You are on page 1of 5

Crank 

shaft change work instruction 
1. Remove the top plate, front door and 2 side panels 
2. Disconnect  the  connector  from  power  supply  plug,  loose  the  motor  lead  wire  from  PCB(red  arrow 
marked in PIC1) 

PIC1 
3. Loose the plastic holder to pull the motor lead wire out.(see PIC2,PIC3) 

PIC2 PIC3 
4. Loose the 8pcs M6 screws (3pcs each side, 2pcs at bottom), and remove the back plate. (red arrow 
marked in PIC4) 

    PIC4 
5. Loose the 2pcs M6 nuts for the leaf spring(red arrow marked in PIC5) 

PIC5 
6. Loose the 4pcs M6 screws to remove the front bracket(red arrow marked in PIC6) 

PIC6         

  (after bracket removed view) 

7. Loose the 8pcs M8 screws of the bearing bracket(4pcs of each side) (red arrow marked in PIC7) 

PIC7      
8. Remove the clamping subassembly from machine. 

  PIC8 
9. Loose the 4pcs M12 screws then remove the crank shaft assembly(red arrow marked in PIC9) 

    PIC9 

(the machine view after those removed) 
10. Loose the 4pcs 3mm setting screws of the two bearings(2pcs of each) 

PIC10     
Crank shaft assembly 
11. Use a handle to remove the 2 bearings. 

PIC11 
12. Loose  the  4pcs  4mm  setting  screws  (crank  install  to  main  shaft  position).2pcs  of  each 
crank, the samll shaft is unnecessary to take apart. 

PIC12     
13. Use a hammer to knock the 2 cranks down through the main shaft 

PIC13 
14. Loose 4pcs 3mm setting screw of inner bearings(2 screws of each)   

PIC14 
15. Loose 2pcs 4mm setting screws of the weight 
Note that length of 2 screws are different. The long one is for tighten the site with key. 
And should aim at the hole of the key when install it.   

PIC15 
 
 
 
16. Use  the  weight  to  knock  the  inner  bearings  out  of  the  shaft,  the  same  method  for  the 
two bearings.   

PIC16 
17. Changing a new shaft, Follow the dis‐assembly process, from last step item16 to first step 
item1, install each conponent to the shaft, and then assemble the crank shaft assembly 
into the whole machine. 
Note:   
Need put locatite 243 to setting screws of crank assmebly. 
When tighten M12 screws (crank shaft assembly into end plate), must use 120NM torque. 

You might also like