Q.2- 1 mm is equal to _______ μ. (a) 1μ (b) 10μ (c) 100μ (d) 1000μ Q.3- 1 inch is equal to ________ cm. (a) 25.4 (b) 2.54 (c) 25 (d) None Q.4- Least count is ________ possible measurement. (a) Smallest (b) largest (c) medium (d) None of these Q.5- Least count of micrometer is ________. (a) 0.01mm (b) 0.02mm (c) 0.05mm (d) None Q.6- Least count of vernier calliper is _________. (a) 0.01mm (b) 0.02mm (c) both (d) None Q.7- Angle protector is used for ______________. (a) Measure the angle (b) Measure of depth ( c) Both (d) None of these Q.8- Height gauge is used for ____________. (a) Measure the angle (b) Measure/gauge the height (c) Both (d) None of these Q.9- Upper limit of 35±0.05mm. (a) 24.950mm (b) 25.050mm (c) 25mm (d) None of these Q.10- Lower limit of 28±0.05mm. (a) 24.950mm (b) 25.050mm (c) 25mm (d) None of these Q.11- Vernier depth gauge is used for ________. (a) Measure the Height (b) measure/gauge the Depth (c) Both (d) None of these Q.12- Vernier calliper is used for ________. (a) Measuring (b) Checking (c) Cutting (d) None of these Q.13- “//” is symbol of ________. (a) Perpendicularity b) Parallelism (c) Angularity (d) Cylindericity Q.14- “ “ is symbol of _________. (a) Perpendicularity (b) Parallelism (c) Angularity (d) None of these Q.15- Vernier calliper can measure the _________. (a) Outside profile (b) Inside profile (c) Depth profile (d) All of these Q.16- Plug gauge is used for checking __________. (a) Hole diameter (b) Shaft diameter (c) Thread pitch (d) All of these Q.17- Anvil & Spindle is part of _________. (a) Micrometer (b) Vernier calliper (c) Depth gauge (d) None of these Q.18- Metrology is science of _________. (a) Technology (b) Measurement (c) Graphic (d) Robotics Q.19- Types of tolerance is _________. (a) Unilateral tolerance (b) Bilateral tolerance (c) Both a & b (d) None of these Q.20- Scriber is a ___________ tool. (a) Marking tool (b) Measuring tool (c) Cutting tool (d) None of these Q.21- Height gauge is used for ____________. (a) Measure the angle (b) Measure/gauge the height (c) Both (d) None of these Q.22- Upper limit of 25±0.05mm. (a) 24.950mm (b) 25.050mm (c) 25mm (d) None of these Q.23- Lower limit of 25±0.05mm. (a) 24.950mm (b) 25.050mm (c) 25mm (d) None of these
Q.24- Vernier depth gauge is used for ________.
(a) Measure the Height (b) measure/gauge the Depth (c) Both (d) None of these
Q.25- Vernier caliper is used for ________.
(a) Measuring (b) Checking (c) Cutting (d) None of these