Professional Documents
Culture Documents
Karachi: Room No.1, Mezzanine Floor, Al-Hayat Chambers, A-7, Block-7/8, K.C.H.S. Tel: +92 21 4535898-99, Fax: +92 21 4558071
Lahore: 25-A, FCC, Syed Maratib Ali Road, Gulberg 4, Tel: +92 42 5763360 Fax: +92 42 5875384
within 24 hours, with the surface
having again been pre-dampened. On
horizontal surfaces duraslurry is
normally applied by brush, although
the second coat of a three-coat system HEALTH & SAFETY
may be notch trowelled. Vertical
surfaces, except for the final coat of duraslurry is alkaline and should not
the system are usually applied by be allowed contact with skin and eyes.
notch trowel. The final coat of a Avoid inhalation of dust during mixing
system must be applied by brush and by wearing dust masks. The use of
left as smooth as possible. gloves, eye protection and dust masks
is advised. Splashes into eyes should
CLEANING be washed immediately with plenty of
clean water and medical advice sought
Tools, brushes and mixing equipment thereafter.
should be cleaned immediately after
use and before material has set with Cured duraslurry is inert and
abe super brush cleaner followed by harmless.
washing with soap and water.
IMPORTANT NOTE
PROTECTION ON COMPLETION
This data sheet is issued as a guide to
duraslurry may be overpainted with a the use of the product(s) concerned.
high quality PVA/acrylic paint. Whilst abe Construction Chemicals
endeavours to ensure that any advice,
TEMPERATURE AND RELATIVE recommendation, specification or
HUMIDITY information is accurate and correct, the
company cannot - because abe has no
Do not apply if temperature is below 5 C.
o direct or continuous control over where
and how abe products are applied -
MODEL SPECIFICATION accept any liability either directly or
indirectly arising from the use of abe
products, whether or not in accordance
Cementitious waterproofing slurry
with any advice, specification,
for reservoirs, dams, basements,
recommendation, or information given
silos and sewage plants.
by the company.
The waterproofing compound will be
duraslurry, a single-component, FURTHER INFORMATION
cementitious slurry applied in
accordance with the recommendations Where other products are to be used
of abe Construction Chemicals. The in conjunction with this material, the
slurry will have a bulk density of 1,1 kg/l. relevant technical data sheets should
be consulted to determine total
requirements. abe Construction
PACKAGING Chemicals has a wealth of technical
and practical experience built up over
duraslurry is supplied in 25 kg
years in the company’s pursuit of
polyethylene lined paper bags.
excellence in building and construction
technology.
HANDLING & STORAGE
Revision 9203
Karachi: Room No.1, Mezzanine Floor, Al-Hayat Chambers, A-7, Block-7/8, K.C.H.S. Tel: +92 21 4535898-99, Fax: +92 21 4558071
Lahore: 25-A, FCC, Syed Maratib Ali Road, Gulberg 4, Tel: +92 42 5763360 Fax: +92 42 5875384