Professional Documents
Culture Documents
The Configration Attentation Point For LTE of TSL Projectv1.1
The Configration Attentation Point For LTE of TSL Projectv1.1
project
1: The main point for ant bitmap configuration in FDD excel sheet:
Here is the rules for Downlink Ant Configure Bitmap, Uplink Ant Configure Bitmap,
Up Active Ant Bitmap, Mapping of Antenna Port and Antenna Channel configuration:
1) if use 1th and 4th port of RRU (most of Macro is this type, means
this site is 2*2MIMO sites—2T2R) And y can got this information from
Noding also,
in noding there have Antenna_information as follows:
Antenna_information
MIMO
MIMO
Downlink Ant Configure Bitmap, Uplink Ant Configure Bitmap, Up Active Ant Bitmap will
been set to 9, Mapping of Antenna Port and Antenna Channel will been set to 0;15; 15;1;
15;15;15;15,,
2) if use 1th port of RRU(most of Indoor site is this type, means this
site cell is SISO—signal in and signal out—1T1R) ) And y can got this
SISO
SISO
Downlink Ant Configure Bitmap, Uplink Ant Configure Bitmap, Up Active Ant Bitmap will
been set to 1, Mapping of Antenna Port and Antenna Channel will been set to 0;15; 15;15;
15;15;15;15,,
Downlink Ant Configure Bitmap, Uplink Ant Configure Bitmap, Up Active Ant Bitmap will
been set to 3, Mapping of Antenna Port and Antenna Channel will been set to 0;1; 15;15;
15;15;15;15,,
Downlink Ant Configure Bitmap, Uplink Ant Configure Bitmap, Up Active Ant Bitmap will
been set to 12, Mapping of Antenna Port and Antenna Channel will been set to 15;15; 0;1;
15;15;15;15,,
2:attentation point
1:For the exiting G&U site, extention to Lte, pls try to make BPN2
board in slot 8, because most of the exiting site the slot 8 is free, so we
will not make more changing. If the slot 8 is not free, pls also installation
BPN2 board to slot8 and take the before board to slot 5, if slot 5 not free
2: For cell mode confiration, when the BPN2 board Used by lte is LTE
signal mode ,we config the cell mode as 5( Twelve Cells Two Ants),
when the BPN2 board used by LTE is GL or UL mode ,we config the cell
2) For IpLayerConfig sheet when we configuration this ,pls try to set the
ipNo follow this rules: omc set to 0, 2G set to 1,3G set to 2,LTE S1-U
3) For Sctp sheet, if GUL site, there have 3 SCTP link need to add, GSM
sctp should use the Iplayer of GSM, UMTS sctp should use the
iplayer of UMTS, LTE sctp should use the Iplayer of LTE S1-MME)
5) For ServiceMap sheet ,if GUL site, there have 3 ServiceMap need to