated 06/19/2017 has revealed that there
is 1 US BROWNFIELDS site within approximately 0.5 miles of the target property.
Equal/Higher Elevation
____________________ Address
________ Direction / Distance
___________________ Map
_____ID Page
_____
HANTZ FARMS 17245 THROUGH 17289 NW 1/4 - 1/2 (0.267 mi.) P60 121
A review of the SWRCY list, as provided by EDR, and dated 09/25/2017 has revealed that there are 2
Equal/Higher Elevation
____________________ Address
________ Direction / Distance
___________________ Map
_____ID Page
_____
MCNICHOLS SCRAP IRON 6500 E. MCNICHOLS RD NW 0 - 1/8 (0.030 mi.) A5 10
SIKORA METALS, INC. 12850 MT. ELLIOTT ST SSW 1/4 - 1/2 (0.407 mi.) 77 156
A review of the PART 201 list, as provided by EDR, and dated 10/01/2013 has revealed that there are 6
PART 201 sites within approximately 1 mile of the target property.
Equal/Higher Elevation
____________________ Address
________ Direction / Distance
___________________ Map
_____ID Page
_____
GENERAL DIE CASTING 13700 MT. ELLIOT WSW 1/8 - 1/4 (0.173 mi.) H23 39
Facility Status: Remedial Action in Progress (may incl. use restrictions, O&M and/or monitoring)
Facility ID: 82000158
PLATING EQUIPMENT US 17210 GABLE WNW 1/4 - 1/2 (0.383 mi.) 75 150
Facility Status: Interim Response in progress
Facility ID: 82000045
MI DEPT/NATURAL RESO 7440 EDGETON NE 1/4 - 1/2 (0.431 mi.) 81 159
Facility Status: Interim Response conducted - No further activities anticipated
Facility ID: 82001630
PELOQUIN ENTERPRISES 5944 DAVISON WNW 1/4 - 1/2 (0.478 mi.) 84 161
Facility Status: Interim Response in progress
Facility ID: 82000041
U S INDUSTRIES 18695 SHERWOOD N 1/2 - 1 (0.864 mi.) 88 165
Facility Status: Interim Response conducted - No further activities anticipated
Facility ID: 82000164
Lower Elevation
____________________ Address
________ Direction / Distance
___________________ Map ID
_____ Page
_____
MI DEPT/NATURAL RESO 13535 HELEN AVE SE 1/8 - 1/4 (0.204 mi.) J31 65
Facility Status: Interim Response conducted - No further activities anticipated
Facility ID: 82001541
INVENTORY: The Inventory of Facilities has three data sources: Facilities under Part 201,
Environmental Remediation, of the Natural Resources and Environmental Protection Act, 1994 PA 451, as amended
(NREPA) identified through state funded or private party response activities (Projects); Facilities under Part
213, Leaking Underground Storage Tanks of the NREPA; and Facilities identified through submittals of Baseline
Environmental Assessments (BEA) submitted pursuant to Part 201 or Part 213 of the NREPA. The Part 201
Projects Inventory does not include all of the facilities that are subject to regulation under Part 201
because owners are not required to inform the Department of Environmental Quality (DEQ) about the facilities
and can pursue cleanup independently. Facilities that are not known to DEQ are not on the Inventory, nor are
locations with releases that resulted in low environmental impact. Part 213 facilities listed here may have
more than one release; a list of releases for which corrective actions have been completed and list of
releases for which corrective action has not been completed is located on the Leaking Underground Storage
Tanks Site Search webpage. The DEQ may or may not have reviewed and concurred with the conclusion that the
corrective actions described in a closure report meets criteria. A BEA is a document that new or prospective
property owners/operations disclose to the DEQ identifying the property as a facility pursuant to Part 201 and
Part 213. The Inventory of BEA Facilities overlaps in part with the Part 201 Projects facilities and Part 213
facilities. There may be more than one BEA for each facility.
A review of the INVENTORY list, as provided by EDR, and dated 07/25/2017 has revealed that there are
36 INVENTORY sites within approximately 0.5 miles of the target property.
Equal/Higher Elevation
____________________ Address
________ Direction / Distance
___________________ Map
_____ID Page
_____
WAREHOUSE BUILDING 13691 GIRARDIN SSW 0 - 1/8 (0.093 mi.) D12 17
WAREHOUSE BUILDING 13691 GIRARDIN SSW 0 - 1/8 (0.093 mi.) D13 17
Facility ID: 41776
GENERAL DIE CASTING 13700 MT. ELLIOT WSW 1/8 - 1/4 (0.173 mi.) H23 39
Facility ID: 82000158
13400 MOUNT ELLIOT 13400 MOUNT ELLIOT SW 1/8 - 1/4 (0.212 mi.) K42 73
Facility ID: 82003038
EAGLE FLY PETRO 6236 E MCNICHOLS RD W 1/8 - 1/4 (0.214 mi.) L43 73
Facility ID: 18527
ABDO M ALI 7100 E MCNICHOLS E 1/8 - 1/4 (0.216 mi.) I44 77
Facility ID: 38539
CADILLAC OIL CO. 13650 HELEN STREET ESE 1/8 - 1/4 (0.226 mi.) M46 79
13445 GIRARDIN 13445 GIRARDIN S 1/8 - 1/4 (0.230 mi.) N47 79
Facility ID: 82003039
GRAND PAPA’S SNACKS, 6500 EAST DAVISON RO N 1/8 - 1/4 (0.233 mi.) 50 106
NOVO LLC 17125 MT. ELLIOTT WNW 1/8 - 1/4 (0.240 mi.) O53 108
Facility ID: 82002839
NOVO LLC 17125 MT. ELLIOTT WNW 1/8 - 1/4 (0.247 mi.) O56 112
Facility ID: 82002839
MIDWEST TRANSPORTATI 13391 GIRARDIN ST S 1/4 - 1/2 (0.250 mi.) N57 112
Facility ID: 35838
HANTZ FARMS, LLC 17289 MT. ELLIOTT ST NW 1/4 - 1/2 (0.267 mi.) P61 124
Facility ID: 82002826
HANTZ FARMS, LLC 17289 MT. ELLIOTT ST NW 1/4 - 1/2 (0.267 mi.) P62 124
Facility ID: 82002826
INTEGRATED MANUFACTU 6555 EAST DAVISON N 1/4 - 1/2 (0.297 mi.) 65 128
HARE LEASING INC 7400 E MCNICHOLS RD E 1/4 - 1/2 (0.356 mi.) 74 148
Facility ID: 3719
PLATING EQUIPMENT US 17210 GABLE WNW 1/4 - 1/2 (0.383 mi.) 75 150
Facility ID: 82000045
NORTOWN COMMUNITY DE 17676 MT. ELLIOTT NNW 1/4 - 1/2 (0.407 mi.) R78 157
Facility ID: 50005754
NORTOWN COMMUNITY DE 17676 MOUNT ELLIOTT NNW 1/4 - 1/2 (0.410 mi.) R79 158
Facility ID: 82002693
CITY OF DETROIT VACA 17665, 17655 MT. ELL NNW 1/4 - 1/2 (0.420 mi.) R80 159
Lower Elevation
____________________ Address
________ Direction / Distance
___________________ Map ID
_____ Page
_____
FORMER INDUSTRIAL MA 13651 HELEN STREET SE 1/8 - 1/4 (0.168 mi.) G21 37
BAAYOUN SERVICE INC 6851 E MCNICHOLS ENE 1/8 - 1/4 (0.181 mi.) I25 46
Facility ID: 6204
MI DEPT/NATURAL RESO 13535 HELEN AVE SE 1/8 - 1/4 (0.204 mi.) J31 65
Facility ID: 82001541
METRO INTERNATIONAL 13550 HELEN SE 1/8 - 1/4 (0.208 mi.) J35 70
TOWER PROPERTY 13550 HELEN STREET SE 1/8 - 1/4 (0.211 mi.) J36 70
Facility ID: 82001766
PARAMOUNT FABRICATIN 13535 HELEN AVENUE ( SSE 1/8 - 1/4 (0.211 mi.) J37 71
Facility ID: 82001541
METAL AND WELDING IN 13550 HELEN STREET SSE 1/8 - 1/4 (0.211 mi.) J38 71
Facility ID: 82001541
IMPERIAL PROPERTIES 13485 AND 13507 HELE SSE 1/8 - 1/4 (0.211 mi.) J39 71
Facility ID: 82001541
WALKER ENTERPRISES C 13550 HELEN STREET SSE 1/8 - 1/4 (0.211 mi.) J40 72
Facility ID: 82001541
EASTOWN DISTRIBUTORS 13542 HELEN ST SE 1/4 - 1/2 (0.280 mi.) 63 125
Facility ID: 15248
A review of the RCRA NonGen / NLR list, as provided by EDR, and dated 09/13/2017 has revealed that
there are 9 RCRA NonGen / NLR sites within approximately 0.25 miles of the target property.
Equal/Higher Elevation
____________________ Address
________ Direction / Distance
___________________ Map
_____ID Page
_____
SKYLINE PAINTING INC 17301 SHERWOOD ST N 1/8 - 1/4 (0.127 mi.) 20 35
US ENVIRONMENTAL PRO 13700 MOUNT ELLIOTT WSW 1/8 - 1/4 (0.173 mi.) H22 38
GENERAL DIE CASTING 13700 MOUNT ELLIOTT WSW 1/8 - 1/4 (0.173 mi.) H24 39
Equal/Higher Elevation
____________________ Address
________ Direction / Distance
___________________ Map ID
_____ Page
_____
CITY OF DETROIT 13445 GIRARDIN ST S 1/8 - 1/4 (0.230 mi.) N48 80
AUREUS HOLDINGS LTD 17245 MOUNT ELLIOTT NW 1/8 - 1/4 (0.246 mi.) P55 110
Lower Elevation
____________________ Address
________ Direction / Distance
___________________ Map ID
_____ Page
_____
SERVICE STEEL 13700 SHERWOOD SE 0 - 1/8 (0.077 mi.) B7 11
GREAT LAKES VACUUM S 13561 HELEN ST SE 1/8 - 1/4 (0.199 mi.) J29 60
USEPA SITE 13535 HELEN AVE SE 1/8 - 1/4 (0.204 mi.) J32 65
MI DEPT/NATURAL RESO 13511 HELEN ST SSE 1/8 - 1/4 (0.224 mi.) J45 78
CONSENT: Major Legal settlements that establish responsibility and standards for cleanup at NPL
(superfund) sites. Released periodically by U.S. District Courts after settlement by parties to litigation
matters.
A review of the CONSENT list, as provided by EDR, and dated 06/30/2017 has revealed that there is 1
CONSENT site within approximately 1 mile of the target property.
Equal/Higher Elevation
____________________ Address
________ Direction / Distance
___________________ Map
_____ID Page
_____
AABCO WASTE OIL INC 17400 SAINT LOUIS ST NW 1/4 - 1/2 (0.321 mi.) Q72 133
BEA: A BEA is a document that new or prospective property owners/operations disclose to the DEQ
identifying the property as a facility pursuant to Part 201 and Part 213. The Inventory of BEA Facilities
overlaps in part with the Part 201 Projects facilities and Part 213 facilities. There may be more than one BEA
for each facility.
A review of the BEA list, as provided by EDR, and dated 08/21/2013 has revealed that there are 11 BEA
sites within approximately 0.5 miles of the target property.
Equal/Higher Elevation
____________________ Address
________ Direction / Distance
___________________ Map
_____ID Page
_____
Not reported 13750 SHERWOOD ESE 0 - 1/8 (0.060 mi.) B6 11
WAREHOUSE BUILDING 13691 GIRARDIN SSW 0 - 1/8 (0.093 mi.) D13 17
GRAND PAPA’S SNACKS, 6500 EAST DAVISON RO N 1/8 - 1/4 (0.233 mi.) 50 106
NOVO LLC 17125 MT. ELLIOTT WNW 1/8 - 1/4 (0.240 mi.) O53 108
HANTZ FARMS, LLC 17289 MT. ELLIOTT ST NW 1/4 - 1/2 (0.267 mi.) P61 124
FACILITY 17437/17443/17450 FI NNW 1/4 - 1/2 (0.287 mi.) 64 127
Not reported 13200 MT. ELLIOTT AV SSW 1/4 - 1/2 (0.299 mi.) 66 128
NORTOWN COMMUNITY DE 17676 MT. ELLIOTT NNW 1/4 - 1/2 (0.407 mi.) R78 157
J FONS CO 6490 NEVADA ST N 1/4 - 1/2 (0.496 mi.) S85 162
Lower Elevation
____________________ Address
________ Direction / Distance
___________________ Map ID
_____ Page
_____
FORMER INDUSTRIAL MA 13651 HELEN STREET SE 1/8 - 1/4 (0.168 mi.) G21 37
TOWER PROPERTY 13550 HELEN STREET SE 1/8 - 1/4 (0.205 mi.) J34 68
A review of the EDR Hist Auto list, as provided by EDR, has revealed that there are 2 EDR Hist Auto
sites within approximately 0.125 miles of the target property.
Equal/Higher Elevation
____________________ Address
________ Direction / Distance
___________________ Map
_____ID Page
_____
NEVADA TERMINAL INC 6451 E MCNICHOLS RD WNW 0 - 1/8 (0.092 mi.) C11 17
Lower Elevation
____________________ Address
________ Direction / Distance
___________________ Map ID
_____ Page
_____
MARCUCCI BROS 6810 E MCNICHOLS RD ENE 0 - 1/8 (0.118 mi.) E16 21
Due to poor or inadequate address information, the following sites were not mapped. Count: 1 records.
Site Name
____________ Database(s)
____________
MCNICHOLS E SOUTH SECTOR RGA PART 201
Search
Distance Target Total
Database (Miles) Property < 1/8 1/8 - 1/4 1/4 - 1/2 1/2 - 1 >1 Plotted
TC5128345.2s Page 4
MAP FINDINGS SUMMARY
Search
Distance Target Total
Database (Miles) Property < 1/8 1/8 - 1/4 1/4 - 1/2 1/2 - 1 >1 Plotted
UST 0.250 1 2 8 NR NR NR 11
AST 0.250 0 1 NR NR NR 1
INDIAN UST 0.250 0 0 NR NR NR 0
State and tribal institutional
control / engineering control registries
AUL 0.500 0 1 0 NR NR 1
State and tribal voluntary cleanup sites
INDIAN VCP 0.500 0 0 0 NR NR 0
State and tribal Brownfields sites
BROWNFIELDS 0.500 0 1 2 NR NR 3
TC5128345.2s Page 5
MAP FINDINGS SUMMARY
Search
Distance Target Total
Database (Miles) Property < 1/8 1/8 - 1/4 1/4 - 1/2 1/2 - 1 >1 Plotted
TC5128345.2s Page 6
MAP FINDINGS SUMMARY
Search
Distance Target Total
Database (Miles) Property < 1/8 1/8 - 1/4 1/4 - 1/2 1/2 - 1 >1 Plotted
- Totals -- 6 14 57 47 1 0 125
NOTES:
TP = Target Property
NR = Not Requested at this Search Distance
Sites may be listed in more than one database
TC5128345.2s Page 7
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Site 1 of 5 in cluster A
Actual:
625 ft.
Site 2 of 5 in cluster A
Actual: UST 2:
625 ft. Owner Name: OWNER ADDRESS UNKNOWN
Owner Address: Not reported
Active Tanks: 3
Site 3 of 5 in cluster A
Actual: WDS:
625 ft. Site Id: MID005378971
WMD Id: 393636
Site Specific Name: WOLVERINE NUT CO
Mailing Address: 6556 E MCNICHOLS RD
Mailing City/State/Zip: 48212
Mailing County: WAYNE
Site 4 of 5 in cluster A
TC5128345.2s Page 8
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Owner/Operator Summary:
Owner/operator name: WOLVERINE NUT COMPANY
Owner/operator address: Not reported
Not reported
Owner/operator country: Not reported
Owner/operator telephone: Not reported
Owner/operator email: Not reported
Owner/operator fax: Not reported
Owner/operator extension: Not reported
Legal status: Private
Owner/Operator Type: Operator
Owner/Op start date: 01/01/1970
Owner/Op end date: Not reported
TC5128345.2s Page 9
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
ECHO:
Envid: 1000430887
Registry ID: 110003581589
DFR URL: http://echo.epa.gov/detailed-facility-report?fid=110003581589
Relative: SWRCY:
Higher SR No: 22
Contact Phone1: 313-365-6100
Actual: EMail: Not reported
626 ft. Website: Not reported
Location Description: 520 miles away
Materials Accepted: Aluminum, Aluminum Cans, Brass, Copper, Copper/Brass/Bronze,
Electronics, Iron, Lead Acid Batteries, Stainless Steel, Steel, Tin
Cans, White Goods, Catalytic Converters, computers, servers,
Appliances
Services: Collector, Exporter, Processor
Collection: Drop off
Service Area: Alcona County, Alger County, Allegan County, Alpena County, Antrim
County, Arenac County, Baraga County, Barry County, Bay County, Benzie
County, Berrien County, Branch County, Calhoun County, Cass County,
Charlevoix County, Cheboygan County, Chippewa County, Clare County,
Clinton County, Crawford County, Delta County, Dickinson County, Eaton
County, Emmet County, Genesee County, Gladwin County, Gogebic County,
Gratiot County, Hillsdale County, Houghton County, Huron County,
Ingham County, Ionia County, Iosco County, Iron County, Isabella
County, Jackson County, Kalamazoo County, Kalkaska County, Kent
County, Keweenaw County, Lake County, Lapeer County, Leelanau County,
Lenawee County, Livingston County, Luce County, Mackinac County,
Macomb County, Manistee County, Marquette County, Mason County,
Mecosta County, Menominee County, Midland County, Missaukee County,
Monroe County, Montcalm County, Montmorency County, Muskegon County,
Newaygo County, Oakland County, Oceana County, Ogemaw County,
Ontonagon County, Osceola County, Oscoda County, Otsego County, Ottawa
County, Roscommon County, Saginaw County, St. Clair County, Sanilac
County, Schoolcraft County, Shiawassee County, Tuscola County, Van
Buren County, Washtenaw County, Wayne County, Wexford County
Notes: Not reported
SWRCY:
SR No 2: 22
Material: Misc. - Carpet
Service: Collector, Processor
Drop Off/Pick Up: Both
Minimum Quantity: None
TC5128345.2s Page 10
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
WDS:
Site Id: Not reported
WMD Id: 466983
Site Specific Name: MCNICHOLS SCRAP IRON AND METAL
Mailing Address: 6500 E MCNICHOLS RD
Mailing City/State/Zip: 48212
Mailing County: WAYNE
B6 BEA S105768214
ESE 13750 SHERWOOD N/A
< 1/8 DETROIT, MI
0.060 mi.
318 ft. Site 1 of 2 in cluster B
Relative: BEA:
Higher Secondary Address: Not reported
BEA Number: 17
Actual: District: Detroit
625 ft. Date Received: 09/21/1999
Submitter Name: LAWRENCE HOLMAN
Petition Determination: Not reported
Petition Disclosure: 1
Category: No Hazardous Substance(s)
Determination 20107A: Pending
Reviewer: temppm
Division Assigned: Environmental Response Division
Owner/Operator Summary:
Owner/operator name: SERVICE STEEL
TC5128345.2s Page 11
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 12
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
ECHO:
Envid: 1016449317
Registry ID: 110056377825
DFR URL: http://echo.epa.gov/detailed-facility-report?fid=110056377825
Relative: RCRA-CESQG:
Higher Date form received by agency: 04/28/2015
Facility name: TWH METALS CORPORATION
Actual: Facility address: 6450 E MCNICHOLS RD
626 ft. DETROIT, MI 48212
EPA ID: MIK114618316
Contact: THOMAS W LUBINSKI
Contact address: Not reported
Not reported
Contact country: Not reported
Contact telephone: 248-990-5531
Contact email: MRLITS@MAC.COM
EPA Region: 05
Classification: Conditionally Exempt Small Quantity Generator
Description: Handler: generates 100 kg or less of hazardous waste per calendar
month, and accumulates 1000 kg or less of hazardous waste at any time;
or generates 1 kg or less of acutely hazardous waste per calendar
month, and accumulates at any time: 1 kg or less of acutely hazardous
waste; or 100 kg or less of any residue or contaminated soil, waste or
other debris resulting from the cleanup of a spill, into or on any
land or water, of acutely hazardous waste; or generates 100 kg or less
of any residue or contaminated soil, waste or other debris resulting
from the cleanup of a spill, into or on any land or water, of acutely
hazardous waste during any calendar month, and accumulates at any
time: 1 kg or less of acutely hazardous waste; or 100 kg or less of
any residue or contaminated soil, waste or other debris resulting from
the cleanup of a spill, into or on any land or water, of acutely
hazardous waste
Owner/Operator Summary:
Owner/operator name: THOMAS W LUBINSKI
Owner/operator address: Not reported
Not reported
Owner/operator country: Not reported
Owner/operator telephone: Not reported
Owner/operator email: Not reported
Owner/operator fax: Not reported
Owner/operator extension: Not reported
Legal status: Private
Owner/Operator Type: Owner
TC5128345.2s Page 13
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
ECHO:
Envid: 1017787054
Registry ID: 110064379943
TC5128345.2s Page 14
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Relative: UST:
Higher Facility ID: 00003138
Facility Type: CLOSED
Actual: Owner Name: J. FONS CO
626 ft. Owner Address: 6451 E MCNICHOLS RD
Owner City,St,Zip: DETROIT, MI 48212-2025
Owner Country: USA
Owner Contact: Not reported
Owner Phone: (313) 893-6656
Contact: GREGORY FONS
Contact Phone: (313) 393-6656
Date of Collection: 01/11/2001
Accuracy: 100
Accuracy Value Unit: FEET
Horizontal Datum: NAD83
Source: STATE OF MICHIGAN
Point Line Area: POINT
Desc Category: Plant Entrance (Freight)
Method of Collection: Address Matching-House Number
Latitude: 42.41939
Longitude: -83.03630
Tank ID: 1
Tank Status: Removed from Ground
Capacity: 10000
Product: Diesel
Install Date: 04/28/1976
Remove Date: 11/02/1999
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Unknown
Piping Type: Not reported
Construction Material: Unknown
Impressed Device: No
Relative: SWF/LF:
Higher Facility ID: 437185
Site ID: MIG000053544
Actual: Specific Name: METROPOLITAN TRANSFER CENTER
626 ft. Contact Name: Not reported
Contact Telephone: Not reported
TC5128345.2s Page 15
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
MI Financial Assurance 2:
Region: 2
Site ID: 437185
PCFT Type: Not reported
PCFT Status: Active
Contact Info: SOUTHEAST MICHIGAN
Account Number: Not reported
Date Signed by Facility: Not reported
Date Executed by DEQ: Not reported
Current Balance: 4000
Current Balance Date: 6/21/2002
Specific Name: METROPOLITAN TRANSFER CENTER
Project Number: Not reported
Original Balance Date: 1/1/1970
Original Balance: 4000
Regulatory Program: Surety Bond
Notes: 1/1/1970 - Just Bond is required.
Region: 2
Site ID: 437185
PCFT Type: Not reported
PCFT Status: Active
Contact Info: SOUTHEAST MICHIGAN
Account Number: Not reported
Date Signed by Facility: Not reported
Date Executed by DEQ: Not reported
Current Balance: 4000
Current Balance Date: 6/21/2002
Specific Name: METROPOLITAN TRANSFER CENTER
Project Number: Not reported
Original Balance Date: 1/1/1970
Original Balance: 4000
Regulatory Program: Surety Bond
Notes: 9/5/2008 - Received bon on most recent revised surety bond form.
Region: 2
Site ID: 437185
PCFT Type: Not reported
PCFT Status: Active
Contact Info: SOUTHEAST MICHIGAN
Account Number: Not reported
Date Signed by Facility: Not reported
Date Executed by DEQ: Not reported
Current Balance: 4000
Current Balance Date: 6/21/2002
Specific Name: METROPOLITAN TRANSFER CENTER
Project Number: Not reported
Original Balance Date: 1/1/1970
Original Balance: 4000
Regulatory Program: Surety Bond
Notes: 8/1/2008 - Resubmitting bond on most recent revised form per Denise at
586-465-4234 or E-mail dryde@macomb-gerlach.com
WDS:
Site Id: MIG000053544
WMD Id: 437185
TC5128345.2s Page 16
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Relative: INVENTORY:
Higher Bea Number: 200502986LV
Township: Detroit
Actual: District: Southeast MI
625 ft. Data Source: BEA
Latitude: Not reported
Longitude: Not reported
Relative: LUST:
Higher Facility ID: 00041776
Source: STATE OF MICHIGAN
Actual: Owner Name: OWNER ADDRESS UNKNOWN
625 ft. Owner Address: Not Recorded
Owner City,St,Zip: Not Recorded, XX 99999
Owner Contact: Not reported
Owner Phone: Not reported
Country: USA
District: Region 1 - SE Michigan District Office
Site Name: Warehouse Building
Latitude: 42.41710
Longitude: -83.03480
TC5128345.2s Page 17
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
BEA:
Secondary Address: Not reported
BEA Number: 2986
District: Southeast MI
Date Received: 12/07/2005
Submitter Name: Girardin Properties LLC
Petition Determination: Affirmed
Petition Disclosure: 1
Category: No Hazardous Substance(s)
Determination 20107A: Affirmed
Reviewer: schlaufj
Division Assigned: Storage Tank Division
WDS:
Site Id: MIG000042691
WMD Id: 442098
Site Specific Name: STANDARD DISTRIBUTING
Mailing Address: 13691 GIRARDIN ST
Mailing City/State/Zip: 48212
Mailing County: WAYNE
Relative: UST 2:
Higher Owner Name: OWNER ADDRESS UNKNOWN
Owner Address: Not reported
Actual: Active Tanks: 1
625 ft.
TC5128345.2s Page 18
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Relative: RCRA-CESQG:
Lower Date form received by agency: 02/23/2001
Facility name: FAIRMONT SIGN CO
Actual: Facility address: 6771 E MCNICHOLS RD
624 ft. DETROIT, MI 48212
EPA ID: MID096323068
Mailing address: 8221 W DAVISON
DETROIT, MI 48238
Contact: DILIP PATEL
Contact address: 6771 E MCNICHOLS RD
DETROIT, MI 48212
Contact country: US
Contact telephone: 313-935-3355
Contact email: Not reported
EPA Region: 05
Classification: Conditionally Exempt Small Quantity Generator
Description: Handler: generates 100 kg or less of hazardous waste per calendar
month, and accumulates 1000 kg or less of hazardous waste at any time;
or generates 1 kg or less of acutely hazardous waste per calendar
month, and accumulates at any time: 1 kg or less of acutely hazardous
waste; or 100 kg or less of any residue or contaminated soil, waste or
other debris resulting from the cleanup of a spill, into or on any
land or water, of acutely hazardous waste; or generates 100 kg or less
of any residue or contaminated soil, waste or other debris resulting
from the cleanup of a spill, into or on any land or water, of acutely
hazardous waste during any calendar month, and accumulates at any
time: 1 kg or less of acutely hazardous waste; or 100 kg or less of
any residue or contaminated soil, waste or other debris resulting from
the cleanup of a spill, into or on any land or water, of acutely
hazardous waste
Owner/Operator Summary:
Owner/operator name: CITY OF DETROIT
Owner/operator address: Not reported
Not reported
Owner/operator country: Not reported
Owner/operator telephone: Not reported
Owner/operator email: Not reported
Owner/operator fax: Not reported
Owner/operator extension: Not reported
Legal status: Municipal
Owner/Operator Type: Owner
Owner/Op start date: 01/01/1901
Owner/Op end date: Not reported
TC5128345.2s Page 19
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Historical Generators:
Date form received by agency: 11/13/2000
Site name: FAIRMONT SIGN CO
Classification: Not a generator, verified
TC5128345.2s Page 20
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
ECHO:
Envid: 1000365058
Registry ID: 110003609015
DFR URL: http://echo.epa.gov/detailed-facility-report?fid=110003609015
Relative: RCRA-CESQG:
Higher Date form received by agency: 05/22/2012
Facility name: REPAIR INDUSTRIES OF MICHIGAN INC
Actual: Facility address: 6501 E MCNICHOLS RD
625 ft. DETROIT, MI 48212
EPA ID: MIR000045617
Contact: TODD SCHORER
Contact address: Not reported
Not reported
Contact country: US
Contact telephone: 313-267-8918
Contact email: TSCHORER@REPAIR-INDUSTRIES.COM
EPA Region: 05
Land type: Private
Classification: Conditionally Exempt Small Quantity Generator
Description: Handler: generates 100 kg or less of hazardous waste per calendar
month, and accumulates 1000 kg or less of hazardous waste at any time;
or generates 1 kg or less of acutely hazardous waste per calendar
month, and accumulates at any time: 1 kg or less of acutely hazardous
waste; or 100 kg or less of any residue or contaminated soil, waste or
other debris resulting from the cleanup of a spill, into or on any
land or water, of acutely hazardous waste; or generates 100 kg or less
of any residue or contaminated soil, waste or other debris resulting
from the cleanup of a spill, into or on any land or water, of acutely
hazardous waste during any calendar month, and accumulates at any
time: 1 kg or less of acutely hazardous waste; or 100 kg or less of
any residue or contaminated soil, waste or other debris resulting from
the cleanup of a spill, into or on any land or water, of acutely
hazardous waste
Owner/Operator Summary:
Owner/operator name: HOWARD A SCHORER
TC5128345.2s Page 21
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Historical Generators:
Date form received by agency: 02/28/2007
Site name: REPAIR INDUSTRIES OF MICHIGAN INC
Classification: Small Quantity Generator
TC5128345.2s Page 22
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 23
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
ICIS:
Enforcement Action ID: MI000A0000261630315600022
FRS ID: 110000406775
Action Name: REPAIR INDUSTRIES OF MI 261630315600022
Facility Name: RIM CUSTOM RACKS
Facility Address: 6501 E MC NICHOLS RD
DETROIT, MI 48212
Enforcement Action Type: Notice of Violation
Facility County: WAYNE
Program System Acronym: AIR
Enforcement Action Forum Desc: Administrative - Informal
EA Type Code: NOV
Facility SIC Code: Not reported
Federal Facility ID: Not reported
Latitude in Decimal Degrees: 42.4196
Longitude in Decimal Degrees: -83.0351
Permit Type Desc: Not reported
Program System Acronym: MI00000000000M3847
Facility NAICS Code: 332439
Tribal Land Code: Not reported
US AIRS (AFS):
Envid: 1001968417
Region Code: 05
County Code: MI163
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
D and B Number: Not reported
Facility Site Name: RIM CUSTOM RACKS
Primary SIC Code: Not reported
NAICS Code: 332439
TC5128345.2s Page 24
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: Federally-Enforceable State Operating Permit - Non Title V
Activity Date: 2015-05-05 00:00:00
Activity Status Date: 2015-09-15 13:00:10
Activity Group: Compliance Monitoring
Activity Type: Inspection/Evaluation
Activity Status: Active
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: Federally-Enforceable State Operating Permit - Non Title V
Activity Date: 2012-04-09 00:00:00
Activity Status Date: Not reported
Activity Group: Compliance Monitoring
Activity Type: Inspection/Evaluation
Activity Status: Not reported
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: Federally-Enforceable State Operating Permit - Non Title V
Activity Date: 2012-04-10 00:00:00
Activity Status Date: Not reported
Activity Group: Compliance Monitoring
Activity Type: Inspection/Evaluation
Activity Status: Not reported
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
TC5128345.2s Page 25
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: New Source Review Permit Requirements
Activity Date: 2015-04-23 00:00:00
Activity Status Date: 2015-09-15 13:00:10
Activity Group: Compliance Monitoring
Activity Type: Inspection/Evaluation
Activity Status: Active
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: New Source Review Permit Requirements
Activity Date: 2015-05-05 00:00:00
Activity Status Date: 2015-09-15 13:00:10
Activity Group: Compliance Monitoring
Activity Type: Inspection/Evaluation
Activity Status: Active
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: New Source Review Permit Requirements
Activity Date: 2008-08-29 00:00:00
Activity Status Date: Not reported
Activity Group: Compliance Monitoring
Activity Type: Inspection/Evaluation
Activity Status: Not reported
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: New Source Review Permit Requirements
Activity Date: 2008-09-18 00:00:00
Activity Status Date: Not reported
Activity Group: Compliance Monitoring
Activity Type: Inspection/Evaluation
Activity Status: Not reported
Region Code: 05
TC5128345.2s Page 26
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: New Source Review Permit Requirements
Activity Date: 2012-04-10 00:00:00
Activity Status Date: Not reported
Activity Group: Compliance Monitoring
Activity Type: Inspection/Evaluation
Activity Status: Not reported
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: New Source Review Permit Requirements
Activity Date: 2012-06-04 00:00:00
Activity Status Date: 2012-06-04 00:00:00
Activity Group: Enforcement Action
Activity Type: Administrative - Informal
Activity Status: Achieved
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: State Implementation Plan for National Primary and Secondary Ambient Air Quality Standards
Activity Date: Not reported
Activity Status Date: 2006-08-08 00:00:00
Activity Group: Case File
Activity Type: Case File
Activity Status: Resolved
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: State Implementation Plan for National Primary and Secondary Ambient Air Quality Standards
Activity Date: 2015-04-23 00:00:00
Activity Status Date: 2015-09-15 13:00:10
Activity Group: Compliance Monitoring
Activity Type: Inspection/Evaluation
TC5128345.2s Page 27
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: State Implementation Plan for National Primary and Secondary Ambient Air Quality Standards
Activity Date: 2015-05-05 00:00:00
Activity Status Date: 2015-09-15 13:00:10
Activity Group: Compliance Monitoring
Activity Type: Inspection/Evaluation
Activity Status: Active
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: State Implementation Plan for National Primary and Secondary Ambient Air Quality Standards
Activity Date: 1994-11-04 00:00:00
Activity Status Date: Not reported
Activity Group: Compliance Monitoring
Activity Type: Inspection/Evaluation
Activity Status: Not reported
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: State Implementation Plan for National Primary and Secondary Ambient Air Quality Standards
Activity Date: 1995-10-17 00:00:00
Activity Status Date: Not reported
Activity Group: Compliance Monitoring
Activity Type: Inspection/Evaluation
Activity Status: Not reported
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: State Implementation Plan for National Primary and Secondary Ambient Air Quality Standards
Activity Date: 1997-07-08 00:00:00
Activity Status Date: Not reported
Activity Group: Compliance Monitoring
Activity Type: Inspection/Evaluation
Activity Status: Not reported
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: State Implementation Plan for National Primary and Secondary Ambient Air Quality Standards
Activity Date: 1997-11-18 00:00:00
TC5128345.2s Page 28
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: State Implementation Plan for National Primary and Secondary Ambient Air Quality Standards
Activity Date: 1999-01-21 00:00:00
Activity Status Date: Not reported
Activity Group: Compliance Monitoring
Activity Type: Inspection/Evaluation
Activity Status: Not reported
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: State Implementation Plan for National Primary and Secondary Ambient Air Quality Standards
Activity Date: 2000-09-22 00:00:00
Activity Status Date: Not reported
Activity Group: Compliance Monitoring
Activity Type: Inspection/Evaluation
Activity Status: Not reported
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: State Implementation Plan for National Primary and Secondary Ambient Air Quality Standards
Activity Date: 2002-10-16 00:00:00
Activity Status Date: Not reported
Activity Group: Compliance Monitoring
Activity Type: Inspection/Evaluation
Activity Status: Not reported
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: State Implementation Plan for National Primary and Secondary Ambient Air Quality Standards
Activity Date: 2004-02-02 00:00:00
Activity Status Date: Not reported
Activity Group: Compliance Monitoring
Activity Type: Inspection/Evaluation
Activity Status: Not reported
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
TC5128345.2s Page 29
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: State Implementation Plan for National Primary and Secondary Ambient Air Quality Standards
Activity Date: 2008-09-18 00:00:00
Activity Status Date: Not reported
Activity Group: Compliance Monitoring
Activity Type: Inspection/Evaluation
Activity Status: Not reported
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: State Implementation Plan for National Primary and Secondary Ambient Air Quality Standards
Activity Date: 2012-04-09 00:00:00
Activity Status Date: Not reported
Activity Group: Compliance Monitoring
Activity Type: Inspection/Evaluation
Activity Status: Not reported
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: State Implementation Plan for National Primary and Secondary Ambient Air Quality Standards
Activity Date: 2012-04-10 00:00:00
Activity Status Date: Not reported
Activity Group: Compliance Monitoring
Activity Type: Inspection/Evaluation
Activity Status: Not reported
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: State Implementation Plan for National Primary and Secondary Ambient Air Quality Standards
Activity Date: 2012-06-04 00:00:00
Activity Status Date: 2012-06-04 00:00:00
Activity Group: Enforcement Action
Activity Type: Administrative - Informal
Activity Status: Achieved
Region Code: 05
TC5128345.2s Page 30
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: Title V Permits
Activity Date: Not reported
Activity Status Date: 2006-08-08 00:00:00
Activity Group: Case File
Activity Type: Case File
Activity Status: Resolved
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: Title V Permits
Activity Date: 2002-11-22 00:00:00
Activity Status Date: Not reported
Activity Group: Compliance Monitoring
Activity Type: Inspection/Evaluation
Activity Status: Not reported
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: Title V Permits
Activity Date: 2004-02-02 00:00:00
Activity Status Date: Not reported
Activity Group: Compliance Monitoring
Activity Type: Inspection/Evaluation
Activity Status: Not reported
Region Code: 05
Programmatic ID: AIR MI00000000000M3847
Facility Registry ID: 110000406775
Air Operating Status Code: OPR
Default Air Classification Code: SMI
Air Program: Title V Permits
Activity Date: 2006-08-22 00:00:00
Activity Status Date: Not reported
Activity Group: Compliance Monitoring
Activity Type: Inspection/Evaluation
TC5128345.2s Page 31
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Relative: LUST:
Higher Facility ID: 00035702
Source: STATE OF MICHIGAN
Actual: Owner Name: Repair Ind
625 ft. Owner Address: 6501 E Mcnichols Rd
Owner City,St,Zip: Detroit, MI 48212-2027
Owner Contact: Not reported
Owner Phone: (313) 365-5300
Country: USA
District: Region 1 - SE Michigan District Office
Site Name: Repair Industries Of Michigan
Latitude: 42.41941
Longitude: -83.03538
Date of Collection: 01/11/2001
Method of Collection: Address Matching-House Number
Accuracy: 100
Accuracy Value Unit: FEET
Horizontal Data: NAD83
Point Line Area: POINT
Desc Category: Plant Entrance (Freight)
TC5128345.2s Page 32
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
AIRS:
State Registration Number: M3847
Naics Code: Not reported
Contact Email: Not reported
Contact Name: TODD SCHORER
Contact Phone: 3133655300
Contact Address: (same as site address)
Contact City,St,Zip: Not reported
Permit Number: 211-06A
Date Received: 11/27/2006
Application Reason: TEMP LIMIT ON HAP’S
Record Type: Not reported
State County FIPS: Not reported
Facility Category: Not reported
SIC Primary: Not reported
Tribal Code: Not reported
Facility Status: Not reported
Supplemental Location Text: Not reported
Business Name: Not reported
Principal Product: Not reported
Principal Product Description: Not reported
UTM Zone (Geo Coordinates Universal Transverse Mercator System): Not reported
UTM Horizontal Coord: Not reported
UTM Vertical Coord: Not reported
Mailing Name: Not reported
Mailing Contact Person: Not reported
Mailing Street: Not reported
Mailing City: Not reported
Mailing State: Not reported
Mailing Zip: Not reported
Mailing Zip 4 Extension: Not reported
Compliance Person: Not reported
Compliance Area Code: Not reported
Compliance Phone Number: Not reported
Emission Inventory Contact Person: Not reported
EI Contact Area Code: Not reported
EI Contact Phone Number: Not reported
Permit Contact Person: Not reported
Permit Contact Person Area Code: Not reported
Permit Contact Person Phone Number: Not reported
Federal Employer Id Number: Not reported
# Of Employees: Not reported
Reporting Year: Not reported
Date Record Was Created: Not reported
TC5128345.2s Page 33
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
WDS:
Site Id: MIR000045617
WMD Id: 413711
Site Specific Name: REPAIR INDUSTRIES OF MICHIGAN INC
Mailing Address: 6501 E MCNICHOLS RD
Mailing City/State/Zip: 48212
Mailing County: WAYNE
Relative: LUST:
Higher Facility ID: 00007392
Source: STATE OF MICHIGAN
Actual: Owner Name: Federal Pipe & Supply Co
627 ft. Owner Address: 6464 E Mcnichols Rd
Owner City,St,Zip: Detroit, MI 48212-2026
Owner Contact: Not reported
Owner Phone: (313) 366-3000
Country: USA
District: Region 1 - SE Michigan District Office
Site Name: Federal Pipe And Supply Company
Latitude: 42.41912
Longitude: -83.03614
Date of Collection: 01/11/2001
Method of Collection: Address Matching-House Number
Accuracy: 100
Accuracy Value Unit: FEET
Horizontal Data: NAD83
Point Line Area: POINT
Desc Category: Plant Entrance (Freight)
TC5128345.2s Page 34
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Tank ID: 1
Tank Status: Removed from Ground
Capacity: 1000
Product: Gasoline
Install Date: 03/14/1981
Remove Date: 02/03/1992
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Galvanized Steel
Piping Type: Suction: No Valve At Tank
Construction Material: Asphalt Coated or Bare Steel,Fiberglass Reinforced plastic
Impressed Device: No
WDS:
Site Id: MIG000029782
WMD Id: 447882
Site Specific Name: FEDERAL PIPE & SUPPLY
Mailing Address: 6464 E MCNICHOLS RD
Mailing City/State/Zip: 48212
Mailing County: WAYNE
Owner/Operator Summary:
Owner/operator name: NO ACTIVE O/OP AS NOT GENERATING WASTE
Owner/operator address: Not reported
Not reported
Owner/operator country: Not reported
Owner/operator telephone: Not reported
Owner/operator email: Not reported
TC5128345.2s Page 35
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Historical Generators:
Date form received by agency: 09/30/2002
Site name: SKYLINE PAINTING INC
Classification: Not a generator, verified
TC5128345.2s Page 36
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
FINDS:
ECHO:
Envid: 1001112737
Registry ID: 110003696108
DFR URL: http://echo.epa.gov/detailed-facility-report?fid=110003696108
Relative: INVENTORY:
Lower Bea Number: 200904145LV
Township: Detroit
Actual: District: Southeast MI
623 ft. Data Source: BEA
Latitude: Not reported
Longitude: Not reported
BEA:
Secondary Address: Not reported
BEA Number: 4145
District: Southeast MI
Date Received: 03/13/2009
Submitter Name: Walker Enterprises LLC II
Petition Determination: Pending
Petition Disclosure: 1
Category: No Hazardous Substance(s)
Determination 20107A: No Request
Reviewer: thorntop
Division Assigned: RRD
TC5128345.2s Page 37
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Owner/Operator Summary:
Owner/operator name: US ENVIRONMENTAL PROTECTION AGENCY
Owner/operator address: Not reported
Not reported
Owner/operator country: Not reported
Owner/operator telephone: Not reported
Owner/operator email: Not reported
Owner/operator fax: Not reported
Owner/operator extension: Not reported
Legal status: Federal
Owner/Operator Type: Operator
Owner/Op start date: 01/01/1970
Owner/Op end date: Not reported
TC5128345.2s Page 38
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Relative: INVENTORY:
Higher Bea Number: Not reported
Township: Detroit
Actual: District: Southeast MI
630 ft. Data Source: Part 201
Latitude: 42.41754
Longitude: -83.03745
PART 201:
Facility ID: 82000158
Facility Status: Remedial Action in Progress (may incl. use restrictions, O&M and/or
monitoring)
Source: Metal Processing
SAM Score: 37
SAM Score Date: 07/20/2004
Township: 01S
Range: 12E
Section: 9
Quarter: SW
Quarter/Quarter: Not reported
Pollutants: CN; Pb
Relative: SEMS:
Higher Site ID: 506440
EPA ID: MID011247806
Actual: Federal Facility: N
630 ft. NPL: Not on the NPL
Non NPL Status: Referred to Removal - NFRAP
Following information
: was gathered from the prior CERCLIS update completed in 10/2013:
Site ID: 0506440
EPA ID: MID011247806
TC5128345.2s Page 39
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 40
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 41
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 42
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 43
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Owner/Operator Summary:
Owner/operator name: NO ACTIVE O/OP AS NOT GENERATING WASTE
Owner/operator address: Not reported
Not reported
Owner/operator country: Not reported
Owner/operator telephone: Not reported
Owner/operator email: Not reported
Owner/operator fax: Not reported
Owner/operator extension: Not reported
Legal status: Private
Owner/Operator Type: Operator
Owner/Op start date: 12/22/2000
Owner/Op end date: Not reported
TC5128345.2s Page 44
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Historical Generators:
Date form received by agency: 08/17/1994
Site name: GENERAL DIE CASTING CO
Classification: Large Quantity Generator
TC5128345.2s Page 45
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Relative: LUST:
Lower Facility ID: 00006204
Source: STATE OF MICHIGAN
Actual: Owner Name: Mohammod S Baayoun
624 ft. Owner Address: 7219 Continental Ave
Owner City,St,Zip: Warren, MI 48091-3533
Owner Contact: Not reported
Owner Phone: (810) 757-1280
Country: USA
District: Region 1 - SE Michigan District Office
Site Name: Baayoun Service Inc.
Latitude: 42.41948
Longitude: -83.03130
Date of Collection: 01/11/2001
Method of Collection: Address Matching-House Number
Accuracy: 100
Accuracy Value Unit: FEET
Horizontal Data: NAD83
Point Line Area: POINT
Desc Category: Plant Entrance (Freight)
TC5128345.2s Page 46
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Tank ID: 2
Tank Status: Removed from Ground
Capacity: 10000
Product: Gasoline
Install Date: 02/01/1976
Remove Date: 07/21/1986
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Unknown
Piping Type: Not reported
Construction Material: Asphalt Coated or Bare Steel
Impressed Device: No
Tank ID: 3
Tank Status: Removed from Ground
Capacity: 10000
Product: Diesel
Install Date: 02/01/1976
Remove Date: 05/16/1995
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Unknown
Piping Type: Not reported
Construction Material: Asphalt Coated or Bare Steel
Impressed Device: No
Tank ID: 4
Tank Status: Removed from Ground
Capacity: 2000
Product: Kerosene
Install Date: 02/01/1976
Remove Date: 07/21/1986
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Unknown
Piping Type: Not reported
Construction Material: Asphalt Coated or Bare Steel
Impressed Device: No
Tank ID: 5
TC5128345.2s Page 47
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Tank ID: 6
Tank Status: Removed from Ground
Capacity: 6000
Product: Gasoline
Install Date: 01/31/1986
Remove Date: 05/15/1995
Tank Release Detection: Not reported
Pipe Realease Detection: Automatic Line Leak Detectors
Piping Material: Galvanized Steel
Piping Type: Pressure
Construction Material: Asphalt Coated or Bare Steel,Cathodically Protected Steel,STI-P3
Impressed Device: No
Tank ID: 7
Tank Status: Removed from Ground
Capacity: 6000
Product: Gasoline
Install Date: 01/31/1986
Remove Date: 05/15/1995
Tank Release Detection: Not reported
Pipe Realease Detection: Automatic Line Leak Detectors
Piping Material: Galvanized Steel
Piping Type: Pressure
Construction Material: Asphalt Coated or Bare Steel,Cathodically Protected Steel,STI-P3
Impressed Device: No
Tank ID: 8
Tank Status: Removed from Ground
Capacity: 6000
Product: Kerosene
Install Date: 01/31/1986
Remove Date: 05/17/1995
Tank Release Detection: Not reported
Pipe Realease Detection: Automatic Line Leak Detectors
Piping Material: Galvanized Steel
Piping Type: Pressure
Construction Material: Asphalt Coated or Bare Steel,Cathodically Protected Steel,STI-P3
Impressed Device: No
INVENTORY:
Bea Number: Not reported
Township: Not reported
TC5128345.2s Page 48
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Relative: AUL:
Lower Status: Recorded
Site Name: Not reported
Actual: Property: Baayoun Service
624 ft. Land Use Restriction Type: NCA
Program Type: Part 213
Program Support Assigned User: Nicholas Swartz
Program Support Assigned Date: 05/14/2010
Legal Description Of Property: Migrated
Based On The Deq Ref #: 12121304250
MDEQ Reference Number: NCA-RRD-213-04-250
Property Or Description Restricted Area: Migrated
Lead Division: STD
File Name Of Hyperlinked Legal Doc: U:\\kermit\\12121304250.pdf
Mapped Polygons Area In Acres: 0.48209999999999997
Mapped Polygons Area In Square Miles: 8.0000000000000004E-4
Date Data Entry Started: 05/14/2010
Date Data Entry Finished: 05/14/2010
Individual Or Staff Assoc With The Mapping: Nicholas Swartz
Program Used To Map Restricted Features: ArcInfo 9.3 and IcoMap 4.2
Date Legal Paperwork Stamped/Filed/Register Of Deeds: 10/01/1996
Commercial I Land Use Restriction: 0
Commercial Ii Land Use Restriction: 0
Commercial Iii Land Use Restriction: 1
Commercial Iv Land Use Restriction: 0
Industrial Land Use Restriction: 0
Residential Land Use Restriction: 0
Recreational Land Use Restriction: 0
Multiple Land-Use Restrictions: 0
Site Specific Restrictions: 0
Groundwater Consumption Restrictions: 0
Groundwater Contact Restrictions: 0
Special Well Construction Requirements: 0
Special Building Restrictions: 0
Excavation And Soil Movement Restrictions: 0
Soil Movement Requirements: 0
There Is A Restriction On All Construction: 0
Monitoring Well Protected, No Tampering Or Removal: 0
There Is An Exposure Barrier In Place: 0
There Is A Health And Safety Plan: 0
There Is A Permanent Marker On The Site: 0
Map Comments: Land restriction has not been mapped in kermit as of February 14,
2008. 20100514 - Added subdivision map to NCA. - Nick Swartz 20100514
- LRUR is mapped in KERMIT - Nick Swartz
Comment: Request received on 8/4/2004
TC5128345.2s Page 49
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Relative: RCRA-CESQG:
Lower Date form received by agency: 01/14/2009
Facility name: METAL AND WELDING INDUSTRIES INC
Actual: Facility address: 13595 HELEN ST
623 ft. DETROIT, MI 48212
EPA ID: MID076345545
Mailing address: 13550 HELEN ST
DETROIT, MI 48212
Contact: JOHN ECKMAN
Contact address: 13595 HELEN ST
DETROIT, MI 48212
Contact country: US
Contact telephone: 313-372-4131
Contact email: Not reported
EPA Region: 05
Land type: Private
Classification: Conditionally Exempt Small Quantity Generator
Description: Handler: generates 100 kg or less of hazardous waste per calendar
month, and accumulates 1000 kg or less of hazardous waste at any time;
or generates 1 kg or less of acutely hazardous waste per calendar
month, and accumulates at any time: 1 kg or less of acutely hazardous
waste; or 100 kg or less of any residue or contaminated soil, waste or
other debris resulting from the cleanup of a spill, into or on any
land or water, of acutely hazardous waste; or generates 100 kg or less
of any residue or contaminated soil, waste or other debris resulting
from the cleanup of a spill, into or on any land or water, of acutely
hazardous waste during any calendar month, and accumulates at any
time: 1 kg or less of acutely hazardous waste; or 100 kg or less of
any residue or contaminated soil, waste or other debris resulting from
the cleanup of a spill, into or on any land or water, of acutely
hazardous waste
Owner/Operator Summary:
Owner/operator name: VIC WOOD
Owner/operator address: Not reported
Not reported
Owner/operator country: Not reported
Owner/operator telephone: Not reported
Owner/operator email: Not reported
Owner/operator fax: Not reported
Owner/operator extension: Not reported
Legal status: Private
Owner/Operator Type: Operator
Owner/Op start date: 01/01/1970
Owner/Op end date: Not reported
TC5128345.2s Page 50
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Historical Generators:
Date form received by agency: 06/30/2005
Site name: METAL AND WELDING INDUSTRIES INC
Classification: Small Quantity Generator
TC5128345.2s Page 51
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 52
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 53
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 54
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 55
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 56
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 57
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
ECHO:
Envid: 1000289043
Registry ID: 110003604172
DFR URL: http://echo.epa.gov/detailed-facility-report?fid=110003604172
TC5128345.2s Page 58
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Relative: LUST:
Lower Facility ID: 50000457
Source: STATE OF MICHIGAN
Actual: Owner Name: Tork Enterprises
623 ft. Owner Address: 13550 Helen St
Owner City,St,Zip: Detroit, MI 48212-2022
Owner Contact: Not reported
Owner Phone: (313) 365-4131
Country: USA
District: Region 1 - SE Michigan District Office
Site Name: Paramount Fabricating
Latitude: 42.41642
Longitude: -83.03126
Date of Collection: 01/11/2001
Method of Collection: Address Matching-House Number
Accuracy: 100
Accuracy Value Unit: FEET
Horizontal Data: NAD83
Point Line Area: POINT
Desc Category: Plant Entrance (Freight)
TC5128345.2s Page 59
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
WDS:
Site Id: MID076345545
WMD Id: 397218
Site Specific Name: W INDUSTRIES
Mailing Address: 13550 HELEN ST
Mailing City/State/Zip: 48212
Mailing County: WAYNE
Owner/Operator Summary:
Owner/operator name: TIM LEWIS
Owner/operator address: Not reported
Not reported
Owner/operator country: Not reported
Owner/operator telephone: Not reported
Owner/operator email: Not reported
TC5128345.2s Page 60
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 61
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Historical Generators:
Date form received by agency: 01/10/2014
Site name: GREAT LAKES GREASE SERVICE LLC
Classification: Not a generator, verified
ECHO:
Envid: 1016453590
Registry ID: 110058887548
DFR URL: http://echo.epa.gov/detailed-facility-report?fid=110058887548
Relative: SEMS:
Lower Site ID: 508679
EPA ID: MIN000508679
Actual: Federal Facility: N
624 ft. NPL: Not on the NPL
Non NPL Status: Removal Only Site (No Site Assessment Work Needed)
Following information
: was gathered from the prior CERCLIS update completed in 10/2013:
Site ID: 0508679
EPA ID: MIN000508679
Facility County: WAYNE
TC5128345.2s Page 62
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 63
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 64
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Relative: BROWNFIELDS:
Lower Facility ID: Not reported
Region: 1
Actual: Status: Not reported
624 ft. Properry Use: Not reported
BEA: No
Ernie Id Number: 82001541
PART 201:
Facility ID: 82001541
Facility Status: Interim Response conducted - No further activities anticipated
Source: Nonclassifiable Establishments
SAM Score: 24
SAM Score Date: 08/05/2004
Township: 1S
Range: 12E
Section: 16
Quarter: NE
Quarter/Quarter: SW
Pollutants: Pb
INVENTORY:
Bea Number: Not reported
Township: Detroit City
District: Southeast MI
Data Source: Part 201
Latitude: 42.41543
Longitude: -83.0322
WDS:
Site Id: MIK667511315
WMD Id: 476347
Site Specific Name: US EPA/ HELEN AVE SITE
Mailing Address: 9311 GROH RD
Mailing City/State/Zip: 48138
Mailing County: WAYNE
TC5128345.2s Page 65
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Owner/Operator Summary:
Owner/operator name: CITY OF DETROIT
Owner/operator address: Not reported
Not reported
Owner/operator country: US
Owner/operator telephone: Not reported
Owner/operator email: Not reported
Owner/operator fax: Not reported
Owner/operator extension: Not reported
Legal status: Municipal
Owner/Operator Type: Owner
Owner/Op start date: 10/28/2003
Owner/Op end date: Not reported
TC5128345.2s Page 66
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Historical Generators:
Date form received by agency: 12/19/2003
Site name: MI DEPT/NATURAL RESOURCES AND ENVIRONMENT
Classification: Not a generator, verified
SUPERFUND (NON-NPL)
TC5128345.2s Page 67
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Relative: UST 2:
Lower Owner Name: OWNER ADDRESS UNKNOWN
Owner Address: Not reported
Actual: Active Tanks: 0
623 ft.
Relative: LUST:
Lower Facility ID: 00017104
Source: STATE OF MICHIGAN
Actual: Owner Name: OWNER ADDRESS UNKNOWN
623 ft. Owner Address: Not Recorded
Owner City,St,Zip: Not Recorded, XX 99999
Owner Contact: Not reported
Owner Phone: Not reported
Country: USA
District: Region 1 - SE Michigan District Office
Site Name: Arrow Uniform Rental Inc
Latitude: 42.41588
Longitude: -83.03123
Date of Collection: 01/11/2001
Method of Collection: Address Matching-House Number
Accuracy: 100
Accuracy Value Unit: FEET
Horizontal Data: NAD83
Point Line Area: POINT
Desc Category: Plant Entrance (Freight)
TC5128345.2s Page 68
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 69
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
WDS:
Site Id: MIG000018230
WMD Id: 454202
Site Specific Name: ARROW UNIFORM
Mailing Address: 13550 HELEN ST
Mailing City/State/Zip: 48212
Mailing County: WAYNE
Relative: INVENTORY:
Lower Bea Number: 201305504LV
Township: Detroit
Actual: District: Southeast MI
623 ft. Data Source: BEA
Latitude: Not reported
Longitude: Not reported
Relative: INVENTORY:
Lower Bea Number: 201104937LV
Township: Detroit
Actual: District: Southeast MI
624 ft. Data Source: BEA
Latitude: 42.44439
Longitude: -83.00526
TC5128345.2s Page 70
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Relative: INVENTORY:
Lower Bea Number: 199600106LV
Township: Detroit
Actual: District: Southeast MI
624 ft. Data Source: BEA
Latitude: 42.41543
Longitude: -83.0322
Relative: INVENTORY:
Lower Bea Number: 199900869LV
Township: Detroit
Actual: District: Southeast MI
624 ft. Data Source: BEA
Latitude: 42.41543
Longitude: -83.0322
Relative: INVENTORY:
Lower Bea Number: 199900899LV
Township: Detroit
Actual: District: Southeast MI
624 ft. Data Source: BEA
Latitude: 42.41543
Longitude: -83.0322
TC5128345.2s Page 71
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Relative: INVENTORY:
Lower Bea Number: 199900819LV
Township: Detroit
Actual: District: Southeast MI
624 ft. Data Source: BEA
Latitude: 42.41543
Longitude: -83.0322
Relative: UST:
Higher Facility ID: 00042081
Facility Type: ACTIVE
Actual: Owner Name: CENTRAL STEEL & WIRE
625 ft. Owner Address: 3000 WEST 51ST STREET
Owner City,St,Zip: CHICAGO, IL 60632
Owner Country: USA
Owner Contact: Not reported
Owner Phone: (773) 471-3800
Contact: Auggie Hardin
Contact Phone: (313) 368-5000
Date of Collection: Not reported
Accuracy: Not reported
Accuracy Value Unit: Not reported
Horizontal Datum: Not reported
Source: Not reported
Point Line Area: Not reported
Desc Category: Not reported
Method of Collection: Not reported
Latitude: Not reported
Longitude: Not reported
Tank ID: 1
Tank Status: Temporarily out of Use
Capacity: 20000
Product: Heating Oil
Install Date: Not reported
Remove Date: Not reported
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Fiberglass Reinforced Plastic
Piping Type: Pressure
Construction Material: Asphalt Coated or Bare Steel
Impressed Device: No
Tank ID: 2
Tank Status: Temporarily out of Use
Capacity: 27000
Product: Heating Oil
TC5128345.2s Page 72
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Relative: INVENTORY:
Higher Bea Number: Not reported
Township: Detroit
Actual: District: Southeast MI
625 ft. Data Source: Part 201
Latitude: Not reported
Longitude: Not reported
Relative: LUST:
Higher Facility ID: 00018527
Source: STATE OF MICHIGAN
Actual: Owner Name: Ibrahim Ajrouche
627 ft. Owner Address: 6236 E McNichols
Owner City,St,Zip: Detroit, MI 48212
Owner Contact: Not reported
Owner Phone: (313) 369-9372
Country: USA
District: Region 1 - SE Michigan District Office
Site Name: Eagle Fly Petro
Latitude: 42.41905
Longitude: -83.03904
Date of Collection: 01/11/2001
Method of Collection: Address Matching-House Number
Accuracy: 100
Accuracy Value Unit: FEET
Horizontal Data: NAD83
Point Line Area: POINT
Desc Category: Plant Entrance (Freight)
TC5128345.2s Page 73
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Tank ID: 1
Tank Status: Removed from Ground
Capacity: 8000
Product: Gasoline
Install Date: 05/06/1971
Remove Date: 03/30/2004
Tank Release Detection: Automatic Tank Gauging,Groundwater Monitoring,Inventory Control,Tank
Tightness Testing
Pipe Realease Detection: Automatic Line Leak Detectors,Line Tightness Testing
Piping Material: Fiberglass reinforced plastic
Piping Type: Pressure
Construction Material: Asphalt Coated or Bare Steel
Impressed Device: Yes
Tank ID: 2
Tank Status: Removed from Ground
Capacity: 8000
Product: Gasoline
Install Date: 05/06/1971
Remove Date: 04/01/2004
Tank Release Detection: Automatic Tank Gauging,Groundwater Monitoring,Inventory Control,Tank
Tightness Testing
Pipe Realease Detection: Automatic Line Leak Detectors,Line Tightness Testing
TC5128345.2s Page 74
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Tank ID: 3
Tank Status: Removed from Ground
Capacity: 10000
Product: Gasoline
Install Date: 05/06/1971
Remove Date: 03/30/2004
Tank Release Detection: Automatic Tank Gauging,Groundwater Monitoring,Inventory Control,Tank
Tightness Testing
Pipe Realease Detection: Automatic Line Leak Detectors,Line Tightness Testing
Piping Material: Fiberglass reinforced plastic
Piping Type: Pressure
Construction Material: Asphalt Coated or Bare Steel
Impressed Device: Yes
Tank ID: 4
Tank Status: Removed from Ground
Capacity: 6000
Product: Gasoline
Install Date: 05/06/1971
Remove Date: 04/02/2004
Tank Release Detection: Automatic Tank Gauging,Groundwater Monitoring,Inventory Control,Tank
Tightness Testing
Pipe Realease Detection: Automatic Line Leak Detectors,Line Tightness Testing
Piping Material: Fiberglass reinforced plastic
Piping Type: Pressure
Construction Material: Asphalt Coated or Bare Steel
Impressed Device: Yes
Tank ID: 5
Tank Status: Removed from Ground
Capacity: 10000
Product: Diesel
Install Date: 05/06/1971
Remove Date: 04/02/2004
Tank Release Detection: Automatic Tank Gauging,Groundwater Monitoring,Inventory Control,Tank
Tightness Testing
Pipe Realease Detection: Automatic Line Leak Detectors,Line Tightness Testing
Piping Material: Fiberglass reinforced plastic
Piping Type: Suction: Valve at Tank
Construction Material: Asphalt Coated or Bare Steel
Impressed Device: Yes
Tank ID: 6
Tank Status: Removed from Ground
Capacity: 12000
Product: Diesel
Install Date: 05/06/1971
Remove Date: 04/01/2004
TC5128345.2s Page 75
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Tank ID: 7
Tank Status: Removed from Ground
Capacity: 8000
Product: Kerosene
Install Date: 05/06/1971
Remove Date: 03/31/2004
Tank Release Detection: Automatic Tank Gauging,Groundwater Monitoring,Inventory Control,Tank
Tightness Testing
Pipe Realease Detection: Automatic Line Leak Detectors,Line Tightness Testing
Piping Material: Fiberglass reinforced plastic
Piping Type: Pressure
Construction Material: Asphalt Coated or Bare Steel
Impressed Device: Yes
Tank ID: 8
Tank Status: Currently In Use
Capacity: 20000
Product: Regular / Premium Gas
Install Date: 04/20/2004
Remove Date: Not reported
Tank Release Detection: Automatic Tank Gauging, Interstitial Monitoring Double Walled Tank
Pipe Realease Detection: Automatic Line Leak Detectors, Interstitial Monitoring Double Walled
Piping
Piping Material: Double Walled
Piping Type: Pressure
Construction Material: Double Walled
Impressed Device: No
Tank ID: 9
Tank Status: Currently In Use
Capacity: 15000
Product: Diesel, Kerosene, Turbo Premium
Install Date: 04/20/2004
Remove Date: Not reported
Tank Release Detection: Automatic Tank Gauging, Interstitial Monitoring Double Walled Tank
Pipe Realease Detection: Automatic Line Leak Detectors, Interstitial Monitoring Double Walled
Piping
Piping Material: Double Walled
Piping Type: Pressure
Construction Material: Double Walled
Impressed Device: No
TC5128345.2s Page 76
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
INVENTORY:
Bea Number: Not reported
Township: Not reported
District: Southeast MI
Data Source: Part 213
Latitude: 42.41906
Longitude: -83.03905
Relative: LUST:
Higher Facility ID: 00038539
Source: STATE OF MICHIGAN
Actual: Owner Name: OWNER ADDRESS UNKNOWN
625 ft. Owner Address: Not Recorded
Owner City,St,Zip: Not Recorded, XX 99999
Owner Contact: Not reported
Owner Phone: Not reported
Country: USA
District: Region 1 - SE Michigan District Office
Site Name: Abdo M. Ali
Latitude: 42.41726
Longitude: -83.14310
Date of Collection: 01/11/2001
Method of Collection: Address Matching-House Number
Accuracy: 100
Accuracy Value Unit: FEET
Horizontal Data: NAD83
Point Line Area: POINT
Desc Category: Plant Entrance (Freight)
TC5128345.2s Page 77
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Owner/Operator Summary:
Owner/operator name: NO ACTIVE O/OP AS NOT GENERATING WASTE
Owner/operator address: Not reported
Not reported
Owner/operator country: Not reported
Owner/operator telephone: Not reported
Owner/operator email: Not reported
Owner/operator fax: Not reported
Owner/operator extension: Not reported
Legal status: Private
Owner/Operator Type: Operator
Owner/Op start date: 09/02/2005
Owner/Op end date: Not reported
TC5128345.2s Page 78
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Historical Generators:
Date form received by agency: 09/01/2005
Site name: MI DEPT/NATURAL RESOURCES AND ENVIRONMENT
Classification: Not a generator, verified
Relative: INVENTORY:
Higher Bea Number: 201707655LV
Township: Detroit
Actual: District: Southeast MI
625 ft. Data Source: BEA
Latitude: Not reported
Longitude: Not reported
Relative: INVENTORY:
Higher Bea Number: Not reported
Township: Hamtramck
Actual: District: Southeast MI
625 ft. Data Source: Part 201
Latitude: Not reported
Longitude: Not reported
TC5128345.2s Page 79
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Owner/Operator Summary:
Owner/operator name: NO ACTIVE O/OP AS NOT GENERATING WASTE
Owner/operator address: Not reported
Not reported
Owner/operator country: Not reported
Owner/operator telephone: Not reported
Owner/operator email: Not reported
Owner/operator fax: Not reported
Owner/operator extension: Not reported
Legal status: Private
Owner/Operator Type: Operator
Owner/Op start date: 01/01/2002
Owner/Op end date: Not reported
TC5128345.2s Page 80
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Historical Generators:
Date form received by agency: 12/02/1999
Site name: CITY OF DETROIT
Classification: Large Quantity Generator
ECHO:
Envid: 1001817624
Registry ID: 110003712670
DFR URL: http://echo.epa.gov/detailed-facility-report?fid=110003712670
Relative: RCRA-CESQG:
Higher Date form received by agency: 03/01/2006
Facility name: CADILLAC ENAMELING TECHNOLOGIES LLC
Actual: Facility address: 17425 SHERWOOD
625 ft. DETROIT, MI 48212
EPA ID: MID005384680
Contact: BARRINGTON S POWELL
TC5128345.2s Page 81
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Owner/Operator Summary:
Owner/operator name: CADILLAC ENAMELING TECHNOLOGIES INC.
Owner/operator address: Not reported
Not reported
Owner/operator country: Not reported
Owner/operator telephone: Not reported
Owner/operator email: Not reported
Owner/operator fax: Not reported
Owner/operator extension: Not reported
Legal status: Private
Owner/Operator Type: Owner
Owner/Op start date: 01/01/1970
Owner/Op end date: Not reported
TC5128345.2s Page 82
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Historical Generators:
Date form received by agency: 05/14/2005
Site name: CADILLAC ENAMELING TECHNOLOGIES LLC
Classification: Conditionally Exempt Small Quantity Generator
TC5128345.2s Page 83
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 84
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 85
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 86
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 87
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 88
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 89
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 90
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 91
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 92
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 93
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 94
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 95
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 96
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 97
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 98
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
TC5128345.2s Page 99
Map ID MAP FINDINGS
Direction
Distance EDR ID Number
Elevation Site Database(s) EPA ID Number
Region Code: 05
Programmatic ID: AIR MI00000000000B3300
Facility Registry ID: 110001299121
Air Operating Status Code: OPR
Default Air Classification Code: MIN
Air Program: State Implementation Plan for National Primary and Secondary Ambient Air Quality Standards
Activity Date: 1997-01-14 00:00:00
Activity Status Date: Not reported
Activity Group: Compliance Monitoring
Activity Type: Inspection/Evaluation
Activity Status: Not reported
Region Code: 05
Programmatic ID: AIR MI00000000000B3300
Facility Registry ID: 110001299121
Air Operating Status Code: OPR
Default Air Classification Code: MIN
Air Program: State Implementation Plan for National Primary and Secondary Ambient Air Quality Standards
Activity Date: 1998-05-26 00:00:00
Activity Status Date: Not reported
Activity Group: Compliance Monitoring
Activity Type: Inspection/Evaluation
Activity Status: Not reported
FINDS:
AIR MINOR
ECHO:
Envid: 1000254416
Registry ID: 110001299121
DFR URL: http://echo.epa.gov/detailed-facility-report?fid=110001299121
Relative: INVENTORY:
Higher Bea Number: 201104793LV
Township: Detroit
Actual: District: Southeast MI
625 ft. Data Source: BEA
Latitude: Not reported
Longitude: Not reported
BEA:
Secondary Address: Not reported
BEA Number: 4793
District: Southeast MI
Date Received: 05/16/2011
Submitter Name: Grand PaPa’s, Inc.
Petition Determination: No Request
Petition Disclosure: 0
Category: Not reported
Determination 20107A: No Request
Reviewer: thorntop
Division Assigned: RRD
Relative: UST 2:
Higher Owner Name: OWNER ADDRESS UNKNOWN
Owner Address: Not reported
Actual: Active Tanks: 3
626 ft.
Relative: RCRA-CESQG:
Higher Date form received by agency: 09/30/2002
Facility name: KNIGHT ENTERPRISES INC
Actual: Facility address: 6236 E 6 MILE RD
627 ft. DETROIT, MI 48212
EPA ID: MID985658301
Mailing address: 40600 GRAND RIVER AVE
NOVI, MI 48375
Contact: SHIRLEY TROMBETTA
Contact address: 6236 E 6 MILE RD
DETROIT, MI 48212
Contact country: US
Contact telephone: 248-478-3651
Contact email: Not reported
Owner/Operator Summary:
Owner/operator name: KNIGHT ENTERPRISES INC
Owner/operator address: Not reported
Not reported
Owner/operator country: Not reported
Owner/operator telephone: Not reported
Owner/operator email: Not reported
Owner/operator fax: Not reported
Owner/operator extension: Not reported
Legal status: Private
Owner/Operator Type: Owner
Owner/Op start date: 01/01/1970
Owner/Op end date: Not reported
Historical Generators:
Date form received by agency: 03/05/1993
Site name: KNIGHT ENTERPRISES INC
Classification: Small Quantity Generator
ECHO:
Envid: 1000828755
Registry ID: 110007583481
DFR URL: http://echo.epa.gov/detailed-facility-report?fid=110007583481
Relative: INVENTORY:
Higher Bea Number: Not reported
Township: Detroit
Actual: District: Southeast MI
626 ft. Data Source: Part 201
BEA:
Secondary Address: Not reported
BEA Number: 5436
District: Southeast MI
Date Received: 01/09/2013
Submitter Name: Novo LLC
Petition Determination: No Request
Petition Disclosure: 0
Category: Not reported
Determination 20107A: No Request
Reviewer: thorntop
Division Assigned: RRD
Relative: LUST:
Higher Facility ID: 00014334
Source: STATE OF MICHIGAN
Actual: Owner Name: Aureus Holdings Ltd
626 ft. Owner Address: 17287 Mt Elliot
Owner City,St,Zip: Detroit, MI 48212
Owner Contact: Not reported
Owner Phone: 313-366-7252
Country: USA
District: Region 1 - SE Michigan District Office
Site Name: Aureus Holdings
Latitude: 42.42048
Longitude: -83.03861
Date of Collection: 01/11/2001
Method of Collection: Address Matching-House Number
Accuracy: 100
Accuracy Value Unit: FEET
Horizontal Data: NAD83
Point Line Area: POINT
Desc Category: Plant Entrance (Freight)
Tank ID: 1
Tank Status: Removed from Ground
Capacity: 6000
Product: Used Oil
Install Date: 05/12/1985
Remove Date: 01/16/2007
Tank Release Detection: Automatic Tank Gauging,Inter Monitoring Double Walled Tank
Pipe Realease Detection: Not reported
Piping Material: Galvanized Steel
Piping Type: Not reported
Construction Material: Composite(Steel w/Fiberglass),Double Walled,Fiberglass Reinforced
plastic
Impressed Device: No
Tank ID: 2
Tank Status: Removed from Ground
Capacity: 6000
Product: Used Oil
Install Date: 05/12/1985
Remove Date: 07/02/2007
Tank Release Detection: Automatic Tank Gauging,Inter Monitoring Double Walled Tank
Pipe Realease Detection: Not reported
Piping Material: Galvanized Steel
Piping Type: Not reported
Construction Material: Composite(Steel w/Fiberglass),Double Walled,Fiberglass Reinforced
plastic
Impressed Device: No
Owner/Operator Summary:
Owner/operator name: AUREUS HOLDINGS LTD
Owner/operator address: Not reported
Not reported
Owner/operator country: Not reported
Owner/operator telephone: Not reported
Owner/operator email: Not reported
Owner/operator fax: Not reported
Owner/operator extension: Not reported
Legal status: Private
Owner/Operator Type: Operator
Owner/Op start date: 07/01/2002
Owner/Op end date: Not reported
Relative: INVENTORY:
Higher Bea Number: 201305436LV
Township: Detroit
Actual: District: Southeast MI
626 ft. Data Source: BEA
Latitude: 42.42026
Longitude: -83.03903
Relative: LUST:
Higher Facility ID: 00035838
Source: STATE OF MICHIGAN
Actual: Owner Name: Harry Twigg Living Trust, Edward
625 ft. Owner Address: 755 Commerce Dr Ste 801
Owner City,St,Zip: Decatur, GA 30030-2623
Owner Contact: Not reported
Owner Phone: (404) 378-4245
Country: USA
District: Region 1 - SE Michigan District Office
Site Name: Midwest Transportation
Latitude: 42.41521
Longitude: -83.03469
Date of Collection: 01/11/2001
Method of Collection: Address Matching-House Number
Accuracy: 100
Accuracy Value Unit: FEET
Horizontal Data: NAD83
Point Line Area: POINT
Desc Category: Plant Entrance (Freight)
Tank ID: 1
Tank Status: Removed from Ground
Capacity: 10000
Product: Diesel
Install Date: Not reported
Remove Date: 03/03/1992
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Unknown
Piping Type: Not reported
Construction Material: Asphalt Coated or Bare Steel
Impressed Device: No
INVENTORY:
Bea Number: Not reported
Township: Not reported
District: Southeast MI
Data Source: Part 213
Latitude: 42.41522
Longitude: -83.0347
Relative: SEMS-ARCHIVE:
Higher Site ID: 502661
EPA ID: MID086147915
Actual: Federal Facility: N
625 ft. NPL: Not on the NPL
Non NPL Status: NFRAP-Site does not qualify for the NPL based on existing information
Following information
: was gathered from the prior CERCLIS update completed in 10/2013:
Site ID: 0502661
Federal Facility: Not a Federal Facility
NPL Status: Not on the NPL
Non NPL Status: NFRAP-Site does not qualify for the NPL based on existing information
Program Priority:
Description: Great Lakes
RCRA-CESQG:
Date form received by agency: 07/05/2017
Facility name: CADILLAC OIL CO
Facility address: 13650 HELEN ST
DETROIT, MI 48212
EPA ID: MID086147915
Contact: TOM TILOTTI
Contact address: Not reported
Not reported
Contact country: Not reported
Contact telephone: 313-365-6200
Contact email: TTIL@CADILLACOIL.COM
EPA Region: 05
Land type: Private
Classification: Conditionally Exempt Small Quantity Generator
Description: Handler: generates 100 kg or less of hazardous waste per calendar
month, and accumulates 1000 kg or less of hazardous waste at any time;
or generates 1 kg or less of acutely hazardous waste per calendar
month, and accumulates at any time: 1 kg or less of acutely hazardous
waste; or 100 kg or less of any residue or contaminated soil, waste or
other debris resulting from the cleanup of a spill, into or on any
land or water, of acutely hazardous waste; or generates 100 kg or less
of any residue or contaminated soil, waste or other debris resulting
from the cleanup of a spill, into or on any land or water, of acutely
hazardous waste during any calendar month, and accumulates at any
time: 1 kg or less of acutely hazardous waste; or 100 kg or less of
any residue or contaminated soil, waste or other debris resulting from
the cleanup of a spill, into or on any land or water, of acutely
hazardous waste
Owner/Operator Summary:
Owner/operator name: JOHN G PICEU
Owner/operator address: Not reported
Not reported
Owner/operator country: Not reported
Owner/operator telephone: Not reported
Owner/operator email: Not reported
Owner/operator fax: Not reported
Owner/operator extension: Not reported
Legal status: Private
Historical Generators:
Date form received by agency: 04/28/1997
Site name: CADILLAC OIL CO
Classification: Conditionally Exempt Small Quantity Generator
ECHO:
Envid: 1000241423
Registry ID: 110000406711
DFR URL: http://echo.epa.gov/detailed-facility-report?fid=110000406711
Relative: LUST:
Higher Facility ID: 00021873
Source: STATE OF MICHIGAN
Actual: Owner Name: Cadillac Oil Co
625 ft. Owner Address: 13650 Helen St
Owner City,St,Zip: Detroit, MI 48212-2008
Owner Contact: Not reported
Owner Phone: (313) 365-6200
Country: USA
District: Region 1 - SE Michigan District Office
Site Name: Cadillac Oil Co.
Latitude: 42.41692
Longitude: -83.03078
Date of Collection: 01/11/2001
Tank ID: 1
Tank Status: Removed from Ground
Capacity: 6000
Product: Gasoline
Install Date: 10/30/1967
Remove Date: 10/29/1990
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Unknown
Piping Type: Not reported
Construction Material: Asphalt Coated or Bare Steel,Unknown
Impressed Device: No
AST:
Facility ID: 91082187
Facility Phone: (313) 365-6200
Owner Name: CADILLAC OIL
Owner Address: 13650 HELEN ST
Owner City,St,Zip: DETROIT, MI 48212-2008
Owner County: Not reported
Owner Contact: Not reported
Owner Telephone: 3133656200
Relative: US BROWNFIELDS:
Higher Property Name: HANTZ FARMS
Recipient Name: Detroit/Wayne County Port Authority
Actual: Grant Type: Assessment
626 ft. Property Number: Not reported
Parcel size: 4.4
Latitude: 42.421399
Longitude: -83.039541
HCM Label: Not reported
Map Scale: Not reported
Point of Reference: Not reported
Highlights: Not reported
Datum: Not reported
Acres Property ID: 115261
IC Data Access: Not reported
Start Date: Not reported
Redev Completition Date: Not reported
Completed Date: Not reported
Acres Cleaned Up: Not reported
Cleanup Funding: Not reported
Cleanup Funding Source: Not reported
Assessment Funding: 2800
Assessment Funding Source: US EPA - Brownfields Assessment Cooperative Agreement
Redevelopment Funding: Not reported
Redev. Funding Source: Not reported
FINDS:
Relative: INVENTORY:
Higher Bea Number: Not reported
Township: Detroit
Actual: District: Southeast MI
626 ft. Data Source: Part 201
Latitude: 42.4214
Longitude: -83.03954
BEA:
Secondary Address: Not reported
BEA Number: 5433
District: Southeast MI
Date Received: 01/04/2013
Submitter Name: Hantz Farms, LLC
Petition Determination: No Request
Petition Disclosure: 0
Category: Not reported
Determination 20107A: No Request
Reviewer: thorntop
Division Assigned: RRD
Relative: INVENTORY:
Higher Bea Number: 201305433LV
Township: Detroit
Actual: District: Southeast MI
626 ft. Data Source: BEA
Latitude: 42.4214
Longitude: -83.03954
Relative: LUST:
Lower Facility ID: 00015248
Source: STATE OF MICHIGAN
Actual: Owner Name: Eastown Distributors
622 ft. Owner Address: 14400 Oakland St
Owner City,St,Zip: Highland Park, MI 48203-2900
Owner Contact: Not reported
Owner Phone: (313) 867-6900
Country: USA
District: Region 1 - SE Michigan District Office
Site Name: Eastown Distributors
Latitude: 42.41581
Longitude: -83.03128
Date of Collection: 01/11/2001
Method of Collection: Address Matching-House Number
Accuracy: 100
Accuracy Value Unit: FEET
Horizontal Data: NAD83
Point Line Area: POINT
Desc Category: Plant Entrance (Freight)
Tank ID: 2
Tank Status: Removed from Ground
Capacity: 6000
Product: Diesel
Install Date: 04/08/1971
Remove Date: 11/30/1990
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Galvanized Steel
Piping Type: Not reported
Construction Material: Asphalt Coated or Bare Steel
Impressed Device: No
Tank ID: 3
Tank Status: Removed from Ground
Capacity: 6000
Product: Diesel
Install Date: 04/08/1971
Remove Date: 11/30/1990
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Galvanized Steel
Piping Type: Not reported
Construction Material: Asphalt Coated or Bare Steel
Impressed Device: No
Tank ID: 4
Tank Status: Removed from Ground
Capacity: 2000
Product: Not reported
Install Date: 04/07/1956
Remove Date: 09/30/1990
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Galvanized Steel
Piping Type: Not reported
Construction Material: Asphalt Coated or Bare Steel
Impressed Device: No
Tank ID: 5
INVENTORY:
Bea Number: Not reported
Township: Not reported
District: Southeast MI
Data Source: Part 213
Latitude: 42.41582
Longitude: -83.03128
WDS:
Site Id: MIG000024720
WMD Id: 420341
Site Specific Name: NOECKER GROUP
Mailing Address: 13542 HELEN ST
Mailing City/State/Zip: 48212
Mailing County: WAYNE
Relative: BEA:
Higher Secondary Address: Not reported
BEA Number: 2804
Actual: District: Southeast MI
627 ft. Date Received: 06/08/2005
Submitter Name: Fitzgerald Finishing, LLC
Petition Determination: Affirmed
Petition Disclosure: 1
Category: Same Hazardous Substance(s)
Determination 20107A: No Request
Reviewer: williakt
Division Assigned: Environmental Response Division
Relative: INVENTORY:
Higher Bea Number: 200803943LV
Township: Detroit
Actual: District: Southeast MI
625 ft. Data Source: BEA
Latitude: Not reported
Longitude: Not reported
66 BEA S105768324
SSW 13200 MT. ELLIOTT AVE N/A
1/4-1/2 DETROIT, MI
0.299 mi.
1579 ft.
Relative: BEA:
Higher Secondary Address: Not reported
BEA Number: 38
Actual: District: Detroit
625 ft. Date Received: 01/20/2000
Submitter Name: MT. ELLIOT STEEL PRODUCTS, LLC
Petition Determination: No Request
Petition Disclosure: 0
Category: Same Hazardous Substance(s)
Determination 20107A: No Request
Reviewer: temppm
Division Assigned: Environmental Response Division
Relative: LUST:
Higher Facility ID: 00000991
Source: STATE OF MICHIGAN
Actual: Owner Name: Wakay Ind
626 ft. Owner Address: 17403 Mount Elliott St
Owner City,St,Zip: Detroit, MI 48212-1340
Owner Contact: Not reported
Owner Phone: (313) 891-6262
Country: USA
District: Region 1 - SE Michigan District Office
Site Name: Wa-kay Industries
Latitude: 42.42190
Longitude: -83.03867
Date of Collection: 01/11/2001
Method of Collection: Address Matching-House Number
Accuracy: 100
Accuracy Value Unit: FEET
Horizontal Data: NAD83
Point Line Area: POINT
Tank ID: 1
Tank Status: Removed from Ground
Capacity: 2000
Product: Diesel
Install Date: 01/07/1971
Remove Date: 11/18/1998
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Unknown
Piping Type: Not reported
Construction Material: Asphalt Coated or Bare Steel
Impressed Device: No
WDS:
Site Id: MIG000055850
WMD Id: 428474
Site Specific Name: WA/KAY INDUSTRIES
Mailing Address: 17403 MOUNT ELLIOTT ST
Mailing City/State/Zip: 48212
Mailing County: WAYNE
Relative: SEMS:
Higher Site ID: 501388
EPA ID: MIN000501388
Actual: Federal Facility: N
625 ft. NPL: Not on the NPL
Non NPL Status: Removal Only Site (No Site Assessment Work Needed)
Relative: LUST:
Higher Facility ID: 00038115
Source: STATE OF MICHIGAN
Actual: Owner Name: OWNER ADDRESS UNKNOWN
625 ft. Owner Address: Not Recorded
Owner City,St,Zip: Not Recorded, XX 99999
Owner Contact: Not reported
Owner Phone: Not reported
Country: USA
District: Region 1 - SE Michigan District Office
Site Name: Master Petroleum #3
Latitude: 42.38625
Longitude: -83.14013
Date of Collection: 01/11/2001
Method of Collection: Address Matching-House Number
Accuracy: 100
Accuracy Value Unit: FEET
Horizontal Data: NAD83
Point Line Area: POINT
Desc Category: Plant Entrance (Freight)
WDS:
Site Id: MIG000011371
WMD Id: 456760
Site Specific Name: ERINE GULF
Mailing Address: 6717 E DAVISON ST
Mailing City/State/Zip: 48212
Relative: LUST:
Higher Facility ID: 00019117
Source: STATE OF MICHIGAN
Actual: Owner Name: City of Detroit / DPW/CED
626 ft. Owner Address: 65 Cadillac Square Ste 900
Owner City,St,Zip: Detroit, MI 48226
Owner Contact: Not reported
Owner Phone: (313) 224-3822
Country: USA
District: Region 1 - SE Michigan District Office
Site Name: City Of Detroit Fire Dept. Engin
Latitude: 42.42236
Longitude: -83.03869
Date of Collection: 01/11/2001
Method of Collection: Address Matching-House Number
Accuracy: 100
Accuracy Value Unit: FEET
Horizontal Data: NAD83
Point Line Area: POINT
Desc Category: Plant Entrance (Freight)
Tank ID: 1
Relative: LUST:
Higher Facility ID: 00034288
Source: STATE OF MICHIGAN
Actual: Owner Name: Cadillac Overall
630 ft. Owner Address: 6401 E Davison St
Owner City,St,Zip: Detroit, MI 48212-1403
Owner Contact: Not reported
Owner Phone: (313) 366-7700
Country: USA
District: Region 1 - SE Michigan District Office
Site Name: Cadillac Overall (dba)
Latitude: 42.38626
Longitude: -83.13981
Date of Collection: 01/11/2001
Method of Collection: Address Matching-House Number
Accuracy: 100
Accuracy Value Unit: FEET
Horizontal Data: NAD83
Point Line Area: POINT
Desc Category: Plant Entrance (Freight)
Tank ID: 1
Tank Status: Removed from Ground
Capacity: 2000
Product: Gasoline
Install Date: 11/01/1968
Remove Date: 10/13/1998
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Unknown
Piping Type: Not reported
Construction Material: Asphalt Coated or Bare Steel
Impressed Device: No
Tank ID: 2
Tank Status: Removed from Ground
Capacity: 10000
Product: Gasoline
Install Date: 11/01/1968
Remove Date: 10/13/1998
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Unknown
Piping Type: Not reported
Construction Material: Asphalt Coated or Bare Steel
Impressed Device: No
WDS:
Site Id: MIG000055177
WMD Id: 429031
Site Specific Name: CADILLAC OVERALL
Mailing Address: 6401 E DAVISON ST
Mailing City/State/Zip: 48212
Mailing County: WAYNE
Following information
: was gathered from the prior CERCLIS update completed in 10/2013:
Site ID: 0507724
EPA ID: MIT270012107
Facility County: WAYNE
Short Name: AABCO WASTE OIL
Congressional District: 14
IFMS ID: B504
SMSA Number: Not reported
USGC Hydro Unit: Not reported
Federal Facility: Not a Federal Facility
DMNSN Number: 0.00000
Site Orphan Flag: Not reported
RCRA ID: Not reported
USGS Quadrangle: Not reported
Site Init By Prog: S
NFRAP Flag: Not reported
Parent ID: Not reported
RST Code: Not reported
EPA Region: 05
Classification: Not reported
Site Settings Code: Not reported
NPL Status: Not on the NPL
DMNSN Unit Code: Not reported
RBRAC Code: Not reported
RResp Fed Agency Code: Not reported
Non NPL Status: Referred to Removal - NFRAP
Non NPL Status Date: 08/22/03
Site Fips Code: 26163
CC Concurrence Date: / /
CC Concurrence FY: Not reported
Alias EPA ID: Not reported
Site FUDS Flag: Not reported
Owner/Operator Summary:
Owner/operator name: NO ACTIVE O/OP AS NOT GENERATING WASTE
Owner/operator address: Not reported
Not reported
ICIS:
Enforcement Action ID: 05-2000-0581
FRS ID: 110003718638
Action Name: AABCO WASTE OIL
Facility Name: AABCO WASTE OIL INC
Facility Address: 17400 ST LOUIS RD
DETROIT, MI 48212
Enforcement Action Type: Civil Judicial Action
Facility County: WAYNE
Program System Acronym: CERCLIS
Enforcement Action Forum Desc: Judicial
EA Type Code: CIV
Facility SIC Code: Not reported
Federal Facility ID: Not reported
Latitude in Decimal Degrees: 42.42168
Longitude in Decimal Degrees: -83.03976
Permit Type Desc: Not reported
Program System Acronym: MIT270012107
Facility NAICS Code: Not reported
Tribal Land Code: Not reported
CONSENT:
EPA ID: MIT270012107
Site ID: Not reported
Case Title: U.S. V. ITT HIGBIE MANUFACTURING COMPANY, ET AL. (AABCO WASTE OIL,
INC.)
Court Num: 02-74727
District: Michigan, East
Entered Date: 20030729
Full-text of the consent decree for this site issued by the United
States District Court is available from EDR. Contact your EDR Account
Executive.
FINDS:
ECHO:
Envid: 1000178241
Registry ID: 110003718638
DFR URL: http://echo.epa.gov/detailed-facility-report?fid=110003718638
Owner/Operator Summary:
Owner/operator name: ALBERT CASSENS
Owner/operator address: Not reported
Not reported
Owner/operator country: Not reported
Owner/operator telephone: Not reported
Owner/operator email: Not reported
Owner/operator fax: Not reported
Owner/operator extension: Not reported
Legal status: Private
Owner/Operator Type: Operator
Owner/Op start date: 08/01/1977
Owner/Op end date: Not reported
Historical Generators:
Date form received by agency: 03/08/2007
Site name: CASSENS TRANSPORT CO
Classification: Conditionally Exempt Small Quantity Generator
Tank ID: 1
Tank Status: Removed from Ground
Capacity: 15000
Product: Diesel
Install Date: 03/26/1976
Remove Date: 12/01/1997
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Tank ID: 2
Tank Status: Removed from Ground
Capacity: 15000
Product: Diesel
Install Date: 03/26/1975
Remove Date: 12/01/1997
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Galvanized Steel
Piping Type: Not reported
Construction Material: Fiberglass Reinforced plastic
Impressed Device: No
Tank ID: 3
Tank Status: Removed from Ground
Capacity: 9000
Product: Gasoline
Install Date: 03/26/1976
Remove Date: 12/01/1997
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Galvanized Steel
Piping Type: Not reported
Construction Material: Fiberglass Reinforced plastic
Impressed Device: No
Tank ID: 4
Tank Status: Removed from Ground
Capacity: 8000
Product: NEW OIL
Install Date: 01/01/1975
Remove Date: 07/01/1989
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Galvanized Steel
Piping Type: Not reported
Construction Material: Asphalt Coated or Bare Steel
Impressed Device: No
Tank ID: 5
Tank Status: Removed from Ground
Capacity: 1000
Product: Used Oil
Install Date: 01/01/1975
Remove Date: 12/01/1998
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Galvanized Steel
Tank ID: 6
Tank Status: Removed from Ground
Capacity: 8000
Product: NEW/OIL
Install Date: 03/26/1985
Remove Date: 12/01/1997
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Galvanized Steel
Piping Type: Not reported
Construction Material: Asphalt Coated or Bare Steel
Impressed Device: No
Tank ID: 7
Tank Status: Removed from Ground
Capacity: 500
Product: Used Oil
Install Date: 01/01/1940
Remove Date: 01/01/1989
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Unknown
Piping Type: Not reported
Construction Material: Unknown
Impressed Device: No
Tank ID: 9
Tank Status: Currently In Use
Capacity: 15000
Product: Diesel
Install Date: 12/01/1997
Remove Date: Not reported
Tank Release Detection: Automatic Tank Gauging,Inter Monitoring Double Walled Tank,Inter
Monitoring/Second Containment
Pipe Realease Detection: Interstitial Monitoring/Second Containment
Piping Material: Double Walled
Piping Type: Pressure
Construction Material: Fiberglass Reinforced plastic
Impressed Device: No
Tank ID: 10
Tank Status: Currently In Use
Capacity: 15000
Product: Diesel
Install Date: 12/01/1997
Remove Date: Not reported
Tank Release Detection: Automatic Tank Gauging,Inter Monitoring Double Walled Tank,Inter
Monitoring/Second Containment
Pipe Realease Detection: Interstitial Monitoring/Second Containment
Tank ID: 11
Tank Status: Currently In Use
Capacity: 11000
Product: Used Oil
Install Date: 12/01/1997
Remove Date: Not reported
Tank Release Detection: Automatic Tank Gauging,Inter Monitoring Double Walled Tank,Inter
Monitoring/Second Containment
Pipe Realease Detection: Interstitial Monitoring/Second Containment
Piping Material: Double Walled
Piping Type: Suction: Valve at Tank
Construction Material: Fiberglass Reinforced plastic
Impressed Device: No
PEAS:
Incident Date: 08/05/2003
Office Status: Not reported
Initials of Incoming Operator: Not reported
Time Received by DNRE Staff: Not reported
Time Occur: Not reported
Date Of PEAS Call: 08/06/2003
Complainant / Company: Lenny Larson w/ Cassens Transport
Complainant Address: 13475 Eldon
Company Involved: Cassens Transport
DEQ Division Involved: Surface Water
Incident Description: the rain, went into oil drain into holding tank 850 gallons, pushed
oil outof tank onto the street into the sewersRained last night, has 2
svc pits they both filled to top with water from
Description: Not reported
Date Discovered: Not reported
Time Discovered: Not reported
Office/After Hours: Not reported
Party Involved - Phone 1: Not reported
Party Involved - Phone 2: Not reported
Ongoing?: Not reported
Release Secured: Not reported
Source: Not reported
FINDS:
ECHO:
Envid: 1000379908
Registry ID: 110003607954
DFR URL: http://echo.epa.gov/detailed-facility-report?fid=110003607954
WDS:
Site Id: MID092460229
WMD Id: 397815
Site Specific Name: CASSENS TRANSPORT CO
Mailing Address: 13475 ELDON ST
Mailing City/State/Zip: 48234
Mailing County: WAYNE
Relative: LUST:
Higher Facility ID: 00003719
Source: STATE OF MICHIGAN
Actual: Owner Name: Hare Leasing Inc
625 ft. Owner Address: 7400 E Mcnichols Rd
Owner City,St,Zip: Detroit, MI 48234-3935
Owner Contact: Not reported
Owner Phone: (313) 365-7404
Country: USA
District: Region 1 - SE Michigan District Office
Site Name: Hare Cartage
Latitude: 42.41929
Longitude: -83.02662
Date of Collection: 01/11/2001
Method of Collection: Address Matching-House Number
Accuracy: 100
Accuracy Value Unit: FEET
Horizontal Data: NAD83
Tank ID: 1
Tank Status: Removed from Ground
Capacity: 12000
Product: Diesel
Install Date: 04/18/1969
Remove Date: 10/18/1991
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Unknown
Piping Type: Not reported
Construction Material: Asphalt Coated or Bare Steel
Impressed Device: No
INVENTORY:
Bea Number: Not reported
Township: Not reported
District: Southeast MI
Data Source: Part 213
Latitude: 42.41929
Longitude: -83.02663
WDS:
Site Id: MIG000037142
WMD Id: 444753
Site Specific Name: MITCHS AUTO CARE
Mailing Address: 7400 E MCNICHOLS RD
Following information
: was gathered from the prior CERCLIS update completed in 10/2013:
Site ID: 0502666
Federal Facility: Not a Federal Facility
NPL Status: Not on the NPL
Non NPL Status: NFRAP-Site does not qualify for the NPL based on existing information
Program Priority:
Description: Great Lakes
Action: DISCOVERY
Date Started: / /
Date Completed: 10/28/85
Priority Level: Not reported
Action: REMOVAL
Date Started: 05/08/90
Date Completed: 05/29/90
Priority Level: Cleaned up
Action: REMOVAL
Date Started: 08/06/87
Date Completed: 12/31/87
Priority Level: Stabilized
PART 201:
Facility ID: 82000045
Facility Status: Interim Response in progress
Source: Not reported
SAM Score: 33
SAM Score Date: 09/03/1991
Township: 01S
Range: 11E
Section: 16
Quarter: NW
Quarter/Quarter: NW
Pollutants: Cd; CN; Pb
INVENTORY:
Bea Number: Not reported
Township: Detroit
District: Southeast MI
Data Source: Part 201
Latitude: 42.41973
Longitude: -83.04201
Owner/Operator Summary:
Owner/operator name: NO ACTIVE O/OP AS NOT GENERATING WASTE
Owner/operator address: Not reported
Not reported
Owner/operator country: Not reported
Owner/operator telephone: Not reported
Owner/operator email: Not reported
Owner/operator fax: Not reported
Owner/operator extension: Not reported
Legal status: Private
Owner/Operator Type: Operator
Owner/Op start date: 08/01/2006
Owner/Op end date: Not reported
Historical Generators:
Date form received by agency: 07/08/1981
Site name: PLATING EQUIPMENT USEPA
Classification: Not a generator, verified
ECHO:
Envid: 1000413248
Registry ID: 110003607188
DFR URL: http://echo.epa.gov/detailed-facility-report?fid=110003607188
WDS:
Site Id: MID088334537
WMD Id: 397702
Site Specific Name: PLATING EQUIPMENT USEPA
Mailing Address: 17210 GABLE ST
Mailing City/State/Zip: 48212
Mailing County: WAYNE
Relative: LUST:
Higher Facility ID: 00017706
Source: STATE OF MICHIGAN
Actual: Owner Name: Freds Arco
628 ft. Owner Address: C/O HUBERT WARF 5930 E MCNICHOLS
Owner City,St,Zip: DETROIT, MI 48212
Owner Contact: Not reported
Owner Phone: (313) 893-8776
Country: USA
District: Region 1 - SE Michigan District Office
Site Name: D & H Auto Parts
Latitude: 42.41898
Longitude: -83.04248
Date of Collection: 01/11/2001
Method of Collection: Address Matching-House Number
Accuracy: 100
Accuracy Value Unit: FEET
Horizontal Data: NAD83
Tank ID: 1
Tank Status: Removed from Ground
Capacity: 6000
Product: Gasoline
Install Date: 04/28/1977
Remove Date: 06/01/1990
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Galvanized Steel
Piping Type: Not reported
Construction Material: Asphalt Coated or Bare Steel,Lined Interier
Impressed Device: No
Tank ID: 2
Tank Status: Removed from Ground
Capacity: 6000
Product: Gasoline
Install Date: 04/28/1977
Remove Date: 06/01/1990
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Galvanized Steel
Piping Type: Not reported
Construction Material: Asphalt Coated or Bare Steel,Lined Interier
Impressed Device: No
Tank ID: 4
Tank Status: Removed from Ground
Capacity: 6000
Product: Gasoline
Install Date: 04/28/1977
Remove Date: 06/01/1990
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Galvanized Steel
Piping Type: Not reported
Construction Material: Asphalt Coated or Bare Steel,Lined Interier
Impressed Device: No
Tank ID: 5
Tank Status: Removed from Ground
Capacity: 300
Product: Used Oil
Install Date: 04/29/1971
Remove Date: 06/01/1990
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Galvanized Steel
Piping Type: Not reported
Construction Material: Asphalt Coated or Bare Steel
Impressed Device: No
WDS:
Site Id: MIG000025613
WMD Id: 450180
Site Specific Name: D & H AUTO
Mailing Address: 5930 E MCNICHOLS RD
Mailing City/State/Zip: 48212
Mailing County: WAYNE
Relative: SWRCY:
Higher SR No: 23
Contact Phone1: 313-366-6311
Actual: EMail: Not reported
625 ft. Website: Not reported
Location Description: 520 miles away
Materials Accepted: Aluminum Cans, Copper/Brass/Bronze, Electronics, Iron, Office
Equipment/Furniture, Stainless Steel, White Goods, Metal Drums or
Barrels
Services: Broker, Collector, Hauler, Processor
Collection: Drop off, Pick up
Service Area: Macomb County, Oakland County, Wexford County
Notes: Not reported
SWRCY:
SR No 2: 23
Material: Metals - Iron
Service: Hauler
Drop Off/Pick Up: Pick-up
Minimum Quantity: None
Unit: None
Service Area: ALLEGAN, BARRY, IONIA, KALAMAZOO, KENT, MUSKEGON, OTTAWA
SR No 2: 23
Material: Metals - Stainless Steel
Service: Hauler
Drop Off/Pick Up: Pick-up
Minimum Quantity: None
Unit: None
Service Area: ALLEGAN, BARRY, IONIA, KALAMAZOO, KENT, MUSKEGON, OTTAWA
SR No 2: 23
Material: P, W & YW - Concrete/Asphalt
Service: Hauler
Drop Off/Pick Up: Pick-up
Minimum Quantity: None
Unit: None
Service Area: ALLEGAN, BARRY, IONIA, KALAMAZOO, KENT, MUSKEGON, OTTAWA
SR No 2: 23
Material: P, W & YW - Construction Materials
Service: Hauler
Drop Off/Pick Up: Pick-up
Minimum Quantity: None
Unit: None
Service Area: ALLEGAN, BARRY, IONIA, KALAMAZOO, KENT, MUSKEGON, OTTAWA
SR No 2: 23
Material: P, W & YW - Demolition Debris
Service: Hauler
Drop Off/Pick Up: Pick-up
Minimum Quantity: None
Unit: None
Service Area: ALLEGAN, BARRY, IONIA, KALAMAZOO, KENT, MUSKEGON, OTTAWA
SR No 2: 23
Material: P, W & YW - Pallets
Service: Hauler
Drop Off/Pick Up: Pick-up
Minimum Quantity: None
Unit: None
Service Area: ALLEGAN, BARRY, IONIA, KALAMAZOO, KENT, MUSKEGON, OTTAWA
SR No 2: 23
Material: P, W & YW - Sawdust
Service: Hauler
Drop Off/Pick Up: Pick-up
Minimum Quantity: None
Unit: None
Service Area: ALLEGAN, BARRY, IONIA, KALAMAZOO, KENT, MUSKEGON, OTTAWA
SR No 2: 23
Material: P, W & YW - Scrap Lumber
Service: Hauler
Drop Off/Pick Up: Pick-up
Minimum Quantity: None
Unit: None
Service Area: ALLEGAN, BARRY, IONIA, KALAMAZOO, KENT, MUSKEGON, OTTAWA
SR No 2: 23
Material: Paper - OCC/Corrugated Containers
Service: Hauler
Drop Off/Pick Up: Pick-up
Minimum Quantity: None
Unit: None
Service Area: ALLEGAN, BARRY, IONIA, KALAMAZOO, KENT, MUSKEGON, OTTAWA
Relative: LUST:
Higher Facility ID: 50005754
Source: STATE OF MICHIGAN
Actual: Owner Name: Nortown Community Development
628 ft. Owner Address: PO Box 34102
Owner City,St,Zip: Detroit, MI 48234
Owner Contact: Not reported
Owner Phone: Not reported
Country: USA
District: Region 1 - SE Michigan District Office
Site Name: Former Arnold Tool
BEA:
Secondary Address: Not reported
BEA Number: 2556
District: Southeast MI
Date Received: 10/29/2004
Submitter Name: Nortown Community Development
Petition Determination: No Request
Petition Disclosure: 0
Category: No Hazardous Substance(s)
Determination 20107A: No Request
Reviewer: novake
Division Assigned: Environmental Response Division
Relative: INVENTORY:
Higher Bea Number: Not reported
Township: Detroit
Actual: District: Southeast MI
627 ft. Data Source: Part 201
Latitude: 42.42437
Longitude: -83.03805
WDS:
Site Id: MIK119363653
WMD Id: 482741
Site Specific Name: FORMER ARNOLD TOOL BUILDING
Mailing Address: PO BOX 34102
Mailing City/State/Zip: 48234
Relative: INVENTORY:
Higher Bea Number: Not reported
Township: Detroit
Actual: District: Southeast MI
628 ft. Data Source: Part 201
Latitude: 42.42462
Longitude: -83.03808
Relative: BROWNFIELDS:
Higher Facility ID: Not reported
Region: 1
Actual: Status: Not reported
625 ft. Properry Use: vacant
BEA: No
Ernie Id Number: 82001630
PART 201:
Facility ID: 82001630
Facility Status: Interim Response conducted - No further activities anticipated
Source: Lumber & Wood Products
SAM Score: 23
SAM Score Date: 11/09/2006
Township: Not reported
Range: Not reported
Section: Not reported
Quarter: Not reported
Quarter/Quarter: Not reported
Pollutants: Not reported
INVENTORY:
Bea Number: Not reported
Township: Detroit
District: Southeast MI
Data Source: Part 201
Latitude: 42.42275
Longitude: -83.02656
WDS:
Site Id: MIK317738755
WMD Id: 463767
Site Specific Name: MI DEPT/NATURAL RESOURCES AND ENVIRONMENT
Relative: INVENTORY:
Higher Bea Number: Not reported
Township: Detroit
Actual: District: Southeast MI
627 ft. Data Source: Part 201
Latitude: 42.42449
Longitude: -83.03887
Relative: LUST:
Higher Facility ID: 50005685
Source: STATE OF MICHIGAN
Actual: Owner Name: City of Detroit
627 ft. Owner Address: Real Estate Division 150 Michigan AVe
Owner City,St,Zip: Detroit, MI 48226
Owner Contact: Not reported
Owner Phone: (313) 224-6514
Country: USA
District: Region 1 - SE Michigan District Office
Site Name: Former Gas Station
Latitude: 42.42465
Longitude: -83.03888
Date of Collection: 03/04/2014
Method of Collection: Interpolation-Photo
Accuracy: 10
Accuracy Value Unit: FEET
Horizontal Data: NAD83
Point Line Area: POINT
Desc Category: Plant Entrance (Freight)
Relative: SEMS-ARCHIVE:
Higher Site ID: 502969
EPA ID: MID980679641
Actual: Federal Facility: N
626 ft. NPL: Not on the NPL
Non NPL Status: NFRAP-Site does not qualify for the NPL based on existing information
Following information
: was gathered from the prior CERCLIS update completed in 10/2013:
Site ID: 0502969
Federal Facility: Not a Federal Facility
NPL Status: Not on the NPL
Non NPL Status: NFRAP-Site does not qualify for the NPL based on existing information
Program Priority:
Description: Great Lakes
INVENTORY:
Bea Number: Not reported
Township: Hamtramck
District: Southeast MI
Data Source: Part 201
Latitude: 42.42263
PART 201:
Facility ID: 82000041
Facility Status: Interim Response in progress
Source: Petroleum Refining
SAM Score: 23
SAM Score Date: 09/27/1990
Township: 01S
Range: 12E
Section: 9
Quarter: SW
Quarter/Quarter: SW
Pollutants: Pb; Oil
Relative: BEA:
Higher Secondary Address: Not reported
BEA Number: 1824
Actual: District: Southeast MI
625 ft. Date Received: 09/19/2002
Submitter Name: Repair Industries of Michigan
Petition Determination: No Request
Petition Disclosure: 0
Category: No Hazardous Substance(s)
Determination 20107A: No Request
Reviewer: williakt
Division Assigned: Environmental Response Division
WDS:
Site Id: MIG000033643
WMD Id: 446489
Site Specific Name: J FONS CO
Mailing Address: 6490 NEVADA ST
Mailing City/State/Zip: 48234
Mailing County: WAYNE
Relative: LUST:
Higher Facility ID: 00036361
Source: STATE OF MICHIGAN
Actual: Owner Name: J. Fons Co
625 ft. Owner Address: 6451 E Mcnichols Rd
Owner City,St,Zip: Detroit, MI 48212-2025
Owner Contact: Not reported
Tank ID: 1
Tank Status: Removed from Ground
Capacity: Not reported
Product: Diesel
Install Date: Not reported
Remove Date: 09/23/1992
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Unknown
Piping Type: Not reported
Construction Material: Unknown
Impressed Device: No
Tank ID: 2
Tank Status: Removed from Ground
Tank ID: 3
Tank Status: Removed from Ground
Capacity: Not reported
Product: Diesel
Install Date: Not reported
Remove Date: 09/23/1992
Tank Release Detection: Not reported
Pipe Realease Detection: Not reported
Piping Material: Unknown
Piping Type: Not reported
Construction Material: Unknown
Impressed Device: No
INVENTORY:
Bea Number: Not reported
Township: Not reported
District: Southeast MI
Data Source: Part 213
Latitude: 42.42633
Longitude: -83.03577
Relative: INVENTORY:
Higher Bea Number: 200201824LV
Township: Detroit
Actual: District: Southeast MI
625 ft. Data Source: BEA
Latitude: Not reported
Longitude: Not reported
INVENTORY:
Bea Number: Not reported
Township: Detroit
District: Southeast MI
Data Source: Part 201
Latitude: 42.4316
Longitude: -83.03479
WDS:
Site Id: MIR000002444
WMD Id: 409532
Site Specific Name: ALRO STEEL DT PLANT
Mailing Address: 18695 SHERWOOD AVE
Mailing City/State/Zip: 48234
Mailing County: WAYNE
DETROIT S115659608 MCNICHOLS E SOUTH SECTOR 1450 E. MCNICHOLS AT I-75(SOUT RGA PART 201
To maintain currency of the following federal and state databases, EDR contacts the appropriate governmental agency
on a monthly or quarterly basis, as required.
Number of Days to Update: Provides confirmation that EDR is reporting records that have been updated within 90 days
from the date the government agency made the information available to the public.
SEMS-ARCHIVE (Superfund Enterprise Management System Archive) tracks sites that have no further interest under
the Federal Superfund Program based on available information. The list was formerly known as the CERCLIS-NFRAP,
renamed to SEMS ARCHIVE by the EPA in 2015. EPA may perform a minimal level of assessment work at a site while
it is archived if site conditions change and/or new information becomes available. Archived sites have been removed
and archived from the inventory of SEMS sites. Archived status indicates that, to the best of EPA’s knowledge,
assessment at a site has been completed and that EPA has determined no further steps will be taken to list the
site on the National Priorities List (NPL), unless information indicates this decision was not appropriate or
other considerations require a recommendation for listing at a later time. The decision does not necessarily mean
that there is no hazard associated with a given site; it only means that. based upon available information, the
location is not judged to be potential NPL site.
Date of Government Version: 07/11/2017 Source: EPA
Date Data Arrived at EDR: 07/28/2017 Telephone: 800-424-9346
Date Made Active in Reports: 10/06/2017 Last EDR Contact: 11/03/2017
Number of Days to Update: 70 Next Scheduled EDR Contact: 01/29/2018
Data Release Frequency: Quarterly
SHWS: This state does not maintain a SHWS list. See the Federal CERCLIS list and Federal NPL list.
This state does not maintain a SHWS list. See the Federal CERCLIS list and Federal NPL list.
Date of Government Version: N/A Source: Dept of Environmental Quality
Date Data Arrived at EDR: 10/31/2013 Telephone: 517-284-5103
Date Made Active in Reports: 11/20/2013 Last EDR Contact: 10/20/2017
Number of Days to Update: 20 Next Scheduled EDR Contact: 02/05/2018
Data Release Frequency: No Update Planned
State and tribal landfill and/or solid waste disposal site lists
FTTS: FIFRA/ TSCA Tracking System - FIFRA (Federal Insecticide, Fungicide, & Rodenticide Act)/TSCA (Toxic Substances Control Act)
FTTS tracks administrative cases and pesticide enforcement actions and compliance activities related to FIFRA,
TSCA and EPCRA (Emergency Planning and Community Right-to-Know Act). To maintain currency, EDR contacts the
Agency on a quarterly basis.
Date of Government Version: 04/09/2009 Source: EPA/Office of Prevention, Pesticides and Toxic Substances
Date Data Arrived at EDR: 04/16/2009 Telephone: 202-566-1667
Date Made Active in Reports: 05/11/2009 Last EDR Contact: 08/18/2017
Number of Days to Update: 25 Next Scheduled EDR Contact: 12/04/2017
Data Release Frequency: Quarterly
FTTS INSP: FIFRA/ TSCA Tracking System - FIFRA (Federal Insecticide, Fungicide, & Rodenticide Act)/TSCA (Toxic Substances Control Act)
A listing of FIFRA/TSCA Tracking System (FTTS) inspections and enforcements.
Date of Government Version: 04/09/2009 Source: EPA
Date Data Arrived at EDR: 04/16/2009 Telephone: 202-566-1667
Date Made Active in Reports: 05/11/2009 Last EDR Contact: 08/18/2017
Number of Days to Update: 25 Next Scheduled EDR Contact: 12/04/2017
Data Release Frequency: Quarterly
HIST FTTS INSP: FIFRA/TSCA Tracking System Inspection & Enforcement Case Listing
A complete inspection and enforcement case listing from the FIFRA/TSCA Tracking System (FTTS) for all ten EPA
regions. The information was obtained from the National Compliance Database (NCDB). NCDB supports the implementation
of FIFRA (Federal Insecticide, Fungicide, and Rodenticide Act) and TSCA (Toxic Substances Control Act). Some
EPA regions are now closing out records. Because of that, and the fact that some EPA regions are not providing
EPA Headquarters with updated records, it was decided to create a HIST FTTS database. It included records that
may not be included in the newer FTTS database updates. This database is no longer updated.
RGA PART 201: Recovered Government Archive State Hazardous Waste Facilities List
The EDR Recovered Government Archive State Hazardous Waste database provides a list of SHWS incidents derived
from historical databases and includes many records that no longer appear in current government lists. Compiled
from Records formerly available from the Department of Environmental Quality in Michigan.
Date of Government Version: N/A Source: Department of Environmental Quality
Date Data Arrived at EDR: 07/01/2013 Telephone: N/A
Date Made Active in Reports: 12/24/2013 Last EDR Contact: 06/01/2012
Number of Days to Update: 176 Next Scheduled EDR Contact: N/A
Data Release Frequency: Varies
OTHER DATABASE(S)
Depending on the geographic area covered by this report, the data provided in these specialty databases may or may not be
complete. For example, the existence of wetlands information data in a specific report does not mean that all wetlands in the
area covered by the report are included. Moreover, the absence of any reported wetlands information does not necessarily
mean that wetlands do not exist in the area covered by the report.
Oil/Gas Pipelines
Source: PennWell Corporation
Petroleum Bundle (Crude Oil, Refined Products, Petrochemicals, Gas Liquids (LPG/NGL), and Specialty
Gases (Miscellaneous)) N = Natural Gas Bundle (Natural Gas, Gas Liquids (LPG/NGL), and Specialty Gases
(Miscellaneous)). This map includes information copyrighted by PennWell Corporation. This information
is provided on a best effort basis and PennWell Corporation does not guarantee its accuracy nor warrant
its fitness for any particular purpose. Such information has been reprinted with the permission of PennWell.
Sensitive Receptors: There are individuals deemed sensitive receptors due to their fragile immune systems and special sensitivity
to environmental discharges. These sensitive receptors typically include the elderly, the sick, and children. While the location of all
sensitive receptors cannot be determined, EDR indicates those buildings and facilities - schools, daycares, hospitals, medical centers,
and nursing homes - where individuals who are sensitive receptors are likely to be located.
AHA Hospitals:
Source: American Hospital Association, Inc.
Telephone: 312-280-5991
The database includes a listing of hospitals based on the American Hospital Association’s annual survey of hospitals.
Medical Centers: Provider of Services Listing
Source: Centers for Medicare & Medicaid Services
Telephone: 410-786-3000
A listing of hospitals with Medicare provider number, produced by Centers of Medicare & Medicaid Services,
a federal agency within the U.S. Department of Health and Human Services.
Nursing Homes
Source: National Institutes of Health
Telephone: 301-594-6248
Information on Medicare and Medicaid certified nursing homes in the United States.
Public Schools
Source: National Center for Education Statistics
Telephone: 202-502-7300
The National Center for Education Statistics’ primary database on elementary
and secondary public education in the United States. It is a comprehensive, annual, national statistical
database of all public elementary and secondary schools and school districts, which contains data that are
comparable across all states.
Private Schools
Source: National Center for Education Statistics
Telephone: 202-502-7300
The National Center for Education Statistics’ primary database on private school locations in the United States.
Daycare Centers: Day Care Centers, Group & Family Homes
Source: Bureau of REgulatory Services
Telephone: 517-373-8300
Flood Zone Data: This data was obtained from the Federal Emergency Management Agency (FEMA). It depicts 100-year and
500-year flood zones as defined by FEMA. It includes the National Flood Hazard Layer (NFHL) which incorporates Flood
Insurance Rate Map (FIRM) data and Q3 data from FEMA in areas not covered by NFHL.
Source: FEMA
Telephone: 877-336-2627
Date of Government Version: 2003, 2015
NWI: National Wetlands Inventory. This data, available in select counties across the country, was obtained by EDR
in 2002, 2005 and 2010 from the U.S. Fish and Wildlife Service.
© 2015 TomTom North America, Inc. All rights reserved. This material is proprietary and the subject of copyright protection
and other intellectual property rights owned by or licensed to Tele Atlas North America, Inc. The use of this material is subject
to the terms of a license agreement. You will be held liable for any unauthorized copying or disclosure of this material.
EDR’s GeoCheck Physical Setting Source Addendum is provided to assist the environmental professional in
forming an opinion about the impact of potential contaminant migration.
Assessment of the impact of contaminant migration generally has two principal investigative components:
Groundwater flow direction may be impacted by surface topography, hydrology, hydrogeology, characteristics
of the soil, and nearby wells. Groundwater flow velocity is generally impacted by the nature of the
geologic strata.
TOPOGRAPHIC INFORMATION
Surface topography may be indicative of the direction of surficial groundwater flow. This information can be used to
assist the environmental professional in forming an opinion about the impact of nearby contaminated properties or,
should contamination exist on the target property, what downgradient sites might be impacted.
626
625
625
625
625
625
625
625
625
625
625
625
625
625
625
624
624
624
623
North South
TP
Elevation (ft)
630
630
629
629
629
628
628
627
627
625
625
625
625
625
624
623
622
620
620
West East
TP
✩ 0 1/2 1 Miles
Target Property Elevation: 625 ft.
Source: Topography has been determined from the USGS 7.5’ Digital Elevation Model and should be evaluated
on a relative (not an absolute) basis. Relative elevation information between sites of close proximity
should be field verified.
HYDROLOGIC INFORMATION
Surface water can act as a hydrologic barrier to groundwater flow. Such hydrologic information can be used to assist
the environmental professional in forming an opinion about the impact of nearby contaminated properties or, should
contamination exist on the target property, what downgradient sites might be impacted.
Refer to the Physical Setting Source Map following this summary for hydrologic information (major waterways
and bodies of water).
HYDROGEOLOGIC INFORMATION
Hydrogeologic information obtained by installation of wells on a specific site can often be an indicator
of groundwater flow direction in the immediate area. Such hydrogeologic information can be used to assist the
environmental professional in forming an opinion about the impact of nearby contaminated properties or, should
contamination exist on the target property, what downgradient sites might be impacted.
AQUIFLOW®
Search Radius: 1.000 Mile.
EDR has developed the AQUIFLOW Information System to provide data on the general direction of groundwater
flow at specific points. EDR has reviewed reports submitted by environmental professionals to regulatory
authorities at select sites and has extracted the date of the report, groundwater flow direction as determined
hydrogeologically, and the depth to water table.
* ©1996 Site−specific hydrogeological data gathered by CERCLIS Alerts, Inc., Bainbridge Island, WA. All rights reserved. All of the information and opinions presented are those of the cited EPA report(s), which were completed under
a Comprehensive Environmental Response Compensation and Liability Information System (CERCLIS) investigation.
TC5128345.2s Page A-3
GEOCHECK® - PHYSICAL SETTING SOURCE SUMMARY
Geologic Age and Rock Stratigraphic Unit Source: P.G. Schruben, R.E. Arndt and W.J. Bawiec, Geology
of the Conterminous U.S. at 1:2,500,000 Scale - a digital representation of the 1974 P.B. King and H.M. Beikman
Map, USGS Digital Data Series DDS - 11 (1994).
The U.S. Department of Agriculture’s (USDA) Soil Conservation Service (SCS) leads the National Cooperative Soil
Survey (NCSS) and is responsible for collecting, storing, maintaining and distributing soil survey information
for privately owned lands in the United States. A soil map in a soil survey is a representation of soil patterns
in a landscape. Soil maps for STATSGO are compiled by generalizing more detailed (SSURGO) soil survey maps.
The following information is based on Soil Conservation Service STATSGO data.
Hydric Status: Soil does not meet the requirements for a hydric soil.
Boundary Classification
Layer Upper Lower Soil Texture Class AASHTO Group Unified Soil Permeability Soil Reaction
Rate (in/hr) (pH)
1 0 inches 60 inches variable Not reported Not reported Max: 0.00 Max: 0.00
Min: 0.00 Min: 0.00
Based on Soil Conservation Service STATSGO data, the following additional subordinant soil types may
appear within the general area of target property.
EDR Local/Regional Water Agency records provide water well information to assist the environmental
professional in assessing sources that may impact ground water flow direction, and in forming an
opinion about the impact of contaminant migration on nearby drinking water wells.
Note: PWS System location is not always the same as well location.
EDR Inc.
GEOCHECK ® - PHYSICAL SETTING SOURCE MAP FINDINGS
Map ID
Direction
Distance
Elevation Database EDR ID Number
Living Area - 1st Floor Not Reported Not Reported Not Reported Not Reported
Living Area - 2nd Floor Not Reported Not Reported Not Reported Not Reported
Basement 0.667 pCi/L 100% 0% 0%
TOPOGRAPHIC INFORMATION
HYDROLOGIC INFORMATION
Flood Zone Data: This data was obtained from the Federal Emergency Management Agency (FEMA). It depicts 100-year and
500-year flood zones as defined by FEMA. It includes the National Flood Hazard Layer (NFHL) which incorporates Flood
Insurance Rate Map (FIRM) data and Q3 data from FEMA in areas not covered by NFHL.
Source: FEMA
Telephone: 877-336-2627
Date of Government Version: 2003, 2015
NWI: National Wetlands Inventory. This data, available in select counties across the country, was obtained by EDR
in 2002, 2005 and 2010 from the U.S. Fish and Wildlife Service.
HYDROGEOLOGIC INFORMATION
GEOLOGIC INFORMATION
STATE RECORDS
RADON
OTHER
Earthquake Fault Lines: The fault lines displayed on EDR’s Topographic map are digitized quaternary faultlines, prepared
in 1975 by the United State Geological Survey
STREET AND ADDRESS INFORMATION
© 2015 TomTom North America, Inc. All rights reserved. This material is proprietary and the subject of copyright protection
and other intellectual property rights owned by or licensed to Tele Atlas North America, Inc. The use of this material is subject
to the terms of a license agreement. You will be held liable for any unauthorized copying or disclosure of this material.
Copyright 2002
F93D-4A73-802D
5128345 - 3 page 8
Certified Sanborn® Map 1998
Site Name: 6556 E. Mcnichols Property
Copyright 1998
F93D-4A73-802D
5128345 - 3 page 9
Certified Sanborn® Map 1993
Site Name: 6556 E. Mcnichols Property
Copyright 1993
F93D-4A73-802D
5128345 - 3 page 10
Certified Sanborn® Map 1990
Site Name: 6556 E. Mcnichols Property
Copyright 1990
F93D-4A73-802D
5128345 - 3 page 11
Certified Sanborn® Map 1987
Site Name: 6556 E. Mcnichols Property
Copyright 1987
F93D-4A73-802D
5128345 - 3 page 12
Certified Sanborn® Map 1984
Site Name: 6556 E. Mcnichols Property
Copyright 1984
F93D-4A73-802D
5128345 - 3 page 13
Certified Sanborn® Map 1977
Site Name: 6556 E. Mcnichols Property
Copyright 1977
F93D-4A73-802D
5128345 - 3 page 15
Certified Sanborn® Map 1961
Site Name: 6556 E. Mcnichols Property
Copyright 1961
F93D-4A73-802D
5128345 - 3 page 17
Certified Sanborn® Map 1957
Site Name: 6556 E. Mcnichols Property
Copyright 1957
F93D-4A73-802D
5128345 - 3 page 18
Certified Sanborn® Map 1951
Site Name: 6556 E. Mcnichols Property
Copyright 1951
F93D-4A73-802D
5128345 - 3 page 20
Certified Sanborn® Map 1949
Site Name: 6556 E. Mcnichols Property
Copyright 1949
F93D-4A73-802D
5128345 - 3 page 22
Certified Sanborn® Map 1940
Site Name: 6556 E. Mcnichols Property
Copyright 1940
F93D-4A73-802D
5128345 - 3 page 23
Certified Sanborn® Map 1933
Site Name: 6556 E. Mcnichols Property
Copyright 1933
F93D-4A73-802D
5128345 - 3 page 24
F
APPENDIX
Owner Questionnaire
APPENDIX
Resume of Environmental
Professionals
G
// Resumes
Ashley P. Lesser, P.E., LEED AP (BD+C)
Project Engineer
Ms. Lesser offers eight years of experience in environmental engineering and consulting,
including project management and field oversight activities. Ms. Lesser has developed
work plans, specifications, and budgetary estimates for a variety of environmental
assessment and remediation projects. Ms. Lesser’s due diligence and site investigation
experience includes preparation of Phase I and II Environmental Site Assessments and
Baseline Environmental Assessments for a variety of properties (including industrial,
gas stations, dry cleaners, and military installations) and transaction types (including
SBA and MSHDA loans). She has also assisted with underground storage tank (UST)
management, site assessments, and leaking UST closures. Ms. Lesser’s environmental
compliance and regulatory experience includes preparation of due care plans, storm
water management plans, and spill prevention plans. She has performed equipment and
safety audits, researched applicable regulations, and documented permit requirements
to assist Fortune 100 retail and utility clients with their compliance programs.
Remediation Services
Provided engineering services in a project involving
remediation of soil and groundwater impacted with
petroleum hydrocarbons at a former gasoline service
station site. Assisted in developing a work plan for
performing pilot studies and a feasibility analysis to
evaluate several corrective action alternatives.
m
m
m
m
m
m
m
m
CANOPY AREA
GIRARDIN STREET
McNICHOLS ROAD (6 MILE ROAD)
LEGEND
N
m
m
m
m
m
m
m
m
m
m
m
m
m
m
m
m
m
m
LOG OF GEOPROBES
DISCRETE SAMPLE INFO.
GROUND
PROBE DEPTH DEPTH (FT.) PID
SURFACE SOIL DESCRIPTION SAMPLE
NO. (FT.) READING
ELEV. NO. FROM TO (PPM)
NOTES:
[1] GEOPROBES BACKFILLED WITH SOIL CUTTINGS AND HYDRATED BENTONITE CHIPS AFTER OBTAINING SOIL AND/OR WATER SAMPLES.
[2] GEOPROBE DRILLING OBSERVED BY H. RILEY OF NTH CONSULTANTS, LTD.
[3] SOIL CLASSIFICATION BASED SOLELY ON VISUAL AND OLFACTORY OBSERVATIONS.
[4] * - SAMPLE SUBMITTED FOR ANALYTICAL TESTING.
DRILLED BY: FIBERTEC ENVIRONMENTAL SERVICES DATE: January 4, 2018 FIGURE NO: 1
LOG OF GEOPROBES
DISCRETE SAMPLE INFO.
GROUND
PROBE DEPTH DEPTH (FT.) PID
SURFACE SOIL DESCRIPTION SAMPLE
NO. (FT.) READING
ELEV. NO. FROM TO (PPM)
NO GROUNDWATER ENCOUNTERED
NOTES:
[1] GEOPROBES BACKFILLED WITH SOIL AND HYDRATED BENTONITE CHIPS AFTER OBTAINING SOIL AND/OR WATER SAMPLES.
[2] GEOPROBE DRILLING OBSERVED BY H. RILEY OF NTH CONSULTANTS, LTD.
[3] SOIL CLASSIFICATION BASED SOLELY ON VISUAL AND OLFACTORY OBSERVATIONS.
[4] * - SAMPLE SUBMITTED FOR ANALYTICAL TESTING.
DRILLED BY: FIBERTEC ENVIRONMENTAL SERVICES DATE: January 4, 2018 FIGURE NO: 1
LOG OF GEOPROBES
DISCRETE SAMPLE INFO.
GROUND
PROBE DEPTH DEPTH (FT.) PID
SURFACE SOIL DESCRIPTION SAMPLE
NO. (FT.) READING
ELEV. NO. FROM TO (PPM)
NO GROUNDWATER ENCOUNTERED
NOTES:
[5] GEOPROBES BACKFILLED WITH SOIL CUTTINGS AND HYDRATED BENTONITE CHIPS AFTER OBTAINING SOIL AND/OR WATER SAMPLES.
[6] GEOPROBE DRILLING OBSERVED BY H. RILEY OF NTH CONSULTANTS, LTD.
[7] SOIL CLASSIFICATION BASED SOLELY ON VISUAL AND OLFACTORY OBSERVATIONS.
[8] * - SAMPLE SUBMITTED FOR ANALYTICAL TESTING.
DRILLED BY: FIBERTEC ENVIRONMENTAL SERVICES DATE: January 4, 2018 FIGURE NO: 1
NO GROUNDWATER ENCOUNTERED
NO GROUNDWATER ENCOUNTERED
NOTES:
[1] HAND AUGER BORINGS BACKFILLED WITH SOIL CUTTINGS AFTER OBTAINING SOIL SAMPLES.
[2] HAND AUGER BORINGS OBSERVED BY H. RILEY OF NTH CONSULTANTS, LTD.
[3] SOIL CLASSIFICATION BASED SOLELY ON VISUAL AND OLFACTORY OBSERVATIONS.
DRILLED BY: FIBERTEC ENVIRONMENTAL SERVICES DATE: January 4, 2018 FIGURE NO: 2
Michigan 10 Metals VOLATILE ORGANIC COMPOUNDS (VOCs) SEMI-VOCs (SVOCS)/ POLYNUCLEAR AROMATICS (PNAs)
Sample Designation
Dibenzo(a,h)anthracene
cis-1,2-Dichloroethylene
1,2,3-Trimethylbenzene
1,2,4-Trimethylbenzene
1,3,5-Trimethylbenzene
Collect Date
Indeno(1,2,3-cd)pyrene
Benzo(b)fluoranthene
Benzo(k)fluoranthene
2-Methylnaphthalene
Benzo(g,h,i)perylene
Benzo(a)anthracene
Tetrachloroethylene
sec-Butylbenzene
Trichloroethylene
Diethyl phthalate
Chromium, Total
Acenaphthylene
Benzo(a)pyrene
n-Butylbenzene
Mercury, Total
Acenaphthene
Phenanthrene
Fluoranthene
Naphthalene
Anthracene
Chrysene
Cadmium
Selenium
Fluorene
Arsenic
Copper
Pyrene
Barium
Silver
Lead
Zinc
7440-38-2 7440-39-3 7440-43-9 7440-47-3 7440-50-8 7439-92-1 7439-97-6 7782-49-2 7440-22-4 7440-66-6 104-51-8 135-98-8 156-59-2 91-57-6 91-20-3 127-18-4 79-01-6 526-73-8 95-63-6 108-67-8 83-32-9 208-96-8 120-12-7 56-55-3 50-32-8 205-99-2 191-24-2 207-08-9 218-01-9 53-70-3 84-66-2 206-44-0 86-73-7 193-39-5 85-01-8 129-00-0
GP-1 S-2 (6' - 7') 01/04/18 18,000 13,000 <50 8,400 1,700 1,200 <50 <200 <100 8,100 <50 <50 <50 <330 <330 <50 <50 <100 <100 <100 <330 <330 <330 <330 <330 <330 <330 <330 <330 <330 ---- <330 <330 <330 <330 <330
GP-2 S-1 (1' - 2') 01/04/18 5,600 64,000 660 13,000 22,000 37,000 <50 300 <100 180,000 <50 <50 <50 460 <330 190 <50 <100 <100 <100 520 <330 1,600 3,300 3,200 4,200 2,200 1,400 3,100 470 ---- 9,700 720 2,000 7,600 8,500
GP-3 S-1 (1' - 2') 01/04/18 18,000 140,000 470 27,000 35,000 220,000 150 1,800 250 180,000 760 210 71 3,200 770 2,000 340 810 1,000 270 <330 1,800 4,800 8,100 6,900 8,700 3,400 3,300 6,900 1,000 ---- 20,000 1,300 3,400 14,000 16,000
GP-4 S-1 (1' - 2') 01/04/18 1,400 17,000 64 4,500 3,200 3,700 <50 <200 <100 11,000 <50 <50 <50 <330 <330 <50 <50 <100 <100 <100 <330 <330 <330 <330 <330 <330 <330 <330 <330 <330 ---- <330 <330 <330 <330 <330
GP-5 S-1 (4' - 5') 01/04/18 ---- ---- 91 3,400 ---- 15,000 ---- ---- ---- ---- <50 <50 <50 <330 <330 18,000 120 <100 <100 <100 <330 <330 <330 <330 <330 <330 <330 <330 <330 <330 410 <330 <330 <330 <330 <330
GP-6 S-2 (4.5' - 5') 01/04/18 1,900 11,000 75 6,100 2,900 5,400 84 340 <100 13,000 <50 <50 <50 <330 <330 <50 <50 <100 <100 <100 <330 <330 <330 <330 <330 <330 <330 <330 <330 <330 ---- <330 <330 <330 <330 <330
SWDB 5,800 75,000 1,200 18,000 32,000 21,000 130 410 1,000 47,000 NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA NA
DWP 4,600 1.3E+06 6,000 30,000 5.8E+06 7.0E+05 1,700 4,000 4,500 2.4E+06 1,600 1,600 1,400 57,000 35,000 100 100 NA 2,100 1,800 3.0E+05 5,900 41,000 NLL NLL NLL NLL NLL NLL NLL 1.1E+05 7.3E+05 3.9E+05 NLL 56,000 4.8E+05
GSIP 4,600 4.4E+05 3,000 3,300 73,000 2.5E+06 50 400 100 1.7E+05 ID ID 12,000 4,200 730 1,200 (X) 4,000 (X) NA 570 1,100 8,700 ID ID NLL NLL NLL NLL NLL NLL NLL 2,200 5,500 5,300 NLL 2,100 ID
PART 201 SVIIC NLV NLV NLV NLV NLV NLV 48,000 NLV NLV NLV ID ID 22,000 2.7E+06 2.5E+05 11,000 1,000 NA 4.3E+06 2.6E+06 1.9E+08 1.6E+06 1.0E+09 NLV NLV ID NLV NLV ID NLV NLV 1.0E+09 5.8E+08 NLV 2.8E+06 1.0E+09
VSIC NLV NLV NLV NLV NLV NLV 52,000 NLV NLV NLV ID ID 1.8E+05 1.5E+06 3.0E+05 1.7E+05 11,000 NA 2.1E+07 1.6E+07 8.1E+07 2.2E+06 1.4E+09 NLV NLV ID NLV NLV ID NLV NLV 7.4E+08 1.3E+08 NLV 1.6E+05 6.5E+08
RESIDENTIAL SOIL
VSIC 5M NLV NLV NLV NLV NLV NLV 52,000 NLV NLV NLV ID ID 4.2E+05 1.5E+06 3.0E+05 4.8E+05 25,000 NA 5.0E+08 3.8E+08 8.1E+07 2.2E+06 1.4E+09 NLV NLV ID NLV NLV ID NLV NLV 7.4E+08 1.3E+08 NLV 1.6E+05 6.5E+08
CLEANUP CRITERIA VSIC 2M NLV NLV NLV NLV NLV NLV 52,000 NLV NLV NLV ID ID 9.9E+05 1.5E+06 3.0E+05 1.1E+06 57,000 NA 5.0E+08 3.8E+08 8.1E+07 2.2E+06 1.4E+09 NLV NLV ID NLV NLV ID NLV NLV 7.4E+08 1.3E+08 NLV 1.6E+05 6.5E+08
PSIC 7.2E+05 3.3E+08 1.7E+06 2.6E+05 1.3E+08 1.0E+08 2.0E+07 1.3E+08 6.7E+06 ID 2.0E+09 4.0E+08 2.3E+09 6.7E+08 2.0E+08 2.7E+09 1.3E+08 NA 8.2E+10 8.2E+10 1.4E+10 2.3E+09 6.7E+10 ID 1.5E+06 ID 8.0E+08 ID ID ID 3.3E+09 9.3E+09 9.3E+09 ID 6.7E+06 6.7E+09
DC 7,600 3.7E+07 5.5E+05 2.5E+06 2.0E+07 4.0E+05 1.6E+05 2.6E+06 2.5E+06 1.7E+08 2.5E+06 2.5E+06 2.5E+06 8.1E+06 1.6E+07 2.0E+05 1.1E+05 NA 3.2E+07 3.2E+07 4.1E+07 1.6E+06 2.3E+08 20,000 2,000 20,000 2.5E+06 2.0E+05 2.0E+06 2,000 1.7E+08 4.6E+07 2.7E+07 20,000 1.6E+06 2.9E+07
SSCSL NA NA NA NA NA NA NA NA NA NA 1.0E+07 1.0E+07 6.4E+05 NA NA 88,000 5.0E+05 NA 1.1E+05 94,000 NA NA NA NA NA NA NA NA NA NA 7.4E+05 NA NA NA NA NA
Residential Vapor Intrusion Soil Levels NA NA NA NA NA NA 0.027 NA NA NA NA NA NA NA NA 6.2 0.33 270 150 100 NA NA NA NA NA NA NA NA NA NA 7.4E+05 NA NA NA NA NA
Nonresidential Vapor Intrusion Soil
NA NA NA NA NA NA 0.12 NA NA NA NA NA NA NA NA 19 1 1,200 650 450 NA NA NA NA NA NA NA NA NA NA 7.4E+05 NA NA NA NA NA
Levels
NOTES:
[1] PART 201 CRITERIA EFFECTIVE DATE: DECEMBER 30, 2013
[2] SAMPLES COLLECTED BY NTH CONSULTANTS PERSONNEL AND ANALYZED BY FIBERTEC ENVIRONMENTAL SERVICES OF HOLT, MICHIGAN.
[3] ALL VALUES PRESENTED AS µG/KG - MICROGRAMS PER KILOGRAM (≈ PARTS PER BILLION).
[4] ID - INADEQUATE DATA TO DEVELOP CRITERION
[5] NLV - CHEMICAL IS NOT LIKELY TO VOLATILIZE UNDER MOST CONDITIONS
[6] NA - NOT APPLICABLE
[7] ND - NOT DETECTED ABOVE LABORATORY REPORTED METHOD DETECTION LIMITS
[8] SWDB - STATE-WIDE DEFAULT BACKGROUND
[9] DWP - RESIDENTIAL DRINKING WATER PROTECTION CRITERIA
[10] GSIP - GROUNDWATER / SURFACE WATER INTERFACE PROTECTION CRITERIA.
[11] SVIIC - SOIL VOLATILIZATION TO INDOOR AIR INHALATION CRITERIA.
[12] VSIC - VOLATILE SOIL INHALATION CRITERIA (AMBIENT AIR; INFINITE SOURCE).
[13] VSIC 5M - FINITE VSIC FOR 5 METER SOURCE THICKNESS
[14] VSIC 2M - FINITE VSIC FOR 2 METER SOURCE THICKNESS
[15] PSIC - PARTICULATE SOIL INHALATION CRITERIA
[16] DC - DIRECT CONTACT CRITERIA
[17] SSCSL - SOIL SATURATION CONCENTRATION SCREENING LEVELS
[18] G - AQUATIC TOXICITY IS PROPORTIONAL TO WATER HARDNESS AND/OR pH OF THE RECEIVING SURFACE WATER; THESE GSI VALUES HAVE BEEN CALCULATED BASED ON DEFAULT
WATER HARDNESS OF 150 PPM AS A REASONABLE ESTIMATE FOR MOST SURFACE WATER BODIES IN MICHIGAN.
[19] X - THE GSI CRITERION LISTED MAY NOT BE PROTECTIVE FOR SURFACE WATER THAT IS USED AS A DRINKING WATER SOURCE. FOR SOIL THAT MAY LEACH AND RESULT IN A IN CLOSE
GROUNDWATER DISCHARGE TO THE GREAT LAKES AND THEIR CONNECTING WATERS OR DISCHARGE IN CLOSE PROXIMITY TO A WATER SUPPLY INTAKE IN INLAND SURFACE WATERS,
THE GENERIC GSI CRITERION WOULD BE THE RESIDENTIAL DWP LISTED IN THE TABLE.
[20] - REPORTED CONCENTRATION EXCEEDS ONE OR MORE APPLICABLE PART 201 CRITERIA
[21] - REPORTED CONCENTRATION EXCEEDS VAPOR INTRUSION SCREENING LEVELS
1 of 2
Table 2: SUMMARY OF WATER ANALYSES
6556 E. McNichols Property
NTH Project No. 62-170450-01
Sample Designation
trans-1,2-Dichloroethylene
cis-1,2-Dichloroethylene
Methylphenol, 3- and 4-
1,2,3-Trimethylbenzene
1,2,4-Trimethylbenzene
1,3,5-Trimethylbenzene
Collect Date
2-Methylnaphthalene
1,1-Dichloroethylene
Tetrachloroethylene
Trichloroethylene
n-Propylbenzene
n-Butylbenzene
Ethylbenzene
Vinyl chloride
Naphthalene
Xylenes
Toluene
104-51-8 156-59-2 156-60-5 75-35-4 100-41-4 91-20-3 103-65-1 127-18-4 108-88-3 79-01-6 526-73-8 95-63-6 108-67-8 75-01-4 1330-20-7 91-57-6 MEPH1314
GP-5 W-1 (8.0') 01/04/18 1.1 36,000 62 26 4.6 12 1.5 87 4.8 3.9 12 21 3.9 17,000 25 7.9 13
DW 80 70 100 7 74 520 80 5 790 5 NA 63 72 2 280 260 NA
PART 201 RESIDENTIAL GSI ID 620 1,500 (X) 130 18 11 ID 60 (X) 270 200 (X) NA 17 45 13 (X) 41 19 25
GROUNDWATER GVIIC ID 93,000 85,000 200 1.1E+05 31,000 ID 25,000 5.3E+05 2,200 NA 56,000 61,000 1,100 1.9E+05 25,000 NA
CLEANUP CRITERIA WS NA 3.5E+06 6.3E+06 2.3E+06 1.7E+05 31,000 NA 2.0E+05 5.3E+05 1.1E+06 NA 55,890 61,150 2.8E+06 1.9E+05 24,600 NA
FESL ID 5.3E+05 2.3E+05 97,000 43,000 NA ID ID 61,000 ID NA 56,000 ID 33,000 70,000 ID NA
Residential Vapor Intrusion Shallow
Water Levels NA 3.4 27 18 2.8 NA NA 1.5 300 0.073 43 25 18 0.12 75 NA NA
Nonresidential Vapor Intrusion Shallow
Water Levels NA 5.8 78 45 8.5 NA NA 4.4 850 0.21 71 44 34 1.8 140 NA NA
NOTES:
[1] PART 201 CRITERIA EFFECTIVE DATE: DECEMBER 30, 2013
[2] SAMPLES COLLECTED BY NTH CONSULTANTS PERSONNEL AND ANALYZED BY FIBERTEC ENVIRONMENTAL SERVICES OF HOLT, MICHIGAN.
[3] ALL VALUES PRESENTED AS µG/L - MICROGRAMS PER LITER (≈ PARTS PER BILLION).
[4] ND - NOT DETECTED AT OR ABOVE LABORATORY REPORTED METHOD DETECTION LIMIT (SEE LABORATORY DATA REPORT FOR PARAMETER/SAMPLE SPECIFIC DETECTION LIMITS).
[5] ID - INADEQUATE DATA TO DEVELOP CRITERION
[6] NLL - CHEMICAL IS NOT LIKELY TO LEACH UNDER MOST SOIL CONDITIONS.
[7] NLV - CHEMICAL IS NOT LIKELY TO VOLATILIZE UNDER MOST CONDITIONS.
[8] DW - CONCENTRATION IN GROUNDWATER, IF NOT EXCEEDED, IS CONSIDERED SAFE FOR EXPOSURE.
[9] GSI - PRESENTED ONLY TO ESTABLISH GROUNDWATER CRITERIA WHICH ARE PROTECTIVE OF SURFACE WATER.
[10] GVIIC - GROUNDWATER VOLATILIZATION TO INDOOR AIR INHALATION CRITERIA.
[11] WS - WATER SOLUBILITY
[12] FESL - FLAMMABILITY AND EXPLOSIVITY SCREENING LEVEL
[13] G = AQUATIC TOXICITY IS PORPORTIONAL TO WATER HARDNESS AND PH OF RECEIVING WATER; THESE GSI VALUES HAVE BEEN CALCULATED BASED ON A DEFAULT WATER HARDNESS OF 150 PPM AS
[14] (X) THE GSI CRITERION LISTED MAY NOT BE PROTECTIVE FOR SURFACE WATER THAT IS USED AS A DRINKING WATER SOURCE. FOR SOIL THAT MAY LEACH AND RESULTS IN A GROUNDWATER
[15] - REPORTED CONCENTRATION EXCEEDS ONE OR MORE APPLICABLE PART 201 CRITERIA
[16] - REPORTED CONCENTRATION EXCEEDS VAPOR INTRUSION SCREENING LEVELS
2 of 2
Thursday, January 11, 2018
Thank you for selecting Fibertec Environmental Services as your analytical laboratory. The samples you submitted have
been analyzed in accordance with NELAC standards and the results compiled in the attached report. Any exceptions to
NELAC compliance are noted in the report. These results apply only to those samples submitted. Please note TO-15
samples will be disposed of 10 calendar days after the reporting date. All other samples will be disposed of 30 days after
the reporting date.
If you have any questions regarding these results or if we may be of further assistance to you, please contact me at (517)
699-0345.
Sincerely,
Enclosures
Client Identification: NTH Consultants, Ltd. - Sample Description: GP-1 S-2 (6.0-7.0') Chain of Custody: 113252
Northville
Client Project Name: 6556 E. McNichols Property (62- Sample No: S-2 Collect Date: 01/04/18
170450-01)
Client Project No: 62-170450-01 Sample Matrix: Soil/Solid Collect Time: 10:30
Sample Comments: Soil results have been calculated and reported on a dry weight basis unless otherwise noted.
Definitions: Q: Qualifier (see definitions at end of report) NA: Not Applicable ‡ : Parameter not included in NELAC Scope of Analysis.
Water (Moisture) Content Dried at 105 ± 5°C Aliquot ID: 82629-002 Matrix: Soil/Solid
Method: ASTM D2216-10 Description: GP-1 S-2 (6.0-7.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
‡ 1. Percent Moisture (Water Content) 13 % 1 1.0 01/05/18 MC180105 01/08/18 MC180105 NCZ
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Volatile Organic Compounds (VOCs) by GC/MS, 5035 Aliquot ID: 82629-002A Matrix: Soil/Solid
Method: EPA 5035A/EPA 8260B Description: GP-1 S-2 (6.0-7.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Client Identification: NTH Consultants, Ltd. - Sample Description: GP-1 S-2 (6.0-7.0') Chain of Custody: 113252
Northville
Client Project Name: 6556 E. McNichols Property (62- Sample No: S-2 Collect Date: 01/04/18
170450-01)
Client Project No: 62-170450-01 Sample Matrix: Soil/Solid Collect Time: 10:30
Sample Comments: Soil results have been calculated and reported on a dry weight basis unless otherwise noted.
Definitions: Q: Qualifier (see definitions at end of report) NA: Not Applicable ‡ : Parameter not included in NELAC Scope of Analysis.
Volatile Organic Compounds (VOCs) by GC/MS, 5035 Aliquot ID: 82629-002A Matrix: Soil/Solid
Method: EPA 5035A/EPA 8260B Description: GP-1 S-2 (6.0-7.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Client Identification: NTH Consultants, Ltd. - Sample Description: GP-1 S-2 (6.0-7.0') Chain of Custody: 113252
Northville
Client Project Name: 6556 E. McNichols Property (62- Sample No: S-2 Collect Date: 01/04/18
170450-01)
Client Project No: 62-170450-01 Sample Matrix: Soil/Solid Collect Time: 10:30
Sample Comments: Soil results have been calculated and reported on a dry weight basis unless otherwise noted.
Definitions: Q: Qualifier (see definitions at end of report) NA: Not Applicable ‡ : Parameter not included in NELAC Scope of Analysis.
Volatile Organic Compounds (VOCs) by GC/MS, 5035 Aliquot ID: 82629-002A Matrix: Soil/Solid
Method: EPA 5035A/EPA 8260B Description: GP-1 S-2 (6.0-7.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Client Identification: NTH Consultants, Ltd. - Sample Description: GP-2 S-1 (1.0-2.0') Chain of Custody: 113252
Northville
Client Project Name: 6556 E. McNichols Property (62- Sample No: S-1 Collect Date: 01/04/18
170450-01)
Client Project No: 62-170450-01 Sample Matrix: Soil/Solid Collect Time: 11:45
Sample Comments: Soil results have been calculated and reported on a dry weight basis unless otherwise noted.
Definitions: Q: Qualifier (see definitions at end of report) NA: Not Applicable ‡ : Parameter not included in NELAC Scope of Analysis.
Water (Moisture) Content Dried at 105 ± 5°C Aliquot ID: 82629-003 Matrix: Soil/Solid
Method: ASTM D2216-10 Description: GP-2 S-1 (1.0-2.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
‡ 1. Percent Moisture (Water Content) 13 % 1 1.0 01/05/18 MC180105 01/08/18 MC180105 NCZ
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Volatile Organic Compounds (VOCs) by GC/MS, 5035 Aliquot ID: 82629-003A Matrix: Soil/Solid
Method: EPA 5035A/EPA 8260B Description: GP-2 S-1 (1.0-2.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Client Identification: NTH Consultants, Ltd. - Sample Description: GP-2 S-1 (1.0-2.0') Chain of Custody: 113252
Northville
Client Project Name: 6556 E. McNichols Property (62- Sample No: S-1 Collect Date: 01/04/18
170450-01)
Client Project No: 62-170450-01 Sample Matrix: Soil/Solid Collect Time: 11:45
Sample Comments: Soil results have been calculated and reported on a dry weight basis unless otherwise noted.
Definitions: Q: Qualifier (see definitions at end of report) NA: Not Applicable ‡ : Parameter not included in NELAC Scope of Analysis.
Volatile Organic Compounds (VOCs) by GC/MS, 5035 Aliquot ID: 82629-003A Matrix: Soil/Solid
Method: EPA 5035A/EPA 8260B Description: GP-2 S-1 (1.0-2.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Client Identification: NTH Consultants, Ltd. - Sample Description: GP-2 S-1 (1.0-2.0') Chain of Custody: 113252
Northville
Client Project Name: 6556 E. McNichols Property (62- Sample No: S-1 Collect Date: 01/04/18
170450-01)
Client Project No: 62-170450-01 Sample Matrix: Soil/Solid Collect Time: 11:45
Sample Comments: Soil results have been calculated and reported on a dry weight basis unless otherwise noted.
Definitions: Q: Qualifier (see definitions at end of report) NA: Not Applicable ‡ : Parameter not included in NELAC Scope of Analysis.
Volatile Organic Compounds (VOCs) by GC/MS, 5035 Aliquot ID: 82629-003A Matrix: Soil/Solid
Method: EPA 5035A/EPA 8260B Description: GP-2 S-1 (1.0-2.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
47. Tetrachloroethene 190 µg/kg 50 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
48. Toluene U µg/kg 50 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
49. 1,2,4-Trichlorobenzene U µg/kg 250 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
50. 1,1,1-Trichloroethane U µg/kg 50 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
51. 1,1,2-Trichloroethane U µg/kg 50 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
52. Trichloroethene U µg/kg 50 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
53. Trichlorofluoromethane U µg/kg 130 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
54. 1,2,3-Trichloropropane U µg/kg 100 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
‡ 55. 1,2,3-Trimethylbenzene U µg/kg 100 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
56. 1,2,4-Trimethylbenzene U µg/kg 100 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
57. 1,3,5-Trimethylbenzene U µg/kg 100 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
58. Vinyl Chloride U µg/kg 40 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
59. m&p-Xylene U µg/kg 100 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
60. o-Xylene U µg/kg 50 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
‡ 61. Xylenes U µg/kg 150 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
1. Acenaphthene (SIM) 520 µg/kg 330 10 01/08/18 PS18A08B 01/08/18 SG18A08B TKT
2. Acenaphthylene (SIM) U µg/kg 330 10 01/08/18 PS18A08B 01/08/18 SG18A08B TKT
3. Anthracene (SIM) 1600 µg/kg 330 10 01/08/18 PS18A08B 01/08/18 SG18A08B TKT
4. Benzo(a)anthracene (SIM) 3300 µg/kg 330 10 01/08/18 PS18A08B 01/08/18 SG18A08B TKT
5. Benzo(a)pyrene (SIM) 3200 µg/kg 330 10 01/08/18 PS18A08B 01/08/18 SG18A08B TKT
6. Benzo(b)fluoranthene (SIM) 4200 µg/kg 330 10 01/08/18 PS18A08B 01/08/18 SG18A08B TKT
7. Benzo(ghi)perylene (SIM) 2200 µg/kg 330 10 01/08/18 PS18A08B 01/08/18 SG18A08B TKT
8. Benzo(k)fluoranthene (SIM) 1400 µg/kg 330 10 01/08/18 PS18A08B 01/08/18 SG18A08B TKT
9. Chrysene (SIM) 3100 µg/kg 330 10 01/08/18 PS18A08B 01/08/18 SG18A08B TKT
10. Dibenzo(a,h)anthracene (SIM) 470 µg/kg 330 10 01/08/18 PS18A08B 01/08/18 SG18A08B TKT
11. Fluoranthene (SIM) 9700 µg/kg 330 10 01/08/18 PS18A08B 01/08/18 SG18A08B TKT
12. Fluorene (SIM) 720 µg/kg 330 10 01/08/18 PS18A08B 01/08/18 SG18A08B TKT
13. Indeno(1,2,3-cd)pyrene (SIM) 2000 µg/kg 330 10 01/08/18 PS18A08B 01/08/18 SG18A08B TKT
14. 2-Methylnaphthalene (SIM) 460 µg/kg 330 10 01/08/18 PS18A08B 01/08/18 SG18A08B TKT
15. Phenanthrene (SIM) 7600 µg/kg 330 10 01/08/18 PS18A08B 01/08/18 SG18A08B TKT
16. Pyrene (SIM) 8500 µg/kg 330 10 01/08/18 PS18A08B 01/08/18 SG18A08B TKT
Client Identification: NTH Consultants, Ltd. - Sample Description: GP-3 S-1 (1.0-2.0') Chain of Custody: 113252
Northville
Client Project Name: 6556 E. McNichols Property (62- Sample No: S-1 Collect Date: 01/04/18
170450-01)
Client Project No: 62-170450-01 Sample Matrix: Soil/Solid Collect Time: 13:20
Sample Comments: Soil results have been calculated and reported on a dry weight basis unless otherwise noted.
Definitions: Q: Qualifier (see definitions at end of report) NA: Not Applicable ‡ : Parameter not included in NELAC Scope of Analysis.
Water (Moisture) Content Dried at 105 ± 5°C Aliquot ID: 82629-006 Matrix: Soil/Solid
Method: ASTM D2216-10 Description: GP-3 S-1 (1.0-2.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
‡ 1. Percent Moisture (Water Content) 14 % 1 1.0 01/05/18 MC180105 01/08/18 MC180105 NCZ
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Client Identification: NTH Consultants, Ltd. - Sample Description: GP-3 S-1 (1.0-2.0') Chain of Custody: 113252
Northville
Client Project Name: 6556 E. McNichols Property (62- Sample No: S-1 Collect Date: 01/04/18
170450-01)
Client Project No: 62-170450-01 Sample Matrix: Soil/Solid Collect Time: 13:20
Sample Comments: Soil results have been calculated and reported on a dry weight basis unless otherwise noted.
Definitions: Q: Qualifier (see definitions at end of report) NA: Not Applicable ‡ : Parameter not included in NELAC Scope of Analysis.
Volatile Organic Compounds (VOCs) by GC/MS, 5035 Aliquot ID: 82629-006A Matrix: Soil/Solid
Method: EPA 5035A/EPA 8260B Description: GP-3 S-1 (1.0-2.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Client Identification: NTH Consultants, Ltd. - Sample Description: GP-3 S-1 (1.0-2.0') Chain of Custody: 113252
Northville
Client Project Name: 6556 E. McNichols Property (62- Sample No: S-1 Collect Date: 01/04/18
170450-01)
Client Project No: 62-170450-01 Sample Matrix: Soil/Solid Collect Time: 13:20
Sample Comments: Soil results have been calculated and reported on a dry weight basis unless otherwise noted.
Definitions: Q: Qualifier (see definitions at end of report) NA: Not Applicable ‡ : Parameter not included in NELAC Scope of Analysis.
Volatile Organic Compounds (VOCs) by GC/MS, 5035 Aliquot ID: 82629-006A Matrix: Soil/Solid
Method: EPA 5035A/EPA 8260B Description: GP-3 S-1 (1.0-2.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
38. Isopropylbenzene U µg/kg 250 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
39. Methylene Chloride U µg/kg 100 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
40. 4-Methyl-2-pentanone U µg/kg 2500 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
41. MTBE U µg/kg 250 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
42. Naphthalene 770 µg/kg 330 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
43. n-Propylbenzene U µg/kg 100 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
44. Styrene U µg/kg 64 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
45. 1,1,1,2-Tetrachloroethane U µg/kg 100 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
46. 1,1,2,2-Tetrachloroethane U µg/kg 50 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
47. Tetrachloroethene 2000 µg/kg 50 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
48. Toluene U µg/kg 50 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
49. 1,2,4-Trichlorobenzene U µg/kg 250 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
50. 1,1,1-Trichloroethane U µg/kg 50 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
51. 1,1,2-Trichloroethane U µg/kg 50 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
52. Trichloroethene 340 µg/kg 50 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
53. Trichlorofluoromethane U µg/kg 130 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
54. 1,2,3-Trichloropropane U µg/kg 100 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
‡ 55. 1,2,3-Trimethylbenzene 810 µg/kg 100 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
56. 1,2,4-Trimethylbenzene 1000 µg/kg 100 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
57. 1,3,5-Trimethylbenzene 270 µg/kg 100 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
58. Vinyl Chloride U µg/kg 40 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
59. m&p-Xylene U µg/kg 100 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
60. o-Xylene U µg/kg 50 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
‡ 61. Xylenes U µg/kg 150 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Client Identification: NTH Consultants, Ltd. - Sample Description: GP-3 S-1 (1.0-2.0') Chain of Custody: 113252
Northville
Client Project Name: 6556 E. McNichols Property (62- Sample No: S-1 Collect Date: 01/04/18
170450-01)
Client Project No: 62-170450-01 Sample Matrix: Soil/Solid Collect Time: 13:20
Sample Comments: Soil results have been calculated and reported on a dry weight basis unless otherwise noted.
Definitions: Q: Qualifier (see definitions at end of report) NA: Not Applicable ‡ : Parameter not included in NELAC Scope of Analysis.
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
8. Benzo(k)fluoranthene (SIM) 3300 µg/kg 330 20 01/08/18 PS18A08B 01/09/18 SG18A08B TKT
9. Chrysene (SIM) 6900 µg/kg 330 20 01/08/18 PS18A08B 01/09/18 SG18A08B TKT
10. Dibenzo(a,h)anthracene (SIM) 1000 µg/kg 330 20 01/08/18 PS18A08B 01/09/18 SG18A08B TKT
11. Fluoranthene (SIM) 20000 µg/kg 330 20 01/08/18 PS18A08B 01/09/18 SG18A08B TKT
12. Fluorene (SIM) 1300 µg/kg 330 20 01/08/18 PS18A08B 01/09/18 SG18A08B TKT
13. Indeno(1,2,3-cd)pyrene (SIM) 3400 µg/kg 330 20 01/08/18 PS18A08B 01/09/18 SG18A08B TKT
14. 2-Methylnaphthalene (SIM) 3200 µg/kg 330 20 01/08/18 PS18A08B 01/09/18 SG18A08B TKT
15. Phenanthrene (SIM) 14000 µg/kg 330 20 01/08/18 PS18A08B 01/09/18 SG18A08B TKT
16. Pyrene (SIM) 16000 µg/kg 330 20 01/08/18 PS18A08B 01/09/18 SG18A08B TKT
Client Identification: NTH Consultants, Ltd. - Sample Description: GP-4 S-1 (1.0-2.0') Chain of Custody: 113252
Northville
Client Project Name: 6556 E. McNichols Property (62- Sample No: S-1 Collect Date: 01/04/18
170450-01)
Client Project No: 62-170450-01 Sample Matrix: Soil/Solid Collect Time: 14:10
Sample Comments: Soil results have been calculated and reported on a dry weight basis unless otherwise noted.
Definitions: Q: Qualifier (see definitions at end of report) NA: Not Applicable ‡ : Parameter not included in NELAC Scope of Analysis.
Water (Moisture) Content Dried at 105 ± 5°C Aliquot ID: 82629-008 Matrix: Soil/Solid
Method: ASTM D2216-10 Description: GP-4 S-1 (1.0-2.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
‡ 1. Percent Moisture (Water Content) 4 % 1 1.0 01/05/18 MC180105 01/08/18 MC180105 NCZ
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Volatile Organic Compounds (VOCs) by GC/MS, 5035 Aliquot ID: 82629-008A Matrix: Soil/Solid
Method: EPA 5035A/EPA 8260B Description: GP-4 S-1 (1.0-2.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Client Identification: NTH Consultants, Ltd. - Sample Description: GP-4 S-1 (1.0-2.0') Chain of Custody: 113252
Northville
Client Project Name: 6556 E. McNichols Property (62- Sample No: S-1 Collect Date: 01/04/18
170450-01)
Client Project No: 62-170450-01 Sample Matrix: Soil/Solid Collect Time: 14:10
Sample Comments: Soil results have been calculated and reported on a dry weight basis unless otherwise noted.
Definitions: Q: Qualifier (see definitions at end of report) NA: Not Applicable ‡ : Parameter not included in NELAC Scope of Analysis.
Volatile Organic Compounds (VOCs) by GC/MS, 5035 Aliquot ID: 82629-008A Matrix: Soil/Solid
Method: EPA 5035A/EPA 8260B Description: GP-4 S-1 (1.0-2.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Client Identification: NTH Consultants, Ltd. - Sample Description: GP-4 S-1 (1.0-2.0') Chain of Custody: 113252
Northville
Client Project Name: 6556 E. McNichols Property (62- Sample No: S-1 Collect Date: 01/04/18
170450-01)
Client Project No: 62-170450-01 Sample Matrix: Soil/Solid Collect Time: 14:10
Sample Comments: Soil results have been calculated and reported on a dry weight basis unless otherwise noted.
Definitions: Q: Qualifier (see definitions at end of report) NA: Not Applicable ‡ : Parameter not included in NELAC Scope of Analysis.
Volatile Organic Compounds (VOCs) by GC/MS, 5035 Aliquot ID: 82629-008A Matrix: Soil/Solid
Method: EPA 5035A/EPA 8260B Description: GP-4 S-1 (1.0-2.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Client Identification: NTH Consultants, Ltd. - Sample Description: GP-5 S-1 (4.0-5.0') Chain of Custody: 113252
Northville
Client Project Name: 6556 E. McNichols Property (62- Sample No: S-1 Collect Date: 01/04/18
170450-01)
Client Project No: 62-170450-01 Sample Matrix: Soil/Solid Collect Time: 16:00
Sample Comments: Soil results have been calculated and reported on a dry weight basis unless otherwise noted.
Definitions: Q: Qualifier (see definitions at end of report) NA: Not Applicable ‡ : Parameter not included in NELAC Scope of Analysis.
Water (Moisture) Content Dried at 105 ± 5°C Aliquot ID: 82629-009 Matrix: Soil/Solid
Method: ASTM D2216-10 Description: GP-5 S-1 (4.0-5.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
‡ 1. Percent Moisture (Water Content) 8 % 1 1.0 01/05/18 MC180105 01/08/18 MC180105 NCZ
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Volatile Organic Compounds (VOCs) by GC/MS, 5035 Aliquot ID: 82629-009A Matrix: Soil/Solid
Method: EPA 5035A/EPA 8260B Description: GP-5 S-1 (4.0-5.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Client Identification: NTH Consultants, Ltd. - Sample Description: GP-5 S-1 (4.0-5.0') Chain of Custody: 113252
Northville
Client Project Name: 6556 E. McNichols Property (62- Sample No: S-1 Collect Date: 01/04/18
170450-01)
Client Project No: 62-170450-01 Sample Matrix: Soil/Solid Collect Time: 16:00
Sample Comments: Soil results have been calculated and reported on a dry weight basis unless otherwise noted.
Definitions: Q: Qualifier (see definitions at end of report) NA: Not Applicable ‡ : Parameter not included in NELAC Scope of Analysis.
Volatile Organic Compounds (VOCs) by GC/MS, 5035 Aliquot ID: 82629-009A Matrix: Soil/Solid
Method: EPA 5035A/EPA 8260B Description: GP-5 S-1 (4.0-5.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Client Identification: NTH Consultants, Ltd. - Sample Description: GP-5 S-1 (4.0-5.0') Chain of Custody: 113252
Northville
Client Project Name: 6556 E. McNichols Property (62- Sample No: S-1 Collect Date: 01/04/18
170450-01)
Client Project No: 62-170450-01 Sample Matrix: Soil/Solid Collect Time: 16:00
Sample Comments: Soil results have been calculated and reported on a dry weight basis unless otherwise noted.
Definitions: Q: Qualifier (see definitions at end of report) NA: Not Applicable ‡ : Parameter not included in NELAC Scope of Analysis.
Volatile Organic Compounds (VOCs) by GC/MS, 5035 Aliquot ID: 82629-009A Matrix: Soil/Solid
Method: EPA 5035A/EPA 8260B Description: GP-5 S-1 (4.0-5.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
45. 1,1,1,2-Tetrachloroethane U µg/kg 100 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
46. 1,1,2,2-Tetrachloroethane U µg/kg 50 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
47. Tetrachloroethene 18000 µg/kg 280 10 01/08/18 VI18A08A 01/08/18 VI18A08A MJP
48. Toluene U µg/kg 50 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
49. 1,2,4-Trichlorobenzene U µg/kg 250 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
50. 1,1,1-Trichloroethane U µg/kg 50 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
51. 1,1,2-Trichloroethane U µg/kg 50 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
52. Trichloroethene 120 µg/kg 50 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
53. Trichlorofluoromethane U µg/kg 110 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
54. 1,2,3-Trichloropropane U µg/kg 100 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
‡ 55. 1,2,3-Trimethylbenzene U µg/kg 100 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
56. 1,2,4-Trimethylbenzene U µg/kg 100 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
57. 1,3,5-Trimethylbenzene U µg/kg 100 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
58. Vinyl Chloride U µg/kg 40 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
59. m&p-Xylene U µg/kg 100 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
60. o-Xylene U µg/kg 50 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
‡ 61. Xylenes U µg/kg 150 1.0 01/05/18 VI18A05A 01/05/18 VI18A05A MES
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Client Identification: NTH Consultants, Ltd. - Sample Description: GP-5 S-1 (4.0-5.0') Chain of Custody: 113252
Northville
Client Project Name: 6556 E. McNichols Property (62- Sample No: S-1 Collect Date: 01/04/18
170450-01)
Client Project No: 62-170450-01 Sample Matrix: Soil/Solid Collect Time: 16:00
Sample Comments: Soil results have been calculated and reported on a dry weight basis unless otherwise noted.
Definitions: Q: Qualifier (see definitions at end of report) NA: Not Applicable ‡ : Parameter not included in NELAC Scope of Analysis.
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
15. Bis(2-ethylhexyl)phthalate U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
16. 4-Bromophenyl Phenylether U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
17. Butyl Benzyl Phthalate U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
‡ 18. Carbazole U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
19. 4-Chloro-3-methylphenol U µg/kg 280 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
20. 2-Chloronaphthalene U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
21. 2-Chlorophenol U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
22. 4-Chlorophenyl Phenylether U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
23. Chrysene U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
24. Dibenzo(a,h)anthracene U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
25. Dibenzofuran U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
26. 2,4-Dichlorophenol U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
27. Diethyl Phthalate 410 B µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
28. Dimethyl Phthalate U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
29. 2,4-Dimethylphenol U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
30. Di-n-butyl Phthalate U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
31. 2,4-Dinitrophenol U * µg/kg 830 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
32. 2,4-Dinitrotoluene U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
33. 2,6-Dinitrotoluene U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
34. Di-n-octyl Phthalate U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
35. Fluoranthene U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
36. Fluorene U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
37. Hexachlorobenzene U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
38. Hexachlorobutadiene U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
39. Hexachlorocyclopentadiene U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
40. Hexachloroethane U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
41. Indeno(1,2,3-cd)pyrene U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
42. Isophorone U L+ µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
43. 2-Methyl-4,6-dinitrophenol U F µg/kg 830 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
44. 2-Methylnaphthalene U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
45. 2-Methylphenol U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
‡ 46. 3&4-Methylphenol U µg/kg 660 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
47. 2-Nitroaniline U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
48. 3-Nitroaniline U µg/kg 830 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
49. 4-Nitroaniline U µg/kg 830 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
50. Nitrobenzene U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
51. 2-Nitrophenol U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
Client Identification: NTH Consultants, Ltd. - Sample Description: GP-5 S-1 (4.0-5.0') Chain of Custody: 113252
Northville
Client Project Name: 6556 E. McNichols Property (62- Sample No: S-1 Collect Date: 01/04/18
170450-01)
Client Project No: 62-170450-01 Sample Matrix: Soil/Solid Collect Time: 16:00
Sample Comments: Soil results have been calculated and reported on a dry weight basis unless otherwise noted.
Definitions: Q: Qualifier (see definitions at end of report) NA: Not Applicable ‡ : Parameter not included in NELAC Scope of Analysis.
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
52. 4-Nitrophenol U µg/kg 830 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
53. N-Nitrosodimethylamine U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
54. N-Nitrosodi-n-propylamine U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
55. N-Nitrosodiphenylamine U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
56. Pentachlorophenol U µg/kg 800 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
57. Phenanthrene U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
58. Phenol U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
59. Pyrene U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
60. Pyridine U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
61. 2,4,5-Trichlorophenol U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
62. 2,4,6-Trichlorophenol U µg/kg 330 1.0 01/08/18 PS18A08F 01/08/18 SJ18A08A GJP
Client Identification: NTH Consultants, Ltd. - Sample Description: GP-6 S-2 (4.5-5.0') Chain of Custody: 113255
Northville
Client Project Name: 6556 E. McNichols Property (62- Sample No: S-2 Collect Date: 01/04/18
170450-01)
Client Project No: 62-170450-01 Sample Matrix: Soil/Solid Collect Time: 16:50
Sample Comments: Soil results have been calculated and reported on a dry weight basis unless otherwise noted.
Definitions: Q: Qualifier (see definitions at end of report) NA: Not Applicable ‡ : Parameter not included in NELAC Scope of Analysis.
Water (Moisture) Content Dried at 105 ± 5°C Aliquot ID: 82629-012 Matrix: Soil/Solid
Method: ASTM D2216-10 Description: GP-6 S-2 (4.5-5.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
‡ 1. Percent Moisture (Water Content) 23 % 1 1.0 01/05/18 MC180105 01/08/18 MC180105 NCZ
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Volatile Organic Compounds (VOCs) by GC/MS, 5035 Aliquot ID: 82629-012A Matrix: Soil/Solid
Method: EPA 5035A/EPA 8260B Description: GP-6 S-2 (4.5-5.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Client Identification: NTH Consultants, Ltd. - Sample Description: GP-6 S-2 (4.5-5.0') Chain of Custody: 113255
Northville
Client Project Name: 6556 E. McNichols Property (62- Sample No: S-2 Collect Date: 01/04/18
170450-01)
Client Project No: 62-170450-01 Sample Matrix: Soil/Solid Collect Time: 16:50
Sample Comments: Soil results have been calculated and reported on a dry weight basis unless otherwise noted.
Definitions: Q: Qualifier (see definitions at end of report) NA: Not Applicable ‡ : Parameter not included in NELAC Scope of Analysis.
Volatile Organic Compounds (VOCs) by GC/MS, 5035 Aliquot ID: 82629-012A Matrix: Soil/Solid
Method: EPA 5035A/EPA 8260B Description: GP-6 S-2 (4.5-5.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Client Identification: NTH Consultants, Ltd. - Sample Description: GP-6 S-2 (4.5-5.0') Chain of Custody: 113255
Northville
Client Project Name: 6556 E. McNichols Property (62- Sample No: S-2 Collect Date: 01/04/18
170450-01)
Client Project No: 62-170450-01 Sample Matrix: Soil/Solid Collect Time: 16:50
Sample Comments: Soil results have been calculated and reported on a dry weight basis unless otherwise noted.
Definitions: Q: Qualifier (see definitions at end of report) NA: Not Applicable ‡ : Parameter not included in NELAC Scope of Analysis.
Volatile Organic Compounds (VOCs) by GC/MS, 5035 Aliquot ID: 82629-012A Matrix: Soil/Solid
Method: EPA 5035A/EPA 8260B Description: GP-6 S-2 (4.5-5.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Client Identification: NTH Consultants, Ltd. - Sample Description: GP-5 W-1 (8.0') Chain of Custody: 113255
Northville
Client Project Name: 6556 E. McNichols Property (62- Sample No: W-1 Collect Date: 01/04/18
170450-01)
Client Project No: 62-170450-01 Sample Matrix: Ground Water Collect Time: 16:22
Sample Comments:
Definitions: Q: Qualifier (see definitions at end of report) NA: Not Applicable ‡ : Parameter not included in NELAC Scope of Analysis.
Trace Elements by ICP/MS, Total Recoverable Aliquot ID: 82629-016A Matrix: Ground Water
Method: EPA 3005A (Total Recoverable)/EPA 6020A Description: GP-5 W-1 (8.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Volatile Organic Compounds (VOCs) by GC/MS Aliquot ID: 82629-016B Matrix: Ground Water
Method: EPA 5030B/EPA 8260B Description: GP-5 W-1 (8.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Client Identification: NTH Consultants, Ltd. - Sample Description: GP-5 W-1 (8.0') Chain of Custody: 113255
Northville
Client Project Name: 6556 E. McNichols Property (62- Sample No: W-1 Collect Date: 01/04/18
170450-01)
Client Project No: 62-170450-01 Sample Matrix: Ground Water Collect Time: 16:22
Sample Comments:
Definitions: Q: Qualifier (see definitions at end of report) NA: Not Applicable ‡ : Parameter not included in NELAC Scope of Analysis.
Volatile Organic Compounds (VOCs) by GC/MS Aliquot ID: 82629-016B Matrix: Ground Water
Method: EPA 5030B/EPA 8260B Description: GP-5 W-1 (8.0')
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
29. 1,1-Dichloroethene 26 µg/L 1.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
30. cis-1,2-Dichloroethene 36000 µg/L 500 500 01/09/18 VB18A09A 01/09/18 VB18A09A ANB
31. trans-1,2-Dichloroethene 62 µg/L 1.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
32. 1,2-Dichloropropane U µg/L 1.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
33. cis-1,3-Dichloropropene U µg/L 0.50 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
34. trans-1,3-Dichloropropene U µg/L 0.50 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
35. Ethylbenzene 4.6 µg/L 1.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
36. Ethylene Dibromide U µg/L 1.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
37. 2-Hexanone U µg/L 50 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
38. Isopropylbenzene U µg/L 5.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
39. Methylene Chloride U µg/L 5.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
40. 4-Methyl-2-pentanone U µg/L 50 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
41. MTBE U µg/L 5.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
42. Naphthalene 12 µg/L 5.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
43. n-Propylbenzene 1.5 µg/L 1.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
44. Styrene U µg/L 1.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
45. 1,1,1,2-Tetrachloroethane U µg/L 1.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
46. 1,1,2,2-Tetrachloroethane U µg/L 1.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
47. Tetrachloroethene 87 µg/L 1.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
48. Toluene 4.8 µg/L 1.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
49. 1,2,4-Trichlorobenzene U µg/L 5.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
50. 1,1,1-Trichloroethane U µg/L 1.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
51. 1,1,2-Trichloroethane U µg/L 1.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
52. Trichloroethene 3.9 µg/L 1.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
53. Trichlorofluoromethane U µg/L 1.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
54. 1,2,3-Trichloropropane U µg/L 1.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
‡ 55. 1,2,3-Trimethylbenzene 12 µg/L 1.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
56. 1,2,4-Trimethylbenzene 21 µg/L 1.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
57. 1,3,5-Trimethylbenzene 3.9 µg/L 1.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
58. Vinyl Chloride 17000 µg/L 500 500 01/09/18 VB18A09A 01/09/18 VB18A09A ANB
59. m&p-Xylene 19 µg/L 2.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
60. o-Xylene 7.0 µg/L 1.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
‡ 61. Xylenes 25 µg/L 3.0 1.0 01/05/18 VB18A05A 01/05/18 VB18A05A ANB
Client Identification: NTH Consultants, Ltd. - Sample Description: GP-5 W-1 (8.0') Chain of Custody: 113255
Northville
Client Project Name: 6556 E. McNichols Property (62- Sample No: W-1 Collect Date: 01/04/18
170450-01)
Client Project No: 62-170450-01 Sample Matrix: Ground Water Collect Time: 16:22
Sample Comments:
Definitions: Q: Qualifier (see definitions at end of report) NA: Not Applicable ‡ : Parameter not included in NELAC Scope of Analysis.
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
Client Identification: NTH Consultants, Ltd. - Sample Description: GP-5 W-1 (8.0') Chain of Custody: 113255
Northville
Client Project Name: 6556 E. McNichols Property (62- Sample No: W-1 Collect Date: 01/04/18
170450-01)
Client Project No: 62-170450-01 Sample Matrix: Ground Water Collect Time: 16:22
Sample Comments:
Definitions: Q: Qualifier (see definitions at end of report) NA: Not Applicable ‡ : Parameter not included in NELAC Scope of Analysis.
Preparation Analysis
Parameter(s) Result Q Units Reporting Limit Dilution P. Date P. Batch A. Date A. Batch Init.
38. Hexachlorobutadiene U µg/L 5.0 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
39. Hexachlorocyclopentadiene U µg/L 5.0 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
40. Hexachloroethane U µg/L 1.0 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
41. Indeno(1,2,3-cd)pyrene U µg/L 2.0 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
42. Isophorone U µg/L 5.0 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
43. 2-Methyl-4,6-dinitrophenol U µg/L 20 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
44. 2-Methylnaphthalene 7.9 µg/L 5.0 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
45. 2-Methylphenol U µg/L 5.0 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
‡ 46. 3&4-Methylphenol 13 µg/L 10 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
47. 2-Nitroaniline U µg/L 20 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
48. 3-Nitroaniline U µg/L 20 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
49. 4-Nitroaniline U µg/L 20 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
50. Nitrobenzene U µg/L 3.0 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
51. 2-Nitrophenol U µg/L 5.0 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
52. 4-Nitrophenol U µg/L 20 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
53. N-Nitrosodimethylamine U µg/L 5.0 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
54. N-Nitrosodi-n-propylamine U µg/L 5.0 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
55. N-Nitrosodiphenylamine U µg/L 5.0 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
56. Pentachlorophenol U µg/L 20 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
57. Phenanthrene U µg/L 2.0 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
58. Phenol U µg/L 5.0 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
59. Pyrene U µg/L 5.0 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
60. Pyridine U µg/L 5.0 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
61. 1,2,4-Trichlorobenzene U µg/L 5.0 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
62. 2,4,5-Trichlorophenol U µg/L 5.0 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
63. 2,4,6-Trichlorophenol U µg/L 4.0 1.0 01/08/18 PS18A08D 01/08/18 SJ18A08A GJP
Definitions/ Qualifiers:
Exception Summary:
* : Duplicate analysis not within control limits.
B : Analyte is found in the associated method blank as well as in the sample.
E1 : The reported value is estimated due to the presence of interference.
F : Recovery from the spiked aliquot failed the expected range (matrix spike or matrix spike duplicate)
L+ : Recovery in the associated laboratory sample (LCS) exceeds the upper control limit. Results may be biased high.
Accreditation Number(s):
T104704518-17-6 (TX)
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
Result RL Result Spike Rec. LCL - UCL Rec. RPD UCL
Parameter µg/kg µg/kg Q µg/kg µg/kg % % Q % % % Q MB LCS LCD
1. Mercury U 50 198 200 99 85 - 115 MB-14 LCS-13
Exception Summary:
Exceptions have been properly noted on reported results or affected samples have been scheduled for reanalysis when appropriate.
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
Result RL Result Spike Rec. LCL - UCL Rec. RPD UCL
Parameter µg/kg µg/kg Q µg/kg µg/kg % % Q % % % Q MB LCS LCD
1. Acenaphthene U 330 4,021 5,333 75 50 - 114 MB-9 LCS-8
2. Acenaphthylene U 330 4,312 5,333 81 53 - 115 MB-9 LCS-8
3. Anthracene U 330 4,397 5,333 82 48 - 119 MB-9 LCS-8
4. Benzo(a)anthracene U 330 4,491 5,333 84 56 - 120 MB-9 LCS-8
5. Benzo(a)pyrene U 330 5,244 5,333 98 57 - 122 MB-9 LCS-8
6. Benzo(b)fluoranthene U 330 4,510 5,333 85 50 - 131 MB-9 LCS-8
7. Benzo(ghi)perylene U 330 4,622 5,333 87 41 - 132 MB-9 LCS-8
8. Benzo(k)fluoranthene U 330 4,644 5,333 87 39 - 137 MB-9 LCS-8
9. Chrysene U 330 4,944 5,333 93 53 - 124 MB-9 LCS-8
10. Dibenzo(a,h)anthracene U 330 4,579 5,333 86 53 - 126 MB-9 LCS-8
11. Fluoranthene U 330 4,997 5,333 94 48 - 135 MB-9 LCS-8
12. Fluorene U 330 4,411 5,333 83 49 - 126 MB-9 LCS-8
13. Indeno(1,2,3-cd)pyrene U 330 4,521 5,333 85 51 - 132 MB-9 LCS-8
14. 2-Methylnaphthalene U 330 4,472 5,333 84 46 - 105 MB-9 LCS-8
15. Phenanthrene U 330 4,362 5,333 82 53 - 119 MB-9 LCS-8
16. Pyrene U 330 5,407 5,333 101 55 - 127 MB-9 LCS-8
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
System Monitoring Compounds Result Spike Rec. Result Spike Rec. LCL - UCL Rec. RPD UCL
(Surrogates): µg/kg µg/kg % Q µg/kg µg/kg % % Q % % % Q MB LCS LCD
1. 2-Fluorobiphenyl(S) 3,800 5,333 71 3,846 5,333 72 49 - 115 MB-9 LCS-8
2. 4-Terphenyl-d14(S) 4,432 5,333 83 4,506 5,333 84 48 - 117 MB-9 LCS-8
3. 1-Fluoronaphthalene(S) 4,045 5,333 76 3,988 5,333 75 46 - 114 MB-9 LCS-8
Exception Summary:
Exceptions have been properly noted on reported results or affected samples have been scheduled for reanalysis when appropriate.
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
Result RL Result Spike Rec. LCL - UCL Rec. RPD UCL
Parameter µg/kg µg/kg Q µg/kg µg/kg % % Q % % % Q MB LCS LCD
1. Aroclor-1016 U 100 610 667 91 60 - 120 MB-11 LCS-10
2. Aroclor-1260 U 100 697 667 105 60 - 120 MB-11 LCS-10
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
System Monitoring Compounds Result Spike Rec. Result Spike Rec. LCL - UCL Rec. RPD UCL
(Surrogates): µg/kg µg/kg % Q µg/kg µg/kg % % Q % % % Q MB LCS LCD
1. Decachlorobiphenyl-PCB(S) 73.0 66.7 110 73.2 66.7 110 40 - 143 MB-11 LCS-10
2. 2,4,5,6-Tetrachloro-m-xylene-PCB(S) 63.6 66.7 95 56.9 66.7 85 42 - 133 MB-11 LCS-10
Exception Summary:
Exceptions have been properly noted on reported results or affected samples have been scheduled for reanalysis when appropriate.
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
Result RL Result Spike Rec. LCL - UCL Rec. RPD UCL
Parameter µg/L µg/L Q µg/L µg/L % % Q % % % Q MB LCS LCD
1. Acenaphthene U 5.0 60.5 80.0 76 53 - 107 76 0 30 MB-7 LCS-7 LCD-5
2. Acenaphthylene U 5.0 56.0 80.0 70 52 - 107 73 4 30 MB-7 LCS-7 LCD-5
3. Aniline U 4.0 39.0 80.0 49 19 - 117 52 6 30 MB-7 LCS-7 LCD-5
4. Anthracene U 5.0 75.5 80.0 94 55 - 112 95 1 30 MB-7 LCS-7 LCD-5
5. Azobenzene U 5.0 67.6 80.0 84 59 - 105 86 2 30 MB-7 LCS-7 LCD-5
6. Benzo(a)anthracene U 1.0 76.5 80.0 96 59 - 116 96 0 30 MB-7 LCS-7 LCD-5
7. Benzo(a)pyrene U 1.0 77.1 80.0 96 60 - 118 100 4 30 MB-7 LCS-7 LCD-5
8. Benzo(b)fluoranthene U 1.0 74.0 80.0 92 58 - 118 96 4 30 MB-7 LCS-7 LCD-5
9. Benzo(ghi)perylene U 1.0 77.9 80.0 97 47 - 122 102 5 30 MB-7 LCS-7 LCD-5
10. Benzo(k)fluoranthene U 1.0 80.5 80.0 101 56 - 120 104 3 30 MB-7 LCS-7 LCD-5
11. Benzyl Alcohol U 5.0 51.6 80.0 64 39 - 100 65 2 30 MB-7 LCS-7 LCD-5
12. Bis(2-chloroethoxy)methane U 5.0 61.0 80.0 76 60 - 112 81 6 30 MB-7 LCS-7 LCD-5
13. Bis(2-chloroethyl)ether U 1.0 51.4 80.0 64 53 - 110 69 8 30 MB-7 LCS-7 LCD-5
14. Bis(2-chloroisopropyl) Ether U 5.0 45.1 80.0 56 42 - 116 63 12 30 MB-7 LCS-7 LCD-5
15. Bis(2-ethylhexyl)phthalate U 5.0 82.0 80.0 102 57 - 126 102 0 30 MB-7 LCS-7 LCD-5
16. 4-Bromophenyl Phenylether U 5.0 73.5 80.0 92 61 - 109 93 1 30 MB-7 LCS-7 LCD-5
17. Butyl Benzyl Phthalate U 5.0 79.8 80.0 100 60 - 120 102 2 30 MB-7 LCS-7 LCD-5
18. Carbazole U 5.0 73.1 80.0 91 59 - 120 94 3 30 MB-7 LCS-7 LCD-5
19. 4-Chloro-3-methylphenol U 5.0 70.1 80.0 88 50 - 120 88 0 30 MB-7 LCS-7 LCD-5
20. 2-Chloronaphthalene U 5.0 50.4 80.0 63 60 - 118 66 5 30 MB-7 LCS-7 LCD-5
21. 2-Chlorophenol U 5.0 51.4 80.0 64 43 - 110 66 3 30 MB-7 LCS-7 LCD-5
22. 4-Chlorophenyl Phenylether U 5.0 65.8 80.0 82 59 - 106 86 5 30 MB-7 LCS-7 LCD-5
23. Chrysene U 1.0 70.4 80.0 88 56 - 117 93 6 30 MB-7 LCS-7 LCD-5
24. Dibenzo(a,h)anthracene U 2.0 57.5 80.0 72 48 - 128 96 29 30 MB-7 LCS-7 LCD-5
25. Dibenzofuran U 4.0 63.8 80.0 80 56 - 106 82 2 30 MB-7 LCS-7 LCD-5
26. 2,4-Dichlorophenol U 5.0 60.7 80.0 76 50 - 118 80 5 30 MB-7 LCS-7 LCD-5
27. Diethyl Phthalate U 5.0 73.3 80.0 92 54 - 114 94 2 30 MB-7 LCS-7 LCD-5
28. Dimethyl Phthalate U 5.0 76.8 80.0 96 64 - 111 98 2 30 MB-7 LCS-7 LCD-5
29. 2,4-Dimethylphenol U 5.0 66.8 80.0 83 51 - 114 84 1 30 MB-7 LCS-7 LCD-5
30. Di-n-butyl Phthalate U 5.0 78.1 80.0 98 60 - 114 99 1 30 MB-7 LCS-7 LCD-5
31. 2,4-Dinitrophenol U 20 56.3 80.0 70 43 - 132 72 3 30 MB-7 LCS-7 LCD-5
32. 2,4-Dinitrotoluene U 5.0 80.8 80.0 101 68 - 119 102 1 30 MB-7 LCS-7 LCD-5
33. 2,6-Dinitrotoluene U 5.0 81.6 80.0 102 67 - 114 105 3 30 MB-7 LCS-7 LCD-5
34. Di-n-octyl Phthalate U 5.0 78.3 80.0 98 60 - 124 103 5 30 MB-7 LCS-7 LCD-5
35. Fluoranthene U 1.0 75.5 80.0 94 57 - 119 97 3 30 MB-7 LCS-7 LCD-5
36. Fluorene U 5.0 65.8 80.0 82 57 - 112 85 4 30 MB-7 LCS-7 LCD-5
37. Hexachlorobenzene U 5.0 72.4 80.0 90 60 - 113 91 1 30 MB-7 LCS-7 LCD-5
38. Hexachlorobutadiene U 5.0 37.7 80.0 47 24 - 116 50 6 30 MB-7 LCS-7 LCD-5
39. Hexachlorocyclopentadiene U 5.0 40.1 80.0 50 17 - 89 53 6 30 MB-7 LCS-7 LCD-5
40. Hexachloroethane U 1.0 34.9 80.0 44 40 - 113 45 2 30 MB-7 LCS-7 LCD-5
41. Indeno(1,2,3-cd)pyrene U 2.0 73.6 80.0 92 54 - 130 96 4 30 MB-7 LCS-7 LCD-5
42. Isophorone U 5.0 76.5 80.0 96 55 - 123 99 3 30 MB-7 LCS-7 LCD-5
43. 2-Methyl-4,6-dinitrophenol U 20 76.1 80.0 95 52 - 116 98 3 30 MB-7 LCS-7 LCD-5
44. 2-Methylnaphthalene U 5.0 47.2 80.0 59 42 - 100 62 5 30 MB-7 LCS-7 LCD-5
45. 2-Methylphenol U 5.0 53.3 80.0 67 39 - 103 67 0 30 MB-7 LCS-7 LCD-5
46. 3&4-Methylphenol U 10 44.2 80.0 55 30 - 86 53 4 30 MB-7 LCS-7 LCD-5
47. 2-Nitroaniline U 20 81.2 80.0 102 59 - 121 102 0 30 MB-7 LCS-7 LCD-5
48. 3-Nitroaniline U 20 82.1 80.0 103 45 - 120 102 1 30 MB-7 LCS-7 LCD-5
49. 4-Nitroaniline U 20 76.0 80.0 95 46 - 126 95 0 30 MB-7 LCS-7 LCD-5
50. Nitrobenzene U 3.0 53.5 80.0 67 56 - 111 74 10 30 MB-7 LCS-7 LCD-5
51. 2-Nitrophenol U 5.0 59.6 80.0 74 56 - 112 81 9 30 MB-7 LCS-7 LCD-5
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
Result RL Result Spike Rec. LCL - UCL Rec. RPD UCL
Parameter µg/L µg/L Q µg/L µg/L % % Q % % % Q MB LCS LCD
52. 4-Nitrophenol U 20 38.8 80.0 49 21 - 59 49 0 30 MB-7 LCS-7 LCD-5
53. N-Nitrosodimethylamine U 5.0 36.4 80.0 45 29 - 89 47 4 30 MB-7 LCS-7 LCD-5
54. N-Nitrosodi-n-propylamine U 5.0 61.5 80.0 77 47 - 131 79 3 30 MB-7 LCS-7 LCD-5
55. N-Nitrosodiphenylamine U 5.0 86.6 80.0 108 70 - 129 109 1 30 MB-7 LCS-7 LCD-5
56. Pentachlorophenol U 20 61.4 80.0 77 46 - 115 79 3 30 MB-7 LCS-7 LCD-5
57. Phenanthrene U 2.0 74.2 80.0 93 58 - 112 95 2 30 MB-7 LCS-7 LCD-5
58. Phenol U 5.0 24.2 80.0 30 17 - 54 31 3 30 MB-7 LCS-7 LCD-5
59. Pyrene U 5.0 76.3 80.0 95 57 - 115 97 2 30 MB-7 LCS-7 LCD-5
60. Pyridine U 5.0 26.4 80.0 33 15 - 68 39 17 30 MB-7 LCS-7 LCD-5
61. 1,2,4-Trichlorobenzene U 5.0 38.2 80.0 48 44 - 142 51 6 30 MB-7 LCS-7 LCD-5
62. 2,4,5-Trichlorophenol U 5.0 66.9 80.0 84 55 - 112 85 1 30 MB-7 LCS-7 LCD-5
63. 2,4,6-Trichlorophenol U 4.0 67.7 80.0 85 60 - 115 86 1 30 MB-7 LCS-7 LCD-5
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
System Monitoring Compounds Result Spike Rec. Result Spike Rec. LCL - UCL Rec. RPD UCL
(Surrogates): µg/L µg/L % Q µg/L µg/L % % Q % % % Q MB LCS LCD
1. 2-Fluorobiphenyl(S) 49.6 80.0 62 53.8 80.0 67 44 - 109 68 1 30 MB-7 LCS-7 LCD-5
2. 2-Fluorophenol(S) 92.6 160 58 72.3 160 45 22 - 85 46 2 30 MB-7 LCS-7 LCD-5
3. Phenol-d6(S) 67.8 160 42 50.6 160 32 11 - 60 31 3 30 MB-7 LCS-7 LCD-5
4. 4-Terphenyl-d14(S) 75.4 80.0 94 75.0 80.0 94 44 - 124 95 1 30 MB-7 LCS-7 LCD-5
5. 2,4,6-Tribromophenol(S) 147 160 92 161 160 101 38 - 138 100 1 30 MB-7 LCS-7 LCD-5
6. 1-Fluoronaphthalene(S) 45.7 80.0 57 45.7 80.0 57 44 - 103 59 3 30 MB-7 LCS-7 LCD-5
Exception Summary:
Exceptions have been properly noted on reported results or affected samples have been scheduled for reanalysis when appropriate.
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
Result RL Result Spike Rec. LCL - UCL Rec. RPD UCL
Parameter µg/kg µg/kg Q µg/kg µg/kg % % Q % % % Q MB LCS LCD
1. Acenaphthene U 330 2,333 2,667 87 50 - 114 MB-10 LCS-9
2. Acenaphthylene U 330 2,277 2,667 85 53 - 115 MB-10 LCS-9
3. Aniline U 330 1,101 2,667 41 34 - 77 MB-10 LCS-9
4. Anthracene U 330 2,442 2,667 92 48 - 119 MB-10 LCS-9
5. Azobenzene U 330 2,338 2,667 88 65 - 102 MB-10 LCS-9
6. Benzo(a)anthracene U 330 2,500 2,667 94 56 - 120 MB-10 LCS-9
7. Benzo(a)pyrene U 330 2,519 2,667 94 57 - 122 MB-10 LCS-9
8. Benzo(b)fluoranthene U 330 2,370 2,667 89 50 - 131 MB-10 LCS-9
9. Benzo(ghi)perylene U 330 2,693 2,667 101 41 - 132 MB-10 LCS-9
10. Benzo(k)fluoranthene U 330 2,559 2,667 96 39 - 137 MB-10 LCS-9
11. Benzyl Alcohol U 3300 2,339 2,667 88 64 - 102 MB-10 LCS-9
12. Bis(2-chloroethoxy)methane U 330 2,468 2,667 93 62 - 98 MB-10 LCS-9
13. Bis(2-chloroethyl)ether U 330 2,316 2,667 87 52 - 100 MB-10 LCS-9
14. Bis(2-chloroisopropyl) Ether U 330 2,410 2,667 90 37 - 107 MB-10 LCS-9
15. Bis(2-ethylhexyl)phthalate U 330 2,723 2,667 102 68 - 128 MB-10 LCS-9
16. 4-Bromophenyl Phenylether U 330 2,486 2,667 93 55 - 118 MB-10 LCS-9
17. Butyl Benzyl Phthalate U 330 2,667 2,667 100 70 - 127 MB-10 LCS-9
18. Carbazole U 330 2,408 2,667 90 72 - 132 MB-10 LCS-9
19. 4-Chloro-3-methylphenol U 280 2,428 2,667 91 57 - 120 MB-10 LCS-9
20. 2-Chloronaphthalene U 330 2,349 2,667 88 53 - 106 MB-10 LCS-9
21. 2-Chlorophenol U 330 2,308 2,667 87 61 - 99 MB-10 LCS-9
22. 4-Chlorophenyl Phenylether U 330 2,414 2,667 91 50 - 119 MB-10 LCS-9
23. Chrysene U 330 2,635 2,667 99 53 - 124 MB-10 LCS-9
24. Dibenzo(a,h)anthracene U 330 3,193 2,667 120 53 - 126 MB-10 LCS-9
25. Dibenzofuran U 330 2,366 2,667 89 51 - 116 MB-10 LCS-9
26. 2,4-Dichlorophenol U 330 2,348 2,667 88 56 - 113 MB-10 LCS-9
27. Diethyl Phthalate 393 330 * 2,654 2,667 100 46 - 128 MB-10 LCS-9
28. Dimethyl Phthalate U 330 2,521 2,667 95 63 - 115 MB-10 LCS-9
29. 2,4-Dimethylphenol U 330 2,505 2,667 94 63 - 106 MB-10 LCS-9
30. Di-n-butyl Phthalate U 330 2,573 2,667 96 45 - 124 MB-10 LCS-9
31. 2,4-Dinitrophenol U 830 915 2,667 34 10 - 96 MB-10 LCS-9
32. 2,4-Dinitrotoluene U 330 2,593 2,667 97 52 - 121 MB-10 LCS-9
33. 2,6-Dinitrotoluene U 330 2,705 2,667 101 57 - 118 MB-10 LCS-9
34. Di-n-octyl Phthalate U 330 2,526 2,667 95 65 - 120 MB-10 LCS-9
35. Fluoranthene U 330 2,438 2,667 91 48 - 135 MB-10 LCS-9
36. Fluorene U 330 2,351 2,667 88 49 - 126 MB-10 LCS-9
37. Hexachlorobenzene U 330 2,461 2,667 92 54 - 118 MB-10 LCS-9
38. Hexachlorobutadiene U 330 2,147 2,667 81 35 - 136 MB-10 LCS-9
39. Hexachlorocyclopentadiene U 330 2,442 2,667 92 43 - 101 MB-10 LCS-9
40. Hexachloroethane U 330 2,217 2,667 83 52 - 104 MB-10 LCS-9
41. Indeno(1,2,3-cd)pyrene U 330 2,547 2,667 96 51 - 132 MB-10 LCS-9
42. Isophorone U 330 2,838 2,667 106 64 - 102 * MB-10 LCS-9
43. 2-Methyl-4,6-dinitrophenol U 830 1,363 2,667 51 46 - 109 MB-10 LCS-9
44. 2-Methylnaphthalene U 330 2,375 2,667 89 46 - 105 MB-10 LCS-9
45. 2-Methylphenol U 330 2,469 2,667 93 60 - 100 MB-10 LCS-9
46. 3&4-Methylphenol U 660 2,108 2,667 79 58 - 104 MB-10 LCS-9
47. 2-Nitroaniline U 330 2,781 2,667 104 66 - 112 MB-10 LCS-9
48. 3-Nitroaniline U 830 2,457 2,667 92 45 - 144 MB-10 LCS-9
49. 4-Nitroaniline U 830 2,652 2,667 99 67 - 162 MB-10 LCS-9
50. Nitrobenzene U 330 2,408 2,667 90 61 - 99 MB-10 LCS-9
51. 2-Nitrophenol U 330 2,503 2,667 94 61 - 105 MB-10 LCS-9
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
Result RL Result Spike Rec. LCL - UCL Rec. RPD UCL
Parameter µg/kg µg/kg Q µg/kg µg/kg % % Q % % % Q MB LCS LCD
52. 4-Nitrophenol U 830 2,175 2,667 82 41 - 105 MB-10 LCS-9
53. N-Nitrosodimethylamine U 330 2,242 2,667 84 36 - 119 MB-10 LCS-9
54. N-Nitrosodi-n-propylamine U 330 2,439 2,667 91 59 - 107 MB-10 LCS-9
55. N-Nitrosodiphenylamine U 330 2,909 2,667 109 67 - 117 MB-10 LCS-9
56. Pentachlorophenol U 800 1,474 2,667 55 53 - 107 MB-10 LCS-9
57. Phenanthrene U 330 2,464 2,667 92 53 - 119 MB-10 LCS-9
58. Phenol U 330 2,306 2,667 86 55 - 91 MB-10 LCS-9
59. Pyrene U 330 2,466 2,667 92 55 - 127 MB-10 LCS-9
60. Pyridine U 330 1,754 2,667 66 10 - 77 MB-10 LCS-9
61. 2,4,5-Trichlorophenol U 330 2,333 2,667 87 52 - 119 MB-10 LCS-9
62. 2,4,6-Trichlorophenol U 330 2,434 2,667 91 53 - 114 MB-10 LCS-9
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
System Monitoring Compounds Result Spike Rec. Result Spike Rec. LCL - UCL Rec. RPD UCL
(Surrogates): µg/kg µg/kg % Q µg/kg µg/kg % % Q % % % Q MB LCS LCD
1. 2-Fluorobiphenyl(S) 2,292 2,667 86 2,304 2,667 86 49 - 115 MB-10 LCS-9
2. 2-Fluorophenol(S) 4,632 5,333 87 4,824 5,333 90 31 - 112 MB-10 LCS-9
3. Phenol-d6(S) 4,619 5,333 87 4,582 5,333 86 32 - 113 MB-10 LCS-9
4. 4-Terphenyl-d14(S) 2,431 2,667 91 2,499 2,667 94 48 - 117 MB-10 LCS-9
5. 2,4,6-Tribromophenol(S) 5,450 5,333 102 5,347 5,333 100 25 - 118 MB-10 LCS-9
6. 1-Fluoronaphthalene(S) 2,275 2,667 85 2,205 2,667 83 46 - 114 MB-10 LCS-9
Exception Summary:
Exceptions have been properly noted on reported results or affected samples have been scheduled for reanalysis when appropriate.
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
Result RL Result Spike Rec. LCL - UCL Rec. RPD UCL
Parameter µg/kg µg/kg Q µg/kg µg/kg % % Q % % % Q MB LCS LCD
1. Aroclor-1016 U 100 696 667 104 60 - 120 MB-15 LCS-14
2. Aroclor-1260 U 100 758 667 114 60 - 120 MB-15 LCS-14
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
System Monitoring Compounds Result Spike Rec. Result Spike Rec. LCL - UCL Rec. RPD UCL
(Surrogates): µg/kg µg/kg % Q µg/kg µg/kg % % Q % % % Q MB LCS LCD
1. Decachlorobiphenyl-PCB(S) 64.2 66.7 96 75.5 66.7 113 40 - 143 MB-15 LCS-14
2. 2,4,5,6-Tetrachloro-m-xylene-PCB(S) 58.1 66.7 87 67.0 66.7 101 42 - 133 MB-15 LCS-14
Exception Summary:
Exceptions have been properly noted on reported results or affected samples have been scheduled for reanalysis when appropriate.
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
Result RL Result Spike Rec. LCL - UCL Rec. RPD UCL
Parameter µg/L µg/L Q µg/L µg/L % % Q % % % Q MB LCS LCD
1. Cadmium U 1.0 102 100 102 85 - 115 MB-4 LCS-5
2. Chromium U 10 212 200 106 85 - 115 MB-4 LCS-5
3. Lead U 3.0 208 200 104 85 - 115 MB-4 LCS-5
Exception Summary:
Exceptions have been properly noted on reported results or affected samples have been scheduled for reanalysis when appropriate.
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
Result RL Result Spike Rec. LCL - UCL Rec. RPD UCL
Parameter µg/kg µg/kg Q µg/kg µg/kg % % Q % % % Q MB LCS LCD
1. Arsenic U 100 10,147 10,000 101 85 - 115 MB-6 LCS-6
2. Barium U 1000 53,339 50,000 107 85 - 115 MB-6 LCS-6
3. Cadmium U 50 10,401 10,000 104 85 - 115 MB-6 LCS-6
4. Chromium U 500 20,624 20,000 103 85 - 115 MB-6 LCS-6
5. Copper U 1000 21,571 20,000 108 85 - 115 MB-6 LCS-6
6. Lead U 1000 21,223 20,000 106 85 - 115 MB-6 LCS-6
7. Selenium U 200 10,357 10,000 104 85 - 115 MB-6 LCS-6
8. Silver U 100 10,327 10,000 103 85 - 115 MB-6 LCS-6
9. Zinc 5,276 1000 * 51,818 50,000 104 85 - 115 MB-6 LCS-6
Exception Summary:
Exceptions have been properly noted on reported results or affected samples have been scheduled for reanalysis when appropriate.
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
Result RL Result Spike Rec. LCL - UCL Rec. RPD UCL
Parameter µg/kg µg/kg Q µg/kg µg/kg % % Q % % % Q MB LCS LCD
1. Selenium U 200 10,058 10,000 101 85 - 115 MB-12 LCS-11
2. Zinc U 1000 50,089 50,000 100 85 - 115 MB-12 LCS-11
Exception Summary:
Exceptions have been properly noted on reported results or affected samples have been scheduled for reanalysis when appropriate.
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
Result RL Result Spike Rec. LCL - UCL Rec. RPD UCL
Parameter µg/L µg/L Q µg/L µg/L % % Q % % % Q MB LCS LCD
1. Acetone U 50 51.2 50.0 102 70 - 147 114 11 20 MB-1 LCS-1 LCD-1
2. Acrylonitrile U 2.0 59.1 50.0 118 70 - 147 120 2 20 MB-1 LCS-1 LCD-1
3. Benzene U 1.0 49.8 50.0 100 70 - 147 96 4 20 MB-1 LCS-1 LCD-1
4. Bromobenzene U 1.0 51.1 50.0 102 70 - 147 100 2 20 MB-1 LCS-1 LCD-1
5. Bromochloromethane U 1.0 56.4 50.0 113 70 - 147 110 3 20 MB-1 LCS-1 LCD-1
6. Bromodichloromethane U 1.0 49.4 50.0 99 70 - 147 96 3 20 MB-1 LCS-1 LCD-1
7. Bromoform U 1.0 49.2 50.0 98 70 - 147 97 1 20 MB-1 LCS-1 LCD-1
8. Bromomethane U 5.0 52.1 50.0 104 70 - 147 99 5 20 MB-1 LCS-1 LCD-1
9. 2-Butanone U 25 55.9 50.0 112 70 - 147 120 7 20 MB-1 LCS-1 LCD-1
10. n-Butylbenzene U 1.0 57.7 50.0 115 70 - 147 110 4 20 MB-1 LCS-1 LCD-1
11. sec-Butylbenzene U 1.0 53.6 50.0 107 70 - 147 102 5 20 MB-1 LCS-1 LCD-1
12. tert-Butylbenzene U 1.0 51.4 50.0 103 70 - 147 100 3 20 MB-1 LCS-1 LCD-1
13. Carbon Disulfide U 5.0 55.0 50.0 110 70 - 147 104 6 20 MB-1 LCS-1 LCD-1
14. Carbon Tetrachloride U 1.0 50.9 50.0 102 70 - 140 96 6 20 MB-1 LCS-1 LCD-1
15. Chlorobenzene U 1.0 48.9 50.0 98 70 - 147 95 3 20 MB-1 LCS-1 LCD-1
16. Chloroethane U 5.0 56.6 50.0 113 70 - 147 104 8 20 MB-1 LCS-1 LCD-1
17. Chloroform U 1.0 52.9 50.0 106 76 - 138 102 4 20 MB-1 LCS-1 LCD-1
18. Chloromethane U 5.0 55.9 50.0 112 70 - 147 107 5 20 MB-1 LCS-1 LCD-1
19. 2-Chlorotoluene U 5.0 52.1 50.0 104 70 - 147 100 4 20 MB-1 LCS-1 LCD-1
20. Dibromochloromethane U 5.0 49.7 50.0 99 70 - 147 98 1 20 MB-1 LCS-1 LCD-1
21. 1,2-Dibromo-3-chloropropane U 1.0 51.0 50.0 102 70 - 147 105 3 20 MB-1 LCS-1 LCD-1
22. Dibromomethane U 5.0 44.9 50.0 90 70 - 147 90 0 20 MB-1 LCS-1 LCD-1
23. 1,2-Dichlorobenzene U 1.0 49.3 50.0 99 70 - 147 96 3 20 MB-1 LCS-1 LCD-1
24. 1,3-Dichlorobenzene U 1.0 48.8 50.0 98 70 - 147 94 4 20 MB-1 LCS-1 LCD-1
25. 1,4-Dichlorobenzene U 1.0 48.7 50.0 97 70 - 147 94 3 20 MB-1 LCS-1 LCD-1
26. Dichlorodifluoromethane U 5.0 54.0 50.0 108 70 - 147 102 6 20 MB-1 LCS-1 LCD-1
27. 1,1-Dichloroethane U 1.0 53.6 50.0 107 70 - 147 104 3 20 MB-1 LCS-1 LCD-1
28. 1,2-Dichloroethane U 1.0 52.0 50.0 104 70 - 147 102 2 20 MB-1 LCS-1 LCD-1
29. 1,1-Dichloroethene U 1.0 56.4 50.0 113 76 - 147 106 6 20 MB-1 LCS-1 LCD-1
30. trans-1,2-Dichloroethene U 1.0 54.7 50.0 109 70 - 147 105 4 20 MB-1 LCS-1 LCD-1
31. 1,2-Dichloropropane U 1.0 51.0 50.0 102 76 - 147 99 3 20 MB-1 LCS-1 LCD-1
32. cis-1,3-Dichloropropene U 0.50 54.2 50.0 108 70 - 147 106 2 20 MB-1 LCS-1 LCD-1
33. trans-1,3-Dichloropropene U 0.50 53.6 50.0 107 70 - 147 105 2 20 MB-1 LCS-1 LCD-1
34. Ethylbenzene U 1.0 51.7 50.0 103 76 - 147 99 4 20 MB-1 LCS-1 LCD-1
35. Ethylene Dibromide U 1.0 49.7 50.0 99 70 - 147 97 2 20 MB-1 LCS-1 LCD-1
36. 2-Hexanone U 50 52.5 50.0 105 70 - 147 110 5 20 MB-1 LCS-1 LCD-1
37. Isopropylbenzene U 5.0 52.9 50.0 106 70 - 147 102 4 20 MB-1 LCS-1 LCD-1
38. Methylene Chloride U 5.0 53.3 50.0 107 70 - 147 103 4 20 MB-1 LCS-1 LCD-1
39. 4-Methyl-2-pentanone U 50 53.1 50.0 106 70 - 147 109 3 20 MB-1 LCS-1 LCD-1
40. MTBE U 5.0 55.0 50.0 110 70 - 147 109 1 20 MB-1 LCS-1 LCD-1
41. Naphthalene U 5.0 51.1 50.0 102 70 - 147 103 1 20 MB-1 LCS-1 LCD-1
42. n-Propylbenzene U 1.0 53.8 50.0 108 70 - 147 103 5 20 MB-1 LCS-1 LCD-1
43. Styrene U 1.0 47.6 50.0 95 70 - 147 92 3 20 MB-1 LCS-1 LCD-1
44. 1,1,1,2-Tetrachloroethane U 1.0 52.1 50.0 104 70 - 147 100 4 20 MB-1 LCS-1 LCD-1
45. 1,1,2,2-Tetrachloroethane U 1.0 53.1 50.0 106 70 - 147 105 1 20 MB-1 LCS-1 LCD-1
46. Tetrachloroethene U 1.0 48.5 50.0 97 70 - 147 92 5 20 MB-1 LCS-1 LCD-1
47. Toluene U 1.0 49.4 50.0 99 76 - 147 96 3 20 MB-1 LCS-1 LCD-1
48. 1,2,4-Trichlorobenzene U 5.0 50.2 50.0 100 70 - 147 98 2 20 MB-1 LCS-1 LCD-1
49. 1,1,1-Trichloroethane U 1.0 53.6 50.0 107 70 - 147 102 5 20 MB-1 LCS-1 LCD-1
50. 1,1,2-Trichloroethane U 1.0 47.9 50.0 96 70 - 147 94 2 20 MB-1 LCS-1 LCD-1
51. Trichloroethene U 1.0 48.4 50.0 97 71 - 157 94 3 20 MB-1 LCS-1 LCD-1
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
Result RL Result Spike Rec. LCL - UCL Rec. RPD UCL
Parameter µg/L µg/L Q µg/L µg/L % % Q % % % Q MB LCS LCD
52. Trichlorofluoromethane U 1.0 56.1 50.0 112 70 - 147 105 6 20 MB-1 LCS-1 LCD-1
53. 1,2,3-Trichloropropane U 1.0 51.1 50.0 102 70 - 147 104 2 20 MB-1 LCS-1 LCD-1
54. 1,2,3-Trimethylbenzene U 1.0 52.0 50.0 104 70 - 147 101 3 20 MB-1 LCS-1 LCD-1
55. 1,2,4-Trimethylbenzene U 1.0 56.3 50.0 113 70 - 147 108 5 20 MB-1 LCS-1 LCD-1
56. 1,3,5-Trimethylbenzene U 1.0 53.0 50.0 106 70 - 147 102 4 20 MB-1 LCS-1 LCD-1
57. m&p-Xylene U 2.0 105 100 105 70 - 147 101 4 20 MB-1 LCS-1 LCD-1
58. o-Xylene U 1.0 51.0 50.0 102 70 - 147 99 3 20 MB-1 LCS-1 LCD-1
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
System Monitoring Compounds Result Spike Rec. Result Spike Rec. LCL - UCL Rec. RPD UCL
(Surrogates): µg/L µg/L % Q µg/L µg/L % % Q % % % Q MB LCS LCD
1. Dibromofluoromethane(S) 53.6 50.0 107 53.4 50.0 107 80 - 120 106 1 20 MB-1 LCS-1 LCD-2
2. Dibromofluoromethane(S) 53.6 50.0 107 53.3 50.0 107 80 - 120 107 0 20 MB-1 LCS-2 LCD-1
3. Dibromofluoromethane(S) 53.6 50.0 107 53.3 50.0 107 80 - 120 106 1 20 MB-1 LCS-2 LCD-2
4. Dibromofluoromethane(S) 53.6 50.0 107 53.4 50.0 107 80 - 120 107 0 20 MB-1 LCS-1 LCD-1
5. Dibromofluoromethane(S) 53.9 50.0 108 53.4 50.0 107 80 - 120 106 1 20 MB-2 LCS-1 LCD-2
6. Dibromofluoromethane(S) 53.9 50.0 108 53.3 50.0 107 80 - 120 106 1 20 MB-2 LCS-2 LCD-2
7. Dibromofluoromethane(S) 53.9 50.0 108 53.4 50.0 107 80 - 120 107 0 20 MB-2 LCS-1 LCD-1
8. Dibromofluoromethane(S) 53.9 50.0 108 53.3 50.0 107 80 - 120 107 0 20 MB-2 LCS-2 LCD-1
9. 1,2-Dichloroethane-d4(S) 54.4 50.0 109 52.8 50.0 106 80 - 120 108 2 20 MB-1 LCS-2 LCD-1
10. 1,2-Dichloroethane-d4(S) 54.4 50.0 109 53.9 50.0 108 80 - 120 107 1 20 MB-1 LCS-1 LCD-2
11. 1,2-Dichloroethane-d4(S) 54.4 50.0 109 53.9 50.0 108 80 - 120 108 0 20 MB-1 LCS-1 LCD-1
12. 1,2-Dichloroethane-d4(S) 54.4 50.0 109 52.8 50.0 106 80 - 120 107 1 20 MB-1 LCS-2 LCD-2
13. 1,2-Dichloroethane-d4(S) 53.4 50.0 107 53.9 50.0 108 80 - 120 108 0 20 MB-2 LCS-1 LCD-1
14. 1,2-Dichloroethane-d4(S) 53.4 50.0 107 52.8 50.0 106 80 - 120 107 1 20 MB-2 LCS-2 LCD-2
15. 1,2-Dichloroethane-d4(S) 53.4 50.0 107 53.9 50.0 108 80 - 120 107 1 20 MB-2 LCS-1 LCD-2
16. 1,2-Dichloroethane-d4(S) 53.4 50.0 107 52.8 50.0 106 80 - 120 108 2 20 MB-2 LCS-2 LCD-1
17. Toluene-d8(S) 51.1 50.0 102 51.9 50.0 104 80 - 120 100 4 20 MB-2 LCS-2 LCD-1
18. Toluene-d8(S) 49.7 50.0 99 51.9 50.0 104 80 - 120 104 0 20 MB-1 LCS-2 LCD-2
19. Toluene-d8(S) 49.7 50.0 99 51.9 50.0 104 80 - 120 100 4 20 MB-1 LCS-2 LCD-1
20. Toluene-d8(S) 49.7 50.0 99 49.7 50.0 99 80 - 120 104 5 20 MB-1 LCS-1 LCD-2
21. Toluene-d8(S) 51.1 50.0 102 49.7 50.0 99 80 - 120 104 5 20 MB-2 LCS-1 LCD-2
22. Toluene-d8(S) 51.1 50.0 102 51.9 50.0 104 80 - 120 104 0 20 MB-2 LCS-2 LCD-2
23. Toluene-d8(S) 51.1 50.0 102 49.7 50.0 99 80 - 120 100 1 20 MB-2 LCS-1 LCD-1
24. Toluene-d8(S) 49.7 50.0 99 49.7 50.0 99 80 - 120 100 1 20 MB-1 LCS-1 LCD-1
25. 4-Bromofluorobenzene(S) 48.9 50.0 98 52.3 50.0 105 80 - 120 106 1 20 MB-1 LCS-2 LCD-2
26. 4-Bromofluorobenzene(S) 52.3 50.0 105 52.3 50.0 105 80 - 120 106 1 20 MB-2 LCS-2 LCD-2
27. 4-Bromofluorobenzene(S) 52.3 50.0 105 50.0 50.0 100 80 - 120 101 1 20 MB-2 LCS-1 LCD-1
28. 4-Bromofluorobenzene(S) 52.3 50.0 105 50.0 50.0 100 80 - 120 106 6 20 MB-2 LCS-1 LCD-2
29. 4-Bromofluorobenzene(S) 52.3 50.0 105 52.3 50.0 105 80 - 120 101 4 20 MB-2 LCS-2 LCD-1
30. 4-Bromofluorobenzene(S) 48.9 50.0 98 50.0 50.0 100 80 - 120 101 1 20 MB-1 LCS-1 LCD-1
31. 4-Bromofluorobenzene(S) 48.9 50.0 98 50.0 50.0 100 80 - 120 106 6 20 MB-1 LCS-1 LCD-2
32. 4-Bromofluorobenzene(S) 48.9 50.0 98 52.3 50.0 105 80 - 120 101 4 20 MB-1 LCS-2 LCD-1
Exception Summary:
Exceptions have been properly noted on reported results or affected samples have been scheduled for reanalysis when appropriate.
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
Result RL Result Spike Rec. LCL - UCL Rec. RPD UCL
Parameter µg/L µg/L Q µg/L µg/L % % Q % % % Q MB LCS LCD
1. cis-1,2-Dichloroethene U 500 46.6 50.0 93 70 - 147 92 1 20 MB-13 LCS-12 LCD-6
2. Vinyl Chloride U 500 48.2 50.0 96 76 - 147 95 1 20 MB-13 LCS-12 LCD-6
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
System Monitoring Compounds Result Spike Rec. Result Spike Rec. LCL - UCL Rec. RPD UCL
(Surrogates): µg/L µg/L % Q µg/L µg/L % % Q % % % Q MB LCS LCD
1. Dibromofluoromethane(S) 48.4 50.0 97 47.2 50.0 94 80 - 120 96 2 20 MB-13 LCS-12 LCD-6
2. 1,2-Dichloroethane-d4(S) 48.1 50.0 96 48.0 50.0 96 80 - 120 95 1 20 MB-13 LCS-12 LCD-6
3. Toluene-d8(S) 49.3 50.0 99 49.0 50.0 98 80 - 120 99 1 20 MB-13 LCS-12 LCD-6
4. 4-Bromofluorobenzene(S) 50.3 50.0 101 47.1 50.0 94 80 - 120 94 0 20 MB-13 LCS-12 LCD-6
Exception Summary:
Exceptions have been properly noted on reported results or affected samples have been scheduled for reanalysis when appropriate.
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
Result RL Result Spike Rec. LCL - UCL Rec. RPD UCL
Parameter µg/kg µg/kg Q µg/kg µg/kg % % Q % % % Q MB LCS LCD
1. Acetone U 1000 2,536 2,500 101 70 - 150 100 1 20 MB-3 LCS-3 LCD-3
2. Acrylonitrile U 100 2,792 2,500 112 70 - 134 118 5 20 MB-3 LCS-3 LCD-3
3. Benzene U 50 2,238 2,500 90 70 - 134 87 3 20 MB-3 LCS-3 LCD-3
4. Bromobenzene U 100 2,190 2,500 88 70 - 134 80 10 20 MB-3 LCS-3 LCD-3
5. Bromochloromethane U 100 2,370 2,500 95 70 - 134 94 1 20 MB-3 LCS-3 LCD-3
6. Bromodichloromethane U 100 2,346 2,500 94 70 - 134 92 2 20 MB-3 LCS-3 LCD-3
7. Bromoform U 100 2,569 2,500 103 70 - 134 104 1 20 MB-3 LCS-3 LCD-3
8. Bromomethane U 200 2,329 2,500 93 70 - 134 91 2 20 MB-3 LCS-3 LCD-3
9. 2-Butanone U 750 2,625 2,500 105 70 - 150 106 1 20 MB-3 LCS-3 LCD-3
10. n-Butylbenzene U 50 2,556 2,500 102 70 - 134 96 6 20 MB-3 LCS-3 LCD-3
11. sec-Butylbenzene U 50 2,516 2,500 101 70 - 134 94 7 20 MB-3 LCS-3 LCD-3
12. tert-Butylbenzene U 50 2,442 2,500 98 70 - 134 92 6 20 MB-3 LCS-3 LCD-3
13. Carbon Disulfide U 250 2,453 2,500 98 70 - 134 95 3 20 MB-3 LCS-3 LCD-3
14. Carbon Tetrachloride U 50 2,549 2,500 102 70 - 134 97 5 20 MB-3 LCS-3 LCD-3
15. Chlorobenzene U 50 2,390 2,500 96 70 - 134 93 3 20 MB-3 LCS-3 LCD-3
16. Chloroethane U 250 2,432 2,500 97 70 - 134 94 3 20 MB-3 LCS-3 LCD-3
17. Chloroform U 50 2,386 2,500 95 75 - 134 93 2 20 MB-3 LCS-3 LCD-3
18. Chloromethane U 250 2,404 2,500 96 70 - 134 94 2 20 MB-3 LCS-3 LCD-3
19. 2-Chlorotoluene U 50 2,331 2,500 93 70 - 134 89 4 20 MB-3 LCS-3 LCD-3
20. Dibromochloromethane U 100 2,513 2,500 101 70 - 134 99 2 20 MB-3 LCS-3 LCD-3
21. 1,2-Dibromo-3-chloropropane U 250 2,688 2,500 108 70 - 134 109 1 20 MB-3 LCS-3 LCD-3
22. Dibromomethane U 250 2,427 2,500 97 70 - 134 96 1 20 MB-3 LCS-3 LCD-3
23. 1,2-Dichlorobenzene U 100 2,291 2,500 92 70 - 134 89 3 20 MB-3 LCS-3 LCD-3
24. 1,3-Dichlorobenzene U 100 2,304 2,500 92 70 - 134 88 4 20 MB-3 LCS-3 LCD-3
25. 1,4-Dichlorobenzene U 100 2,279 2,500 91 70 - 134 89 2 20 MB-3 LCS-3 LCD-3
26. Dichlorodifluoromethane U 250 2,796 2,500 112 70 - 134 107 5 20 MB-3 LCS-3 LCD-3
27. 1,1-Dichloroethane U 50 2,306 2,500 92 70 - 134 90 2 20 MB-3 LCS-3 LCD-3
28. 1,2-Dichloroethane U 50 2,375 2,500 95 70 - 134 94 1 20 MB-3 LCS-3 LCD-3
29. 1,1-Dichloroethene U 50 2,413 2,500 97 75 - 134 92 5 20 MB-3 LCS-3 LCD-3
30. cis-1,2-Dichloroethene U 50 2,395 2,500 96 70 - 134 93 3 20 MB-3 LCS-3 LCD-3
31. trans-1,2-Dichloroethene U 50 2,377 2,500 95 70 - 134 92 3 20 MB-3 LCS-3 LCD-3
32. 1,2-Dichloropropane U 50 2,312 2,500 92 75 - 134 90 2 20 MB-3 LCS-3 LCD-3
33. cis-1,3-Dichloropropene U 50 2,487 2,500 99 70 - 134 97 2 20 MB-3 LCS-3 LCD-3
34. trans-1,3-Dichloropropene U 50 2,545 2,500 102 70 - 134 100 2 20 MB-3 LCS-3 LCD-3
35. Ethylbenzene U 50 2,419 2,500 97 75 - 134 93 4 20 MB-3 LCS-3 LCD-3
36. Ethylene Dibromide U 50 2,483 2,500 99 70 - 134 99 0 20 MB-3 LCS-3 LCD-3
37. 2-Hexanone U 2500 2,687 2,500 107 70 - 150 110 3 20 MB-3 LCS-3 LCD-3
38. Isopropylbenzene U 250 2,620 2,500 105 70 - 134 100 5 20 MB-3 LCS-3 LCD-3
39. Methylene Chloride U 100 2,187 2,500 87 70 - 134 86 1 20 MB-3 LCS-3 LCD-3
40. 4-Methyl-2-pentanone U 2500 2,768 2,500 111 70 - 134 113 2 20 MB-3 LCS-3 LCD-3
41. MTBE U 250 2,574 2,500 103 70 - 134 104 1 20 MB-3 LCS-3 LCD-3
42. Naphthalene U 330 2,476 2,500 99 70 - 134 99 0 20 MB-3 LCS-3 LCD-3
43. n-Propylbenzene U 100 2,417 2,500 97 70 - 134 91 6 20 MB-3 LCS-3 LCD-3
44. Styrene U 50 2,374 2,500 95 70 - 134 93 2 20 MB-3 LCS-3 LCD-3
45. 1,1,1,2-Tetrachloroethane U 100 2,644 2,500 106 70 - 134 104 2 20 MB-3 LCS-3 LCD-3
46. 1,1,2,2-Tetrachloroethane U 50 2,437 2,500 97 70 - 134 98 1 20 MB-3 LCS-3 LCD-3
47. Tetrachloroethene U 50 2,417 2,500 97 70 - 134 93 4 20 MB-3 LCS-3 LCD-3
48. Toluene U 50 2,367 2,500 95 75 - 134 92 3 20 MB-3 LCS-3 LCD-3
49. 1,2,4-Trichlorobenzene U 250 2,456 2,500 98 70 - 134 94 4 20 MB-3 LCS-3 LCD-3
50. 1,1,1-Trichloroethane U 50 2,421 2,500 97 70 - 134 94 3 20 MB-3 LCS-3 LCD-3
51. 1,1,2-Trichloroethane U 50 2,333 2,500 93 70 - 134 93 0 20 MB-3 LCS-3 LCD-3
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
Result RL Result Spike Rec. LCL - UCL Rec. RPD UCL
Parameter µg/kg µg/kg Q µg/kg µg/kg % % Q % % % Q MB LCS LCD
52. Trichloroethene U 50 2,506 2,500 100 70 - 134 97 3 20 MB-3 LCS-3 LCD-3
53. Trichlorofluoromethane U 100 2,238 2,500 90 70 - 134 85 6 20 MB-3 LCS-3 LCD-3
54. 1,2,3-Trichloropropane U 100 2,470 2,500 99 70 - 134 99 0 20 MB-3 LCS-3 LCD-3
55. 1,2,3-Trimethylbenzene U 100 2,351 2,500 94 70 - 134 90 4 20 MB-3 LCS-3 LCD-3
56. 1,2,4-Trimethylbenzene U 100 2,597 2,500 104 70 - 134 99 5 20 MB-3 LCS-3 LCD-3
57. 1,3,5-Trimethylbenzene U 100 2,456 2,500 98 70 - 134 93 5 20 MB-3 LCS-3 LCD-3
58. Vinyl Chloride U 40 2,446 2,500 98 75 - 134 94 4 20 MB-3 LCS-3 LCD-3
59. m&p-Xylene U 100 4,900 5,000 98 70 - 134 95 3 20 MB-3 LCS-3 LCD-3
60. o-Xylene U 50 2,400 2,500 96 70 - 134 93 3 20 MB-3 LCS-3 LCD-3
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
System Monitoring Compounds Result Spike Rec. Result Spike Rec. LCL - UCL Rec. RPD UCL
(Surrogates): µg/kg µg/kg % Q µg/kg µg/kg % % Q % % % Q MB LCS LCD
1. Dibromofluoromethane(S) 2,560 2,500 102 2,622 2,500 105 76 - 126 106 1 20 MB-3 LCS-3 LCD-3
2. 1,2-Dichloroethane-d4(S) 2,555 2,500 102 2,541 2,500 102 75 - 120 102 0 20 MB-3 LCS-3 LCD-3
3. Toluene-d8(S) 2,580 2,500 103 2,578 2,500 103 80 - 120 103 0 20 MB-3 LCS-3 LCD-3
4. 4-Bromofluorobenzene(S) 2,360 2,500 94 2,529 2,500 101 76 - 127 96 5 20 MB-3 LCS-3 LCD-3
Exception Summary:
Exceptions have been properly noted on reported results or affected samples have been scheduled for reanalysis when appropriate.
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
Result RL Result Spike Rec. LCL - UCL Rec. RPD UCL
Parameter µg/kg µg/kg Q µg/kg µg/kg % % Q % % % Q MB LCS LCD
1. Tetrachloroethene U 250 2,377 2,500 95 70 - 134 96 1 20 MB-5 LCS-4 LCD-4
Method Blank (MB) Laboratory Control Sample (LCS) LCS Duplicate (LCD) Run Code
System Monitoring Compounds Result Spike Rec. Result Spike Rec. LCL - UCL Rec. RPD UCL
(Surrogates): µg/kg µg/kg % Q µg/kg µg/kg % % Q % % % Q MB LCS LCD
1. Dibromofluoromethane(S) 2,530 2,500 101 2,610 2,500 104 76 - 126 104 0 20 MB-5 LCS-4 LCD-4
2. 1,2-Dichloroethane-d4(S) 2,619 2,500 105 2,652 2,500 106 75 - 120 104 2 20 MB-5 LCS-4 LCD-4
3. Toluene-d8(S) 2,596 2,500 104 2,611 2,500 104 80 - 120 104 0 20 MB-5 LCS-4 LCD-4
4. 4-Bromofluorobenzene(S) 2,395 2,500 96 2,440 2,500 98 76 - 127 96 2 20 MB-5 LCS-4 LCD-4
Exception Summary:
Exceptions have been properly noted on reported results or affected samples have been scheduled for reanalysis when appropriate.