You are on page 1of 10

1/2

TECHNICAL INFORMATION

FROM

NETWORK AND COMMUNICATION GROUP

Subject : CBG-2692 PS UNIT REPLACEMENT

Equipment : JSS-296 MF/HF RADIO EQUIPMENT


(NAH-692 POWER AMPLIFIER)

Date : October 28, 2003

Issue Number : JD-1269-03

M.Kawaguchi
Assistant General Manager,
Network and Communication Group
Engineering Department
Marine Electronics Division
2/2
Priority × A: Carry out immediately
B: Carry out at periodical inspection
C: Carry out upon client’s request
D: Information and news

1. Subject
CBG-2692 PS UNIT REPLACEMENT

2. Objective Equipment
JSS-296 MF/HF RADIO EQUIPMENT
(NAH-692 POWER AMPLIFIER)
Refer to the Objective ships list for JD-1269-03.

3. Outlines
Problem:
The coil (L3) on the PS UNIT (CBG-2692) in POWER AMPLIFIER (NAH-692) will be burned.
Countermeasure:
Exchange the PS UNIT (CBG-2692) in accordance with the CBG-2692 replacement procedures.
Be sure to send back the removed PS UNIT (CBG-2692) to the COMMUNICATION GROUP,
QUALTY ASSURANCE DEPARTMENT, MARINE ELECTRONICS DIVISION Via MARIN
SERVICE DEPARTMENT.
Note1: The replacement of NAH-692 and JSB-196GM changes into replacement of only the PS UNIT.
Note2: The PS UNIT is attached in the aluminum board.
Note3: The JRC code of the PS UNIT is CBG-2692.

4. Attached document
CBG-2692 PS UNIT replacement procedures
Objective ships list for JD-1269-03.
CBG-2692 PS UNIT 交換手順書
CBG-2692 PS UNIT Replacement procedures

(1) NAH-692 POWER AMPLIFIER の AC,DC スイッチを OFF にします。


Turn off the “AC” and “DC” switch of NAH-692 POWER AMPLIFIER.

(2) 全面パネルのビス 12 個を外します。


Remove the 12 screws of the front panel.

(3) NAH-692 POWER AMPLIFIER を引き出します


Pull out the NAH-692 from the console.

(4) NAH-692 背面のケーブルを全て外します。


Disconnect all cables on the back of NAH-692.

(5) NAH-692 を作業スペースに移動します。


Carry the equipment to working area with care.

-1-
(6) 天井板のビス 9 個を外します。
Remove 9 screws of the upper panel.

(7) フラットケーブル J4、J5 および、スイッチケーブル J1, J3 を外します。


Disconnect the flat cables J4 , J5, and switch cables J1, J3.

J1 (AC SW)

J4 (CDJ-2692)

J5 (CDJ-2692)

J3 (DC SW)

(8) 背面パネルからのコネクタ J2、J6、J7、J8、J9 を外します。


Disconnect the cable J2, J 6, J7, J8 and J9.

J2 (AUX PS)

J9 (BATT MONI)

J6 (ACCESSORY)

J7 (NFC)

J8 (JSB)

-2-
(9) 以下の端子のビスを外します。
Remove the screws of the
following terminals

TB10 (BATT+) Red


TB11 (BATT+) Red
TB12 (BATT−) Blue
TB13 (BATT−) Blue

TB21 (13.6V+) Red


TB22 (13.6V+) Red
TB23 (13.6V−) Blue
TB24 (13.6V−) Blue

(10) J10, J11, J12 FAN 用コネクタ


を外します。
Disconnect cable J10, J11
and J12 for fan.

(11) PS1 のコネクタ CN1, CN2 を


外します。
Disconnect the CN1 and
CN2 of PS1 unit.

(12) AC ケ ー ブ ル の ビ ス を
TB1(ACL)、TB2(CAN)端子か
ら外します。
Remove the screws of AC
cables from the TB1 (ACL)
and TB2 (ACN) terminals.

-3-
(13) 下記端子のビスを外す。
Remove the screws of the following terminals.
TB3 (L1)、TB4 (L1)、TB5 (T1-P)、TB6 (T1-P)、TB7 (T1-S)、TB8 (L2)、TB9 (T1-S)、
TB14 (T5-P)、TB18 (T5-S)、TB17 (L4)、 TB15 (T5-P)、TB16 (T5-S)、
TB19 (80V+) Red、TB20 (80V−) Blue

(14)IC 固定ビス、基板と放熱器
を固定しているビスを外す。
(取り外すビスの位置は次
ページを参照。)
Remove the screws from
IC and PCB. (Refer to the
next page for the position
of the screws to remove.)

-4-
下図のビスを取り外すします。(55 本)
Remove the screws of the following figure. (55 screws)

-5-
(15) 基板を外し、放熱器上に残った
取付足(スペーサ)を全て外す。
Remove the spacers from the
radiator.

取付足
Spacer

(16) 交換用基板を取り出す。
Prepare the new PCB.

(17) 交換用基板の事前準備として
本体放熱器との固定用ビスを
ピンセット等で、予め挿入して
おく。(使用するビスの長さは
次 ペ ー ジ の 図 参 照 )
For the easy assemble, insert
the screws each fixing points
before assemble.
(Refer to the next page to use
proper screws.)

-6-
図示の個所のネジは 本体の放熱器と確実に固定する事。 (計 18 本)
Fix with radiator, using proper screws. (18 screws)

-7-
(19) 交換用基板を本体に入れます。
Attach the new PCB on the radiator
with care.
.

(20) 本体放熱器と交換用基板を固定しま
す。
Tighten all screws on the PCB and
IC to the radiator.

CAUTION
プリント板の固定には 18 本全てのビスを使用してください。少ないビスでの
固定は故障の原因となります。
Use all 18 screws for fixation of the PCB. Fixation on a few screws may
lead to malfunction.

(21) 手順(2)から(14)で取り外した全ての配線・ネジを取り付け後、NAH-692 をコンソールに戻します。


Return the NAH-692 to the console after attaching all of the wirings and screws that were
removed in the procedure of (2) to (14).

-8-

You might also like