Professional Documents
Culture Documents
Tel : +82 52 204 7860 / FAX: +82 52 204 7801 / E-MAIL : service@hyundai-gs.com
Service Letter
Subject: Notice for repair procedure of cylinder head closing cover leakage
Product: HiMSEN
Type : All
Recently we were asked for repair procedure of cylinder head closing cover leakage from
several vessels.
In case of leakage from closing cover(section no. 21100, item no. 115), re-assembly of closing
cover is required on cylinder head body’s machining holes by interference fit with fabrication of
fitting tool as follows.
[Repair procedure]
- Closing cover(sample) – Fig. 1
1) Remove the old closing cover by drilling
2) Fabricate the fitting tool with round bar for interference fit
(Round bar diameter = closing cover diameter – 2 mm)
3) Clean the closing cover hole on cylinder head
4) Insert new closing cover with Loctite 638 by using the fitting tool with hammering
5) Work completion
Fig. 1
Ref.No.:HGS-HSM-SL-19-011
For more information, please contact Machinery Service department of Hyundai Global Service.
Faithfully yours,
Technical Division
http://www.hyundai-gs.com
[EOD]