Professional Documents
Culture Documents
The Antennacraft FM13 is a log-Yagi array with 13 elements on a 137″ boom. Five of the elements are driven. A review is
here.
I modeled the antenna with the AO 9.67 Antenna Optimizer program. This image shows the antenna geometry.
This shows segmentation detail for the phasing lines and feedpoint. I jumpered a wire across the feedpoint terminals and placed
a source at its center. Blue dots mark analysis segments. The red dot is the feedpoint.
Modeling Results
Calculated performance is for 28 analysis segments per conductor halfwave with additional segments for the phasing lines.
Forward gain includes mismatch and conductor losses. F/R is the ratio of forward power to that of the worst backlobe in the
rear half-plane.
Antenna File
Antennacraft FM13
Free Space
98.000 MHz
77 6063-T832 wires, inches
de1 = 15.75 ; driven element locations
de2 = 25.75
de3 = 35.75
de4 = 45.75
de5 = 55.75
d = .11 ; phasing-line diameter
r = 3 / 2 ; half of rivet spacing (insulated elements)
h = 10 / 2 ; half of DE spacing
y1 = r * (1 - 2.375 / h) ; y at first phasing-line bend
y2 = r * (1 - 2.875 / h) ; y at second bend
y3 = -y2 ; y at third bend
y4 = -y1 ; y at fourth bend
x1 = de1 + 2.375 ; x at first phasing-line bend, rear line
x2 = de1 + 2.875 ; x at second bend
x3 = de2 - 2.875 ; x at third bend
x4 = de2 - 2.375 ; x at fourth bend
x5 = de2 + 2.375 ; x at first phasing-line bend, second line
x6 = de2 + 2.875 ; x at second bend
x7 = de3 - 2.875 ; x at third bend
x8 = de3 - 2.375 ; x at fourth bend
x9 = de3 + 2.375 ; x at first phasing-line bend, third line
x10 = de3 + 2.875 ; x at second bend
x11 = de4 - 2.875 ; x at third bend
x12 = de4 - 2.375 ; x at fourth bend
x13 = de4 + 2.375 ; x at first phasing-line bend, forward line
x14 = de4 + 2.875 ; x at second bend
x15 = de5 - 2.875 ; x at third bend
x16 = de5 - 2.375 ; x at fourth bend
s = .375 / 2 ; half of phasing-line crossover spacing
b = .75 ; feedpoint bolt length
1 source
Wire 76, center
Bracket 4" x 1.625" x 0.5" x 0.05" modeled as a U channel with YO 8.00 to get
the 1.28" equivalent diameter of the inner taper section for the parasitic
elements.