Self-sustain Power Generator using Dynamo Motor and Rechargeable Battery
Advincula, Cabalo, Cabellon, Casilao, De La Pena, Diamante, Pansoy
La Consolacion College
Introductio Methods Results and Discussion
n The increased Importance -Prepare all the materials The researchers will discuss the results and the of fuel saving has been -Put 20 cm wires alternate red and efficiency of the prototype generator. responsible for the revival of black in the DC motor. Table 1 interest in so called Voltage Testing of different arrangement of -Install the pulley in the shaft of Dynamo Motors. alternative source of energy. DC motor. In this study the researchers -Arrange the DC motor in the Induced Dynamo Output creates a prototype for an board about 1 ½ inch distance Voltage Motors alternate source of energy apart. (V) using only dynamo motor -Glue the DC motor on its place in 3.7 Volt 9 Volt – 4.8 Volt and rechargeable battery. the board. 9 Volt - 5 -Attach the rubber band on the Volt pulley in every DC motor. 3.7 Volt 9 Volt – 3.6 Volt Materials -Attach wire on the battery holder. 5 Volt – -Glue the battery holder on the 9 Volt (3) DC Motors surface of the board. (1) Meter Wire (Red/Black) 3.7 Volt 5 Volt – 2.9 Volt - Attach the capacitor on the red (1) Multi-tester wire connecting in the battery 9 Volt - 9 (1) 3.7 Volts Rechargeable holder. Volt Battery -Attach the diode in the black wire Table 1 shows the result of the Voltage (3) Plastic Pulley connecting in the 2nd DC motor. output of the different arrangements of the (3) Rubber Band -Connect the battery holder on the DC motors. This concludes that the output (1) Capacitor 1st and 2nd DC motor. depends on the arrangement of DC (1) Diode -Attach a USB port on the 3rd DC Motorand the induced current. (1) Battery Holder motor. (1) Glue Table 2. (1) Soldering iron and lead Testing on actual devices using the (1) USB port Conclusion 9v-9v-5v DC motor arrangement. Devices Efficiency result The researchers concludes that to Charging Smart Slow charge about provide much voltage power needs Phone 3hrs to full. higher voltage induced, higher power capacity DC motors and Lighting LED bulb Lighted up but not right arrangement of DC so bright motor.Along with the circuits. This Table 2 shows the experiment on shows that the power produce is actual devices using the two 9volt DC dependent in the over all structure motor connecting to the 5volt DC of the prototype generator. motor. Smart phone charge but slow. LED bulb lights up but shows dim light Recommendation because of minor fluctuations. The higher the voltage of the DC motor the much current it produced. Also dependent to the voltage induce Figure 1 in the DC motor. Higher capacity DC motor induced by greater current produce much greater current. Use proper material for better efficiency.