Professional Documents
Culture Documents
General Description
COMMUNICATION SYSTEM
1. General Description
A: COMPONENT
(1)
(2)
(3)
(4)
(5)
COM00142
(1) Horn switch (driver’s airbag (3) Horn relay (5) Horn ASSY - Hi
module ASSY)
(2) Roll connector (4) Horn ASSY - Lo
B: CAUTION
• Before disassembling or reassembling parts, always disconnect the battery ground cable from battery.
When replacing the audio, control module and other parts provided with memory functions, record the mem-
ory contents before disconnecting the battery ground cable. Otherwise, the memory is cleared.
• Reassemble the parts in the reverse order of disassembly procedure unless otherwise indicated.
• Connect the connectors securely during reassembly.
• After reassembly, make sure that the each component operates normally.
• Yellow connectors and harnesses with yellow tapes around them are the connectors and harnesses for the
airbag system. Using a tester above such circuits may cause malfunction of airbag system. Follow the cau-
tions of “AIRBAG SYSTEM” in this case. <Ref. to AB-10, CAUTION, General Description.>
• Be careful not to damage the airbag system wiring harness when servicing electrical parts and switches.
C: PREPARATION TOOL
1. GENERAL TOOL
TOOL NAME REMARKS
Circuit tester Used for measuring resistance and voltage.
COM-2
15IM_US_EN.book 3 ページ 2015年12月25日 金曜日 午前9時22分
(A)
(B)
COM00115
NOTE:
For other related fuses, refer to the wiring diagram.
• Gasoline engine model <Ref. to WI(w/o HEV)-16, Power Supply Circuit.>
• HEV model <Ref. to WI(HEV)-21, Power Supply Circuit.>
B: INSPECTION
1. CHECK FUSE
1) Remove the fuse and check visually.
2) If the fuse is blown out, replace the fuse.
2. CHECK RELAY
1) Check the resistance between relay terminals.
Terminal
Inspection conditions Specification Circuit
No.
1—2 Always 1 MΩ or more
1 2 1
1—2
Apply battery voltage between
Less than 1 Ω
2
4 — 3 terminals. 3 4 3 4
SR-00180
2) Replace the relay if the inspection result is not within the standard value.
COM-3
15IM_US_EN.book 4 ページ 2015年12月25日 金曜日 午前9時22分
Horn System
COMMUNICATION SYSTEM
3. Horn System
A: WIRING DIAGRAM
Refer to “Horn System” in the wiring diagram.
• Gasoline engine model <Ref. to WI(w/o HEV)-142, WIRING DIAGRAM, Horn System.>
• HEV model <Ref. to WI(HEV)-150, WIRING DIAGRAM, Horn System.>
B: INSPECTION
Symptoms Inspection steps
1. Check the fuse.
2. Check the horn relay.
3. Check the role connector.
Horn does not sound
4. Check the horn switch.
5. Check the horn assembly.
6. Check the harness.
C: NOTE
For operation procedures of each component of the horn system, refer to the respective section.
• Horn ASSY: <Ref. to COM-5, Horn.>
• Horn switch: <Ref. to COM-8, Horn Switch.>
COM-4
15IM_US_EN.book 5 ページ 2015年12月25日 金曜日 午前9時22分
Horn
COMMUNICATION SYSTEM
4. Horn
A: REMOVAL
CAUTION:
Do not remove the bumper face - front when removing the horn, in order to prevent damaging the
claws of the bracket - front bumper corner and the bracket - front bumper side.
1) Disconnect the ground cable from battery.
2) Remove the clip, and remove the bracket - grille.
COM00143
AC-03184
COM-5
15IM_US_EN.book 6 ページ 2015年12月25日 金曜日 午前9時22分
Horn
COMMUNICATION SYSTEM
COM00144
COM00098
COM-6
15IM_US_EN.book 7 ページ 2015年12月25日 金曜日 午前9時22分
Horn
COMMUNICATION SYSTEM
B: INSTALLATION
CAUTION:
Install so that the front end of the under cover (b) comes inside the bumper face - front (a), and the
front end of the mud guard (c) comes outside the bumper face - front (a).
(a)
COM00138
COM00099
COM-7
15IM_US_EN.book 8 ページ 2015年12月25日 金曜日 午前9時22分
Horn Switch
COMMUNICATION SYSTEM
5. Horn Switch
A: NOTE
Horn switch is a unit with the driver’s airbag module. For operation procedures, refer to “Driver’s Airbag Mod-
ule” in “AIRBAG SYSTEM”. <Ref. to AB-32, Driver’s Airbag Module.>
B: INSPECTION
1. CHECK HORN SWITCH
1) Remove the driver’s airbag module. <Ref. to AB-32, REMOVAL, Driver’s Airbag Module.>
2) Check that the connection of the horn switch harness connector is correct.
3) Disconnect the horn switch harness connector and check the resistance between the harness connectors.
Preparation tool:
Circuit tester
1 2 3 4 5 6
7 8 9 10 11 12
(a) (b)
COM00114
4) Replace the driver’s airbag module if the inspection result is not within the standard value.
COM-8
15IM_US_EN.book 9 ページ 2015年12月25日 金曜日 午前9時22分
Horn Switch
COMMUNICATION SYSTEM
3) Replace the roll connector if the inspection result is not within the standard value.
COM-9
15IM_US_EN.book 10 ページ 2015年12月25日 金曜日 午前9時22分
Horn Switch
COMMUNICATION SYSTEM
COM-10
15IM_US_EN.book 1 ページ 2015年12月25日 金曜日 午前9時22分
GLASS/WINDOWS/MIRRORS
GW
Page
1. General Description ...................................................................................2
2. Relay and Fuse ..........................................................................................8
3. Power Window System ............................................................................10
4. Power Window Control Switch .................................................................12
5. Front Door Glass ......................................................................................18
6. Front Regulator and Motor Assembly ......................................................21
7. Remote Control Mirror System .................................................................23
8. Outer Mirror Assembly .............................................................................24
9. Remote Control Mirror Switch ..................................................................28
10. Rearview Mirror ........................................................................................30
11. Rear Door Glass ......................................................................................31
12. Rear Regulator and Motor Assembly .......................................................33
13. Windshield Glass .....................................................................................35
14. Rear Window Glass .................................................................................44
15. Rear Gate Glass ......................................................................................47
16. Rear Window Defogger System ...............................................................50
17. Rear Quarter Glass ..................................................................................53
18. Wiper Deicer System ...............................................................................56