Professional Documents
Culture Documents
F 430 (C2 E)
F 430 is especially designed for fixing ceramic and • Optimal processing properties
porcelain tiles. It can be utilized in wall and floor tiles
• Fast track application with designed tools
fixation in showers, bathrooms, kitchens, and toilets. It
can be used on concrete and plaster substrates, • Extended open times &polymer modified
especially for swimming pools or wet areas, where an • Increased resistance against vibrations
absolute vibration resistance is expected.
• Mineral binders and mineral aggregates
o Cement plasters • Noncombustible, no shrinkage, and water resistance
o Concrete surfaces
o Floor and wall tiles, internal and external.
• Extreme bonding strength & shear resistance
Substrate:
• All substrates must be clean, dry, and free of CONSISTENCY Granular Powder
contaminants that may affect the bonding strength. Color Grey/white
• Prior to applying the material, spray enough
Cement, polymers modified, limestone
clean potable water to neutralize the suction of Composition
and silica sand selected (0.1-0.5mm)
background.
Wet Density 1500 - 1700 Kg/m3
Temperature: Pot Life 1 Hr.
• Ideal application temp between 10°c-35°c, if more Layer
2-10mm
than 35°c use cool water to avoid de bonding. Thickness
Consumption Approx. 6 - 7 kg/m2 @ 6 mm Notch trowel
Bonding
Strength 1 N/mm2 @ 28 days
DISCLAIMER
Curing is not required. All instruction and data of this data sheet
are general information only and are
based on our experience and tests
performed. Under all circumstances the
relevant standard and general
knowledge of construction /engineering
must be implemented. In case of specific
question or requirements please contact
our Technical Services /Sales team. Users
must always refer to the most recent
“revision” of the Product Data Sheet,
copies of which will be supplied on
request.
PRODUCT DATA SHEET P.O. Box 111681, Industrial City (ICAD2) Abu Dhabi,
EXEED PREMIUM DRY MORTAR UAE T +971 2 203 8760 F +971 2 550 2157 Email :
Rev 01 – 01/01/2023 info.premium@exeed.ae / www.exeedpremium.ae
C2
Temperature Restrictions
It is suggested that, for temperatures higher than 35°C, the following guidelines are adopted as
Equipment
SectionB:B:Application
Section ApplicationMethod
Method
Surface preparation
• Clean the selected substrate and remove any dust, unsound materials, oil, paint, grease
etc.
• Make sure to spray enough amount of water to achieve a moist substrate.
Mixing
• The mixing should be done in a suitable sized mixing vessel, with 40 litres capacity.
• Pour 5.5 ltrs of water into the mixing vessel and slowely add F 430, respectively.
• Check the consistency and the homogeneity of the mix. The homogeneity is the condition
where there are no lumps and the consistency is uniform. Continue mixing until a
homogeneous and consistent state is achieved.
Application
Cleaning
• All tools must be cleaned immediately after application. If the material sets on the tools, then
mechanical cleaning will be required.
-This method statement is offered by Exeed premium Dry Mortar as a ‘standard proposal’ for the
application of F 430. It remains the responsibility of the Engineer to determine the correct
method for any given application.
-This information is furnished without warranty, expressed or implied, except that it is accurate to the
best knowledge. The data on this sheet are related only to the specific materials designated herein. Exeed premium
Dry Mortar assumes no legal responsibility for use or reliance upon this data.