Professional Documents
Culture Documents
INTRODUCTION
This mobile detector circuit detects the mobile phones at low distances.
The frequencies which are emitted by mobile phones are detected by this
circuit.
WORKING PRINCIPLE
We have used 2 diodes IN34 series. These two diodes are connected
alternate to each other. They act as a Schottky Diode. So when the
frequencies between Kilo Hz or Mega Hz comes in range of these diodes
the LED will glow.
To simulate the circuit and to get output I used function generator and
connect across diodes, which produces frequency and the LED will glow.
We will check circuit from 1kHz to 500mHz frequency. The range of this
circuit is in few meters.
The diodes we used are 1n34 series diodes which are used to detect
the frequencies. These are the main components in the circuit as they
detect the mobile frequencies.
If you use 22uF capacitor LED will glow more brightly when circuit
will detect mobile phone frequencies.
WORKING PRINCIPLE
CONSTRUCTION
RF Amplifier
o RF Amplifier is made up of capacitors, transistor and resistor and
which is used to amplify the signal and noise signal produced by
capacitors.
Tuned oscillator
o Tuned oscillator produces high frequency with less damping.
To increase the range of frequency, you should change the values of 22nH
inductor and 15pF capacitor. As you reduce the values of these two
components range of frequency will increase.
To find how much range of frequency your circuit will produce use above
formula....
1/(2 x pi x square root of (L x C))
If you choose capacitor of 1pF and inductor less than 22nH then the circuit
will produce 1GHz frequency means circuit will able to jam frequencies
up to 1GHz.