The document provides instructions for using a 1P2385 protractor tool to set angles. It describes setting the angle indicator to the desired angle, then positioning either the indicator arm or plate until bubble levels and lever centerlines are aligned according to three different procedures depending on the specific housing face or lever being used.
The document provides instructions for using a 1P2385 protractor tool to set angles. It describes setting the angle indicator to the desired angle, then positioning either the indicator arm or plate until bubble levels and lever centerlines are aligned according to three different procedures depending on the specific housing face or lever being used.
The document provides instructions for using a 1P2385 protractor tool to set angles. It describes setting the angle indicator to the desired angle, then positioning either the indicator arm or plate until bubble levels and lever centerlines are aligned according to three different procedures depending on the specific housing face or lever being used.
Set angle indicator (1) on desired angle (A). Place
indicator arm (2) on a vertical housing face and rotate lever (3) until the lever centerline lies on the edge of plate (4); secure lever (3) in this position.
Set angle indicator (1) on desired angle (A). Rotate
plate (4) until the bubble in level (5) is centered. Rotate lever (3) until the lever centerline lies on the outside edge of indicator arm (2).
Set angle indicator (1) on desired angle (A). Place
the edge of plate (4) on the centerline of fixed lever (6) and rotate lever (3) until the lever centerline lies on the inside edge of indicator arm (2).
Created from page 23 SMHS7188 Special Instructions “Governor Linkage Adjustments”
Created 6/10/94 Last Updated 6/10/94 Printed February 4, 2000