Professional Documents
Culture Documents
Name : ………………………………………..
Class : ……………………………………….. SKOR
No. Absent : ………………………………………..
ELECTRODYNAMICS
Electrodynamics | UNESA
Page 2
V (volt)
constant resistance (R) expressed by the picture
graph of the number …. below. If V =
3
4,5 volts, the
large currents
flowing is ….
a. 5 mA I (ampere)
0,02
b. 10 mA
c. 20 mA
d. 30 mA
e. 35 mA
Electrodynamics | UNESA
Page 3
d. 44 volt b. 1/2R
e. 69 volt c. 1/4R
d. 1/8R
18. The potential difference that must be given e. 1/16R
at the ends of a wire that has resistance 2 Ω
and the electric current 12 A flowing 24. The table below as the results of
through the wire is …. experiments from five types of wire that
a. 2 volt have the same resistivity.
b. 6 volt Wire Length Cross-Sectional Area
c. 12 volt (1) l A
d. 24 volt (2) 2l A
e. 30 volt (3) 0,5l 3A
(4) 0,2l 2A
19. A wire has a resistance 0,4 Ω given the (5) 5l 0,5A
potential difference 200 mV at its ends. The
Based on the table above, the wire which
electric current flowing on the wire is ….
has the largest resistance of wire is ….
a. 1/50 A
a. (1)
b. 0,5 A
b. (2)
c. 5 A
c. (3)
d. 50 A
d. (4)
e. 500 A
e. (5)
20. Electric heater required 5 A if it is
25. If a piece of wire is divided into four
connected to 110 V. The value of resistance
sections in the same length, then the
is ….
resistance of each part equals ….
a. 0,05 Ω
a. ¼ times of the first resistance
b. 5 Ω
b. ⅓ times of the first resistance
c. 22 Ω
c. ½ times of the first resistance
d. 110 Ω
d. 2 times of the first resistance
e. 550 Ω
e. 4 times of the first resistance
21. This following are the factors of determine
26. The figure below shows three copper
the resistance of a conductor, except ….
conductors with cross-sectional area and
a. Cross-sectional area of conductor
length as shown.
b. Density of conductor L
c. Temperature of conductor 1,5 L L/2
d. Length of conductor A
A/2 A/2
e. Type of conductor
(1) (2) (3)
22. Resistance wire electricity networks will
If the ends of the three conductors are given
increase in daylight, because:
the same voltage (V), the electric current
(1) The wire becomes longer
flowing through a conductor is ….
(2) Electric current decreases during the
a. (1) > (2) > (3)
day
b. (2) > (1) > (3)
(3) Resistivity of wire is increase
c. (3) = (2) > (1)
(4) Cross-sectional area of wire enlarge
d. (1) = (2) < (3)
The statement is true ….
e. (1) = (3) > (2)
a. (1), (2) and (3)
b. (1) and (3)
27. A wire has electrical resistance 2 Ω. This
c. (2) and (4)
wire then pulled up without changing the
d. (4)
volume, temperature, and resistivity, so that
e. All
its diameter is become reduced half its
original value. Now, the resistance of wire
23. A copper wire has a resistance R. Another
is ….
copper wire has weighs the same but the
a. 2 Ω
diameter is twice the original copper wire.
b. 4 Ω
Resistance to this copper wire is ….
c. 8 Ω
a. R
d. 16 Ω
Electrodynamics | UNESA
Page 4
e. 32 Ω b. Ohm’s law
c. Kirchhoff’s first law
28. A piece of metal wires 60 Ω is pulled up to d. Kirchhoff’s second law
the length to a half times the length e. Sum of electric current’s law
originally. New resistance would be ….
a. 60 Ω 34. Consider the picture below:
b. 70 Ω I2
c. 80 Ω I1 I4
d. 90 Ω
I3
e. 100 Ω
The correct statement to say a magnitude
29. It is known that the resistivity of conductor electric current that flow is ….
material as follows: a. I1 = I2 + I3 + I4
1. Iron 0,0038 b. I1 = I2 + I3 - I4
2. Aluminum 0,0040 c. I1 + I2 = I3 + I4
3. Tungsten 0,0045 d. I1 + I4 = I2+ I3
4. Copper 0,0039 e. I1 = I2 + I3 = I4
5. Silicon -0,0700
We will get the biggest resistance, the
material chosen as a good conductor is …. 35.
5A 2A
a. Iron
b. Aluminum
c. Tungsten 9A 1,5 A
d. Copper
e. Silicon X
30. The sequence of the resistivity below from From the circuit above, the magnitude and
the smallest to the largest is …. direction of electric current of X is ….
a. Conductor, semiconductor, isolator a. 3,5 A enter branch point
b. Conductor, isolator, semiconductor b. 4,5 A exit branch point
c. Isolator, semiconductor, conductor c. 4,5 A enter branch point
d. Isolator, conductor, semiconductor d. 7,5 A exit branch point
e. Semiconductor, isolator, conductor e. 7,5 A enter branch point
31. A wire has resistance 30 ohm. If the wire 36. Consider the circuit figure below!
length 1 m and cross-sectional area 0,4 I1 = 2 I2 A
mm2. The resistivity of wire is ….(ᴨ = 3,14)
I = 12 I2 = 3 A
a. 1,2 Ω.mm2/m
b. 1,2 Ω.m A I3 = ? B
c. 12 Ω.mm2/m
d. 12 Ω.mm
e. 12 Ω.m Electric current in the I3 is ….
a. 1 A
32. The length of conductor is 10 m, with b. 3 A
diameter 2 mm. The wire has a resistance c. 4 A
type of 3,14 x 10-5 Ω.m. The resistance of d. 6 A
wire is ….(ᴨ = 3,14) e. 9 A
a. 60 Ω
b. 70 Ω 37. If there is resistance R1, R2 and R3 is
c. 80 Ω connected series, then the formula to
d. 90 Ω determine the resistance equivalent of true
e. 100 Ω is ….
a. R1 + R2 + R3
33. “Sum of electric current entering a branch b. R1 - R2 - R3
point is equal to sum electric current c. R1 x R2 x R3
leaving that branch point”. This statement is d. R1 : R2 : R3
known …. e. 1/R1 + 1/R2 + 1/R3
a. Electric current’s law
Electrodynamics | UNESA
Page 5
38. If there is resistance R1, R2 and R3 is e. L1 and L2 are turn off and are switch on
connected parallel, then the formula to
determine the resistance equivalent of true 43. Lamps A, B, C and E, if lamp A off, hence
is …. …. A B
a. R1 + R2 + R3
b. R1 - R2 - R3 C
c. R1 x R2 x R3
d. R1 : R2 : R3 D
E
e. 1/R1 + 1/R2 + 1/R3
39. Which shows the characteristics of the a. Four lamps are turn on
parallel circuit is .... b. Only lamp B, D and E which are turn
a. The resistance equivalent always on
smaller than the smallest resistance c. Only lamp C, D and E which are turn
b. The resistance equivalent always on
smaller than the largest resistance d. Only lamp D and E which are turn on
c. The resistance equivalent always larger e. Four lamps are turn off
than the smallest resistance
d. The resistance equivalent always larger 4Ω 5Ω 3Ω
than the largest resistance 44.
e. The resistance equivalent equals with The value of resistance equivalent
total every smaller resistance according circuit above is ….
a. 1,3 Ω
40. Resistance equivalent from a circuit of b. 4 Ω
compose three resistors of 2 Ω cannot c. 12 Ω
probable has value is …. d. 36 Ω
a. 2/3 Ω e. 60 Ω
b. 4/3 Ω
c. 1,5 Ω 45. The value of resistance equivalent from
d. 3 Ω circuit below is …. 2Ω
e. 6 Ω a. 1 Ω
b. 3 Ω 3Ω
41. The figure below shows the same four c. 6 Ω
resistors are connected in a square. If this d. 12 Ω 6Ω
arrangement is connected to a circuit, this e. 36 Ω
arrangement will give the smallest
resistance if a connection is made at the 46. The value of resistance between A and B
ends …. are …. B
P Q 20 Ω
a. P and Q a. 10 Ω 30 Ω
b. Q and R b. 16 Ω
c. R and S c. 20 Ω A C
d. S and P d. 25 Ω
e. Q and S S R e. 100 Ω 10 Ω 40 Ω
Electrodynamics | UNESA
Page 6
R1
b. 15 Ω The potential difference between P and Q is
c. 20 Ω R3 ….
d. 25 Ω R2 R4 a. 5 V
e. 30 Ω b. 10 V
c. 20 V
49. If electrical resistance is measured between d. 30 V
point A and B in the circuit below, so the e. 40 V
value will be obtained is ….
a. 6 Ω 2Ω 2Ω 2Ω 2Ω
b. 8 Ω A
c. 10 Ω
d. 12 Ω 6Ω 4Ω
e. 16 Ω
2Ω 2Ω 2Ω 2Ω
B
P
10 V
20 Ω
Electrodynamics | UNESA