Professional Documents
Culture Documents
CAM
Floor Leveling Procedure
NM
43 87 929, Rev. 05
Siemens Medical Systems, Inc. has prepared this document for use by its personnel and
licensees. Siemens reserves the right to change any products described in this document
as well as information included herein without prior notice. Although the information
presented in this document has been thoroughly tested and reviewed and is considered
reliable, this document does not convey any license or warranty beyond the terms and
conditions set forth in the written contracts between Siemens and its customer.
Any software described herein is licensed from and is a trade secret of Siemens Medical
Systems, Inc.
Siemens Medical Systems, Inc. reserves the right to make any content changes to this
document at any time.
The contents of this document might be affected by one or more Service Document
Updates (SDUs). Contact Service Technical Writing for a listing of the SDUs available
for this document.
All rights reserved. No part of this document may be reproduced, in any form or by any
means, without direct permission in writing from Siemens Medical Systems, Inc.
SMS-NMG E.CAM Floor Leveling Procedure
Revision History
43 87 929, Rev. 05 i
E.CAM Floor Leveling Procedure SMS-NMG
ii 43 87 929, Rev. 05
SMS-NMG E.CAM Floor Leveling Procedure
iv 43 87 929, Rev. 05
SMS-NMG E.CAM Floor Leveling Procedure
1.2 Precautions
– Epoxy resins may sensitize certain personnel.
– Wear protective clothing, plastic gloves and chemical splash
goggles.
– Avoid inhaling fumes.
– Wash skin and clothes with soap and water only.
– If eye contact occurs, flush immediately with clean water
and consult a physician.
– Seller makes no warranty and user assumes all risks with
respect to the use of this product.
– Allow 8 hours for curing.
– Suggested to pour epoxy floor late in afternoon when most
department personnel have left. This also allows over night
for curing.
1.3 Material
43 87 911 E.CAM Floor Leveling Kit contents:
43 87 929, Rev. 05 1
E.CAM Floor Leveling Procedure SMS-NMG
Tools needed:
Note
Note
Floor plate template is designed to be used with standard and
extended base plates. See fig. 2
Tape
Cut
Cut Rear Patient Bed template Foam
Foam
2 43 87 929, Rev. 05
SMS-NMG E.CAM Floor Leveling Procedure
167(65.75")
167(65.75)
71.8(28.25")
Standard Base
95.6(37.65")
Floor Plate under Gantry
23.9(9.4")
57.8(22.75") 85.1(33.4")
24.1(9.5")
43 87 929, Rev. 05 3
E.CAM Floor Leveling Procedure SMS-NMG
Floor
Figure 3 Wax Seal
10) Apply generous wax coating to entire floor area inside foam
frame.
4 43 87 929, Rev. 05
SMS-NMG E.CAM Floor Leveling Procedure
43 87 929, Rev. 05 5